Kinetics of carotenoids degradation during the storage of einkorn (Triticum monococcum L. ssp. monococcum) and bread wheat (Triticum aestivum L. ssp. aestivum) flours

Carotenoid retention during post-harvest storage of Capsicum annuum: the role of the fruit surface structure

In this study, a chilli pepper (Capsicum annuum) panel for post-harvest carotenoid retention was studied to elucidate underlying mechanisms associated with this commercial trait of interest. Following drying and storage, some lines within the panel had an increase in carotenoids approaching 50% compared with the initial content at the fresh fruit stage. Other lines displayed a 25% loss of carotenoids. The quantitative determination of carotenoid pigments with concurrent cellular analysis indicated that in most cases, pepper fruit with thicker (up to 4-fold) lipid exocarp layers and smooth surfaces exhibit improved carotenoid retention properties. Total cutin monomer content increased in medium/high carotenoid retention fruits and subepidermal cutin deposits were responsible for the difference in exocarp thickness. Cutin biosynthesis and cuticle precursor transport genes were differentially expressed between medium/high and low carotenoid retention genotypes, and this supports the hypothesis that the fruit cuticle can contribute to carotenoid retention. Enzymatic degradation of the cuticle and cell wall suggests that in Capsicum the carotenoids (capsanthin and its esters) are embedded in the lipidic exocarp layer. This was not the case in tomato. Collectively, the data suggest that the fruit cuticle could provide an exploitable resource for the enhancement of fruit quality.

Carotenoid degradation rate in milled grain of dent maize hybrids and its relationship with the grain physicochemical properties

Carotenoids in maize grain degrade during storage, but the relationship between their stability and the physicochemical properties of the grain is unclear. Therefore, the carotenoid degradation rate in milled grain of three dent hybrids differing in grain hardness was evaluated at various temperatures (-20, 4 and 22 °C). The carotenoid degradation rate was calculated using first-order kinetics based on the content in the samples after 7, 14, 21, 28, 42, 56, 70 and 90 days of storage and related to the physicochemical properties of the grain. The highest grain hardness was found in the hybrid with the highest zein and endosperm lipid concentration, while the lowest grain hardness was found in the hybrid with the highest amylose content and the specific surface area of starch granule (SSA). As expected, carotenoids in milled maize grain were most stable at -20 °C, followed by storage at 4 and 22 °C. Tested hybrids differed in the degradation rate of zeaxanthin, α-cryptoxanthin and β-carotene, and these responses were also temperature-dependent. In contrast, all hybrids showed similar degradation rate for lutein and β-cryptoxanthin regardless of the storage temperature. Averaged over the hybrids, the degradation rate for individual carotenoids ranked as follows: lutein < zeaxanthin < α-cryptoxanthin < β-cryptoxanthin < β-carotene. The lower degradation rate for most carotenoids was mainly associated with a higher content of zein and specific endosperm lipids, with the exception of zeaxanthin, which showed an opposite pattern of response. Degradation rate for lutein and zeaxanthin negatively correlated with SSA, but interestingly, small starch granules were positively associated with higher degradation rate for mostcarotenoids. Dent-type hybrids may differ significantly in carotenoid degradation rate, which was associated with specific physicochemical properties of the maize grain.

Breadmaking Performance of Elite Einkorn (Triticum monococcum L. subsp. monococcum) Lines: Evaluation of Flour, Dough and Bread Characteristics

Einkorn flour, rich in proteins, carotenoids, and other antioxidants, generally has poor breadmaking value. In this research, the composition and technological characteristics of the flours and breads of two elite einkorns (Monlis and ID331) and a bread wheat (Blasco), cropped in four different environments, were evaluated. The einkorns confirmed better flour composition than bread wheat for proteins (on average, 16.5 vs. 10.5 g/100 g), soluble pentosans (1.03 vs. 0.85 g/100 g), and yellow pigment (10.0 vs. 1.0 mg/kg). Technologically, they had better SDS sedimentation values (89 vs. 66 mL), lower farinographic water absorption (52.6 vs. 58.8%), and a similar development time, stability, and degree of softening. Viscoelasticity tests showed lower storage and loss moduli and more prevalent elastic behaviour for Blasco, while rheofermentographic tests showed an anticipated development time (120.8 vs. 175.0 min), higher maximum height (73.0 vs. 63.0 mm), and superior retention coefficient (99.1 vs. 88.7%), but a lower CO₂ total (1152 vs. 1713 mL) for einkorn doughs. Einkorn breads were bigger than the control (736 vs. 671 cm³); crumb pores percentage was similar, but medium-size pores were scarcer. Finally, a 52-h shelf-life trial demonstrated that einkorn bread had a softer texture, maintained for a longer time, and a slower retrogradation than the control. Therefore, choice of appropriate varieties and process optimisation allows the production of excellent einkorn breads with a superior nutritional value and longer shelf life.

Microencapsulation of Carotenoid-Rich Extract from Guaraná Peels and Study of Microparticle Functionality through Incorporation into an Oatmeal Paste

The peels of guaraná (Paullinia cupana) fruit contain abundant carotenoid content, which has demonstrated health benefits. However, these compounds are unstable in certain conditions, and their application into food products can be changed considering the processing parameters. This study aimed to encapsulate the carotenoid-rich extract from guaraná peels by spray drying (SD), characterize the microparticles, investigate their influence on the pasting properties of oatmeal paste, and evaluate the effects of temperature and shear on carotenoid stability during the preparation of this product. A rheometer with a pasting cell was used to simulate the extrusion conditions. Temperatures of 70, 80, and 90 °C and shear rates of 50 and 100 1/s were the parameters evaluated. Microparticles with a total carotenoid content between 40 and 96 µg/g were obtained. Over the storage period, carotenoid stability, particle size, color, moisture, and water activity varied according to the core:carrier material proportion used. Afterward, the formulation SD1:2 was selected to be incorporated in oatmeal, and the paste viscosity was influenced by the addition of this powder. β-carotene retention was higher than that of lutein following the treatment. The less severe treatment involving a temperature of 70 °C and a shear rate of 50 1/s exhibited better retention of total carotenoids, regardless of whether the carotenoid-rich extract was encapsulated or non-encapsulated. In the other treatments, the thermomechanical stress significantly influenced the stability of the total carotenoid. These results suggest that the addition of encapsulated carotenoids to foods prepared at higher temperatures has the potential for the development of functional and stable products.

Kinetics of Carotenoids Degradation during the Storage of Encapsulated Carrot Waste Extracts

The encapsulates of carrot waste oil extract improved the antioxidant properties of durum wheat pasta. The aim of this research was to study the kinetics of carotenoids degradation in the freeze-dried (FDE) and spray-dried (SDE) encapsulates of carrot waste extract during storage at four different temperatures (+4, +21.3, +30, +37 °C) up to 413 days by HPLC. Carotenoids levels decreased as a function of time and temperature, following zero-order kinetics. At 4 °C carotenes were stable for at least 413 days, but their half-lives decreased with increasing temperatures: 8-12 months at 21 °C; 3-4 months at 30 °C; and 1.5-2 months at 37 °C. The freeze-drying technique was more effective against carotenes degradation. An initial lag-time with no or very limited carotenes degradation was observed: from one week at 37 °C up to 3 months (SDE) or more (FDE) at 21 °C. The activation energies (Ea) varied between 66.6 and 79.5 kJ/mol, and Ea values tended to be higher in FDE than in SDE.

Antioxidants of Amaranth, Quinoa and Buckwheat Wholemeals and Heat-Damage Development in Pseudocereal-Enriched Einkorn Water Biscuits

A viable approach to improve the nutritional quality of cereal-based foods is their enrichment with pseudocereals. The aim of this research was to evaluate the antioxidant properties of amaranth, quinoa and buckwheat, and the heat damage of water biscuits (WB) produced from either wholemeal or refined flour of einkorn and enriched with 50% buckwheat, amaranth or quinoa wholemeal. Buckwheat had the highest tocols content (86.2 mg/kg), and einkorn the most carotenoids (5.6 mg/kg). Conjugated phenolics concentration was highest in buckwheat (230.2 mg/kg) and quinoa (218.6 mg/kg), while bound phenolics content was greatest in einkorn (712.5 mg/kg) and bread wheat (675.7 mg/kg). The all-wholemeal WB had greater heat damage than those containing refined flour (furosine: 251.5 vs. 235.8 mg/100 g protein; glucosylisomaltol: 1.0 vs. 0.6 mg/kg DM; hydroxymethylfurfural: 4.3 vs. 2.8 mg/kg DM; furfural: 8.6 vs. 4.8 mg/kg DM). The 100% bread wheat and einkorn wholemeal WB showed greater heat damage than the WB with pseudocereals (furfural, 9.2 vs. 5.1 mg/kg; glucosylisomaltol 1.1 vs. 0.7 mg/kg). Despite a superior lysine loss, the amino-acid profile of the pseudocereals-enriched WB remained more balanced compared to that of the wheats WB.

Cooking Quality and Chemical and Technological Characteristics of Wholegrain Einkorn Pasta Obtained from Micronized Flour

The increased demand for healthier foods, the recognition of dry pasta as an ideal carrier of functional ingredients, and the current interest for ancient wheats such as einkorn motivated the present research. Two varieties of Triticum monococcum, namely cv Norberto and the free-threshing cv Hammurabi, were milled by ultra-fine milling process (micronization) to produce wholegrain spaghetti. Einkorn pasta was assessed in terms of technological and biochemical properties and cooking and sensorial quality and compared to durum wheat semolina pasta. Wholewheat einkorn pasta showed a threefold increase in total dietary fibre content as well as in total antioxidant capacity in comparison to the control. The level of resistant starch in cv Norberto resulted significantly higher respect to semolina and einkorn cv Hammurabi pasta. Despite the very weak einkorn gluten network, the sensory and instrumental assessment of pasta quality highlighted that einkorn spaghetti presented good sensorial properties related to their technological quality, in particular, for the overall judgment and firmness. Cultivar Hammurabi emerged as the preeminent compromise on the basis of technological performances together with chemical and sensorial aspects.

Variation in the Content and Composition of Tocols in a Wheat Population

Wheat is a well-known source of B vitamins but also contains significant amounts of vitamin E and related tocols, which have a number of positive health benefits. However, there are no reports on increasing the tocol content of wheat. A prerequisite for increasing the tocol content is the identification of variation in its amount within wheat and related cereals. We therefore determined the tocol content and composition in the grain of 230 recombinant inbred lines (RILs) of a diverse biparental wheat population (Mv Toborzó/Tommi), showing variation in the total content from 13.69 to 45.18 μg/g d.m. The total content also showed transgressive segregation in the population. The effect of the genotype on the variance components of tocols was studied, and the broad-sense heritability was calculated to be 0.71. The lines were also grouped based on their tocol content and analyzed for their chemical composition and breadmaking quality. The high heritability value and the wide variation found in the total amount indicate that increasing the content of tocols is a possible breeding strategy.

General Health Benefits and Pharmacological Activities of Triticum aestivum L

Common wheat (Triticum aestivum), one of the world's most consumed cereal grains, is known for its uses in baking and cooking in addition to its medicinal uses. As this plant's medical benefits are enormous and scattered, this narrative review was aimed at describing the pharmacological activities, phytochemistry, and the nutritional values of Triticum aestivum. It is a good source of dietary fiber, resistant starch, phenolic acids, alkylresorcinols, lignans, and diverse antioxidant compounds such as carotenoids, tocopherols and tocotrienols. These constituents provide Triticum aestivum with a wide range of pharmacological properties, including anticancer, antimicrobial, antidiabetic, hypolipemic, antioxidant, laxative, and moisturizing effects. This review summarized the established benefits of wheat in human health, the mode of action, and different clinical, in vitro and in vivo studies for different varieties and cultivars. This review also gives an insight for future research into the better use of this plant as a functional food. More clinical trials, in vivo and in vitro studies are warranted to broaden the knowledge about the effect of Triticum aestivum on nutrition-related diseases prevention, and physical and mental well-being sustenance.

Biochemical and Immunological implications of Lutein and Zeaxanthin

Throughout history, nature has been acknowledged for being a primordial source of various bioactive molecules in which human macular carotenoids are gaining significant attention. Among 750 natural carotenoids, lutein, zeaxanthin and their oxidative metabolites are selectively accumulated in the macular region of living beings. Due to their vast applications in food, feed, pharmaceutical and nutraceuticals industries, the global market of lutein and zeaxanthin is continuously expanding but chemical synthesis, extraction and purification of these compounds from their natural repertoire e.g., plants, is somewhat costly and technically challenging. In this regard microbial as well as microalgal carotenoids are considered as an attractive alternative to aforementioned challenges. Through the techniques of genetic engineering and gene-editing tools like CRISPR/Cas9, the overproduction of lutein and zeaxanthin in microorganisms can be achieved but the commercial scale applications of such procedures needs to be done. Moreover, these carotenoids are highly unstable and susceptible to thermal and oxidative degradation. Therefore, esterification of these xanthophylls and microencapsulation with appropriate wall materials can increase their shelf-life and enhance their application in food industry. With their potent antioxidant activities, these carotenoids are emerging as molecules of vital importance in chronic degenerative, malignancies and antiviral diseases. Therefore, more research needs to be done to further expand the applications of lutein and zeaxanthin.

Current Trends in Enrichment of Wheat Pasta: Quality, Nutritional Value and Antioxidant Properties

Wheat pasta is one of the most important cereal products and is becoming increasingly popular worldwide because of its convenience, simple formulation, long shelf life, and high energetic value. Wheat pasta is usually obtained from refined flour rich in carbohydrates but with low content of phytochemicals, micronutrients, and fibre. The increased demand of consumers for healthy foods has generated interest among both researchers and food producers in developing functional food products. This review showcases the current trends in pasta fortification. Changes in the nutritional value, cooking quality, sensory attributes, and antioxidant properties of durum and common wheat pasta enriched with both plant and animal raw materials are discussed.

Carotenoids in Cereal Food Crops: Composition and Retention throughout Grain Storage and Food Processing

Carotenoids are C40 isoprenoids synthesized by plants, as well as some bacteria, fungi and algae, that have been reported to be responsible for a number of benefits conferred on human health. The inability of animals and humans to synthesize de novo these compounds is the reason why they must be introduced from dietary sources. In cereal grains, carotenoids are important phytochemicals responsible for the characteristic yellow colour of the endosperm, which confers nutritional and aesthetic quality to cereal-based products. Cereals are staple foods for a large portion of the world population, and the biofortification of cereal grains with carotenoids may represent a simple way to prevent many human diseases and disorders. Unfortunately, evidence exists that the storage and processing of cereal grains into food products may negatively impact their carotenoid content; so, this loss should be taken into consideration when analysing the potential health benefits of the cereal-based products. Focusing on the recent updates, this review summarizes the chemical composition of the carotenoids in the grains of staple cereals, including wheat, maize, rice and sorghum, the main factors that affect their carotenoid content during storage and processing and the most fruitful strategies used improve the grain carotenoid content and limit the carotenoid post-harvest losses.

Carotenoid content in tritordeum is not primarily associated with esterification during grain development

Tritordeums show a significant proportion of lutein esters which increases carotenoid stability and retention throughout the food chain. Esterification is a common means of carotenoid sequestration. A putative association between lutein esters formation acting as a metabolic sink during early stages of grain development and the high carotenoid content of tritordeums is analyzed in this work. Compared to wheat, tritordeums accumulated significantly higher lutein contents from 20 days post anthesis (dpa) but lutein esters were not detected until 36 dpa. Thus esterification is not acting as a metabolific sink before 36 dpa. The presence of lutein esters at late stages of grain development may have a complementary role in carotenoid accumulation by reducing and/or counteracting their catabolism. The differences for lutein esterification among tritordeums suggest the existence of diversity for xanthophyll acyl transferases that could be exploited to increase lutein retention in this cereal and through the food chain.

Evaluation of the oxidative stability of Chipotle chili (

Capsicum annuum L. (Chipotle chili) is a natural source of bioactive metabolites with antioxidant properties. The objective of this research was to obtain and characterize the oxidative stability under storage of Chipotle chili oleoresins extracted with cold-pressed avocado oil. The most efficient conditions obtained to extract carotenoids and phenolic compounds were at 1:3 ratio (chipotle chili: avocado oil; w:v) at room temperature in darkness during 48 h. At the end of the harshest conditions (45 °C, 30 days), the extracts were stable to lipid oxidation with a final Totox value of 27.34, a carotenoid preservation of 85.6%, antioxidant activity retention of 80.66% and a color change (ΔE) of 1.783. The kinetic constants obtained were higher for peroxide formation than for carotenoid degradation. The oleoresins obtained could be considered an economic and sustainable alternative to extract carotenoids with good oxidation stability that could be used in foodstuffs.

Quality properties of puffed corn snacks incorporated with sesame seed powder

Puffed corn snacks are tasty and affordable cereal‐based food products which have a relatively poor nutritional quality. Sesame seed is a rich source of essential amino and fatty acids, phenolic compounds, tocopherols, and antioxidants. In this study, puffed corn snacks were produced by incorporating sesame powder at 0% (control sample), 5%, 10%, and 15% levels in its formulation and stored at room temperature (24°C) for 60 days. Fatty acid composition, tocopherol, sesamin and sesamolin, phenolic compounds, peroxide value (PV), acidity (AV), and sensory evaluation of the samples were determined. The results indicate that oleic acid content increased and palmitic acid decreased significantly (p < .05) in all the samples at 10% and 15% inclusion levels. The content of phenolic compounds, γ‐tocopherols, sesamin, and sesamolin had significant increases in all the formulated samples. PV results indicated that the formulated samples had a higher stability when the ratio of sesame powder was increased, while the AV values showed a significant increase during storage. Incorporation of 10% sesame powder in the snack formulation had a positive effect on the stability, sensory, and nutritional quality of the product. This approach can be used to modify nutritional quality of this food product and introduce to food market as a relatively healthy snack.

Breeding Major Cereal Grains through the Lens of Nutrition Sensitivity

Cereal grains are the common food staples that collectively provide over 50% of dietary calories and proteins for the world's population. Although the Green Revolution has greatly increased the yield of commercial cereal crops, they often lack nutrients essential for human health in the edible tissues. In developing nutrition-sensitive agriculture, the nutritional quality of cereal grains has been a major target for improvement using breeding and biotechnology approaches. This review examines recent progress on biofortification of micronutrients (provitamin A and folates) and an essential amino acid (lysine) in three major cereal grains, wheat, rice, and maize, through plant breeding. In addition, how natural variations, induced mutations, and the advanced genome-editing technologies can be applied to improving the nutrient content and stability in these cereal grains are discussed. High-yield cereal crops pyramided with improved (micro)nutrient contents hold great promise to meet the increasing demand of nutritionally limited populations and to contribute to achieving sustainable nutrition security.

Lutein Esterification in Wheat Flour Increases the Carotenoid Retention and Is Induced by Storage Temperatures

The present study aimed to evaluate the effects of long-term storage on the carotenoid pigments present in whole-grain flours prepared from durum wheat and tritordeum. As expected, higher storage temperatures showed a catabolic effect, which was very marked for free carotenoid pigments. Surprisingly, for both cereal genotypes, the thermal conditions favoured the synthesis of lutein esters, leading to an enhanced stability, slower degradation, and, subsequently, a greater carotenoid retention. The putative involvement of lipase enzymes in lutein esterification in flours is discussed, particularly regarding the preferential esterification of the hydroxyl group with linoleic acid at the 3' in the ε-ring of the lutein molecule. The negative effects of processing on carotenoid retention were less pronounced in durum wheat flours, which could be due to an increased esterifying activity (the de novo formation of diesterified xanthophylls was observed). Moreover, clear differences were observed for tritordeum depending on whether the lutein was in a free or esterified state. For instance, lutein-3'-O-monolinoleate showed a three-fold lower degradation rate than free lutein at 37 °C. In view of our results, we advise that the biofortification research aimed at increasing the carotenoid contents in cereals should be based on the selection of varieties with an enhanced content of esterified xanthophylls.

Wheat germ stabilization by infrared radiation

Wheat germ has an important enzymatic activity, being lipases the enzymes which cause the highest impact in the reduction of shelf life. The objective of this study was to evaluate the effects of infrared radiation on wheat germ stabilization in an attempt to extend the shelf life. The effects of treatment time, gap (sample distance to IR emitters) and infrared radiation intensity on wheat germ were analyzed through response surface methodology. Final moisture content, final temperature, color of germ and germ oil quality parameters: free fatty acid content changes and total tocopherol content were the responses evaluated using a Box-Behnken design. A combination of an infrared radiation intensity of 4800 W/m², a 3 min treatment and 0.2 m emitter-sample distance were the best processing condition to stabilize the wheat germ without significantly reduction of the tocopherol content. A confirmatory experiment was conducted with these optimal conditions, and the heat-treated and raw germ samples were stored for 90 days at room temperature in three layer packages to protect them against light and oxygen. The oil quality parameters indicated that the raw germ had a shelf-life of about 15 days, with the heat-treated wheat germ maintaining its quality for at least 90 days under these stored conditions.

Lutein ester profile in wheat and tritordeum can be modulated by temperature: Evidences for regioselectivity and fatty acid preferential of enzymes encoded by genes on chromosomes 7D and 7Hch

The increase of lutein retention through the food chain is desirable for wheat breeding. Lutein esters are more stable than free lutein during post-harvest storage and two loci on chromosomes 7D and 7H^ch are important for esterification. We investigated the effect of temperature during grain filling on carotenoid accumulation and lutein ester profile including fatty acid selectivity (palmitic vs. linoleic) and regioselectivity (esterification at positions 3 vs. 3'). Three different temperature regimes were assayed (controlled, semi-controlled and non-controlled). Lutein esters were more stable than free carotenoids in vivo and the enzymes encoded by chromosomes 7H^ch and 7D are complementary. Indeed, they show differential preferences for the fatty acid (palmitic and linoleic, respectively) and regioselectivity (3 and 3', respectively). Besides, H. chilense has additional genes for esterification. Finally, the increase of temperature favoured the accumulation of lutein esters with linoleic acid and the synthesis of regioisomers at position 3'.

Lipid profiles, in vitro digestion and oxidative stability of mutton bird oil

The lipid profile, in vitro digestion and oxidative stability of mutton bird oil were investigated. Wax ester, triacylglycerol and sterol were the major lipids present as determined using capillary chromatography with flame ionisation detector (Iatroscan). Fatty acid analysis by gas chromatography (GC) showed that wax esters had a higher total omega-3 fatty acids content including EPA, DPA and DHA than TAGs (31 % and 24 %, respectively). In TAGs, (13)C nuclear magnetic resonance (NMR) data showed that EPA was statistically positioned at sn-1,3 and sn-2, while DHA was preferentially at sn-2. In vitro digestion using porcine pancreatic lipase resulted in 75 % of TAG and 10 % wax ester hydrolysis in 120 min. As reflected in the measured conjugated dienes (CD) and thiobarbituric acid reactive substances (TBARS) values during accelerated oxidation at 60 °C for 5 days, the oil was relatively stable against oxidation considering its high omega-3 content.

Plastids and Carotenoid Accumulation

Plastids are ubiquitously present in plants and are the organelles for carotenoid biosynthesis and storage. Based on their morphology and function, plastids are classified into various types, i.e. proplastids, etioplasts, chloroplasts, amyloplasts, and chromoplasts. All plastids, except proplastids, can synthesize carotenoids. However, plastid types have a profound effect on carotenoid accumulation and stability. In this chapter, we discuss carotenoid biosynthesis and regulation in various plastids with a focus on carotenoids in chromoplasts. Plastid transition related to carotenoid biosynthesis and the different capacity of various plastids to sequester carotenoids and the associated effect on carotenoid stability are described in light of carotenoid accumulation in plants.

Infant Milk Formulas: Effect of Storage Conditions on the Stability of Powdered Products towards Autoxidation

Thirty samples of powdered infant milk formulas containing polyunsaturated fatty acids (PUFAs) have been stored at four different temperatures (20, 28, 40 and 55 °C) and periodically monitored for their malondialdehyde (MDA) content up to one year. MDA levels ranged between 250 and 350 ng/kg in sealed samples with a maximum of 566 ng/kg in samples stored at 28 °C for three weeks after opening of their original packages, previously maintained for ten months at 20 °C. Sample stored at 40° and 55 °C were also submitted to CIE (Commission Internationale de l'Eclairage) colorimetric analysis, since color is the first sensorial property that consumers may evaluate. Overall, the results demonstrated a good stability of PUFA-enriched infant milk formulas in terms of MDA content. However, some care has to be paid when these products are not promptly consumed and stored for a long time after first opening.

Improving the color of bulgur: new industrial applications of tempering and UV/sun-light treatments

Color (CIE b*; yellowness) is an important parameter for bulgur quality. Color of bulgur is mainly due to natural pigments (carotenoids) that are present at different levels in wheat. In order to increase the customer acceptability, the producers try to obtain yellowish color in bulgur. In this study, two different tempering methods (spray and steam) were used before sun and UV- light polishing applications. Sun and UV-light were applied to tempered bulgur for 12, 24, 36, 48, 60 and 72 h. Moisture content (%, d.b.), ash content (%, d.b.), protein content (%, d.b.), total carotenoid content in terms of lutein equivalent (TCC) and color values (CIE L*; lightness, CIE b*; yellowness, CIE a*; redness and CIE YI; yellowness index) were determined. It was found that UV-light was more effective (P < 0.05) on the CIE L* and CIE b* values compared to sunlight. Both tempering methods were significantly (P < 0.05) increased the CIE L*, CIE b* and CIE YI values. Steam tempering has a significant effect (P < 0.05) on the CIE b* values as well as UV and time of UV exposure. The highest value of TCC i.e. 6.31 μg/g was obtained by using spray tempering and UV-light exposure. As a conclusion, as proposed methods steam tempering and UV-light have an obvious positive effect on the color of bulgur.

Down-regulation of lipoxygenase gene reduces degradation of carotenoids of golden rice during storage

Down-regulation of lipoxygenase enzyme activity reduces degradation of carotenoids of bio-fortified rice seeds which would be an effective tool to reduce huge post-harvest and economic losses of bio-fortified rice seeds during storage. Bio-fortified provitamin A-enriched rice line (golden rice) expressing higher amounts of β-carotene in the rice endosperm provides vitamin A for human health. However, it is already reported that degradation of carotenoids during storage is a major problem. The gene responsible for degradation of carotenoids during storage has remained largely unexplored till now. In our previous study, it has been shown that r9-LOX1 gene is responsible for rice seed quality deterioration. In the present study, we attempted to investigate if r9-LOX1 gene has any role in degradation of carotenoids in rice seeds during storage. To establish our hypothesis, the endogenous lipoxygenase (LOX) activity of high-carotenoid golden indica rice seed was silenced by RNAi technology using aleurone layer and embryo-specific Oleosin-18 promoter. To check the storage stability, LOX enzyme down-regulated high-carotenoid T3 transgenic rice seeds were subjected to artificial aging treatment. The results obtained from biochemical assays (MDA, ROS) also indicated that after artificial aging, the deterioration of LOX-RNAi lines was considerably lower compared to β-carotene-enriched transgenic rice which had higher LOX activity in comparison to LOX-RNAi lines. Furthermore, it was also observed by HPLC analysis that down-regulation of LOX gene activity decreases co-oxidation of β-carotene in LOX-RNAi golden rice seeds as compared to the β-carotene-enriched transgenic rice, after artificial aging treatment. Therefore, our study substantially establishes and verifies that LOX is a key enzyme for catalyzing co-oxidation of β-carotene and has a significant role in deterioration of β-carotene levels in the carotenoid-enriched golden rice.

Chlorophylls and carotenoids of kiwifruit puree are affected similarly or less by microwave than by conventional heat processing and storage

The impact of microwave (1000 W - 340 s) and conventional heat (97 °C - 30s) pasteurisation and storage (4, 10, 22 °C for up to 63 d) on total and individual carotenoids and chlorophylls in kiwifruit puree was evaluated. Bioaccessibility of carotenoids, before and after pasteurisation and storage, was also studied. Microwaves and conventional heating led to marked changes in the chlorophyll (42-100% losses) and carotenoid (62-91% losses) content. First- and second-order kinetics appropriately explained the degradation of total carotenoids and chlorophylls over time, respectively. Pasteurised samples showed significantly (p < 0.05) enhanced stability of these pigments, with microwaves (k = 0.007-0.031100 g mg(-1) day(-1) at 4-22 °C) promoting chlorophyll stability to a greater extent than conventional heating (k = 0.0015-0.034100 g mg(-1) day(-1) at 4-22 °C). Bioaccessibility of carotenoids remained (p < 0.05) unaffected by processing and storage. These results highlighted that the pigment composition of microwaved kiwifruit was more similar to that of the fresh fruit and better preserved during storage.

Retention of provitamin a carotenoids in staple crops targeted for biofortification in Africa: cassava, maize and sweet potato

HarvestPlus, part of the Consultative Group on Internation Agriculture research (CGIAR) Program on Agriculture for Nutrition and Health (A4NH) uses conventional plant breeding techniques to develop staple food crops that are rich in micronutrients, a food-based approach to reduce micronutrient malnutrition known as biofortification. The nutritional breeding targets are established based on the food intake of target populations, nutrient losses during storage and processing and bioavailability. This review collates the evidence on the retention of provitamin A carotenoid (pVAC) after processing, cooking, and storing of the staple crops targeted for pVAC biofortification: cassava, maize, and sweet potato. Sun drying was more detrimental to the pVAC levels (27-56% retention) in cassava than shade (59%) or oven (55-91%) drying, while the pVAC retention levels (66-96%) in sweet potato were not significantly different among the various drying methods. Overall, boiling and steaming had higher pVAC retention (80-98%) compared to baking (30-70%) and frying (18-54%). Gari, the most frequently consumed form of cassava in West Africa had the lowest pVAC retention (10-30%). The pVAC retention of maize grain and cassava and sweet potato flour reached levels as low as 20% after 1-4 months of storage and was highly dependent on genotype. Therefore, we recommend that an evaluation of the pVAC degradation rate among different genotypes be performed before a high pVAC crop is promoted.