Physicochemical stability profile of Tulane virus: a human norovirus surrogate

Evaluating the Potential of Ozone Microbubbles for Inactivation of Tulane Virus, a Human Norovirus Surrogate

This study investigated the efficacy of low-dose ozone microbubble solution and conventional aqueous ozone as inactivation agents against Tulane virus samples in water over a short period of time. Noroviruses are the primary cause of foodborne illnesses in the US, and the development of effective inactivation agents is crucial. Ozone has a high oxidizing ability and naturally decomposes to oxygen, but it has limitations due to its low dissolution rate, solubility, and stability. Ozone microbubbles have been promising in enhancing inactivation, but little research has been done on their efficacy against noroviruses. The study examined the influence of the dissolved ozone concentration, inactivation duration, and presence of organic matter during inactivation. The results showed that ozone microbubbles had a longer half-life (14 ± 0.81 min) than aqueous ozone (3 ± 0.35 min). After 2, 10, and 20 min postgeneration, the ozone concentration of microbubbles naturally decreased from 4 ppm to 3.2 ± 0.2, 2.26 ± 0.19, and 1.49 ± 0.23 ppm and resulted in 1.43 ± 0.44, 0.88 ± 0.5, and 0.68 ± 0.53 log10 viral reductions, respectively, while the ozone concentration of aqueous ozone decreased from 4 ppm to 2.52 ± 0.07, 0.43 ± 0.05, and 0.09 ± 0.01 ppm and produced 0.8 ± 0.28, 0.29 ± 0.41, and 0.16 ± 0.21 log10 reductions against Tulane virus, respectively (p = 0.0526), suggesting that structuring of ozone in the bubbles over the applied treatment conditions did not have a significant effect, though future study with continuous generation of ozone microbubbles is needed.

Hydroponic Nutrient Solution Temperature Impacts Tulane Virus Persistence over Time

Controlled environment agriculture (CEA), or indoor agriculture, encompasses non-traditional farming methods that occur inside climate-controlled structures (e.g., greenhouses, warehouses, high tunnels) allowing for year-round production of fresh produce such as leaf lettuce. However, recent outbreaks and recalls associated with hydroponically grown lettuce contaminated with human pathogens have raised concerns. Few studies exist on the food safety risks during hydroponic cultivation of leaf lettuce; thus, it is important to identify contributing risk factors and potential mitigation strategies to prevent foodborne transmission via hydroponically grown produce. In this study, the concentration of infectious Tulane virus (TV), a human norovirus surrogate, in hydroponic nutrient solution at 15 °C, 25 °C, 30 °C, and 37 °C was determined over a duration of 21 days to mimic the time from seedling to mature lettuce. The mean log PFU reduction for TV was 0.86, 1.80, 2.87, and ≥ 3.77 log10 at 15 °C, 25 °C, 30 °C, and 37 °C, respectively, at the end of the 21-day period. Similarly, average decimal reduction values (D-values) of TV at 15 °C, 25 °C, 30 °C, and 37 °C were 48.0, 11.3, 8.57, and 7.02 days, respectively. This study aids in the (i) identification of possible food safety risks associated with hydroponic systems specifically related to nutrient solution temperature and (ii) generation of data to perform risk assessments within CEA leaf lettuce operations to inform risk management strategies for the reduction of foodborne outbreaks, fresh produce recalls, and economic losses.

Tulane Virus Persistence and Microbial Stability in 3D Food Ink under Various Storage Conditions: A Pre- and Post-Printing Analysis

3D food printers facilitate novel customization of the physicochemical properties of food. This study aimed to investigate the impact of storage conditions on the inactivation of the human norovirus surrogate, Tulane virus (TuV), within 3D printed foods. TuV-inoculated protein cookie food ink (∽ 4 log PFU/g) was distributed into 18 3D food printer capsules (50 g each); half immediately underwent extrusion. Storage of the capsules and printed food products at 20 °C (0, 6, 12, and 24 h), 4 °C (0, 1, 3, and 5d), and - 18 °C (0, 1, 3, and 5d) was completed before analysis for TuV via plaque assays in addition to aerobic plate count, yeast and mold counts, and pH and water activity (aw) measurements. A significant 3-way interaction effect was observed between time, temperature, and storage method (capsule/print) (p = 0.006). Significant findings include: (1) A greater reduction in virions was observed in capsules after 24 h at 20 °C and (2) a substantial reduction in virions at 4 °C from day 0 to day 1 was observed, independent of storage method. Microbial indicators remained steady across temperatures, with storage temperature significantly impacting pH and aw. A significant two-way interaction effect (p = 0.006) was found between microorganism type (yeast/aerobic counts) and temperature. This research seeks to provide insights for the food industry and regulatory bodies in crafting guidelines for the safe storage and handling of 3D printed foods and inks.

Human Norovirus Surrogate Is Highly Stable in Berry Smoothies and under In Vitro Simulated Digestion

Human noroviruses are major causes of foodborne outbreaks linked to berries. The overall goal of this study was to investigate the persistence of a human norovirus surrogate, Tulane virus (TV), in berry smoothies and under simulated digestion through the gastrointestinal track. Two types of smoothies were prepared from blueberries and strawberries. Tulane virus was spiked into each smoothie and incubated either at 37 or 4 °C for 2, 60, and 120 min. Furthermore, the virus-spiked smoothies were subjected to sequential oral (2 min), gastric (10 and 60 min), and intestinal (15 and 120 min) digestion according to the standardized INFOGEST model. Quantification of infectious TV was carried out using the TCID50 assay. At 4 °C, in both berry smoothies, TV infectivity did not show significant changes throughout the 120 min period. At 37 °C, TV infectivity showed significant reduction (~0.5 log TCID50/mL) only in blueberry smoothies starting at 60 min. During the oral, gastric, and intestinal digestion phases, the mean log reduction in TV infectivity in blueberry did not exceed ~0.5 log, while infectious TV in strawberry smoothies under all phases was stable. Given the notable stability of infectious viruses in berry smoothies and the gastrointestinal tract, prevention of norovirus contamination of berries is paramount to reduce virus outbreaks linked to berries.

Transfer rates of Salmonella Typhimurium, Listeria monocytogenes, and a human norovirus surrogate impacted by macronutrient composition of food inks in 3D food printing systems

3D food printers (3DFPs) allow for the customization of the physiochemical properties of foods in new ways. Transfer kinetics of foodborne pathogens between surfaces and food inks have not been evaluated in 3DFPs. This study aimed to determine if the macromolecular composition of food inks would impact the transfer rate of foodborne pathogens from the stainless steel food ink capsule to the 3D printed food. Salmonella Typhimurium, Listeria monocytogenes, and a human norovirus surrogate, Tulane virus (TuV), were inoculated onto the interior surface of stainless steel food ink capsules and dried for 30 min. Subsequently, 100 g of one of the following prepared food inks was extruded: (1) pure butter, (2) a powdered sugar solution, (3) a protein powder solution, and (4) a 1:1:1 ratio of all three macromolecules. Pathogen enumeration was completed for both the soiled capsules and the printed food products and resulting transfer rates were estimated using a generalized linear model with quasibinomial errors. A significant two-way interaction effect was found between microorganism type and food ink type (P = 0.0002). Tulane virus was typically transferred the most, and no significant differences between L. monocytogenes and S. Typhimurium were observed for any food matrix or across food matrices. Among food matrices, the complex mixture transferred fewer microorganisms in all instances, while butter, protein, and sugar were all statistically indistinguishable. This research seeks to further develop the field of 3DFP safety and to advance the understanding of the role of macromolecular composition in pathogen transfer kinetics, which have not previously been explored in pure matrices.

Antiviral Effects of Quillaja saponaria Extracts Against Human Noroviral Surrogates

Aqueous extracts of Quillaja saponaria Molina are US FDA approved as food additives in beverages with known antiviral activity. Due to lack of commercially available vaccines against human noroviruses (HNoVs), alternate methods to prevent their spread and the subsequent emergence of variant strains are being researched. Furthermore, HNoVs are not yet culturable at high enough titers to determine inactivation, therefore surrogates continue to be used. This research analyzed the effect of aqueous Quillaja saponaria extracts (QE) against HNoV surrogates, Tulane virus (TV), murine norovirus (MNV-1), and feline calicivirus (FCV-F9) at room temperature (RT) and 37 °C. Viruses (~ 5 log PFU/mL) were individually treated with 1:1 or 1:5 (v/v) diluted QE (pH ~ 3.75), malic acid control (pH 3.0) or phosphate-buffered saline (pH 7.2, as control) at 37 °C or RT for up to 6 h. Individual treatments were replicated three times using duplicate plaque assays for each treatment. FCV-F9 at ~ 5 log PFU/mL was not detectable after 15 min by 1:1 QE at 37 °C and RT. At RT, 1:5 QE lowered FCV-F9 titers by 2.05, 2.14 and 2.74 log PFU/mL after 0.5 h, 1 h and 2 h, respectively. MNV-1 showed marginal reduction of < 1 log PFU/mL after 15 min with 1:1 or 1:5 QE at 37 °C without any significant reduction at RT, while TV titers decreased by 2.2 log PFU/mL after 30 min and were undetectable after 3 h at 37 °C. Longer incubation with higher QE concentrations may be required for improved antiviral activity against MNV-1 and TV.

Microgreen Variety Impacts Leaf Surface Persistence of a Human Norovirus Surrogate

Human norovirus (HuNoV) is a pathogenic agent that is frequently associated with foodborne disease outbreaks linked to fresh produce. Within microgreen production systems, understanding of virus transmission routes and persistence is limited. To investigate virus persistence on microgreen leaf surfaces, this study mimicked virus contaminations caused during microgreen handling by farm workers or during overhead irrigation with contaminated water. Specifically, approximately 5 log PFU of Tulane virus (TV)-a HuNoV surrogate-was inoculated on sunflower (SF) and pea shoot (PS) microgreen leaves at 7-day age. The virus reduction on SF was significantly higher than PS (p < 0.05). On day 10, total TV reduction for SF and PS were 3.70 ± 0.10 and 2.52 ± 0.30 log PFU/plant, respectively. Under the environmental scanning electron microscope (ESEM) observation, the leaf surfaces of SF were visually smoother than PS, while their specific effect on virus persistence were not further characterized. Overall, this study revealed that TV persistence on microgreen leaves was plant variety dependent. In addition, this study provided a preliminary estimation on the risk of HuNoV contamination in a microgreen production system which will aim the future development of prevention and control measures.

Performance of Manufacturer Cleaning Recommendations Applied to 3D Food Ink Capsules for the Control of a Human Norovirus Surrogate

With the widespread availability of 3D food printing systems for purchase, users can customize their food in new ways. Manufacturer recommendations for cleaning these machines remain untested with regard to the prevention of foodborne pathogen transmission. This study aimed to determine if manufacturer cleaning recommendations for food ink capsules utilized in 3D food printers are adequate to control human norovirus (HuNoV). A HuNoV surrogate, Tulane virus (TuV; ~ 6 log₁₀ PFU/mL), was inoculated onto the interior surface of stainless steel food ink capsules. Capsules were either unsoiled or soiled with one of the following: butter, protein powder solution, powdered sugar solution, or a mixture containing all three food components. The capsules were allowed to dry and then one of three hygienic protocols was applied: manual washing (MW), a dishwasher speed cycle (DSC), or a dishwasher heavy cycle (DHC). The interaction effect between DSC and pure butter was a significant predictor of log reduction (P = 0.0067), with the pure butter and DSC combination achieving an estimated mean log reduction of 4.83 (95% CI 4.13, 5.59). The DSC was the least effective method of cleaning when compared with MW and the DHC. The 3-way interaction effects between wash type, soil, and capsule position were a significant predictor of log reduction (P = 0.00341). Capsules with butter in the DSC achieved an estimated mean log reduction of 2.81 (95% CI 2.80, 2.83) for the front-most position versus 6.35 (95% CI 6.33, 6.37) for the back-most position. Soil matrix, cleaning protocol, and capsule position all significantly impact capsule cleanability and potential food safety risk. The DHC is recommended for all capsules, and the corners should be avoided when placing capsules into the dishwasher. The current study seeks to provide recommendations for users of additive manufacturing and 3D food printing including consumers, restaurants, industry, and regulatory industries.

Persistence and transfer of Tulane virus in a microgreen cultivation system

Microgreens are niche salad greens which have increased in popularity among consumers in recent years. Due to similarities with sprouts and leafy greens-both attributed to numerous foodborne disease outbreaks-characterization of the food safety risks associated with microgreen production is warranted. The present study aimed to determine the fate and persistence of a human norovirus (HuNoV) surrogate, Tulane virus (TV), within a microgreen production system. Initially, the persistence of TV in two types of microgreen soil-free cultivation matrix (SFCM)-BioStrate® (biostrate) and peat-was determined. On day 0, water containing 7.6 log PFU of TV was applied to SFCM in growing trays, and the trays were maintained under microgreen growth conditions. TV persisted throughout the 10-day observation in biostrate and peat with overall reductions of 3.04 and 1.76 log plaque forming units (PFU) per tray, respectively. Subsequently, the transfer of TV to microgreen edible tissue was determined when planted on contaminated SFCM. Trays containing each type of SFCM were pre-inoculated with 7.6 log PFU of TV and equally divided into two areas. On day 0, sunflower (SF) or pea shoot (PS) seeds were planted on one-half of each tray, while the other half was left unplanted to serve as a control. The microgreens were harvested on day 10, and SFCM samples were collected from planted and unplanted areas of each tray. No TV were detected from the edible portion of either type of microgreen, yet TV were still present in the SFCM. TV concentrations were significantly lower in the root-containing planted area compared with the unplanted area for both biostrate (P = 0.0282) and peat (P = 0.0054). The mean differences of TV concentrations between unplanted and planted areas were 1.22 and 0.51 log PFU/g for biostrate and peat, respectively. In a subsequent investigation, TV transfer from day 7 inoculated SFCM to microgreens edible portion was not detected either. Overall, this study characterized the viral risk in a microgreen production system, which will help to understand the potential food safety risk related to HuNoV and to develop preventive measures.

Human Norovirus Surrogates Persist in Nontraditional Sources of Irrigation Water in Excess of 100 Days

Human norovirus (HuNoV) has been implicated as the leading cause of foodborne illness worldwide. The ability of HuNoV to persist in water can significantly impact food safety as agriculture and processing water could serve as vehicles of virus transmission. This study focused on the persistence and infectivity of the HuNoV surrogate viruses, murine norovirus (MNV), and Tulane virus (TV), after prolonged storage in diverse environmental water types currently used for agricultural irrigation. In this study, vegetable processing water (VW), brackish tidal surface water (SW), municipal reclaimed water (RW), and pond water (PW) were inoculated with each virus in a 1:10 v/v ratio containing virus at 3.5-4.5 logPFU/mL and stored at 16°C for 100 days. This time and temperature combination was chosen to mimic growing and harvest conditions in the mid-Atlantic area of the United States. Samples were then assayed for the presence of viral RNA using reverse transcription-quantitative polymerase chain reaction (RT-qPCR) approximately weekly throughout the study. Persistence of MNV and TV was not significantly different (p > 0.05) from one another in any water sample (n = 7) or the control (HBSS). However, there was variability observed in viral persistence across water samples with significant differences observed between several water samples. The presence of intact viral capsids enclosing the genomes of MNV and TV were evaluated by an RNase assay coupled with RT-qPCR on specific timepoints and determined to be intact up to and at 100 days after inoculation. TV was also shown to remain infectious in a cell culture assay (TCID50) up to 100 days of incubation. These findings are significant in that the potential for not only detection of enteric viruses can occur long after a contamination event occurs but these viruses may also remain infectious.

The Efficacy of Commercial Surface Sanitizers against Norovirus on Formica Surfaces with and without Inclusion of a Wiping Step

Commonly used surface sanitizers often lack activity against human noroviruses (hNoVs). The impact of inactivation versus removal when these products are applied via wiping is poorly characterized. The purpose of this work was to assess the anti-hNoV efficacy of various surface sanitizer chemistries, as applied to a laminate material commonly used for restaurant tabletops, using standard surface assays (ASTM E1053-11) and a newly developed wiping protocol. Four commercially available products with different active ingredient(s) (i.e., ethanol [EtOH], acid + anionic surfactant [AAS], quaternary ammonium compound [QAC], and sodium hypochlorite [NaOCl]) and a water control were evaluated against hNoV GII.4 Sydney, hNoV GI.6, and the cultivable surrogate Tulane virus (TuV). Virus concentration was evaluated using RNase-reverse transcriptase (RT)-quantitative PCR (qPCR) (hNoV) and infectivity assay (TuV). Only the EtOH-based product significantly reduced virus concentration (>3.5 log10 reduction [LR]) by surface assay, with all other products producing ≤0.5 LR. The inclusion of a wiping step enhanced the efficacy of all products, producing complete virus elimination for the EtOH-based product and 1.6 to 3.8 LR for the other chemistries. For hNoVs, no detectable residual virus could be recovered from paper towels used to wipe the EtOH-based product, while high concentrations of virus could be recovered from the used paper towel and the wiped coupon (1.5 to 2.5 log10 lower genome equivalent copies [GEC] compared to control) for the QAC- and AAS-based products and for water. These results illustrate the variability in anti-hNoV activity of representative surface sanitizers and highlights the value of wiping, the efficacy of which appears to be driven by a combination of virus inactivation and removal. IMPORTANCE Human noroviruses (hNoVs) are the leading cause of acute gastroenteritis and food-borne disease worldwide. Noroviruses are difficult to inactivate, being recalcitrant to sanitizers and disinfectants commonly used by the retail food sector. This comparative study demonstrates the variability in anti-hNoV activity of representative surface sanitizers, even those allowed to make label claims based on the cultivable surrogate, feline calicivirus (FCV). It also highlights the importance of wiping in the process of sanitization, which significantly improves product efficacy through the action of physical removal of surface microbes. There is a need for more and better product formulations with demonstrated efficacy against hNoVs, which will likely necessitate the use of alternative cultivable surrogates, such as Tulane virus (TuV). These findings help food safety professionals make informed decisions on sanitizing product selection and application methods in order to reduce the risk of hNoV contamination and transmission in their facilities.

Evaluation of heat treatment for inactivation of norovirus genogroup II in foods

The effective food processing technology is a key step in eliminating human noroviruses in foods mainly due to their stability in diverse environmental conditions. The aim of this study was to evaluate the effect of rising temperatures for inactivation of norovirus genogroup (G) II and murine norovirus 1 in samples of tomato sauce (72-74 °C for 1 min) and ground meat (100 °C for 30 min). Spiking experiments were carried out in triplicate using TRIzol® reagent method associated with quantitative polymerase chain reaction (qPCR) TaqMan™ system combined with previous free RNA digestion. Success rate and efficiency recoveries of both viruses as well limit of detection of a method for each matrix were also conducted. The heat treatment applied here proved to be efficient to reduce the burden of norovirus GII in a range of 1-4 log₁₀ genomic copies per gram (percentage ranging from 0.45 to 104.54%) in both matrices. The experiments in this study showed that the results of norovirus GII and murine norovirus 1 in tomato sauce and ground meat tested during thermal treatments cannot be generalized to other food matrices, since there may be food-specific protective effects, as the presence of different components, that can interfere in virus inactivation. Studies using different food matrices reinforce the importance to investigate viruses' inactivation thermal processes in foods due to the resistance of these viruses to adverse conditions, contributing to food security in food virology.

Temperature, Time, and Type, Oh My! Key Environmental Factors Impacting the Recovery of Salmonella Typhimurium, Listeria monocytogenes, and Tulane Virus from Surfaces

ABSTRACT

Environmental monitoring (EM) programs are designed to detect the presence of pathogens in food manufacturing environments, with the goal of preventing microbial contamination of food. Nevertheless, limited knowledge exists regarding the influence of environmental conditions on microbial recovery during EM. This study uses a commercially available polyurethane foam EM tool to determine the influence of environmental factors on the recovery of foodborne pathogens. The specific objectives of this study were to determine if environmental conditions and surface composition impact the recovery of sought-after microorganisms found in food processing environments. These data are compared across (i) microorganism type, (ii) surface type, (iii) environmental temperature and relative humidity (RH), and (iv) exposure time. Two bacteria (Listeria monocytogenes and Salmonella Typhimurium) and one human norovirus surrogate (Tulane virus) were inoculated onto three nonporous surfaces (polypropylene, stainless steel, and neoprene). Surfaces were held in an environmental chamber for 24 or 72 h at 30°C with 30% RH, 6°C with 85% RH, and 30°C with 85% RH. Data indicate that microbial recovery from environmental surfaces significantly (P ≤ 0.05) varies by microorganism type, environmental conditions, and exposure time. For instance, all microorganisms were significantly different from each other, with the greatest mean log reduction being Tulane virus and the lesser reduction being L. monocytogenes at 4.94 ± 1.75 log PFU per surface and 2.54 ± 0.91 log CFU per surface, respectively. Overall, these data can be used to improve the effectiveness of EM programs and underscores the need to better comprehend how EM test results are impacted by food manufacturing environmental conditions.

HIGHLIGHTS

Efficacy and Mechanisms of Copper Ion-Catalyzed Inactivation of Human Norovirus

The antinoroviral effect of copper ions is well known, yet most of this work has previously been conducted in copper and copper alloy surfaces, not copper ions in solution. In this work, we characterized the effects that Cu ions have on human norovirus capsids’ and surrogates’ integrity to explain empirical data, indicating virus inactivation by copper alloy surfaces, and as means of developing novel metal ion-based virucides. Comparatively high concentrations of Cu(II) ions (>10 mM) had little effect on the infectivity of human norovirus surrogates, so we used sodium ascorbate as a reducing agent to generate unstable Cu(I) ions from solutions of copper bromide. We found that significantly lower concentrations of monovalent copper ions (∼0.1 mM) compared to divalent copper ions cause capsid protein damage that prevents human norovirus capsids from binding to cell receptors in vitro and induce a greater than 4-log reduction in infectivity of Tulane virus, a human norovirus surrogate. Further, these Cu(I) solutions caused reduction of GII.4 norovirus from stool in suspension, producing about a 2-log reduction of virus as measured by a reverse transcriptase-quantitative polymerase chain reaction. Sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE) data indicate substantial major capsid protein cleavage of both GI.7 and GII.4 norovirus capsids, and TEM images show the complete loss of capsid integrity of GI.7 norovirus. GII.4 virus-like particles (VLPs) were less susceptible to inactivation by copper ion treatments than GI.7 VLPs based upon receptor binding and SDS-PAGE analysis of viral capsids. The combined data demonstrate that stabilized Cu(I) ion solutions show promise as highly effective noroviral disinfectants in solution that can potentially be utilized at low concentrations for inactivation of human noroviruses.

Photoinactivation of bacteriophage MS2, Tulane virus and Vibrio parahaemolyticus in oysters by microencapsulated rose bengal

Objectives

Bivalve molluscan shellfish such as oysters are important vectors for the transmission of foodborne pathogens including both viruses and bacteria. Photoinactivation provides a cold-sterilization option against the contamination as excited photosensitizers could transfer electronic energy to oxygen molecules producing reactive oxygen species such as singlet oxygen, leading to oxidative damage and death of the pathogens. However, the efficacy of photoinactivation is very often compromised by the presence of food matrix due to the non-selective reactions of short-lived singlet oxygen with the organic matters other than the target pathogens.

Materials and Methods

In order to address this issue, we encapsulated a food grade photosensitizer rose bengal (RB) in alginate microbeads. An extra coating of chitosan effectively prevented the release of RB from the microbeads in seawater, and more importantly, enhanced the selectivity of the photoinactivation via the electrostatic interactions between cationic chitosan and anionic charge of the virus particles (bacteriophage MS2 and Tulane virus) and the gram-negative bacteria Vibrio parahaemolyticus.

Results

The treatment of oysters with microencapsulated RB resulted in significantly higher reductions of MS2 phage, Tulane virus and V. parahaemolyticus than free RB and non-RB carrying microbeads (P &lt; 0.05) tested with both in vitro and in vivo experimental set-ups. (4)

Conclusions

This study demonstrated a new strategy in delivering comprehensively formulated biochemical sanitizers in bivalve shellfish through their natural filter feeding activity and thereby enhancing the mitigation efficiency of foodborne pathogen contamination.

Inactivation of Murine Norovirus Suspended in Organic Matter Simulating Actual Conditions of Viral Contamination

Foodborne viral illnesses are frequent worldwide and costly for the society. Human norovirus is one of the most common causal agents. Although some norovirus genotypes can now be cultured, surrogates are still used for inactivation studies. The aim of this study was to evaluate the effects of different organic loads individually (artificial feces, real fecal matter, ASTM tripartite organic load, fetal bovine serum) on the efficacy of three highly used sanitization treatments (thermal inactivation, peracetic acid and sodium hypochlorite treatment) using murine norovirus 3 in solutions and surfaces. Based on plaque-forming units, we show that organic matter protects murine norovirus 3 against thermal inactivation (viral reduction of ~ 1 log compared to 2.67 with PBS). However, there was a low-level but significant protection against peracetic acid (viral reduction of ~ 2 log compared to 2.85 with PBS) and none in the presence of sodium hypochlorite. Our study showed that the tested organic matters do not behave similarly depending on the treatments, especially with heat treatments, which showed a higher protection. Furthermore, Feclone ™ artificial feces mimicked some aspect of real fecal matter and may be used instead. Our results will be helpful to researchers undertaking viral inactivation studies in which an organic matrix is used to simulate actual conditions of human norovirus environment.

Aichi virus inactivation by heat in 2-ml glass vials

Aichi virus (AiV) that results in gastroenteritis worldwide, is spread through contaminated shellfish and water. The resistance/tolerance of AiV to common inactivation processes along with the absence of commercially available vaccines makes it necessary to study its thermal inactivation kinetics. This research evaluated the heat inactivation of AiV in cell-culture media using 2-ml sterile glass vials by the linear and Weibull models. Heat treatments of AiV titers of 7 log plaque forming units (PFU)/ml were conducted thrice in a water-bath at 50, 54, and 58 °C for up to 90 min. Plaque assays for each dilution in duplicate were used to determine infectious virus titers. Linear model D-values for AiV at 50 ± 1 °C (± = standard error) (come-up time = 68 s), 54 ± 0.7 °C (130 s), and 58 ± 0.6°C (251 s) were 43.3 ± 4.23 (R² = 0.40, RMSE = 0.56), 5.69 ± 0.28 (R² = 0.80, RMSE = 0.43), and 1.20 ± 0.63 min (R² = 0.69, RMSE = 0.39), respectively, and the linear model z-value was 5.14 ± 0.39°C (R² = 0.99, RMSE = 0.08). For the same temperatures, the Weibull model t_{d = 1} values were 20.98 ± 8.8 (R² = 0.62, RMSE = 0.46, α (scale parameter) = 2.30, β (shape parameter) = 0.38), 3.84 ± 0.69 (R² = 0.85, RMSE = 0.38, α = 1.08, β = 0.66), and 0.87 ± 0.10 min (R² = 0.80, RMSE = 0.32, α = 0.22, β = 0.61), respectively and the z-value (using T_{d = 1} ) was 5.79 ± 0.22 °C (R² = 1.0, RMSE = 0.03). A better fit was obtained with the Weibull model for log reductions versus time with higher R² and lower RMSE values. Application of AiV inactivation parameters can help reduce the risk of AiV outbreaks.

Factors impacting microbial release from environmental monitoring tools

The U.S. FDA Food Safety Modernization Act Preventive Controls for Human Food Rule underlines the importance of an effective environmental monitoring (EM) program. EM is used to determine harborage sites of microorganisms on processing equipment, assess effectiveness of sanitation programs, and prevent transmission of foodborne pathogens. This study characterizes commercially-available polyurethane foam (PUF) and cellulose (CELL) EM tools for their efficacy in the release of foodborne pathogens from their sponge matrices. Specifically, the objectives of this study were to 1) compare the ability of EM tools to release microorganisms into a recovery eluent, 2) characterize EM tool performance at decreasing inoculum concentrations, and 3) assess the impact of various operators during the processing of EM samples. Two bacteria (Listeria monocytogenes, Salmonella Typhimurium) and one human norovirus surrogate (Tulane virus [TV]) were compared at decreasing inoculum levels utilizing two elution techniques (mechanical stomacher, manually by operator), and across six operators. Data indicated that EM tool material composition impacted the release of microorganisms (p = 0.0001), where the PUF EM tool released TV more readily than the CELL EM tool. Conversely, the decreasing inoculum levels did not statistically differ in the release of microorganisms from the EM tool matrices. In addition, no significant difference was found between the machine stomacher and manual elution by human operator or between operators. Overall, the study provides a detailed characterization of two commercially-available EM tools, and the differences identified in this study can be used to improve the effectiveness of EM programs.

Impact of chlorine dioxide and electron-beam irradiation for the reduction of murine norovirus in low-salted "jogaejeotgal", a traditional Korean salted and fermented clam

Clam jeotgal, called "jogaejeotgal," is a Korean fermented seafood product with, generally, a high amount of added salt to inhibit the growth of pathogenic microorganisms. This study aimed to evaluate the efficacy of chlorine dioxide (ClO₂) and sodium hypochlorite (NaOCl) against murine norovirus 1 (MNV-1), a surrogate for human norovirus, in salt-fermented clam, jogaejeotgal. The sequential effect of ClO₂ and electron-beam (e-beam) irradiation on the inactivation of MNV-1 was also investigated. Treatments of up to 300 ppm ClO₂ and 1000 ppm NaOCl were used to determine the disinfectant concentrations at which more than 1 log (90%) MNV-1 inactivation occurred. The sequential treatment of ClO₂ (50-300 ppm) and e-beam (1-5.5 kGy) was performed after storage at 4 °C for 7 days. There was a 1.9-log reduction of the virus in seasoned clams irradiated at 5.5 kGy after ClO₂ treatment at 300 ppm. No significant change (p > 0.05) in physicochemical quality was observed after the combined treatment, suggesting the potential for the use of a combined treatment using ClO₂ (300 ppm) and e-beam (5.5 kGy) in the jeotgal manufacturing industry for the reduction of norovirus.

Energy Requirements for Loss of Viral Infectivity

Outside the host, viruses will eventually lose their ability to infect cells due to conformational changes that occur to proteins on the viral capsid. In order to undergo a conformational change, these proteins require energy to activate the chemical reaction that leads to the conformational change. In this study, data from the literature is used to calculate the energy required for viral inactivation for a variety of different viruses by means of the Arrhenius equation. We find that some viruses (rhinovirus, poliovirus, human immunodeficiency virus, Alkhumra hemorrhagic fever virus, and hepatitis A virus) have high inactivation energies, indicative of breaking of a chemical double bond. We also find that several viruses (respiratory syncytial virus, poliovirus, and norovirus) have nonlinear Arrhenius plots, suggesting that there is more than a single pathway for inactivation of these viruses.

The Basis of Peracetic Acid Inactivation Mechanisms for Rotavirus and Tulane Virus under Conditions Relevant for Vegetable Sanitation

We determined the disinfection efficacy and inactivation mechanisms of peracetic acid (PAA)-based sanitizer using pH values relevant for vegetable sanitation against rotavirus (RV) and Tulane virus (TV; a human norovirus surrogate). TV was significantly more resistant to PAA disinfection than RV: for a 2-log10 reduction of virus titer, RV required 1 mg/liter PAA for 3.5 min of exposure, while TV required 10 mg/liter PAA for 30 min. The higher resistance of TV can be explained, in part, by significantly more aggregation of TV in PAA solutions. The PAA mechanisms of virus inactivation were explored by quantifying (i) viral genome integrity and replication using reverse transcription-quantitative PCR (RT-qPCR) and (ii) virus-host receptor interactions using a cell-free binding assay with porcine gastric mucin conjugated with magnetic beads (PGM-MBs). We observed that PAA induced damage to both RV and TV genomes and also decreased virus-receptor interactions, with the latter suggesting that PAA damages viral proteins important for binding its host cell receptors. Importantly, the levels of genome-versus-protein damage induced by PAA were different for each virus. PAA inactivation correlated with higher levels of RV genome damage than of RV-receptor interactions. For PAA-treated TV, the opposite trends were observed. Thus, PAA inactivates each of these viruses via different molecular mechanisms. The findings presented here potentially contribute to the design of a robust sanitation strategy for RV and TV using PAA to prevent foodborne disease.IMPORTANCE In this study, we examined the inactivation mechanisms of peracetic acid (PAA), a sanitizer commonly used for postharvest vegetable washing, for two enteric viruses: Tulane virus (TV) as a human norovirus surrogate and rotavirus (RV). PAA disinfection mechanisms for RV were mainly due to genome damage. In contrast, PAA disinfection in TV was due to damage of the proteins important for binding to its host receptor. We also observed that PAA triggered aggregation of TV to a much greater extent than RV. These studies demonstrate that different viruses are inactivated via different PAA mechanisms. This information is important for designing an optimal sanitation practice for postharvest vegetable washing to minimize foodborne viral diseases.

Characterization of Polyurethane Foam Environmental Monitoring Tools for the Recovery and Release of Viruses

The U.S. FDA Food Safety Modernization Act Preventive Controls for Human Food Rule emphasizes the importance of an effective environmental monitoring (EM) program. This study aims to characterize polyurethane foam (PUF) EM tools-currently used in the food industry for the recovery of bacteria from food contact surfaces-for their efficacy in the release and recovery of human enteric viruses. Two viruses (human norovirus [hNoV] and Tulane virus [TV]) were compared at varying inoculum levels, with two EM tools (PUF swab and sponge), two delayed processing times (24 h and 72 h), and one surface type (stainless steel [SS]). Specifically, the objectives were to (1) determine the ability of PUF devices to release viruses for detection and (2) assess the ability of PUF devices to recover viruses from SS surfaces. For TV release from the sponge, there was a significant difference (p = 0.0064) when compared across inoculum level (10⁵ plaque forming unit [PFU]/sponge vs. 10² PFU/sponge). Release of hNoV at a single inoculum level by PUF sponge and swab was compared resulting in a significant difference (p < 0.0001). Data on recovery of TV from SS surfaces using both the sponge and swab indicate significant differences depending on the inoculum level. Recovery of hNoV from SS surfaces differed significantly (p = 0.0030) between the sponge and swab devices. Overall, the study provides a detailed characterization of two commercially available, PUF-based EM tools, and the differences identified in this study can be used to improve the efficacy of EM tools.

Stability of hepatitis E virus at different pH values

Infection with the hepatitis E virus (HEV) can cause acute and chronic hepatitis in humans. The zoonotic HEV genotype 3 is mainly transmitted by consumption of raw and fermented meat products prepared from infected pigs or wild boars. Lowering of pH during fermentation is one of the microbiological hurdles considered to inhibit growth of certain pathogens. However, no data are currently available on pH stability of HEV. As a reliable and reproducible measurement of HEV infectivity in meat products is not established so far, the stability of the cell culture-adapted HEV genotype 3 strain 47832c was analyzed here in phosphate-buffered saline (PBS) at different pH values. Only a minimal decrease of infectivity (up to 0.6 log₁₀ focus forming units) was found after treatment at pH 2 to 9 for 3 h at room temperature. At pH 10, a decrease of about 3 log₁₀ was evident, whereas no remaining virus (>3.5 log₁₀ decrease) was detected at pH 1. The conditions usually achieved during curing of raw sausages were simulated using D/L-lactic acid added to PBS resulting in pH 4.5 to 6.5. After incubation at 4 °C for 7 days at these conditions, no significant differences as compared to a standard PBS solution at pH 7.7 were evident. At room temperature, a 0.8 log₁₀ decrease was found at pH 4.7 after 7 days incubation compared to pH 7.7, but less at the other pH values. In conclusion, only minimal inactivating effects were found at pH conditions commonly occurring during food processing. Therefore, remaining infectious virus might be present in fermented meat products if HEV-contaminated starting material was used. Additional effects of other factors like high salt concentrations and low a_w values should be investigated in future studies.

Heat sensitization of hepatitis A virus and Tulane virus using grape seed extract, gingerol and curcumin

Human noroviruses (HNoV) and hepatitis A virus (HAV) are predominantly linked to foodborne outbreaks worldwide. As cell-culture systems to propagate HNoV in laboratories are not easily available, Tulane virus (TV) is used as a cultivable HNoV surrogate to determine inactivation. Heat-sensitization of HAV and TV by "generally recognized as safe'' (GRAS) substances can potentially reduce their time-temperature inactivation parameters during processing to ensure food safety. Curcumin, gingerol (from ginger), and grape seed extract (GSE) reportedly have anti-inflammatory, immune-modulating and antiviral properties. The objective of this study was to determine and compare the D-values and z-values of HAV and TV at 52-68 °C with or without curcumin (0.015 mg/ml), gingerol (0.1 mg/ml), or GSE (1 mg/ml) in 2-ml glass vials. HAV at ~7 log PFU/ml and TV at ~6 log PFU/ml were diluted in phosphate buffered saline (PBS) and added to two sets of six 2-mL sterile glass vials. One set served as the control and the second set had the three extracts individually added for thermal treatments in a circulating water bath for 0-10 min. The D-values for TV in PBS ranged from 4.55 ± 0.28 to 1.08 ± 0.16 min, and for HAV in PBS ranged from to 9.21 ± 0.24 to 0.67 ± 0.19 min at 52-68 °C. Decreased D-values (52-58 °C) for TV with curcumin ranging from 4.32 ± 0.25 to 0.62 ± 0.17 min, gingerol from 4.09 ± 0.18 to 0.72 ± 0.09 min and GSE from 3.82 ± 0.18 to 0.80 ± 0.07 min, with similar trends for HAV were observed. The linear model showed significant differences (p < 0.05) between the D-values of HAV and TV with and without plant extracts for most tested temperatures. This suggests that GRAS substances can potentially lower temperature and time regimens needed to inactivate HAV and TV.

Co-culture with Enterobacter cloacae does not Enhance Virus Resistance to Thermal and Chemical Treatments

Human noroviruses (hNoV) are the primary cause of foodborne disease in the USA. Most studies on inactivation kinetics of hNoV and its surrogates are performed in monoculture, while the microbial ecosystem effect on virus inactivation remains limited. This study investigated the persistence of hNoV surrogates, murine norovirus (MNV) and Tulane virus (TuV), along with Aichi virus (AiV) under thermal and chemical inactivation in association with Gram-negative (Enterobacter cloacae) bacteria. Thermal inactivation of viruses in co-culture with E. cloacae revealed no protective effects of bacteria. At 56 °C, AiV with and without bacteria was completely inactivated by 10 min with decimal reduction values (D-values) of 41 and 43 s, respectively. Similar results were also observed for TuV. Conversely, MNV with bacteria was completely inactivated by 10 min while MNV alone remained stable up to 30 min at 56 °C. Both MNV and TuV were slightly more stable than AiV at 63 °C with TuV detection up to 2 min without bacteria. For chemical inactivation on stainless steel surfaces, viruses alone and in association with bacteria were treated with 1000 ppm sodium hypochlorite. Virus association with bacteria had no significant effect (p > 0.05) on virus resistance to bleach inactivation compared to virus alone. Specifically, exposure to 1000 ppm bleach for 5 min resulted in an average of 3.86, 2.14, and 0.94 log₁₀ PFU/ml reductions for TuV, MNV, and AiV without bacteria, respectively. Reductions in TuV, MNV, and AiV were 3.50, 1.88, and 0.61 log10 PFU/ml when associated with E. cloacae, respectively.

Surfactant-Enhanced Organic Acid Inactivation of Tulane Virus, a Human Norovirus Surrogate

Combination treatments of surfactants and phenolic or short-chain organic acids (SCOA) may act synergistically or additively as sanitizers to inactive foodborne viruses and prevent outbreaks. The purpose of this study was to investigate the effect of gallic acid (GA), tannic acid, p-coumaric acid, lactic acid (LA), or acetic acid (AA), in combination with sodium dodecyl sulfate (SDS), against Tulane virus (TV), a surrogate for human norovirus. An aqueous stock solution of phenolic acids or SCOA with or without SDS was prepared and diluted in a twofold dilution series to 2× the desired concentration with cell growth media (M119 plus 10% fetal bovine serum). The solution was inoculated with an equal proportion of 6 log PFU/mL TV with a treatment time of 5 min. The survival of TV was quantified using a plaque assay with LLC-MK2 cells. The minimum virucidal concentration was 0.5:0.7% (v/v) for LA-SDS at pH 3.5 (4.5-PFU/mL reduction) and 0.5:0.7% (v/v) AA-SDS at pH 4.0 (2.6-log PFU/mL reduction). GA and SDS demonstrated a minimum virucidal concentration of 12.5 mM GA-SDS at pH 7.0 (0.2:0.3% GA-SDS) with an 0.8-log PFU/mL reduction and 50 mM GA-SDS (0.8:1.4% GA-SDS at pH 7.0) increased log reduction to 1.6 log PFU/mL. The combination treatments of AA or LA with SDS at pH 7.0 did not produce significant log reduction, nor did individual treatments of tannic acid, GA, p-coumaric acid, AA, LA, or SDS. This study demonstrates that a surfactant, such as SDS, aids in the phenolic acid and SCOA toxicities against viruses. However, inactivation of TV by combination treatments is contingent upon the pH of the sanitizing solution being lower than the pK_a value of the organic acid being used. This information can be used to develop sanitizing washes to disinfect food contact surfaces, thereby aiding in the prevention of foodborne outbreaks.

Inhibition of Murine Norovirus and Feline Calicivirus by Edible Herbal Extracts

Human noroviruses (HuNoVs) cause foodborne and waterborne viral gastroenteritis worldwide. Because HuNoV culture systems have not been developed thus far, no available medicines or vaccines preventing infection with HuNoVs exist. Some herbal extracts were considered as phytomedicines because of their bioactive components. In this study, the inhibitory effects of 29 edible herbal extracts against the norovirus surrogates murine norovirus (MNV) and feline calicivirus (FCV) were examined. FCV was significantly inhibited to 86.89 ± 2.01 and 48.71 ± 7.38% by 100 μg/mL of Camellia sinensis and Ficus carica, respectively. Similarly, ribavirin at a concentration of 100 μM significantly reduced the titer of FCV by 77.69 ± 10.40%. Pleuropterus multiflorus (20 μg/mL) showed antiviral activity of 53.33 ± 5.77, and 50.00 ± 16.67% inhibition was observed after treatment with 20 μg/mL of Alnus japonica. MNV was inhibited with ribavirin by 59.22 ± 16.28% at a concentration of 100 μM. Interestingly, MNV was significantly inhibited with 150 µg/mL Inonotus obliquus and 50 μg/mL Crataegus pinnatifida by 91.67 ± 5.05 and 57.66 ± 3.36%, respectively. Treatment with 20 µg/mL Coriandrum sativum slightly reduced MNV by 45.24 ± 4.12%. The seven herbal extracts of C. sinensis, F. carica, P. multiflorus, A. japonica, I. obliquus, C. pinnatifida, and C. sativum may have the potential to control noroviruses without cytotoxicity.

Noroviruses on surfaces: detection, persistence, disinfection and role in environmental transmission

Human noroviruses (HuNoVs), the most common cause of infectious nonbacterial gastroenteritis and the cause of numerous foodborne and hospital outbreaks, are easily transmitted from person-to-person. HuNoVs may persist on surfaces for long periods of time and may be transferred via hands, foods, fomites and air. In this review, studies on methods for detecting HuNoVs on environmental surfaces, such as swabbing, are presented. The review also focuses on recent studies on the efficiency of disinfectants for inactivating HuNoV or its surrogates, such as murine norovirus, on environmental surfaces and hands. Although HuNoV is probably more resistant than MuNoV, this study data adds to the understanding of HuNoV transmission routes and selection of tools for the prevention of HuNoV gastroenteritis outbreaks.

Efficacy of oxidizing disinfectants at inactivating murine norovirus on ready-to-eat foods

Noroviruses are the leading cause of foodborne illness, and ready-to-eat foods are frequent vehicles of their transmission. Studies of the disinfection of fruits and vegetables are becoming numerous. It has been shown that strong oxidizing agents are more effective than other chemical disinfectants for inactivating enteric viruses. The aim of this study was to evaluate the efficacy of oxidizing disinfectants (sodium hypochlorite, chloride dioxide and peracetic acid) at inactivating noroviruses on fruits and vegetables, using a norovirus surrogate, namely murine norovirus 3, which replicates in cell culture. Based on plaque assay, solutions of peracetic acid (85 ppm) and chlorine dioxide (20 ppm) reduced the infectivity of the virus in suspension by at least 3 log10 units after 1 min, while sodium hypochlorite at 50 ppm produced a 2-log reduction. On the surface of blueberries, strawberries and lettuce, chlorine dioxide was less effective than peracetic acid and sodium hypochlorite, which reduced viral titers by approximately 4 logs. A surprising increase in the efficacy of sodium hypochlorite on surfaces fouled with artificial feces was noted.

Environmental persistence of Tulane virus - a surrogate for human norovirus

Human noroviruses (HuNoVs) are the leading cause of acute viral gastroenteritis worldwide. The persistence of HuNoV in the environment contributes significantly to its transmission to humans. Surrogate viruses are used to study HuNoV owing to the lack of a cell culture system for this virus. Here, the persistence of Tulane virus (TV) - a novel HuNoV surrogate - in surface water (SW) and groundwater (GW) as well as on acrylic-based solid (ABS) and stainless steel (SS) surfaces was investigated. After 28 days, TV remained stable in SW (<1 log10 reduction) but was reduced by ≥3.5 to 4 log10 in GW by day 21. TV had a higher rate of reduction on SS compared with ABS, with corresponding D values of 18.5 ± 0.34 and 13.1 ± 0.36 days, respectively. This is the first study to demonstrate the persistence of TV in environmental waters and on fomite surfaces.