Fusariotoxins in Avian Species: Toxicokinetics, Metabolism and Persistence in Tissues

Toxicity, biodegradation, and nutritional intervention mechanism of zearalenone

Zearalenone (ZEA), a global mycotoxin commonly found in a variety of grain products and animal feed, causes damage to the gastrointestinal tract, immune organs, liver and reproductive system. Many treatments, including physical, chemical and biological methods, have been reported for the degradation of ZEA. Each degradation method has different degradation efficacies and distinct mechanisms. In this article, the global pollution status, hazard and toxicity of ZEA are summarized. We also review the biological detoxification methods and nutritional regulation strategies for alleviating the toxicity of ZEA. Moreover, we discuss the molecular detoxification mechanism of ZEA to help explore more efficient detoxification methods to better reduce the global pollution and hazard of ZEA.

Toxicokinetics of Zearalenone following Oral Administration in Female Dezhou Donkeys

Zearalenone (ZEN) is a mycotoxin produced by various Fusarium strains, that is present in food and feed raw materials worldwide, causing toxicity effects in animals and humans. This research aimed to explore the toxicokinetics of ZEN on female Dezhou donkeys following a single oral exposure dosage of 2 mg/kg BW (body weight). The sample collection of donkeys plasma was carried out at 0, 5, 10, 15, 20, 30, 45, 60, 90 min, 2 h, 2.5 h, 3 h, 3.5 h, 4 h, 4.5 h, 6 h, 9 h, 12 h, 24 h, 48 h, 72 h, 96 h and 120 h via intravenous catheter, and fecal and urinary samples were severally collected at 0 h and every 6 h until 120 h. The concentrations of ZEN, α-zearalenol (α-ZOL), β-zearalenol (β-ZOL), α-zearalanol (α-ZAL), β-zearalanol (β-ZAL), zearalanone (ZAN) in plasma, urine, and feces were detected by UPLC-MS/MS. Only ZEN was detected in plasma, and the maximum was 15.34 ± 5.12 µg/L occurred at 0.48 h after gavage. The total plasma clearance (Cl) of ZEN was 95.20 ± 8.01 L·kg·BW-1·h-1. In addition, the volume of distribution (Vd) was up to 216.17 ± 58.71 L/kg. The percentage of total ZEN (ZEN plus the main metabolites) excretion in feces and urine was 2.49% and 2.10%, respectively. In summary, ZEN was fast absorbed and relatively slowly excreted in female donkeys during 120 h after a single gavage, indicating a trend of wider tissue distribution and longer tissue persistence.

Subclinical doses of dietary fumonisins and deoxynivalenol cause cecal microbiota dysbiosis in broiler chickens challenged with Clostridium perfringens

Fusarium toxins are one of the most common contaminants in poultry diets. The co-occurrence of fumonisins (FUM) and deoxynivalenol (DON), even at a subclinical dose, negatively affects the growth performance, intestinal integrity and induce subclinical necrotic enteritis in broiler chickens. Loss of gut integrity can be expected to alter the intestinal microbiota’s composition. The objective of this study was to identify the effects of combined FUM and DON on the cecal microbiome profile and predicted metabolic functions and a short chain fatty acid profile in broilers challenged with Clostridium perfringens. A total of 240 1 day-old chicks were randomly assigned to two treatments: a control diet and the control diet with 3 mg/kg FUM + 4 mg/kg DON each with eight replications. All the birds were received cocci vaccine at d0. All birds in both treatment groups were challenged with C. perfringens 1 × 108 CFU via feed on d 19 and 20 to achieve 5% mortality. On d 35, the FUM and DON contaminated diet numerically (P = 0.06) decreased the body weight gain (BWG) by 84 g compared to the control group. The bacterial compositions of the cecal contents were analyzed by sequencing the V3–V4 region of the 16S rRNA gene. Overall, microbial richness and diversity increased (P < 0.02) during the studied period (d 21–35). Cecal contents of birds in the FUM + DON group had greater (P < 0.05) microbial evenness and diversity (Shannon index) compared to the control group. FUM + DON exposure decreased (P = 0.001) the relative abundance of Proteobacteria in the cecal content, compared to the control group. The combined FUM + DON significantly increased the relative abundance of the Defluviitaleaceae and Lachnospiraceae families (P < 0.05) but decreased the abundances of the Moraxellaceae and Streptococcaceae (P < 0.05) compared to the control group birds. At the genus level, FUM + DON exposure decreased (P < 0.05) Acinetobacter and Pseudomonas abundance and had a tendency (P = 0.08) to decrease Thermincola abundance compared to the control group. In the ileum, no NE-specific microscopic abnormalities were found; however, the tip of the ileal villi were compromised. The present findings showed that dietary FUM and DON contamination, even at subclinical levels, altered cecal microbial composition, dysregulated intestinal functions, and impaired the gut immune response, potentially predisposing the birds to necrotic enteritis.

The natural occurrence, toxicity mechanisms and management strategies of Fumonisin B1：A review

Fumonisin B1 (FB1) contaminates various crops, causing huge losses to agriculture and livestock worldwide. This review summarizes the occurrence regularity, toxicity, toxic mechanisms and management strategies of FB1. Specifically, FB1 contamination is particularly serious in developing countries, humid and hot regions. FB1 exposure can produce different toxic effects on the nervous system, respiratory system, digestive system and reproductive system. Furthermore, FB1 can also cause systemic immunotoxicity. The mechanism of toxic effects of FB1 is to interfere with the normal pathway of sphingolipid de novo biosynthesis by acting as a competitive inhibitor of ceramide synthase. Meanwhile, the toxic products of sphingolipid metabolic disorders can cause oxidative stress and apoptosis. FB1 also often causes feed contamination by mixing with other mycotoxins, and then exerts combined toxicity. For detection, lateral flow dipstick technology and enzyme linked immunosorbent assay are widely used in the detection of FB1 in commercial feeds, while mainstream detection methods such as high performance liquid chromatography and liquid chromatography-mass spectrometry are widely used in the laboratory theoretical study of FB1. For purification means of FB1, some natural plant extracts (such as Zingiber officinale and Litsea Cubeba essential oil) and their active compounds have been proved to inhibit the toxic effects of FB1 and protect livestock due to their antifungal and antioxidant effects. Natural plant extract has the advantages of high efficiency, low cost and no contamination residue. This review can provide information for comprehensive understanding of FB1, and provide reference for formulating reasonable treatment and management strategies in livestock production.

Evaluation of Effectiveness of a Novel Multicomponent Mycotoxins Detoxification Agent in the Presence of AFB1 and T-2 Toxin on Broiler Chicks

This experimental study was conducted to determine the ability of a novel mycotoxins detoxification agent (MR) at a concentration of 0.2% to reduce the toxicity of aflatoxin B1 (AFB1) or T-2 toxin, alone or in combination, and to examine its effect on performance, pathohistological changes (PH) and the residue of these toxins in the tissues of broiler chicks. A total of 96 broiler chicks were divided into eight equal groups: group C, which served as control (without any additives); group MR, which received the novel detoxification agent (supplemented with 0.2%); group E-I (0.1 mg AFB1/kg of diet); group E-II (0.1 mg AFB1/kg of diet + MR 0.2%); group E-III (0.5 mg T-2 toxin/kg of diet); group E-IV (0.5 mg T-2 toxin/kg of diet + 0.2% MR); group E-V (combination of 0.1 mg AFB1/kg, 0.5 mg T-2 toxin/kg of diet); and group E-VI (combination of 0.1 mg AFB1/kg, 0.5 mg T-2 toxin + 0.2% MR). Results indicate that feeds containing AFB1 and T-2 toxin, alone or in combination, adversely affected the health and performance of poultry. However, the addition of MR to diets containing AFB1 and T-2 toxin singly and in combination exerted a positive effect on body weight, feed intake, weight gain, feed efficiency and microscopic lesions in visceral organs. Residual concentration of AFB1 in liver samples was significantly (p < 0.05) decreased when chicks were fed diets supplemented with 0.2% of MR.

Assessment of information as regards the toxicity of fumonisins for pigs, poultry and horses

In 2018, the EFSA Panel on Contaminants in the Food Chain (CONTAM) adopted a Scientific Opinion on the risks for animal health related to the presence of fumonisins, their modified forms and hidden forms in feed. A no observed adverse effect level (NOAEL) of 1 mg/kg feed was established for pigs. In poultry a NOAEL of 20 mg/kg feed and in horses a reference point for adverse animal health effect of 8.8 mg/kg feed was established, referred to as NOAEL. The European Commission (EC) requested EFSA to review the information regarding the toxicity of fumonisins for pigs, poultry and horses and to revise, if necessary, the established NOAELs. The EFSA CONTAM Panel considered that the term reference point (RP) for adverse animal health effects better reflects the uncertainties in the available studies. New evidence which had become available since the previous opinion allowed to revise an RP for adverse animal health effects for poultry from 20 mg/kg to 1 mg/kg feed (based on a LOAEL of 2.5 mg/kg feed for reduced intestinal crypt depth) and for horses from 8.8 to 1.0 mg/kg feed (based on case studies on equine leukoencephalomalacia (ELEM)). For pigs, the previously established NOAEL was confirmed as no further studies suitable for deriving an RP for adverse animal health effects could be identified. Based on exposure estimates performed in the previous opinion, the risk of adverse health effects of feeds containing FB1-3 was considered a concern for poultry, when taking into account the RP of 1 mg/kg feed for intestinal effects. For horses and other solipeds, the risk is considered low, although a large uncertainty associated with exposure was identified. The same conclusions apply to the sum of FB1-3 and their hidden forms.

Associative and Physical Mapping of Markers Related to Fusarium in Maize Resistance, Obtained by Next-Generation Sequencing (NGS)

On the basis of studies carried out in the last few years, it is estimated that maize diseases cause yield losses of up to 30% each year. The most dangerous diseases are currently considered to be caused by fungi of the genus Fusarium, which are the main culprits of root rot, ear rots, and stalk rot. Early plant infection causes grain diminution, as well as a significant deterioration in nutritional value and fodder quality due to the presence of harmful mycotoxins. Therefore, the aim of the research was to identify new markers of the SilicoDArT and SNP type, which could be used for the mass selection of varieties resistant to fusarium. The plant material consisted of 186 inbred maize lines. The lines came from experimental plots belonging to two Polish breeding companies: Plant Breeding Smolice Ltd., (Co., Kobylin, Poland). Plant Breeding and Acclimatization Institute-National Research Institute Group (51°41'23.16″ N, 17°4'18.241″ E), and Małopolska Plant Breeding Kobierzyce, Poland Ltd., (Co., Kobierzyce, Poland) (50°58'19.411″ N, 16°55'47.323″ E). As a result of next-generation sequencing, a total of 81,602 molecular markers were obtained, of which, as a result of the associative mapping, 2962 (321 SilicoDArT and 2641 SNP) significantly related to plant resistance to fusarium were selected. Out of 2962 markers significantly related to plant resistance in the fusarium, seven markers (SilicoDArT, SNP) were selected, which were significant at the level of 0.001. They were used for physical mapping. As a result of the analysis, it was found that two out of seven selected markers (15,097-SilicoDArT and 58,771-SNP) are located inside genes, on chromosomes 2 and 3, respectively. Marker 15,097 is anchored to the gene encoding putrescine N-hydroxycinnamoyltransferase while marker 58,771 is anchored to the gene encoding the peroxidase precursor 72. Based on the literature data, both of these genes may be associated with plant resistance to fusarium. Therefore, the markers 15,097 (SilicoDArT) and 58,771 (SNP) can be used in breeding programs to select lines resistant to fusarium.

Targeted Analysis of Sphingolipids in Turkeys Fed Fusariotoxins: First Evidence of Key Changes That Could Help Explain Their Relative Resistance to Fumonisin Toxicity

The effects of fumonisins on sphingolipids in turkeys are unknown, except for the increased sphinganine to sphingosine ratio (Sa:So) used as a biomarker. Fumonisins fed at 20.2 mg/kg for 14 days were responsible for a 4.4 fold increase in the Sa:So ratio and a decrease of 33% and 36% in C14-C16 ceramides and C14-C16 sphingomyelins, respectively, whereas C18-C26 ceramides and C18-C26 sphingomyelins remained unaffected or were increased. Glucosyl- and lactosyl-ceramides paralleled the concentrations of ceramides. Fumonisins also increased dihydroceramides but had no effect on deoxysphinganine. A partial least squfares discriminant analysis revealed that all changes in sphingolipids were important in explaining the effect of fumonisins. Because deoxynivalenol and zearalenone are often found in feed, their effects on sphingolipids alone and in combination with fumonisins were investigated. Feeding 5.12 mg deoxynivalenol/kg reduced dihydroceramides in the liver. Zearalenone fed at 0.47 mg/kg had no effect on sphingolipids. When fusariotoxins were fed simultaneously, the effects on sphingolipids were similar to those observed in turkeys fed fumonisins alone. The concentration of fumonisin B1 in the liver of turkeys fed fumonisins was 0.06 µmol/kg. Changes in sphingolipid concentrations differed but were consistent with the IC50 of fumonisin B1 measured in mammals; these changes could explain the relative resistance of turkeys to fumonisins.

LC-MS/MS Analysis of Fumonisin B1, B2, B3, and Their Hydrolyzed Metabolites in Broiler Chicken Feed and Excreta

An accurate, reliable, and specific method was developed for the quantitative determination of fumonisins B1, B2, B3, and their hydrolyzed metabolites, HFB1, HFB2, and HFB3, in broiler chicken feed and excreta using ultra-performance liquid chromatography combined with tandem mass spectrometry (UPLC-MS/MS). The samples were extracted and diluted for the determination of parent fumonisins. Another portion of the extracted samples was alkaline-hydrolyzed and cleaned using a strong anionic exchange adsorbent (MAX) for the determination of hydrolyzed fumonisins. Chromatographic separation was performed on a CORTECS C18 column (2.1 mm × 100 mm, 1.6 μm) using 0.2% formic acid aqueous solution and methanol with 0.2% formic acid as the mobile phase under gradient elution. The six fumonisins, FB1, FB2, FB3, HFB1, HFB2, and HFB3, were analyzed by tandem mass spectrometry using multiple-reaction monitoring (MRM) mode. The six fumonisins showed good linearity, with relative coefficients of r > 0.99. The limits of quantitation (LOQs) were 160 μg/kg. At the low, medium, and high spiked levels, the recovery of fumonisins in chicken feed and excreta ranged from 82.6 to 115.8%, with a precision (RSD) of 3.9–18.9%. This method was successfully applied to investigate the migration and transformation of fumonisins in broiler chickens.

Levels of T-2 toxin and its metabolites, and the occurrence of Fusarium fungi in spring barley in the Czech Republic

Mycotoxins have been widely studied by many research groups but further multidisciplinary research is needed to better understand and clarify many issues. This study describes the use of high-performance liquid chromatography coupled with ion trap mass spectrometry (HPLC-MS) to measure T-2 toxin and its metabolites, such as HT-2 toxin, neosolaniol (NEO) and diacetoxyscirpenol (DAS), as well as masked glucosylated mycotoxins in Fusarium-infected Czech spring barley. In total, 152 spring barley samples from the 2018 harvest were analyzed by the ELISA screening method for the presence of T-2 toxin. The most contaminated samples (15), which exceeded the recommended maximum level set by the EU for the sum of T-2 and HT-2 toxin in unprocessed cereals (200 μg/kg), were analyzed by HPLC-MS/MS and microbiological testing. Isolated fungi were evaluated microscopically and identified by polymerase chain reaction (PCR) assays. The prevalence of Fusarium species in spring barley across the Czech Republic in 2018 showed a predominance of F. poae (12 barley samples) and F. tricinctum (9 barley samples). Other strains (F. sporotrichioides and F. langsethiae) were present at a lower frequency, in 1 and 2 samples, respectively. The average concentration of T-2 plus HT-2 toxin was 107.7 μg/kg, while NEO and DAS were found in a few samples at values close to their limit of quantification. HT-2 glucoside was identified in all samples.

Fumonisin B1 Accumulates in Chicken Tissues over Time and This Accumulation Was Reduced by Feeding Algo-Clay

The toxicokinetics of the food and feed contaminant Fumonisin B (FB) are characterized by low oral absorption and rapid plasma elimination. For these reasons, FB is not considered to accumulate in animals. However, recent studies in chicken and turkey showed that, in these species, the hepatic half-elimination time of fumonisin B1 (FB1) was several days, suggesting that FB1 may accumulate in the body. For the present study, 21-day-old chickens received a non-toxic dose of around 20 mg FB1 + FB2/kg of feed to investigate whether FB can accumulate in the body over time. Measurements taken after four and nine days of exposure revealed increased concentrations of sphinganine (Sa) and sphingosine (So) over time in the liver, but no sign of toxicity and no effect on performances were observed at this level of FB in feed. Measurements of FB in tissues showed that FB1 accumulated in chicken livers from four to nine days, with concentrations of 20.3 and 32.1 ng FB1/g observed, respectively, at these two exposure periods. Fumonisin B2 (FB2) also accumulated in the liver, from 0.79 ng/g at four days to 1.38 ng/g at nine days. Although the concentrations of FB found in the muscles was very low, an accumulation of FB1 over time was observed in this tissue, with concentrations of 0.036 and 0.072 ng FB1/g being measured after four and nine days of exposure, respectively. Feeding algo-clay to the chickens reduced the accumulation of FB1 in the liver and muscle by , approximately 40 and 50% on day nine, respectively. By contrast, only a weak non-significant effect was observed on day four. The decrease in the concentration of FB observed in tissues of chickens fed FB plus algo-clay on day nine was accompanied by a decrease in Sa and So contents in the liver compared to the levels of Sa and So measured in chickens fed FB alone. FB1 in the liver and Sa or So contents were correlated in liver tissue, confirming that both FB1 and Sa are suitable biomarkers of FB exposure in chickens. Further studies are necessary to determine whether FB can accumulate at higher levels in chicken tissues with an increase in the time of exposure and in the age of the animals.

Fumonisins and zearalenone fed at low levels can persist several days in the liver of turkeys and broiler chickens after exposure to the contaminated diet was stopped

Previous studies using zearalenone (ZEN) and fumonisins (FB) revealed alpha-zearalanol (α-ZOL) and FB1 in the liver of turkeys and chickens with no sign of toxicity. The aim of the present study was to determine whether contamination persists after distribution of a mycotoxin-free diet for several days. Turkeys and broilers were fed for 14 days with a diet containing respectively, 7.5 and 0.6 mg/kg of FB and ZEN, then fed for 0, 2 or 4 days with a mycotoxin-free diet. FB1 and total α-ZOL were the most abundant metabolites found, and their concentration decreased with time. The decrease was linear for FB1 (P < 0.001) and exponential for α-ZOL. Mean concentrations of FB1 on days 0, 2, and 4 were respectively, 4.9, 4, and 2.9 ng/g in turkeys, and respectively, 5, 2.3, and 1.3 ng/g in chickens. The decrease in concentration of FB1 with time was modeled by linear regression (P < 0.001). Mean concentrations of α-ZOL on days 0, 2 and 4, were respectively, 4.8, 0.8, and 0.5 ng/g in turkeys, whereas α-ZOL was only quantified in chickens on day 0 at 0.3 ng/g. A strong correlation was found between α-ZOL and β-zearalenol (P < 0.001).

Feedborne Mycotoxins Beauvericin and Enniatins and Livestock Animals

Mycotoxins are secondary metabolites produced by several species of fungi, including the Fusarium, Aspergillus, and Penicillium species. Currently, more than 300 structurally diverse mycotoxins are known, including a group called minor mycotoxins, namely enniatins, beauvericin, and fusaproliferin. Beauvericin and enniatins possess a variety of biological activities. Their antimicrobial, antibiotic, or ionoforic activities have been proven and according to various bioassays, they are believed to be toxic. They are mainly found in cereal grains and their products, but they have also been detected in forage feedstuff. Mycotoxins in feedstuffs of livestock animals are of dual concern. First one relates to the safety of animal-derived food. Based on the available data, the carry-over of minor mycotoxins from feed to edible animal tissues is possible. The second concern relates to detrimental effects of mycotoxins on animal health and performance. This review aims to summarize current knowledge on the relation of minor mycotoxins to livestock animals.

Zearalenone and Metabolites in Livers of Turkey Poults and Broiler Chickens Fed with Diets Containing Fusariotoxins

Zearalenone (ZEN) and metabolites were measured in livers of turkeys and broilers fed a control diet free of mycotoxins, a diet that contained 0.5 mg/kg ZEN (ZEN diet), and a diet that contained 0.5, 5, and 20 mg/kg of ZEN, fumonisins, and deoxynivalenol, respectively (ZENDONFB diet). The feed was individually distributed to male Grade Maker turkeys from the 55th to the 70th day of age and to male Ross chickens from the 1st to the 35th day of age, without any signs of toxicity. Together, the free and conjugated forms of ZEN, α- and β-zearalenols (ZOLs), zearalanone (ZAN), and α- and β-zearalanols (ZALs) were measured by UHPLC-MS/MS with [¹³C₁₈]-ZEN as an internal standard and immunoaffinity clean-up of samples. ZAN and ZALs were not detected. ZEN and ZOLs were mainly found in their conjugated forms. α-ZOL was the most abundant and was found at a mean concentration of 2.23 and 1.56 ng/g in turkeys and chickens, respectively. Consuming the ZENDONFB diet significantly increased the level of total metabolites in the livers of chickens. Furthermore, this increase was more pronounced for the free forms of α-ZOL than for the conjugated forms. An investigation of the presence of ZEN and metabolites in muscle with the methods validated for the liver failed to reveal any traces of these contaminants in this tissue. These results suggest that concomitant dietary exposure to deoxynivalenol (DON) and fumonisins (FB) may alter the metabolism and persistence of ZEN and its metabolites in the liver.

Lactobacillus spp. reduces morphological changes and oxidative stress induced by deoxynivalenol on the intestine and liver of broilers

The mycotoxin deoxynivalenol (DON) contaminates animal feed worldwide, frequently resulting in poor performance and economic losses. Data concerning the effects on poultry health or focusing on intestinal toxicity or the response to oxidative stress are scarce. Also, there is a need for strategies to mitigate the negative effects of DON. This study aimed to investigate the effects of Lactobacillus spp. treatments on the intestine, liver and kidney of poultry fed a DON-contaminated diet. To achieve this aim, histological, morphometrical and histochemical assays were performed. The oxidative stress response was also analyzed by the tests: reduced glutathione, ferric reducing ability, reducing of 2,2'-azino-bis (3-ethylbenzothiazoline-6-sulphonic acid), nitro blue tetrazolium detection of superoxide anion, and thiobarbituric acid reactive substances. One-day-old broilers chickens (n 50) were submitted to the following treatments: control, DON (19.3 mg kg^-1), viable Lactobacillus spp. + DON (VL + DON), heat-inactivated Lactobacillus spp. + DON (HIL + DON), Lactobacillus spp. culture supernatant + DON (LCS + DON). The animals received the contaminated diet for seven days. DON increased the intestinal and liver lesion score, while the Lactobacillus spp. treatments (LT) remained like the control. DON reduced the villi height and increased the crypt depths. The LT showed crypt depths similar to control, and higher villi: crypt ratio in duodenum and jejunum. In the ileum, the LT reduced the goblet cell count in relation to DON group. DON increased the number of intraepithelial lymphocytes (IEL) in jejunum and ileum, while the VL + DON treatment induced a significant decrease in IEL in comparison to DON. DON-diet induced an oxidative stress response in the intestine and liver, and also reduced the antioxidant capacity in these tissues, while LT treatments remained mostly similar to control. DON induced no change in redox balance in the kidney. The LT improved the intestinal health after DON acute exposure, reducing the oxidative stress damage mainly on jejunum and liver.

Toxicokinetics of Hydrolyzed Fumonisin B1 after Single Oral or Intravenous Bolus to Broiler Chickens Fed a Control or a Fumonisins-Contaminated Diet

The toxicokinetics (TK) of hydrolyzed fumonisin B₁ (HFB₁) were evaluated in 16 broiler chickens after being fed either a control or a fumonisins-contaminated diet (10.8 mg fumonisin B₁, 3.3 mg B₂ and 1.5 mg B₃/kg feed) for two weeks, followed by a single oral (PO) or intravenous (IV) dose of 1.25 mg/kg bodyweight (BW) of HFB₁. Fumonisin B₁ (FB₁), its partially hydrolyzed metabolites pHFB_1a and pHFB_1b, and fully hydrolyzed metabolite HFB₁, were determined in chicken plasma using a validated ultra-performance liquid chromatography–tandem mass spectrometry method. None of the broiler chicken showed clinical symptoms of fumonisins (FBs) or HFB₁ toxicity during the trial, nor was an aberration in body weight observed between the animals fed the FBs-contaminated diet and those fed the control diet. HFB₁ was shown to follow a two-compartmental pharmacokinetic model with first order elimination in broiler chickens after IV administration. Toxicokinetic parameters of HFB₁ demonstrated a total body clearance of 16.39 L/kg·h and an intercompartmental flow of 8.34 L/kg·h. Low levels of FB₁ and traces of pHFB_1b were found in plasma of chickens fed the FBs-contaminated diet. Due to plasma concentrations being under the limit of quantification (LOQ) after oral administration of HFB₁, no toxicokinetic modelling could be performed in broiler chickens after oral administration of HFB₁. Moreover, no phase II metabolites, nor N-acyl-metabolites of HFB₁ could be detected in this study.

Fumonisin B1, B2 and B3 in Muscle and Liver of Broiler Chickens and Turkey Poults Fed with Diets Containing Fusariotoxins at the EU Maximum Tolerable Level

Although provisional maximum tolerable daily intake and recommended guidelines have been established for fumonisins (FB) in food, few data are available concerning levels of FB in edible animal tissues. Such data are of particular interest in avian species that can tolerate relatively high levels of fumonisins in their feed. Also, even if multiple contamination of animal feed by toxins produced by Fusarium is very frequent, little is known about the consequences of multiple contamination for FB levels in tissues. The aim of this study was to analyze the concentrations of FB in the muscle and liver of chickens and turkeys fed with FB alone and with FB combined with deoxynivalenol (DON), and with zearalenone (ZEN). Experimental diets were formulated by incorporating ground cultured toxigenic Fusarium strains in corn-soybean based feeds. Control diets were free of mycotoxins, FB diets contained 20 mg FB1+FB2/kg, and FBDONZEN diets contained 20, 5, and 0.5 mg/kg of FB1+FB2, DON, and ZEN, respectively. Animals were reared in individual cages with free access to water and feed. The feed was distributed to male Ross chickens from the 1st to the 35th day of age and to male Grade Maker turkeys from the 55th to the 70th day of age. On the last day of the study, the birds were starved for eight hours, killed, and autopsied for tissues sampling. No sign of toxicity was observed. A UHPLC-MS/MS method with isotopic dilution and immunoaffinity clean-up of samples has been developed for analysis of FB in muscle (n = 8 per diet) and liver (n = 8 per diet). Only traces of FB that were below the LOQ of 0.25 µg/kg were found in most of the samples of animals fed with the control diets. Mean concentrations of FB1, FB2, and FB3 in muscle were 17.5, 3.39, and 1.26 µg/kg, respectively, in chickens, and 5.77, 1.52, and 0.54 µg/kg in turkeys, respectively. In the liver, the respective FB1, FB2, and FB3 concentrations were 44.7, 2.61, and 0.79 µg/kg in chickens, and 41.47, 4.23, and 1.41 µg/kg, in turkeys. Cumulated level of FB1+FB2+FB3 in the highly contaminated samples were above 60 and 100 µg/kg in muscle and liver, respectively. The concentrations of FB in the tissues of animals fed the FBDONZEN diet did not greatly differ from the concentrations measured in animals fed the diet containing only FB.

Lack of Toxic Interaction Between Fusariotoxins in Broiler Chickens Fed throughout Their Life at the Highest Level Tolerated in the European Union

Fusarium mycotoxins (FUS) occur frequently in poultry diets, and regulatory limits are laid down in several countries. However, the limits were established for exposure to a single mycotoxin, whereas multiple contamination is more realistic, and different studies have demonstrated that it is not possible to predict interactions between mycotoxins. The purpose of this study was thus to compare the toxic effect of deoxynivalenol (DON), fumonisins (FB) and zearalenone (ZON), alone and in combination on broiler chickens, at the maximum tolerated level established by the EU for poultry feed. Experimental corn-soybean diets incorporated ground cultured toxigenic Fusarium strains. One feed was formulated for chickens 0 to 10 days old and another for chickens 11 to 35 days old. The control diets were mycotoxin free, the DON diets contained 5 mg DON/kg, the FB diet contained 20 mg FB1 + FB2/kg, and the ZON diet contained 0.5 mg ZON/kg. The DONFBZON diet contained 5, 20, and 0.5 mg/kg of DON, FB1 + FB2, and ZON, respectively. Diets were distributed ad libitum to 70 broilers (male Ross PM3) separated into five groups of 14 chickens each reared in individual cages from one to 35 days of age. On day 35, after a starvation period of 8 h, a blood sample was collected, and all the animals were killed and autopsied. No difference between groups that could be attributed to FUS was observed in performances, the relative weight of organs, biochemistry, histopathology, intestinal morphometry, variables of oxidative damage, and markers of testicle toxicity. A significant increase in sphinganine and in the sphinganine to sphingosine ratio was observed in broilers fed FB. Taken together, these results suggest that the regulatory guidelines established for single contamination of broiler chickens fed with DON, FB, and ZON can also be used in the case of multiple contamination with these toxins.

Feeding study for the mycotoxin zearalenone in yellow mealworm (Tenebrio molitor) larvae-investigation of biological impact and metabolic conversion

Edible insects as additional food and/or feed source may represent one important component to solve the problem of food security for a growing human population. Especially for covering the rising demand for protein of animal origin, seven insect species currently allowed as feed constituents in the European Union are gaining more interest. However, before considering insects such as yellow mealworm larvae (Tenebrio molitor) as suitable for, e.g. human consumption, the possible presence and accumulation of contaminants must be elucidated. The present work investigates the effects of the mycotoxin zearalenone (ZEN) and its metabolites on insect larvae. Seven different diets were prepared: toxin-free control, spiked and artificially contaminated (both containing approx.500 μg/kg and approx. 2000 μg/kg of ZEN) as well as two naturally contaminated diets (600 μg/kg and 900 μg/kg ZEN). The diets were used in a multiple-week feeding trial using T. molitor larvae as model insects. The amount of ZEN and its metabolites in the feed, larvae and the residue were measured by HPLC-MS/MS. A significantly enhanced individual larval weight was found for the insects fed on the naturally contaminated diets compared to the other feeding groups after 8 weeks of exposure. No ZEN or ZEN metabolites were detected in the T. molitor larvae after harvest. However, ZEN, α- and β-stereoisomers of zearalenol were found in the residue samples indicating an intense metabolism of ZEN in the larvae. No further ZEN metabolites could be detected in any sample. Thus, ZEN is not retained to any significant amount in T. molitor larvae.

Mycotoxins at the Start of the Food Chain in Costa Rica: Analysis of Six Fusarium Toxins and Ochratoxin A between 2013 and 2017 in Animal Feed and Aflatoxin M1 in Dairy Products

Mycotoxins are secondary metabolites, produced by fungi of genera Aspergillus, Penicillium and Fusarium (among others), which produce adverse health effects on humans and animals (carcinogenic, teratogenic and immunosuppressive). In addition, mycotoxins negatively affect the productive parameters of livestock (e.g., weight, food consumption, and food conversion). Epidemiological studies are considered necessary to assist stakeholders with the process of decision-making regarding the control of mycotoxins in processing environments. This study addressed the prevalence in feed ingredients and compound feed of eight different types of toxins, including metabolites produced by Fusarium spp. (Deoxynivalenol/3-acetyldeoxynivalenol, T-2/HT-2 toxins, zearalenone and fumonisins) and two additional toxins (i.e., ochratoxin A (OTA) and aflatoxin M1 (AFM1)) from different fungal species, for over a period of five years. On the subject of Fusarium toxins, higher prevalences were observed for fumonisins (n = 80/113, 70.8%) and DON (n = 212/363, 58.4%), whereas, for OTA, a prevalence of 40.56% was found (n = 146/360). In the case of raw material, mycotoxin contamination exceeding recommended values were observed in cornmeal for HT-2 toxin (n = 3/24, 12.5%), T-2 toxin (n = 3/61, 4.9%), and ZEA (n = 2/45, 4.4%). In contrast, many compound feed samples exceeded recommended values; in dairy cattle feed toxins such as DON (n = 5/147, 3.4%), ZEA (n = 6/150, 4.0%), T-2 toxin (n = 10/171, 5.9%), and HT-2 toxin (n = 13/132, 9.8%) were observed in high amounts. OTA was the most common compound accompanying Fusarium toxins (i.e., 16.67% of co-occurrence with ZEA). This study also provided epidemiological data for AFM1 in liquid milk. The outcomes unveiled a high prevalence of contamination (i.e., 29.6-71.1%) and several samples exceeding the regulatory threshold. Statistical analysis exposed no significant climate effect connected to the prevalence of diverse types of mycotoxins.

Enzymatic hydrolysis of fumonisins in the gastrointestinal tract of broiler chickens

Fumonisins (FB) are among the most frequently detected mycotoxins in feedstuffs and finished feed, and recent data suggest that the functions of the gastrointestinal tract (GIT) in poultry species might be compromised at doses ranging from 10 to 20 mg/kg, close to field incidences and below the US and EU guidelines. Strategies are therefore necessary to reduce the exposure of poultry to FB. In the present study, we assessed the efficacy of fumonisin esterase FumD (EC 3.1.1.87, commercial name FUMzyme®) to cleave the tricarballylic acid side chains of FB, leading to the formation of non-toxic hydrolyzed fumonisins in the GIT of broiler chickens. Broiler chickens were fed for 14 d (7 to 21 d of age) 3 different diets (6 birds/cage, 6 cages/diet), i) control feed (negative control group), ii) feed contaminated with 10 mg FB/kg (FB group), and iii) feed contaminated with 10 mg FB/kg and supplemented with 100 units of FUMzyme®/kg (FB+FUMzyme® group). To determine the degree of reduction of FB in the GIT, 2 characteristics were analyzed. First, the sphinganine-to-sphingosine ratio in the serum and liver was determined as a biomarker of effect for exposure to FB. Second, the concentration of fumonisin B1 and its hydrolyzed forms was evaluated in the gizzard, the proximal and distal parts of the small intestine, and the excreta. Significantly reduced sphinganine-to-sphingosine ratios in the serum and liver of the FB+FUMzyme® group (serum: 0.15 ± 0.01; liver: 0.17 ± 0.01) compared to the FB group (serum: 0.20 ± 0.01; liver: 0.29 ± 0.03) proved that supplementation of broiler feed with FUMzyme® was effective in partially counteracting the toxic effect of dietary FB. Likewise, FB concentrations in digesta and excreta were significantly reduced in the FB+FUMzyme® group compared to the FB group (P < 0.05; up to 75%). FUMzyme® furthermore partially counteracted FB-induced up-regulation of cytokine gene expression (IL-8 and IL-10) in the jejunum. The FB group showed significantly higher gene expression of IL-8 and IL-10 compared to the negative control group (IL-8: fold change = 2.9 ± 1.1, P < 0.05; IL-10: fold change = 3.6 ± 1.4, P < 0.05), whereas IL-8 and IL-10 mRNA levels were not significantly different in the FB+FUMzyme®® group compared to the other 2 groups. In conclusion, FUMzyme® is suitable to detoxify FB in chickens and maintain gut functions.

Risks for animal health related to the presence of fumonisins, their modified forms and hidden forms in feed

Fumonisins, mycotoxins primarily produced by Fusarium verticillioides and Fusarium proliferatum, occur predominantly in cereal grains, especially in maize. The European Commission asked EFSA for a scientific opinion on the risk to animal health related to fumonisins and their modified and hidden forms in feed. Fumonisin B1 (FB 1), FB 2 and FB 3 are the most common forms of fumonisins in feedstuffs and thus were included in the assessment. FB 1, FB 2 and FB 3 have the same mode of action and were considered as having similar toxicological profile and potencies. For fumonisins, the EFSA Panel on Contaminants in the Food Chain (CONTAM) identified no-observed-adverse-effect levels (NOAELs) for cattle, pig, poultry (chicken, ducks and turkeys), horse, and lowest-observed-adverse-effect levels (LOAELs) for fish (extrapolated from carp) and rabbits. No reference points could be identified for sheep, goats, dogs, cats and mink. The dietary exposure was estimated on 18,140 feed samples on FB 1-3 representing most of the feed commodities with potential presence of fumonisins. Samples were collected between 2003 and 2016 from 19 different European countries, but most of them from four Member States. To take into account the possible occurrence of hidden forms, an additional factor of 1.6, derived from the literature, was applied to the occurrence data. Modified forms of fumonisins, for which no data were identified concerning both the occurrence and the toxicity, were not included in the assessment. Based on mean exposure estimates, the risk of adverse health effects of feeds containing FB 1-3 was considered very low for ruminants, low for poultry, horse, rabbits, fish and of potential concern for pigs. The same conclusions apply to the sum of FB 1-3 and their hidden forms, except for pigs for which the risk of adverse health effect was considered of concern.

Comparative Toxicokinetics and Plasma Protein Binding of Ochratoxin A in Four Avian Species

Ochratoxin A (OTA, 0.25 mg/kg body weight) was absorbed rapidly ( T_max = 0.31-1.88 h) in all avian species (broiler chickens, laying hens, turkeys, and Muscovy ducks) but more slowly in broiler chickens ( T_max = 1.43-4.63 h). The absolute oral bioavailability was complete in these bird species (88.0-109.6%). Ducks have a significantly higher volume of distribution ( V_d) and turkeys a lower V_d compared to chickens and layers (broiler chickens, 0.27 ± 0.12 L/kg; layers, 0.23 ± 0.08 L/kg; turkeys, 0.18 ± 0.04 L/kg; ducks, 0.76 ± 0.44 L/kg). This difference in V_d can be attributed to the species-dependent differences in plasma protein binding of OTA, namely ranging between 82.2 and 88.9% in ducks and between 96.5 and 98.8% in turkeys. No significant gender differences were found in toxicokinetics or plasma protein binding.

Risks to human and animal health related to the presence of deoxynivalenol and its acetylated and modified forms in food and feed

Deoxynivalenol (DON) is a mycotoxin primarily produced by Fusarium fungi, occurring predominantly in cereal grains. Following the request of the European Commission, the CONTAM Panel assessed the risk to animal and human health related to DON, 3-acetyl-DON (3-Ac-DON), 15-acetyl-DON (15-Ac-DON) and DON-3-glucoside in food and feed. A total of 27,537, 13,892, 7,270 and 2,266 analytical data for DON, 3-Ac-DON, 15-Ac-DON and DON-3-glucoside, respectively, in food, feed and unprocessed grains collected from 2007 to 2014 were used. For human exposure, grains and grain-based products were main sources, whereas in farm and companion animals, cereal grains, cereal by-products and forage maize contributed most. DON is rapidly absorbed, distributed, and excreted. Since 3-Ac-DON and 15-Ac-DON are largely deacetylated and DON-3-glucoside cleaved in the intestines the same toxic effects as DON can be expected. The TDI of 1 μg/kg bw per day, that was established for DON based on reduced body weight gain in mice, was therefore used as a group-TDI for the sum of DON, 3-Ac-DON, 15-Ac-DON and DON-3-glucoside. In order to assess acute human health risk, epidemiological data from mycotoxicoses were assessed and a group-ARfD of 8 μg/kg bw per eating occasion was calculated. Estimates of acute dietary exposures were below this dose and did not raise a health concern in humans. The estimated mean chronic dietary exposure was above the group-TDI in infants, toddlers and other children, and at high exposure also in adolescents and adults, indicating a potential health concern. Based on estimated mean dietary concentrations in ruminants, poultry, rabbits, dogs and cats, most farmed fish species and horses, adverse effects are not expected. At the high dietary concentrations, there is a potential risk for chronic adverse effects in pigs and fish and for acute adverse effects in cats and farmed mink.

Studies on the Presence of Mycotoxins in Biological Samples: An Overview

Mycotoxins are fungal secondary metabolites with bioaccumulation levels leading to their carry-over into animal fluids, organs, and tissues. As a consequence, mycotoxin determination in biological samples from humans and animals has been reported worldwide. Since most mycotoxins show toxic effects at low concentrations and considering the extremely low levels present in biological samples, the application of reliable detection methods is required. This review summarizes the information regarding the studies involving mycotoxin determination in biological samples over the last 10 years. Relevant data on extraction methodology, detection techniques, sample size, limits of detection, and quantitation are presented herein. Briefly, liquid-liquid extraction followed by LC-MS/MS determination was the most common technique. The most analyzed mycotoxin was ochratoxin A, followed by zearalenone and deoxynivalenol—including their metabolites, enniatins, fumonisins, aflatoxins, T-2 and HT-2 toxins. Moreover, the studies were classified by their purpose, mainly focused on the development of analytical methodologies, mycotoxin biomonitoring, and exposure assessment. The study of tissue distribution, bioaccumulation, carry-over, persistence and transference of mycotoxins, as well as, toxicokinetics and ADME (absorption, distribution, metabolism and excretion) were other proposed goals for biological sample analysis. Finally, an overview of risk assessment was discussed.

Worldwide Mycotoxins Exposure in Pig and Poultry Feed Formulations

The purpose of this review is to present information about raw materials that can be used in pig and poultry diets and the factors responsible for variations in their mycotoxin contents. The levels of mycotoxins in pig and poultry feeds are calculated based on mycotoxin contamination levels of the raw materials with different diet formulations, to highlight the important role the stage of production and the raw materials used can have on mycotoxins levels in diets. Our analysis focuses on mycotoxins for which maximum tolerated levels or regulatory guidelines exist, and for which sufficient contamination data are available. Raw materials used in feed formulation vary considerably depending on the species of animal, and the stage of production. Mycotoxins are secondary fungal metabolites whose frequency and levels also vary considerably depending on the raw materials used and on the geographic location where they were produced. Although several reviews of existing data and of the literature on worldwide mycotoxin contamination of food and feed are available, the impact of the different raw materials used on feed formulation has not been widely studied.

Age-related change of hepatic uridine diphosphate glucuronosyltransferase and sulfotransferase activities in male chickens and pigs

The hepatic activities of uridine diphosphate glucuronosyltransferase (UGT) and sulfotransferase (SULT) of male Ross 708 broiler chickens at the age of 1, 7, 14, 28, and 56 days and male Camborough-29 pigs at the age of 1 day and 2, 5, 10, and 20 weeks were investigated. Glucuronidation and sulfation of 4-nitrophenol were used to evaluate the activities. Porcine hepatic UGT and SULT activities were low at birth, peaked at around 5-10 weeks, and then declined. Both hepatic UGT and SULT activities of chickens were high at hatch and declined. Chicken hepatic UGT activity had a peak at the age of 28 days. Affinity of hepatic SULT to 4-nitrophenol is similar in chickens and pigs, but the affinity of hepatic UGT in pigs was about 10 times higher than that in chickens. 4-nitrophenol was predominantly conjugated by SULT instead of UGT in chicken livers from hatch to day 56. Conversely, hepatic UGT contributed predominantly in 4-nitrophenol conjugation than the SULT in pigs from birth to 20 weeks. Therefore, age has significant impact on hepatic activities of UGT and SULT, and the importance of UGT and SULT on conjugation is different in chickens and pigs.

Gastrointestinal Degradation of Fumonisin B₁ by Carboxylesterase FumD Prevents Fumonisin Induced Alteration of Sphingolipid Metabolism in Turkey and Swine

The mycotoxin fumonisin B₁ (FB₁) is a frequent contaminant of feed and causes various adverse health effects in domestic animals. Hence, effective strategies are needed to prevent the impact of fumonisins on livestock productivity. Here we evaluated the capability of the fumonisin carboxylesterase FumD to degrade FB₁ to its less toxic metabolite hydrolyzed FB₁ (HFB₁) in the gastrointestinal tract of turkeys and pigs. First, an ex vivo pig model was used to examine the activity of FumD under digestive conditions. Within 2 h of incubation with FumD, FB₁ was completely degraded to HFB₁ in the duodenum and jejunum, respectively. To test the efficacy of the commercial application of FumD (FUMzyme) in vivo, female turkeys (n = 5) received either basal feed (CON), fumonisin-contaminated feed (15 mg/kg FB₁+FB₂; FB) or fumonisin-contaminated feed supplemented with FUMzyme (15 U/kg; FB+FUMzyme) for 14 days ad libitum. Addition of FUMzyme resulted in significantly decreased levels of FB₁ in excreta, whereas HFB₁ concentrations were significantly increased. Compared to the FB group (0.24 ± 0.02), the mean serum sphinganine-to-sphingosine (Sa/So) ratio was significantly reduced in the FB+FUMzyme group (0.19 ± 0.02), thus resembling values of the CON group (0.16 ± 0.02). Similarly, exposure of piglets (n = 10) to 2 mg/kg FB₁+FB₂ for 42 days caused significantly elevated serum Sa/So ratios (0.39 ± 0.15) compared to the CON group (0.14 ± 0.01). Supplementation with FUMzyme (60 U/kg) resulted in gastrointestinal degradation of FB₁ and unaffected Sa/So ratios (0.16 ± 0.02). Thus, the carboxylesterase FumD represents an effective strategy to detoxify FB₁ in the digestive tract of turkeys and pigs.

Review on Mycotoxin Issues in Ruminants: Occurrence in Forages, Effects of Mycotoxin Ingestion on Health Status and Animal Performance and Practical Strategies to Counteract Their Negative Effects

Ruminant diets include cereals, protein feeds, their by-products as well as hay and grass, grass/legume, whole-crop maize, small grain or sorghum silages. Furthermore, ruminants are annually or seasonally fed with grazed forage in many parts of the World. All these forages could be contaminated by several exometabolites of mycotoxigenic fungi that increase and diversify the risk of mycotoxin exposure in ruminants compared to swine and poultry that have less varied diets. Evidence suggests the greatest exposure for ruminants to some regulated mycotoxins (aflatoxins, trichothecenes, ochratoxin A, fumonisins and zearalenone) and to many other secondary metabolites produced by different species of Alternaria spp. (e.g., AAL toxins, alternariols, tenuazonic acid or 4Z-infectopyrone), Aspergillus flavus (e.g., kojic acid, cyclopiazonic acid or β-nitropropionic acid), Aspergillus fuminatus (e.g., gliotoxin, agroclavine, festuclavines or fumagillin), Penicillium roqueforti and P. paneum (e.g., mycophenolic acid, roquefortines, PR toxin or marcfortines) or Monascus ruber (citrinin and monacolins) could be mainly related to forage contamination. This review includes the knowledge of mycotoxin occurrence reported in the last 15 years, with special emphasis on mycotoxins detected in forages, and animal toxicological issues due to their ingestion. Strategies for preventing the problem of mycotoxin feed contamination under farm conditions are discussed.