Worldwide contamination of food-crops with mycotoxins: Validity of the widely cited ‘FAO estimate’ of 25%

Enhanced selectivity for convenient extraction of acidic mycotoxins using a miniaturized centrifugal integrated cold-induced phase separation: Determination of fumonisins and ochratoxins in cereals as a proof-of-concept study

Starches-rich and protein-rich cereal samples commonly need tedious sample preparation steps before instrumental analysis. This study developed a miniaturized centrifugal integrated cold-induced phase separation (CIPS) method for convenient sample preparation. A small-sized centrifuge tube (2 mL) and a low-temperature centrifuge, both of which are easily accessible, make up the basic components of the system. Unlike conventional sample preparation methods that need a step-by-step extraction, enrichment, purification, and centrifugation, this centrifugal integrated CIPS method can be performed by a one-step combination protocol under a low-temperature centrifuge. As a proof-of-concept study, satisfactory recoveries and enrichment factors were demonstrated for the extraction of fumonisins and ochratoxins from cereals. A sensitive and selective quantification method was yielded by combining LC-HRMS using tSIM acquisition mode, with good linearity (R2 > 0.998), accuracy (82.9-106.5%), and precision (<13.4%). This strategy is convenient, low-cost, repeatable, and easy to semi-automate, further expanding the extraction potential for other acidic mycotoxins.

Emerging mycotoxin occurrence in chicken feed and eggs from Algeria

Poultry farming has developed into one of Algeria's most productive industrial farming because of the growing demand for sources of protein among Algerian society. Laying hen feed consists mainly of cereals, which can be contaminated with molds and subsequently with their secondary metabolites known as mycotoxins. These later can pose a serious danger to the production and quality of eggs in the commercial layer industry. This work focuses on the detection of emerging mycotoxins, mainly enniatins (ENNs) and beauvericin (BEA), in poultry feed and eggs from different locations in Algeria. Two different QuEChERS-based extractions were established to extract ENNs and BEA from chicken feed and eggs. The determination of mycotoxin occurrence was achieved by a UHPLC-MS/MS method using 0.1% (v/v) formic acid in water and MeOH as mobile phase, an ESI interface operating in positive mode, and a triple quadrupole mass spectrometer operating in MRM for the detection. Matrix-matched calibration curves were carried out for both matrices, obtaining good linearity (R2 > 0.99). The method performance was assessed in terms of extraction recovery (from 87 to 107%), matrix effect (from - 47 to - 86%), precision (RSD < 15%), and limits of quantitation (≤ 1.1 µg/kg for feed and ≤ 0.8 µg/kg for eggs). The analysis of 10 chicken feed samples and 35 egg samples composed of a 10-egg pool each showed that ENN B1 was the most common mycotoxin (i.e., found in 9 feed samples) with contamination levels ranging from 3.6 to 41.5 µg/kg, while BEA was detected only in one feed sample (12 µg/kg). However, eggs were not found to be contaminated with any mycotoxin at the detection limit levels. Our findings indicate that the searched mycotoxins are present in traces in feed and absent in eggs. This can be explained by the application of a mycotoxin binder. However, this does not put a stop on the conduction of additional research and ultimately setting regulations to prevent the occurrence of emerging mycotoxins.

Role of albumin in the metabolism and excretion of ochratoxin A

Ochratoxin A (OTA) is known to be strongly bound to serum albumin, but it remains unknown how albumin affects its metabolism and kinetics. To close this gap, we used a mouse model, where heterozygous albumin deletion reduces serum albumin to concentrations similar to hypoalbuminemic patients and completely eliminates albumin by a homozygous knockout. OTA and its potential metabolites (OTα, 4-OH-OTA, 7'-OH-OTA, OTHQ, OP-OTA, OTB-GSH, OTB-NAC, OTB) were time-dependently analyzed in plasma, bile, and urine by LC-MS/MS and were compared to previously published hepatotoxicity and nephrotoxicity data. Homozygous albumin deletion strongly accelerated plasma clearance as well as biliary and urinary excretion of the parent compound and its hydroxylation products. Decreasing albumin in mice by the heterozygous and even more by the homozygous knockout leads to an increase in the parent compound in urine which corresponded to increased nephrotoxicity. The role of albumin in OTA-induced hepatotoxicity is more complex, since heterozygous but not homozygous nor wild-type mice showed a strong biliary increase in the toxic open lactone OP-OTA. Correspondingly, OTA-induced hepatotoxicity was higher in heterozygous than in wild-type and homozygous animals. We present evidence that albumin-mediated retention of OTA in hepatocytes is required for formation of the toxic OP-OTA, while complete albumin elimination leads to rapid biliary clearance of OTA from hepatocytes with less formation of OP-OTA. In conclusion, albumin has a strong influence on metabolism and toxicity of OTA. In hypoalbuminemia, the parent OTA is associated with increased nephrotoxicity and the open lactone with increased hepatotoxicity.

Multiple mycotoxins associated with maize (Zea mays L.) grains harvested from subsistence farmers' fields in southwestern Ethiopia

Fifty-four maize grain samples freshly harvested from subsistence farmers' fields in southwestern Ethiopia were analyzed for multiple mycotoxins using liquid chromatography-tandem mass spectrometric (LC-MS/MS) method following extraction by acetonitrile/water/acetic acid on a rotary shaker. The grain samples were contaminated with a total of 164 metabolites, of which Fusarium and Penicillium metabolites were the most prevalent accounting for 27 and 30%, respectively. All the major mycotoxins and derivatives except one (citrinin) were of Fusarium origin. Zearalenone was the most frequent major mycotoxin occurring in 74% of the samples at concentrations of 0.32-1310 µg/kg. It was followed by nivalenol (63%), zearalenone-sulfate (44%), and fumonisin B1 (41%). Nivalenol, nivalenol glucoside, and fusarenon-X were detected at unusually high levels of 8-1700 µg/kg, 21-184 µg/kg, and 33-149 µg/kg, respectively. Deoxynivalenol and DON-3 glucoside contaminated 32% of the samples, each at levels of 15.9-5140 µg/kg and 10-583 µg/kg, respectively. Moniliformin and W493B occurred in 96 and 22% samples at levels of 3.27-4410 µg/kg and 3-652 µg/kg, respectively. Fumonisins were also detected in the samples at levels of 9-6770 µg/kg (B1), 16-1830 µg/kg (B2), 9.5-808 µg/kg (B3), and 1.3-128 µg/kg (A1). This study confirmed the presence of an array of mycotoxins contaminating maize grains right from the field. The effect of the co-occurring mycotoxins on consumers' health should be investigated along with that of the newly emerging ones. Results of the current study call for application of pre-harvest mycotoxin mitigation strategies to safeguard maize-based food and feed.

Occurrence of the two major regulated mycotoxins, ochratoxin A and fumonisin B1, in cereal and cereal-based products in Europe and toxicological effects: A review

Among cereal contaminants, mycotoxins are of concern due to their importance in terms of food and feed safety. The difficulty in establishing a diagnosis for mycotoxicosis relies on the fact that the effects are most often subclinical for chronic exposure and the most common scenario is multi-contamination by various toxins. Mycotoxin co-occurrence is a major food safety concern as additive or even synergic toxic impacts may occur, but also regarding current regulations as they mainly concern individual mycotoxin levels in specific foods and feed in the food chain. However, due to the large number of possible mycotoxin combinations, there is still limited knowledge on co-exposure toxicity data, which depends on several parameters. In this context, this systematic review aims to provide an overview of the toxic effects of two regulated mycotoxins, namely ochratoxin A and fumonisin B1. This review focused on the 2012-2022 period and analysed the occurrence in Europe of the selected mycotoxins in different food matrices (cereals and cereal-derived products), and their toxic impact, alone or in combination, on in vitro intestinal and hepatic human cells. To better understand and evaluate the associated risks, further research is needed using new approach methodologies (NAM), such as in vitro 3D models. KEY CONTRIBUTION: Cereals and their derived products are the most important food source for humans and feed for animals worldwide. This manuscript is a state of the art review of the literature over the last ten years on ochratoxin A and fumonisin B1 mycotoxins in these products in Europe as well as their toxicological effects, alone and in combination, on human cells. Future perspectives and some challenges regarding the assessment of toxicological effects of mycotoxins are also discussed.

Aflatoxin B1 induces ROS-dependent mitophagy by modulating the PINK1/Parkin pathway in HepG2 cells

Aflatoxin B1 (AFB1) is extremely harmful to both humans and animals. Mitophagy is a selective process of self-elimination and has an important role in controlling mitochondrial quality. The present study aimed to investigate the effect of reactive oxygen species (ROS) accumulation on AFB1-induced mitophagy in HepG2 cells to provide a new perspective from which to design novel therapeutic strategies to treat AFB1 poisoning. ROS release was induced in HepG2 cells with AFB1 (10 μmol/L). Cell autophagy activity, mitochondrial membrane potential (MMP), adenosine triphosphate (ATP) levels, Parkin translocation and both the transcription and expression of mitophagy-related proteins were measured when N-acetyl-L-cysteine (NAC) partially decreased the ROS level, while the knockdown of nuclear factor erythroid 2-related factor 2 (Nrf2) resulted in a large accumulation of ROS. The results reveal that NAC pretreatment ameliorated the decline in both the MMP and the ATP levels while also activating phosphoglycerate mutase 5 (PGAM5)-PTEN-induced kinase 1 (PINK1)/Parkin, while the Nrf2 knockdown group exhibited the opposite trend. These results suggest that AFB1-induced mitophagy in HepG2 cells depends on ROS, and proper ROS activates mitophagy to play a protective role.

Smart proteins as a new paradigm for meeting dietary protein sufficiency of India: a critical review on the safety and sustainability of different protein sources

India, a global leader in agriculture, faces sustainability challenges in feeding its population. Although primarily a vegetarian population, the consumption of animal derived proteins has tremendously increased in recent years. Excessive dependency on animal proteins is not environmentally sustainable, necessitating the identification of alternative smart proteins. Smart proteins are environmentally benign and mimic the properties of animal proteins (dairy, egg and meat) and are derived from plant proteins, microbial fermentation, insects and cell culture meat (CCM) processes. This review critically evaluates the technological, safety, and sustainability challenges involved in production of smart proteins and their consumer acceptance from Indian context. Under current circumstances, plant-based proteins are most favorable; however, limited land availability and impending climate change makes them unsustainable in the long run. CCM is unaffordable with high input costs limiting its commercialization in near future. Microbial-derived proteins could be the most sustainable option for future owing to higher productivity and ability to grow on low-cost substrates. A circular economy approach integrating agri-horti waste valorization and C1 substrate synthesis with microbial biomass production offer economic viability. Considering the use of novel additives and processing techniques, evaluation of safety, allergenicity, and bioavailability of smart protein products is necessary before large-scale adoption.

Detoxification of DON-induced hepatotoxicity in mice by cold atmospheric plasma

Deoxynivalenol (DON) is one of the most common mycotoxins distributed in food and feed, which causes severe liver injury in humans and animals. Cold atmospheric plasma (CAP) has received much attention in mycotoxin degradation due to the advantages of easy operation, high efficiency, and low temperature. So far, the majority of studies have focused on the degradation efficiency and mechanism of CAP on DON, while there is still little information available on the hepatotoxicity of DON after CAP treatment. Herein, this study aimed to investigate the effect of CAP on DON-induced hepatotoxicity both in vitro and in vivo and its underlying mechanisms. The results showed that 120-s CAP treatment achieved 97 % degradation of DON. The vitro hepatotoxicity of DON in L02 cells was significantly reduced with CAP treatment time. Meanwhile, CAP markedly alleviated DON-induced liver injury in mice including the balloon-like degeneration of liver tissues and elevation of AST and ALP level. The underlying mechanism for CAP detoxification of DON-induced hepatotoxicity was further elucidated. The results showed that DON caused severe oxidative stress in cells by suppressing the antioxidant signaling pathway of Nrf2/HO-1/NQO-1, consequently leading to mitochondrial dysfunction and cell apoptosis, accompanied by cellular senescence and inflammation. CAP blocked DON inhibition on the Nrf2/HO-1/NQO-1 signaling pathway through the efficient degradation of DON, accordingly alleviating the oxidative stress and liver injury induced by DON. Therefore, CAP is an effective method to eliminate DON hepatotoxicity, which can be applied in the detoxification of mycotoxin-contaminated food and feed to ensure human and animal health.

Lateral flow assay for simultaneous detection of multiple mycotoxins using nanozyme to amplify signals

Co-contamination of multiple mycotoxins produces synergistic toxic effects, leading to more serious hazards. Therefore, the simple, rapid and accurate simultaneous detection of multiple mycotoxins is crucial. Herein, a three-channel aptamer-based lateral flow assay (Apt-LFA) was established for the detection of aflatoxin M1 (AFM1), aflatoxin B1 (AFB1) and ochratoxin A (OTA). The multi-channel Apt-LFA utilized gold‑iridium nanozyme to catalyze the chromogenic substrate, which effectively achieved signal amplification. Moreover, the positions and lengths of the complementary sequences were screened by changes in fluorescence intensity. After grayscale analysis, the semi-quantitative results showed that the detection limits of AFM1, AFB1 and OTA were 0.39 ng/mL, 0.36 ng/mL and 0.82 ng/mL. The recoveries of the multiplexed competitive sensors in complex matrices of real samples were 93.33%-97.01%, 95.72%-102.67%, and 106.88%-109.33%, respectively. In conclusion, the assembly principle of the three-channel Apt-LFA is simple, which can provide a new idea for the simultaneous detection of small molecule targets.

Vertasile ferritin nanocages: Applications in detection and bioimaging

Food safety and human health remain significant concerns in the food industry. Detecting food contaminants and diagnosing diseases are critical aspects. Ferritin, an iron storage protein widely found in nature, offers unique advantages. Its hollow protein nanocage structure, distinct interfaces, hydrophobic or hydrophilic channels, and B-C loop regions recognized by transferrin receptor 1 make ferritin versatile for detecting heavy metals, free radicals, and bioimaging both in vitro and in vivo. This review summarizes ferritin's general characteristics, its specific properties as biosensors, and its applications in food safety and in vivo imaging. It emphasizes not only ferritin's role in detecting heavy metals like mercury and chemical hazards but also its potential in early diagnosing chronic diseases such as tumors, macrophages, and kidney diseases. Further research into ferritin promises advancements in enhancing food safety and improving human health diagnostics.

Monitoring of Aflatoxins B1, G1, B2, and G2 in Spices from Riyadh Markets by Liquid Chromatography Coupled to Tandem Mass Spectrometry

A total of 1053 samples of spices were collected from Riyadh markets during 2022. The contamination with aflatoxins (AF) B1 (AFB1), B2 (AFB2), G1 (AFG1), and G2 (AFG2) was determined via liquid chromatography coupled to tandem mass spectrometry. AF extraction from spices was performed using an acetonitrile-formic acid mixture. The results obtained show that the highest value for AFB1 (3.865 μg/kg) was detected in the bay leaf sample, while the highest value for AFB2 (3.461 μg/kg) was found in red chili powder. The values of AFG1 and AFG2 did not exceed 2.59 μg/kg. The AF analysis shows that 24 out of 1053 samples (2.3%) contained one or more of these AFs. The highest percentage of contaminated samples was detected in black pepper. AFB1 was found in 21 samples of six types of spices, while AFG2 was detected in eight samples of four types of spices. Also, none of the samples exceeded the Saudi Food and Drug Authority and EU limits of 10 μg/kg. The present research is not a comprehensive study; however, it provides valuable information on AFB1, AFB2, AFG1, and AFG2 levels in the Kingdom of Saudi Arabia spices.

MINIstock: Model for INsect Inclusion in sustainable agriculture: USDA-ARS's research approach to advancing insect meal development and inclusion in animal diets

Animal agriculture is under pressure to increase efficiency, sustainability, and innovation to meet the demands of a rising global population while decreasing adverse environmental effects. Feed cost and availability are 2 of the biggest hurdles to sustainable production. Current diets depend on sources of grain and animal byproduct protein for essential amino acids which have limited sustainability. Insects have arisen as an attractive, sustainable alternative protein source for animal diets due to their favorable nutrient composition, low space and water requirements, and natural role in animal diets. Additionally, insects are capable of bioremediating waste streams including agricultural and food waste, manure, and plastics helping to increase their sustainability. The insect rearing industry has grown rapidly in recent years and shows great economic potential. However, state-of-the-art research is urgently needed to overcome barriers to adoption in commercial animal diets such as regulatory restrictions, production scale issues, and food safety concerns. To address this need, the USDA Agricultural Research Service "MINIstoc: Model for INsect Inclusion" project was created to bring together diverse scientists from across the world to synergistically advance insect meal production and inclusion in animal diets. Here, we provide a short review of insects as feed while describing the MINIstock project which serves as the inspiration for the Journal of Economic Entomology Special Collection "Insects as feed: sustainable solutions for food waste and animal production practices."

A comprehensive review on novel synthetic foods: Potential risk factors, detection strategies, and processing technologies

Nowadays, the food industry is facing challenges due to the simultaneous rise in global warming, population, and food consumption. As the integration of synthetic biology and food science, novel synthetic foods have obtained high attention to address these issues. However, these novel foods may cause potential risks related to human health. Four types of novel synthetic foods, including plant-based foods, cultured meat, fermented foods, and microalgae-based foods, were reviewed in the study. The original food sources, consumer acceptance, advantages and disadvantages of these foods were discussed. Furthermore, potential risk factors, such as nutritional, biological, and chemical risk factors, associated with these foods were described and analyzed. Additionally, the current detection methods (e.g., enzyme-linked immunosorbent assay, biosensors, chromatography, polymerase chain reaction, isothermal amplification, and microfluidic technology) and processing technologies (e.g., microwave treatment, ohmic heating, steam explosion, high hydrostatic pressure, ultrasound, cold plasma, and supercritical carbon dioxide) were reviewed and discussed critically. Nonetheless, it is crucial to continue innovating and developing new detection and processing technologies to effectively evaluate these novel synthetic foods and ensure their safety. Finally, approaches to enhance the quality of these foods were briefly presented. It will provide insights into the development and management of novel synthetic foods for food industry.

Analysis of the impact of drying on common wheat quality and safety

Mycotoxin contamination in grain has been an ongoing concern in the world. Wheat, as a staple crop in China, is particularly notable for its mycotoxin contamination. The main mycotoxins in wheat include deoxynivalenol (DON) and its derivates, zearalenone (ZEN) and aflatoxin B1 (AFB1). After harvest, drying process is an effective technique and a necessary step to ensure the long-term safe storage of wheat. In this study, the moisture content, the concentrations of total fungi and main mycotoxins in post-harvest wheat of three wheat growing areas in the North China Plain were examined, and the effect of different drying methods on wheat quality was evaluated. The results showed that 87.5% of wheat samples were simultaneously contaminated with two or more mycotoxins. Due to the pre-harvest heavy rainfall, the moisture content, the levels of total fungi and mycotoxins in wheat samples of Liaocheng city were significantly higher compared to other regions. Moreover, the effects of different drying methods on the starch gelatinization and viscosity properties of wheat were investigated. The results showed that both natural air drying and dryer drying altered the crystal structure within starch particles and affected the gelatinization and viscosity properties of wheat starch. However, there is no significant difference between the wheat samples treated with two drying methods.

Nutritional compounds and risk assessment of mycotoxins in ecological and conventional nuts

This comprehensive study aimed to determine the level of nutritional compounds (20 amino acids, 11 phenolic acids, and 8 vitamins) and hazard compounds (14 mycotoxins) in ten types of conventional and ecological nuts from 25 countries. Moreover, chronic and acute toxicological risk assessment of mycotoxins was performed. Examined constituents were determined using LC-MS/MS. Ecological pine nuts showed the highest level of amino acids (233.87 g kg-1) compared to conventional (207 g kg-1), pecans-phenolic acids (816.6 mg kg-1 in ecological and 761 mg kg-1 in conventional), while pistachios-vitamins (3471.4 mg kg-1 in ecological and 3098.4 mg kg-1 in conventional). Increased concentration of mycotoxins was determined in conventional peanuts (54 μg kg-1) and walnuts (49.9 μg kg-1). Children were the most exposed population to acute intoxication with HT-2 toxin in conventional pistachios (20.66% ARfD). The results confirmed the nutritional importance of ecological nuts and emphasized the need for continuous screening of mycotoxins.

Simultaneous detection of multiple mycotoxins using MXene-based electrochemical aptasensor array and a self-developed multi-channel portable device

In response to the pressing need for highly efficient simultaneous detection of multiple mycotoxins, which are often found co-occurring in food raw materials and feed, an MXene-based electrochemical aptasensor array (MBEAA) was developed. This aptasensor array utilizes high-specificity aptamers as recognition elements, enabling the capture of electrical signal changes in the presence of target mycotoxins. Based on this platform, a multi-channel portable electrochemical device, enabling rapid, cost-effective, and simultaneous detection of aflatoxin B1 (AFB1), ochratoxin A (OTA), and zealenone (ZEN) was further developed. The developed system boasts a wide detection range of 1.0 × 10-1 to 10.0 ng mL-1, with remarkable performance characterized by ultra-low detection limits of 41.2 pg mL-1, 27.6 pg mL-1, and 33.0 pg mL-1 for AFB1, OTA, and ZEN, respectively. Successfully applied in corn samples, this method offers a portable, easy-to-operate, and cost-effective solution for simultaneous multi-mycotoxin detection. Moreover, the application of the self-developed detection system could be expanded for simultaneous detection of many different targets when their specific aptamers or antibodies were available.

Challenges and Opportunities Arising from Host-Botrytis cinerea Interactions to Outline Novel and Sustainable Control Strategies: The Key Role of RNA Interference

The necrotrophic plant pathogenic fungus Botrytis cinerea (Pers., 1794), the causative agent of gray mold disease, causes significant losses in agricultural production. Control of this fungal pathogen is quite difficult due to its wide host range and environmental persistence. Currently, the management of the disease is still mainly based on chemicals, which can have harmful effects not only on the environment and on human health but also because they favor the development of strains resistant to fungicides. The flexibility and plasticity of B. cinerea in challenging plant defense mechanisms and its ability to evolve strategies to escape chemicals require the development of new control strategies for successful disease management. In this review, some aspects of the host-pathogen interactions from which novel and sustainable control strategies could be developed (e.g., signaling pathways, molecules involved in plant immune mechanisms, hormones, post-transcriptional gene silencing) were analyzed. New biotechnological tools based on the use of RNA interference (RNAi) are emerging in the crop protection scenario as versatile, sustainable, effective, and environmentally friendly alternatives to the use of chemicals. RNAi-based fungicides are expected to be approved soon, although they will face several challenges before reaching the market.

Natural products for Gut-X axis: pharmacology, toxicology and microbiology in mycotoxin-caused diseases

Introduction: The gastrointestinal tract is integral to defending against external contaminants, featuring a complex array of immunological, physical, chemical, and microbial barriers. Mycotoxins, which are toxic metabolites from fungi, are pervasive in both animal feed and human food, presenting substantial health risks. Methods: This review examines the pharmacological, toxicological, and microbiological impacts of natural products on mycotoxicosis, with a particular focus on the gut-x axis. The analysis synthesizes current understanding and explores the role of natural products rich in polysaccharides, polyphenols, flavonoids, and saponins. Results: The review highlights that mycotoxins can disrupt intestinal integrity, alter inflammatory responses, damage the mucus layer, and disturb the bacterial balance. The toxins' effects are extensive, potentially harming the immune system, liver, kidneys, and skin, and are associated with serious conditions such as cancer, hormonal changes, genetic mutations, bleeding, birth defects, and neurological issues. Natural products have shown potential anticancer, anti-tumor, antioxidant, immunomodulatory, and antitoxic properties. Discussion: The review underscores the emerging therapeutic strategy of targeting gut microbial modulation. It identifies knowledge gaps and suggests future research directions to deepen our understanding of natural products' role in gut-x axis health and to mitigate the global health impact of mycotoxin-induced diseases.

Comprehensive Review of Aflatoxin and Ochratoxin A Dynamics: Emergence, Toxicological Impact, and Advanced Control Strategies

Filamentous fungi exhibit remarkable adaptability to diverse substrates and can synthesize a plethora of secondary metabolites. These metabolites, produced in response to environmental stimuli, not only confer selective advantages but also encompass potentially deleterious mycotoxins. Mycotoxins, exemplified by those originating from Alternaria, Aspergillus, Penicillium, and Fusarium species, represent challenging hazards to both human and animal health, thus warranting stringent regulatory control. Despite regulatory frameworks, mycotoxin contamination remains a pressing global challenge, particularly within cereal-based matrices and their derived by-products, integral components of animal diets. Strategies aimed at mitigating mycotoxin contamination encompass multifaceted approaches, including biological control modalities, detoxification procedures, and innovative interventions like essential oils. However, hurdles persist, underscoring the imperative for innovative interventions. This review elucidated the prevalence, health ramifications, regulatory paradigms, and evolving preventive strategies about two prominent mycotoxins, aflatoxins and ochratoxin A. Furthermore, it explored the emergence of new fungal species, and biocontrol methods using lactic acid bacteria and essential mustard oil, emphasizing their efficacy in mitigating fungal spoilage and mycotoxin production. Through an integrative examination of these facets, this review endeavored to furnish a comprehensive understanding of the multifaceted challenges posed by mycotoxin contamination and the emergent strategies poised to ameliorate its impact on food and feed safety.

Biological Detoxification of Aflatoxin B1 by Enterococcus faecium HB2-2

Aflatoxin B1 (AFB1) contamination in food and feed is a global health and economic threat, necessitating the immediate development of effective strategies to mitigate its negative effects. This study focuses on the isolation and characterization of Enterococcus faecium HB2-2 (E. faecium HB2-2) as a potent AFB1-degrading microorganism, using morphological observation, biochemical profiling, and 16S rRNA sequence analysis. An incubation of E. faecium HB2-2 at 32 °C for 96 h in a pH 10 nutrient broth (NB) medium resulted in a remarkable degradation rate of 90.0% for AFB1. Furthermore, E. faecium HB2-2 demonstrated 82.9% AFB1 degradation rate in the peanut meal, reducing AFB1 levels from 105.1 to 17.9 μg/kg. The AFB1 degradation ability of E. faecium HB2-2 was found to be dependent on the fermentation supernatant. The products of AFB1 degradation by E. faecium HB2-2 were analyzed by liquid chromatography-mass spectrometry (LC-MS), and a possible degradation mechanism was proposed based on the identified degradation products. Additionally, cytotoxicity assays revealed a significant reduction in the toxicity of the degradation products compared to the parent AFB1. These findings highlight the potential of E. faecium HB2-2 as a safe and effective method for mitigating AFB1 contamination in food and feed.

Machine Learning Applied to the Detection of Mycotoxin in Food: A Systematic Review

Mycotoxins, toxic secondary metabolites produced by certain fungi, pose significant threats to global food safety and public health. These compounds can contaminate a variety of crops, leading to economic losses and health risks to both humans and animals. Traditional lab analysis methods for mycotoxin detection can be time-consuming and may not always be suitable for large-scale screenings. However, in recent years, machine learning (ML) methods have gained popularity for use in the detection of mycotoxins and in the food safety industry in general due to their accurate and timely predictions. We provide a systematic review on some of the recent ML applications for detecting/predicting the presence of mycotoxin on a variety of food ingredients, highlighting their advantages, challenges, and potential for future advancements. We address the need for reproducibility and transparency in ML research through open access to data and code. An observation from our findings is the frequent lack of detailed reporting on hyperparameters in many studies and a lack of open source code, which raises concerns about the reproducibility and optimisation of the ML models used. The findings reveal that while the majority of studies predominantly utilised neural networks for mycotoxin detection, there was a notable diversity in the types of neural network architectures employed, with convolutional neural networks being the most popular.

Exposure And Health Risk Assessment Of Aflatoxins In Hot Red Pepper Marketed In North Shewa Zone, Oromia Region, Ethiopia

Aflatoxins (AFs) are secondary metabolites mainly produced by Aspergillus flavus and A. parasiticus and their contamination of red peppers can cause hepatocellular carcinoma, growth retardation in children, immune suppression, and death. In addition, their presence in the red peppers can affect international trade and cause significant economic burdens. Thus, the objective of this study was to assess the level of AFs contamination in packed powder (from supermarkets) and raw red pepper samples commercially available in the towns of Fiche and Mukaturi. Furthermore, this study aimed to determine the potential health and cancer risks associated with the consumption of red pepper contaminated with AFs. Red pepper samples (raw and packed powder) were collected randomly from the Fiche and Mukaturi open markets. Then AFs in the samples were extracted using methanol: water (80:20, v/v). These extract samples were then cleaned up using an immunoaffinity column (IAC) and determined with a high-performance liquid chromatography-fluorescence detector (HPLC-FLD). The finding showed that the amount of AFB1, AFB2, and AFG1 in raw red pepper was found to be 3.19 ± 0.01, 0.19 ± 0.001, and 4.07 ± 0.01 μg kg-1, respectively. The raw red pepper samples had a total of 7.66 ± 0.01 μg kg-1 of AFs. On the other hand, the amount of AFB1, AFB2, and AFG1 in Afiya-packed red pepper was found to be 7.04 ± 0.03, 2.15 ± 0.06, and 0.50 ± 0.01 μg kg-1, while Mudayi packed red pepper contained 31.60 ± 0.22, 24.40 ± 0.17, 3.37 ± 0.02 and 2.48 ± 0.004 μg kg-1 of aflatoxins, respectively. Afiya and Mudayi packed powder peppers had a total AFs content of 10.4 ± 0.07 and 61.90 ± 0.28 μg kg-1, respectively. The total AFs concentrations in packed pepper powder samples were higher than maximum toleratable limits (MTLs) set by the European Commission Regulation (EU) 2023/915 (5.00 μg kg-1 for AFB1 and 10 μg kg-1 for total AFs). AFB1 (31.60 ± 0.22 μg kg-1) had the highest level of contamination, followed by AFB2 (24.40 ± 0.17 μg kg-1) in packed pepper powder. In the adult population, the estimated daily intake (EDI) of AFB1, AFB2, AFG1, and AFG2 ranged from 0.80 to 7.90, 0.04 to 6.10, 0.02 to 1.02, and 0.05 to 0.62  μ g kg-1 body weight (bw) per day, respectively. However, the Margins of Exposure (MOE) values and combined Margin of Exposure (MoET) for these chemicals were significantly lower than the safe margin (<10 000). Therefore, this study highlights the potential health risks associated with consuming AFs-contaminated red peppers and the need for stricter regulations and monitoring to ensure food safety.

Mycobiome mediates the interaction between environmental factors and mycotoxin contamination in wheat grains

Environmental factors significantly impact grain mycobiome assembly and mycotoxin contamination. However, there is still a lack of understanding regarding the wheat mycobiome and the role of fungal communities in the interaction between environmental factors and mycotoxins. In this study, we collected wheat grain samples from 12 major wheat-producing provinces in China during both the harvest and storage periods. Our aim was to evaluate the mycobiomes in wheat samples with varying deoxynivalenol (DON) contamination levels and to confirm the correlation between environmental factors, the wheat mycobiome, and mycotoxins. The results revealed significant differences in the wheat mycobiome and co-occurrence network between contaminated and uncontaminated wheat samples. Fusarium was identified as the main differential taxon responsible for inducing DON contamination in wheat. Correlation analysis identified key factors affecting mycotoxin contamination. The results indicate that both environmental factors and the wheat mycobiome play significant roles in the production and accumulation of DON. Environmental factors can affect the wheat mycobiome assembly, and wheat mycobiome mediates the interaction between environmental factors and mycotoxin contamination. Furthermore, a random forest (RF) model was developed using key biological indicators and environmental features to predict DON contamination in wheat with accuracies exceeding 90 %. The findings provide data support for the accurate prediction of mycotoxin contamination and lay the foundation for the research on biological control technologies of mycotoxin through the assembly of synthetic microbial communities.

Self-assembled thymol-betaine co-crystals with controlled release and hygroscopic properties as green preservatives for aflatoxin prevention

Mycotoxins are representative contaminants causing food losses and food safety problems worldwide. Thymol can effectively inhibit pathogen infestation and aflatoxin accumulation during grain storage, but high volatility limits its application. Here, a thymol-betaine co-crystal system was synthesized through grinding-induced self-assembly. The THY-TMG co-crystal exhibited excellent thermal stability with melting point of 91.2 °C owing to abundant intermolecular interactions. Remarkably, after 15 days at 30 °C, the release rate of thymol from co-crystal was only 55%, far surpassing that of pure thymol. Notably, the co-crystal demonstrated the ability to bind H2O in the environment while controlling the release of thymol, essentially acting as a desiccant. Moreover, the co-crystals effectively inhibited the growth of Aspergillus flavus and the biosynthesis of aflatoxin B1. In practical terms, the THY-TMG co-crystal was successful in preventing AFB1 contamination and nutrients loss in peanuts, thereby prolonging their shelf-life under conditions of 28 °C and 70% RH.

Recent advances and challenges in the analysis of natural toxins

Natural toxins (NTs) are poisonous secondary metabolites produced by living organisms developed to ward off predators. Especially low molecular weight NTs (MW<∼1 kDa), such as mycotoxins, phycotoxins, and plant toxins, are considered an important and growing food safety concern. Therefore, accurate risk assessment of food and feed for the presence of NTs is crucial. Currently, the analysis of NTs is predominantly performed with targeted high pressure liquid chromatography tandem mass spectrometry (HPLC-MS/MS) methods. Although these methods are highly sensitive and accurate, they are relatively expensive and time-consuming, while unknown or unexpected NTs will be missed. To overcome this, novel on-site screening methods and non-targeted HPLC high resolution mass spectrometry (HRMS) methods have been developed. On-site screening methods can give non-specialists the possibility for broad "scanning" of potential geographical regions of interest, while also providing sensitive and specific analysis at the point-of-need. Non-targeted chromatography-HRMS methods can detect unexpected as well as unknown NTs and their metabolites in a lab-based approach. The aim of this chapter is to provide an insight in the recent advances, challenges, and perspectives in the field of NTs analysis both from the on-site and the laboratory perspective.

Fusarium mycotoxins: The major food contaminants

Mycotoxins, which are secondary metabolites produced by toxicogenic fungi, are natural food toxins that cause acute and chronic adverse reactions in humans and animals. The genus Fusarium is one of three major genera of mycotoxin-producing fungi. Trichothecenes, fumonisins, and zearalenone are the major Fusarium mycotoxins that occur worldwide. Fusarium mycotoxins have the potential to infiltrate the human food chain via contamination during crop production and food processing, eventually threatening human health. The occurrence and development of Fusarium mycotoxin contamination will change with climate change, especially with variations in temperature, precipitation, and carbon dioxide concentration. To address these challenges, researchers have built a series of effective models to forecast the occurrence of Fusarium mycotoxins and provide guidance for crop production. Fusarium mycotoxins frequently exist in food products at extremely low levels, thus necessitating the development of highly sensitive and reliable detection techniques. Numerous successful detection methods have been developed to meet the requirements of various situations, and an increasing number of methods are moving toward high-throughput features. Although Fusarium mycotoxins cannot be completely eliminated, numerous agronomic, chemical, physical, and biological methods can lower Fusarium mycotoxin contamination to safe levels during the preharvest and postharvest stages. These theoretical innovations and technological advances have the potential to facilitate the development of comprehensive strategies for effectively managing Fusarium mycotoxin contamination in the future.

Response of broilers to dietary inclusion of atoxigenic Aspergillus flavus strain as a biocontrol strategy of aflatoxin

The objective of this trial was to evaluate how broilers responded to Aspergillus flavus strains that are toxigenic and atoxigenic. The study included four treatments in a 2 × 2 factorial design, with six replicates of 10 birds each. As a result of this study measuring feed intake (FI), weight gain (WG), feed conversion ratio (FCR), crude protein, ether extract, and crude fibre, the interaction was insignificant between the toxigenic and atoxigenic diets (P > 0.05). Consumption of toxigenic aflatoxin B1-500 ppb diet decreased FI and WG but increased FCR, and cost to produce live broiler weight (P < 0.05) compared to the control diets. The addition of atoxigenic strains to contaminated diets significantly offset (P < 0.05) the effects. Diets with or without 500 ppb toxigenic and atoxigenic A. flavus did not affect the relative weight g/100gBW of pancreas, gizzard and bursa of Fabricius. Dietary inclusion of 500 ppb toxigenic Aspergillus spp. increased the relative weight (P < 0.05) of the kidney, liver, spleen and thymus while atoxigenic dietary addition reduced the relative weight of the same organs (P < 0.05). Dietary inclusion of toxigenic and atoxigenic Aspergillus spp. did not significantly affect the haematological parameters measured (P < 0.05). Dietary inclusion of 500 ppb toxigenic Aspergillus elevated the urea, creatine, alanine aminotransferase (ALT), aspartate aminotransferase (AST) and alkaline phosphatase (ALP) in the serum of the broilers (P < 0.05). A decrease was observed when atox igenic A. flavus was used in the intervention for urea, creatinine and AST (P < 0.05), whereas an insignificant reduction was observed for ALT and ALP (P ≤ 0.05). This study concluded that dietary atoxigenic strain improved broiler performance, digestibility, and blood parameters.

Fungal profile, levels of aflatoxin M1, exposure, and the risk characterization of local cheese 'wagashi' consumed in the Ho Municipality, Volta Region, Ghana

Wagashi is a West African type cottage cheese locally prepared from cow milk. Wagashi like other milk products, is prone to microbial contamination, particularly by fungi. Many of these fungal species produce mycotoxins which are of serious public health concern. This work aimed to update the mycoflora profile and determine the concentrations of aflatoxin M1 and its health risk characterization due to the consumption of wagashi. Culturing the wagashi on mycological media (Oxytetracycline Glucose Yeast Extract OGYE, Dichloran Rose Bengal Chloramphenicol DRBC) caused a de-novo growth of the quiescent spores at 28-30 °C for 5-7 days. The analysis of AFM1 levels in the samples was done using High-Performance Liquid Chromatography connected to a Fluorescence detector (HPLC-FLD). The exposure and risk assessment to the AFMI levels were determined using deterministic models prescribed by the European Food Safety Authority (EFSA). The fungal counts ranged between 2.36-4.30 log10 CFU/g. In total, thirteen (13) fungal species from eight (8) genera were isolated from all wagashi samples. They are; Fusarium oxysporum, Aspergillus flavus, Aspergillus niger, Fusarium verticillioides, Penicillium digitatum, Trichoderma harzianum, Aspergillus terreus, Rhodotorula mucilaginosa, Rhizopus stolonifer, Aspergillus fumigatus, Yeast sp., Mucor racemosus and Fusarium oligosporum belonging to the genera Fusarium, Aspergillus, Penicillium, Trichoderma, Rhodotorula, Rhizopus, Yeast, and Mucor. The AFM1 observed in the wagashi samples' analysis was low, ranging from 0.00 (Not Detected) ± 0.00 - 0.06 ± 0.002 µg/Kg. Risk assessments of AFM1 using deterministic models produced outcomes that ranged between 5.92 × 10-3- 0.14 ng/kg bw/day, 1.42 -44.35, 0-0.0323 ng aflatoxins/kg bw/day, and 1.51 × 10-3 - 9.69 × 10-4 cases/100,000 person/yr for estimated daily intake (EDI), margin of exposure (MOE), average potency, and cancer risks, respectively, for the age categories investigated. Fungal counts were interpreted as medium to high. It was also established that the consumption of wagashi may pose adverse health effects on all age categories in the selected zones of the study since all calculated MOE values were less than 100,000.

m6A methyltransferase AflIme4 orchestrates mycelial growth, development and aflatoxin B1 biosynthesis in Aspergillus flavus

Aflatoxin B1 (AFB1), a highly toxic secondary metabolite produced by Aspergillus flavus, poses a severe threat to agricultural production, food safety and human health. The methylation of mRNA m6A has been identified as a regulator of both the growth and AFB1 production of A. flavus. However, its intracellular occurrence and function needs to be elucidated. Here, we identified and characterized a m6A methyltransferase, AflIme4, in A. flavus. The enzyme was localized in the cytoplasm, and knockout of AflIme4 significantly reduced the methylation modification level of mRNA. Compared with the control strains, ΔAflIme4 exhibited diminished growth, conidial formation, mycelial hydrophobicity, sclerotium yield, pathogenicity and increased sensitivity to CR, SDS, NaCl and H2O2. Notably, AFB1 production was markedly inhibited in the A. flavus ΔAflIme4 strain. RNA-Seq coupled with RT-qPCR validation showed that the transcriptional levels of genes involved in the AFB1 biosynthesis pathway including aflA, aflG, aflH, aflK, aflL, aflO, aflS, aflV and aflY were significantly upregulated. Methylated RNA immunoprecipitation-qPCR (MeRIP-qPCR) analysis demonstrated a significant increase in m6A methylation modification levels of these pathway-specific genes, concomitant with a decrease in mRNA stability. These results suggest that AflIme4 attenuates the mRNA stability of genes in AFB1 biosynthesis by enhancing their mRNA m6A methylation modification, leading to impaired AFB1 biosynthesis. Our study identifies a novel m6A methyltransferase AflIme4 and highlights it as a potential target to control A. flavus growth, development and aflatoxin pollution.

Recent advances in nanomaterial-based optical biosensors for food safety applications: Ochratoxin-A detection, as case study

Global population growth tremendously impacts the global food industry, endangering food safety and quality. Mycotoxins, particularly Ochratoxin-A (OTA), emerge as a food chain production threat, since it is produced by fungus that contaminates different food species and products. Beyond this, OTA exhibits a possible human toxicological risk that can lead to carcinogenic and neurological diseases. A selective, sensitive, and reliable OTA biodetection approach is essential to ensure food safety. Current detection approaches rely on accurate and time-consuming laboratory techniques performed at the end of the food production process, or lateral-flow technologies that are rapid and on-site, but do not provide quantitative and precise OTA concentration measurements. Nanoengineered optical biosensors arise as an avant-garde solution, providing high sensing performance, and a fast and accurate OTA biodetection screening, which is attractive for the industrial market. This review core presents and discusses the recent advancements in optical OTA biosensing, considering engineered nanomaterials, optical transduction principle and biorecognition methodologies. Finally, the major challenges and future trends are discussed, and current patented OTA optical biosensors are emphasized for a particular promising detection method.

Understanding How Chemical Pollutants Arise and Evolve in the Brewing Supply Chain: A Scoping Review

In this study, a critical review was carried out using the Web of ScienceTM Core Collection database to analyse the scientific literature published to date to identify lines of research and future perspectives on the presence of chemical pollutants in beer brewing. Beer is one of the world's most popular drinks and the most consumed alcoholic beverage. However, a widespread challenge with potential implications for human and animal health is the presence of physical, chemical, and/or microbiological contaminants in beer. Biogenic amines, heavy metals, mycotoxins, nitrosamines, pesticides, acrylamide, phthalates, bisphenols, microplastics, and, to a lesser extent, hydrocarbons (aliphatic chlorinated and polycyclic aromatic), carbonyls, furan-derivatives, polychlorinated biphenyls, and trihalomethanes are the main chemical pollutants found during the beer brewing process. Pollution sources include raw materials, technological process steps, the brewery environment, and packaging materials. Different chemical pollutants have been found during the beer brewing process, from barley to beer. Brewing steps such as steeping, kilning, mashing, boiling, fermentation, and clarification are critical in reducing the levels of many of these pollutants. As a result, their residual levels are usually below the maximum levels allowed by international regulations. Therefore, this work was aimed at assessing how chemical pollutants appear and evolve in the brewing process, according to research developed in the last few decades.

An overview of mycotoxicoses in rabbits

Mycotoxicoses are usually a consideration in large animal species but can affect companion animals as well. Due to increasing interest and the ease of using rabbits as laboratory models, a growing number of published experimental studies discuss the effects of various mycotoxins on this species. However, the available evidence is fragmented and heterogeneous, and has not recently been collated in a review, to my knowledge. Although mycotoxicoses in rabbits are typically subclinical, clinical signs can include weight loss, anorexia, gastrointestinal disorders, stunted growth, reproductive abnormalities, and susceptibility to infections. An antemortem diagnosis typically relies on a comprehensive clinical history, and assessment of clinical signs and relevant laboratory findings, with confirmation of exposure achieved through the measurement of mycotoxin concentrations in feed or target organs. My review focuses on the clinicopathologic and histopathologic effects of the mycotoxins most important in rabbits, including fumonisins, ochratoxins, aflatoxins, trichothecenes, and zearalenone. This review offers a thorough overview of the effects of mycotoxins in rabbits, serving as a one-stop resource for veterinary practitioners, diagnosticians, and researchers.

Aflatoxins in maize and groundnuts on markets in Accra and consumers risk

This study presents the results of aflatoxin contamination of maize and groundnuts in major markets in Accra and assesses the population's exposure to aflatoxins. Raw maize and groundnuts from 6 major markets in Accra were sampled and analysed for their aflatoxin content. A total of 92 samples comprising 48 maize and 44 groundnuts were analysed using high-performance liquid chromatography, after extraction with methanol/water and cleanup on an immunoaffinity column. Total aflatoxins were quantified in 98% of the maize samples and 70% of the groundnut samples, with concentrations ranging from 0.60 to 1065 µg/kg and 0.20 to 627 µg/kg, respectively. Exposure assessment showed an estimated daily intake of 0.436 μg/kg bw/day and 0.0632 μg/kg bw/day for maize and groundnut consumption, respectively, suggesting significant health risks for consumers. The high prevalence and concentrations of aflatoxins call for an urgent need for measures to control exposure of the Ghanaian population.

Influence of regional and yearly weather patterns on multi-mycotoxin occurrence in Austrian wheat: a liquid chromatographic-tandem mass spectrometric and multivariate statistics approach

BACKGROUND

Mycotoxin surveys play an essential role in our food safety system. The obtained occurrence data form the basis for the assessment of the exposure of humans and animals to these toxic fungal secondary metabolites. Liquid chromatography coupled with tandem mass spectrometry (LC-MS/MS) has become the gold standard for mycotoxin determination because it enables selective and sensitive multi-toxin analysis. Simultaneous determination of several hundreds of secondary fungal metabolites is feasible using this technique. In this study, we combined a targeted dilute-and-shoot LC-MS/MS-based multi-analyte approach with multivariate statistics for the analysis of Austrian wheat from two different years and different geographical origins.

RESULTS

We quantified 47 secondary fungal metabolites, including regulated emerging and masked mycotoxins. The resulting multi-mycotoxin occurrence data were further analyzed using both multivariate and univariate statistics. Principal component analysis (PCA) and analysis of variance (ANOVA) simultaneous component analysis (ASCA) were employed to identify regional and yearly trends within the dataset and to quantify the variance in metabolite occurrence attributed to the different effects. In addition, secondary fungal metabolites significantly impacted by these factors were selected via ANOVA. Of the 47 secondary metabolites identified, 39 were affected by the year, region or a combined effect. Moreover, our findings show that 43 of the secondary fungal metabolites were significantly influenced by the weather conditions.

CONCLUSION

The results presented in this study underline the added value of combining targeted LC-MS/MS with multivariate statistics for monitoring a broad spectrum of secondary fungal metabolites in food crops. Through multivariate statistics, trends associated with the year or region can be readily studied. The approach presented could pave the way for a better understanding of the impact of climate change on plant pathogenic fungi and its implications for food safety. © 2024 The Author(s). Journal of The Science of Food and Agriculture published by John Wiley & Sons Ltd on behalf of Society of Chemical Industry.

The role of larvae of black soldier fly and house fly and of feed substrate microbes in biotransformation of aflatoxin B1

Over the past few years, there has been growing interest in the ability of insect larvae to convert various organic side-streams containing mycotoxins into insect biomass that can be used as animal feed. Various studies have examined the effects of exposure to aflatoxin B1 (AFB1) on a variety of insect species, including the larvae of the black soldier fly (BSFL; Hermetia illucens L.; Diptera: Stratiomyidae) and the housefly (HFL; Musca domestica L.; Diptera: Muscidae). Most of these studies demonstrated that AFB1 degradation takes place, either enzymatic and/or non-enzymatic. The possible role of feed substrate microorganisms (MOs) in this process has thus far not been investigated. The main objective of this study was therefore to investigate whether biotransformation of AFB1 occurred and whether it is caused by insect-enzymes and/or by microbial enzymes of MOs in the feed substrate. In order to investigate this, sterile and non-sterile feed substrates were spiked with AFB1 and incubated either with or without insect larvae (BSFL or HFL). The AFB1 concentration was determined via LC-MS/MS analyses and recorded over time. Approximately 50% of the initially present AFB1 was recovered in the treatment involving BSFL, which was comparable to the treatment without BSFL (60%). Similar patterns were observed for HFL. The molar mass balance of AFB1 for the sterile feed substrates with BSFL and HFL was 73% and 78%, respectively. We could not establish whether non-enzymatic degradation of AFB1 in the feed substrates occurred. The results showed that both BSFL and substrate-specific MOs play a role in the biotransformation of AFB1 as well as in conversion of AFB1 into aflatoxin P1 and aflatoxicol, respectively. In contrast, HFL did not seem to contribute to AFB1 degradation. The obtained results contribute to our understanding of aflatoxin metabolism by different insect species. This information is crucial for assessing the safety of feeding fly larvae with feed substrates contaminated with AFB1 with the purpose of subsequent use as animal feed.

Development of a microfluidic device to enrich and detect zearalenone in food using quantum dot-embedded molecularly imprinted polymers

Mycotoxins are secondary metabolites of certain moulds, prevalent in 60-80% of food crops and many processed products but challenging to eliminate. Consuming mycotoxin-contaminated food and feed can lead to various adverse effects on humans and livestock. Therefore, testing mycotoxin residue levels is critical to ensure food safety. Gold standard analytical methods rely on liquid chromatography coupled with optical detectors or mass spectrometers, which are high-cost with limited capacity. This study reported the successful development of a microfluidic "lab-on-a-chip" device to enrich and detect zearalenone in food samples based on the fluorescence quenching effect of quantum dots and selective affinity of molecularly imprinted polymers (MIPs). The dummy template and functional polymer were synthesized and characterized, and the detailed microfluidic chip design and optimization of the flow conditions in the enrichment module were discussed. The device achieved an enrichment factor of 9.6 (±0.5) in 10 min to quantify zearalenone spiked in food with high recoveries (91-105%) at 1-10 mg kg-1, covering the concerned residue levels in the regulations. Each sample-to-answer test took only 20 min, involving 3 min of manual operation and no advanced equipment. This microfluidic device was mostly reusable, with a replaceable detection module compatible with fluorescence measurement using a handheld fluorometer. To our best knowledge, the reported device was the first application of an MIP-based microfluidic sensor for detecting mycotoxin in real food samples, providing a novel, rapid, portable, and cost-effective tool for monitoring mycotoxin contamination for food safety and security.

One-Pot Preparation of Mixed-Mode Reversed-Phase Anion-Exchange Silica Sorbent and its Application in the Detection of Cyclopiazonic Acid in Feeds and Agricultural Products

A novel co-bonded octyl and pyridine silica (OPS) sorbent was prepared and applied for the solid phase extraction (SPE) of cyclopiazonic acid (CPA, a type of mycotoxin) in feed and agricultural products for the first time. A simple mixed-ligand one-pot reaction strategy was employed for OPS sorbent preparation. Nitrogen adsorption-desorption measurements, elemental analysis (EI), thermal gravimetric analysis (TGA), and Fourier transform infrared spectroscopy (FT-IR) analysis demonstrated the successful immobilization of octyl and quaternary ammonium groups onto the surface of silica gel. The large specific surface area, high-density functional groups, and mixed-mode anion-exchange characteristics of these silica particles made them the ideal material for the efficient extraction of CPA. Additionally, the OPS sorbents displayed excellent batch-to-batch reproducibility, satisfactory reusability, and low cost. The SPE parameters were optimized to explore the ionic and hydrophobic interactions between CPA and the functional groups, and the ultra-high performance liquid chromatography coupled with triple-quadrupole tandem mass spectrometry (UPLC-MS/MS) parameters were optimized to obtain a desirable extraction efficiency and high sensitivity to CPA. Meanwhile, the OPS sorbent presented a satisfactory extraction selectivity and low matrix effect. Under the optimized conditions, our developed CPA detection method was used to determine CPA level in rice, wheat flour, corn flour, peanut, and feed samples, exhibiting a lower detection limit, better linearity, higher sensitivity, and satisfactory extraction recovery rate than previously reported methods. Therefore, our method can be preferentially used as a method for the detection of CPA in agricultural products and feeds.

Monitoring Mycotoxin Exposure in Food-Producing Animals (Cattle, Pig, Poultry, and Sheep)

Food-producing animals are exposed to mycotoxins through ingestion, inhalation, or dermal contact with contaminated materials. This exposure can lead to serious consequences for animal health, affects the cost and quality of livestock production, and can even impact human health through foods of animal origin. Therefore, controlling mycotoxin exposure in animals is of utmost importance. A systematic literature search was conducted in this study to retrieve the results of monitoring exposure to mycotoxins in food-producing animals over the last five years (2019-2023), considering both external exposure (analysis of feed) and internal exposure (analysis of biomarkers in biological matrices). The most commonly used analytical technique for both approaches is LC-MS/MS due to its capability for multidetection. Several mycotoxins, especially those that are regulated (ochratoxin A, zearalenone, deoxynivalenol, aflatoxins, fumonisins, T-2, and HT-2), along with some emerging mycotoxins (sterigmatocystin, nivalenol, beauvericin, enniantins among others), were studied in 13,818 feed samples worldwide and were typically detected at low levels, although they occasionally exceeded regulatory levels. The occurrence of multiple exposure is widespread. Regarding animal biomonitoring, the primary objective of the studies retrieved was to study mycotoxin metabolism after toxin administration. Some compounds have been suggested as biomarkers of exposure in the plasma, urine, and feces of animal species such as pigs and poultry. However, further research is required, including many other mycotoxins and animal species, such as cattle and sheep.

Seasonal variation of mycotoxin levels in poultry feeds and feed ingredients in Oyo State, Nigeria

Mycotoxins pose a major problem to poultry production as a result of feed contamination which has deleterious consequences such as production losses and human health risks. A total of 158 chicken feed samples were randomly collected from 46 consenting poultry farms in Oyo State throughout the wet season (April-October; 91 samples) and the dry season (November-March; 67 samples), including compounded feed (n = 129) and feed ingredients (n = 29). Samples were promptly transported to the laboratory in sterile plastic vials for lateral flow assay for mycotoxins using six different commercial mycotoxin test kits each for aflatoxin B1, zearalenone, deoxynivalenol, ochratoxin A, fumonisin, and T-2 toxin/HT-2 toxin. Summary values of mycotoxin levels (µg/kg) in the feedstuffs were represented as frequency or median (and range). Fisher exact or Mann-Whitney U tests were carried out where appropriate at α = 0.05. Every sample contained at least four mycotoxins. Aflatoxins and fumonisin co-occurred in 80% of the samples. Aflatoxin and fumonisin concentrations were above the permissible limits in 32.9% and 18.4% respectively in feedstuff sampled in the dry season while the values were 17.1% and 6.3% respectively during the wet season. Among feed ingredients, peanut cake and maize had the highest median concentration of aflatoxin and fumonisin, respectively. Median aflatoxin concentration in the feedstuff was significantly higher than the permissible limit irrespective of season. There is a need to frequently monitor mycotoxin levels of feed and feed ingredients and improve storage system for feed ingredients in order to reduce the risk associated with high mycotoxin intake in poultry.

Macrophage AHR-TLR4 cross-talk drives p-STAT3 (Ser727)-mediated mitochondrial oxidative stress and upregulates IDO/ICAM-1 in the steatohepatitis induced by aflatoxin B1

Aflatoxin B1 (AFB1) is a major mycotoxin contaminant showing in the environment and foods. In this study, the molecular initiating events (MIEs) of AFB1-induced steatohepatitis were explored in mice and human cell model. We observed dose-dependent steatohepatitis in the AFB1-treated mice, including triglyceride accumulation, fibrotic collagen secretion, enrichment of CD11b + and F4/80+ macrophages/Kupffer cells, cell death, lymphocytes clusters and remarkable atrophy areas. The gut barrier and gut-microbiota were also severely damaged after the AFB1 treatment and pre-conditioned colitis in the experimental mice aggravated the steatohepatitis phenotypes. We found that macrophages cells can be pro-inflammatorily activated to M1-like phenotype by AFB1 through an AHR/TLR4/p-STAT3 (Ser727)-mediated mitochondrial oxidative stress. The phenotypes can be rescued by AHR inhibitors in the mice model and human cell model. We further showed that this signaling axis is based on the cross-talk interaction between AHR and TLR4. Gene knock-up experiment found that the signaling is dependent on AFB1 ligand-binding with AHR, but not protein expressions of TLR4. The signaling elevated NLRP3 and two immune metabolic enzymes ICAM-1 and IDO that are associated with macrophage polarization. Results from intervention experiments with natural anti-oxidant and AHR inhibitor CH223191 suggest that the macrophage polarization may rely on AHR and ROS. Our study provides novel and critical references to the food safety and public health regulation of AFB1.

Genotoxic and cytotoxic effects of aflatoxin on the reproductive system: Focus on cell cycle dynamics and apoptosis in testicular tissue

Aflatoxins (AFs) are inevitable environmental contaminants that are detrimental to human and animal health. AFs interfere with metabolic processes, metabolizing into different hydroxylated derivatives in the liver, as well as mechanistically induce ROS accumulation, S-phase arrest, DNA damage, and cell apoptosis. Chronic consumption of aflatoxin-contaminated foods can adversely affect the male reproductive system, cause testicular damage, prevent testosterone synthesis, decline sperm quality, and cause infertility. Oxidative stress is the fundamental pathogenesis of aflatoxin-induced reproductive toxicity. The overproduction of reactive oxygen substances can cause testicular failure and disturb the process of spermatogenesis. Mitochondria are susceptible to being impaired by oxidative stress, and its damage is associated with infertility. AFs also disturb the process of spermatogenesis by disrupting the regulation of genes related to the progression of the cell cycle such as cyclins and inducing genes related to apoptosis, thereby weakening fertility and negatively affecting the testicular endocrine potential by suppressing androgen synthesis. Additionally, AFs downregulate ERα expression, potentially negatively impacting spermatogenesis by enhancing the apoptotic mechanism. In this review, we provide new insights into the genotoxic and cytotoxic effects of AFB1 on the male reproductive system with a focus on the cell cycle and apoptosis destruction of testicular tissue.

A facile dual-mode immunosensor based on speckle Ag-doped nanohybrids for ultrasensitive detection of Ochratoxin A

Ochratoxin A (OTA) is a potent carcinogen, and is among the most dangerous mycotoxins in agricultural products. In this study, an ultrasensitive dual-mode immunosensor was developed for naked-eye and fluorescence detection of OTA based on Ag-doped core-shell nanohybrids (Ag@CSNH). Complete antigen-labeled Ag@CSNH (CA-Ag@CSNH) were used as a competitive bind and dual-mode probe. The diffused doping structure of CA-Ag@CSNH provided improved stability, color and fluorescence quencher performance. Antibodies modified magnetic beads were used as a capture probe. The competitive binding between OTA and CA-Ag@CSNH produced both color change and fluorescence quenching. Ultraviolet and fluorescence intensitie correlated linearly with OTA concentration ranges of 0.03-3 ng/mL and 10-10000 pg/mL, and limits of detection of 0.0235 ng/mL and 0.9921 pg/mL, respectively. The practical applicability of proposed strategy was demonstrated by analysis of OTA in spiked corn, soybean and flour samples. This study offers a new insight on multi-mode platforms for various applications.

Targeting of Antifungal Metabolites from Grapevine Byproducts by UPLC-HRMS/MS Approaches Using Bioactivity-Based Molecular Networking

This study focuses on countering Fusarium graminearum, a harmful fungal pathogen impacting cereal crops and human health through mycotoxin production. These mycotoxins, categorized as type B trichothecenes, pose significant health risks. Research explores natural alternatives to synthetic fungicides, particularly investigating phenolics in grapevine byproducts. Thirteen eco-extracts from five French grape varieties (Merlot, Cabernet Sauvignon, Sauvignon blanc, Tannat, and Artaban) exhibited substantial antifungal properties, with ten extracts displaying remarkable effects. Extracts from grapevine stems and roots notably reduced fungal growth by over 91% after five days. Through UHPLC-HRMS/MS analysis and metabolomics, the study identified potent antifungal compounds such as ampelopsin A and cyphostemmin B, among other oligomeric stilbenes. Interestingly, this approach showed that flavan-3-ols have been identified as markers for extracts that induce fungal growth. Root extracts from rootstocks, rich in oligostilbenes, demonstrated the highest antifungal activity. This research underscores grapevine byproducts' potential both as a sustainable approach to control F. graminearum and mycotoxin contamination in cereal crops and the presence of different metabolites from the cultivars of grapevine, suggesting different activities.

Climate Change and Mycotoxins Trends in Serbia and Croatia: A 15-Year Review

This review examines the 15-year presence of mycotoxins in food from Serbia and Croatia to provide a comprehensive overview of trends. Encompassing the timeframe from 2009 to 2023, this study integrates data from both countries and investigates climate change patterns. The results from Serbia focus primarily on maize and milk and show a strong dependence of contamination on weather conditions. However, there is limited data on mycotoxins in cereals other than maize, as well as in other food categories. Conversely, Croatia has a broader spectrum of studies, with significant attention given to milk and maize, along with more research on other cereals, meat, and meat products compared to Serbia. Over the investigated 15-year period, both Serbia and Croatia have experienced notable shifts in climate, including fluctuations in temperature, precipitation, and humidity levels. These changes have significantly influenced agriculture, consequently affecting the occurrence of mycotoxins in various food products. The results summarized in this 15-year review indicate the urgent need for further research and action to address mycotoxins contamination in Serbian and Croatian food supply chains. This urgency is further emphasized by the changing climatic conditions and their potential to exacerbate public health and food safety risks associated with mycotoxins.

Dietary chamomile flowers extract improved performance and mitigated aflatoxin B1 toxicity in rabbits

Aflatoxin B1 (AFB1) is among the poisonous mycotoxins that contaminate food and feed. Limited studies are available on the efficacy of chamomile (Cha) against oxidative stress, liver damage and pro-inflammatory response induced by AFB1. The present study aims to evaluate the effects of Cha on the performance and protective effects against AFB1 in growing rabbits. The experimental rabbits were divided into four different groups, including Cha (70 mg kg day-1), AFB1 (AF; 30 μg kg day-1), AFB1+Cha (AFLCha) and control (CON). The results indicated that the AFB1 treatment had lower values of performance, and carcass parameters compared to the Cha and AFLCha treatments. Furthermore, the Cha and AFLCha groups had lower values of liver and kidney function activities compared to the AFB1 treatment. The higher values of antioxidant enzymes were observed in Cha and AFLCha treatments than in the AFB1 treatment. AFB1 treatments had higher levels of malondialdehyde and liver functions with lower levels of antioxidant enzymes (glutathione and superoxide dismutase) compared to Cha and CON groups. In conclusion, dietary Cha could mitigate the oxidative stress of AFB1-induced liver deterioration.

What do We Know about Cryptic Aspergillosis?

Cryptic Aspergillus species are increasingly recognized as pathogens involved in human disease. They are ubiquitarian fungi with high tenacity in their environment and can express various resistance mechanisms, often due to exposure to antifungal agents employed in agriculture and farming. The identification of such species is increasing thanks to molecular techniques, and a better description of this type of pathogen is granted. Nevertheless, the number of species and their importance in the clinical setting still need to be well studied. Furthermore, their cross-sectional involvement in animal disease, plants, and human activities requires a multidisciplinary approach involving experts from various fields. This comprehensive review aims to provide a sharp vision of the cryptic Aspergillus species, from the importance of correct identification to the better management of the infections caused by these pathogens. The review also accentuates the importance of the One Health approach for this kind of microorganism, given the interconnection between environmental exposure and aspergillosis, embracing transversely the multidisciplinary process for managing the cryptic Aspergillus species. The paper advocates the need for improving knowledge in this little-known species, given the burden of economic and health implications related to the diffusion of these bugs.

First Synthesis of Ergotamine-13CD3 and Ergotaminine-13CD3 from Unlabeled Ergotamine

Ergot alkaloids (EAs) formed by Claviceps fungi are one of the most common food contaminants worldwide, affecting cereals such as rye, wheat, and barley. To accurately determine the level of contamination and to monitor EAs maximum levels set by the European Union, the six most common EAs (so-called priority EAs) and their corresponding epimers are quantified using high-performance liquid chromatography coupled with tandem mass spectrometry (HPLC-MS/MS). The quantification of EAs in complex food matrices without appropriate internal standards is challenging but currently carried out in the standard method EN 17425:2021 due to their commercial unavailability. To address the need for isotopically labeled EAs, we focus on two semi-synthetic approaches for the synthesis of these reference standards. Therefore, we investigate the feasibility of the N6-demethylation of native ergotamine to yield norergotamine, which can subsequently be remethylated with an isotopically labeled methylating reagent, such as iodomethane (13CD3-I), to yield isotopically labeled ergotamine and its C8-epimer ergotaminine. Testing the isotopically labeled ergotamine/-inine against native ergotamine/-inine with HPLC coupled to high-resolution HR-MS/MS proved the structure of ergotamine-13CD3 and ergotaminine-13CD3. Thus, for the first time, we can describe their synthesis from unlabeled, native ergotamine. Furthermore, this approach is promising as a universal way to synthesize other isotopically labeled EAs.

Prediction of Deoxynivalenol Contamination in Wheat via Infrared Attenuated Total Reflection Spectroscopy and Multivariate Data Analysis

The climate crisis further exacerbates the challenges for food production. For instance, the increasingly unpredictable growth of fungal species in the field can lead to an unprecedented high prevalence of several mycotoxins, including the most important toxic secondary metabolite produced by Fusarium spp., i.e., deoxynivalenol (DON). The presence of DON in crops may cause health problems in the population and livestock. Hence, there is a demand for advanced strategies facilitating the detection of DON contamination in cereal-based products. To address this need, we introduce infrared attenuated total reflection (IR-ATR) spectroscopy combined with advanced data modeling routines and optimized sample preparation protocols. In this study, we address the limited exploration of wheat commodities to date via IR-ATR spectroscopy. The focus of this study was optimizing the extraction protocol for wheat by testing various solvents aligned with a greener and more sustainable analytical approach. The employed chemometric method, i.e., sparse partial least-squares discriminant analysis, not only facilitated establishing robust classification models capable of discriminating between high vs low DON-contaminated samples adhering to the EU regulatory limit of 1250 μg/kg but also provided valuable insights into the relevant parameters shaping these models.

How does active yeast supplementation reduce the deleterious effects of aflatoxins in Wistar rats? A radiolabeled assay and histopathological study

The aim of this study was to investigate the mechanisms by which yeasts (Saccharomyces cerevisiae) control the toxic effects of aflatoxins, which are not yet fully understood. Radiolabeled aflatoxin B1 (AFB13H) was administered by gavage to Wistar rats fed with aflatoxin (AflDiet) and aflatoxin supplemented with active dehydrated yeast Y904 (AflDiet + Yeast). The distribution of AFB13H and its metabolites were analyzed at 24, 48 and 72 h by tracking back of the radioactivity. No significant differences were observed between the AflDiet and AflDiet + Yeast groups in terms of the distribution of labeled aflatoxin. At 72 h, for the AflDiet group the radiolabeled aflatoxin was distributed as following: feces (79.5%), carcass (10.5%), urine (1.7%), and intestine (7.4%); in the AflDiet + Yeast the following distribution was observed: feces (76%), carcass (15%), urine (2.9%), and intestine (4.9%). These values were below 1% in other organs. These findings indicate that even after 72 h considerable amounts of aflatoxins remains in the intestines, which may play a significant role in the distribution and metabolism of aflatoxins and its metabolites over time. The presence of yeast may not significantly affect this process. Furthermore, histopathological examination of hepatic tissues showed that the presence of active yeast reduced the severity of liver damage caused by aflatoxins, indicating that yeasts control aflatoxin damage through biochemical mechanisms. These findings contribute to a better understanding of the mechanisms underlying the protective effects of yeasts against aflatoxin toxicity.

Lycopene as a Therapeutic Agent against Aflatoxin B1-Related Toxicity: Mechanistic Insights and Future Directions

Aflatoxin (AFT) contamination poses a significant global public health and safety concern, prompting widespread apprehension. Of the various AFTs, aflatoxin B1 (AFB1) stands out for its pronounced toxicity and its association with a spectrum of chronic ailments, including cardiovascular disease, neurodegenerative disorders, and cancer. Lycopene, a lipid-soluble natural carotenoid, has emerged as a potential mitigator of the deleterious effects induced by AFB1 exposure, spanning cardiac injury, hepatotoxicity, nephrotoxicity, intestinal damage, and reproductive impairment. This protective mechanism operates by reducing oxidative stress, inflammation, and lipid peroxidation, and activating the mitochondrial apoptotic pathway, facilitating the activation of mitochondrial biogenesis, the endogenous antioxidant system, and the nuclear factor erythroid 2-related factor 2 (Nrf2)/kelch-like ECH-associated protein 1 (KEAP1) and peroxisome proliferator-activated receptor-γ coactivator-1 (PGC-1) pathways, as well as regulating the activities of cytochrome P450 (CYP450) enzymes. This review provides an overview of the protective effects of lycopene against AFB1 exposure-induced toxicity and the underlying molecular mechanisms. Furthermore, it explores the safety profile and potential clinical applications of lycopene. The present review underscores lycopene's potential as a promising detoxification agent against AFB1 exposure, with the intent to stimulate further research and practical utilization in this domain.