Rapid and simultaneous quantitation of Escherichia coli 0157:H7, Salmonella, and Shigella in ground beef by multiplex real-time PCR and immunomagnetic separation

Electrospun Nanofiber-Based Biosensors for Foodborne Bacteria Detection

Food contamination has emerged as a significant global health concern, posing substantial challenges to the food industry. Bacteria are the primary cause of foodborne diseases. Consequently, it is crucial to develop accurate and efficient sensing platforms to detect foodborne bacteria in food products. Among various detection methods, biosensors have emerged as a promising solution due to their portability, affordability, simplicity, selectivity, sensitivity, and rapidity. Electrospun nanofibers have gained increasing popularity in enhancing biosensor performance. These nanofibers possess a distinctive three-dimensional structure, providing a large surface area and ease of preparation. This review provides an overview of the electrospinning technique, nanofibers and nanofiber-based biosensors. It also explores their mechanisms and applications in the detection of foodborne bacteria such as Salmonella, Listeria monocytogenes (L. monocytogenes), Escherichia coli (E. coli), Staphylococcus aureus (S. aureus) and Pseudomonas putida (P. putida).

Amino acid digestibility of insect meals and effects on key bacterial groups in excreta of caecectomised laying hens

The chemical composition and amino acids (AA) digestibility were determined in insect meals from mealworms, crickets, black soldier fly (BSF) larvae and BSF prepupae, and soybean meal. Six caecectomised laying hens were individually housed in metabolism cages and fed either a basal diet or one of five assay diets. Diets and hens were arranged in a 6 × 6 Latin square design with 6 subsequent periods. In each period, the laying hens were fed their respective diet for 9 d, and excreta samples were quantitatively collected twice daily from day 5 to 8. On day 9, a sterile plastic bag was attached to the cloaca of each hen to collect excreta for microbiota analysis. The AA digestibility of the insect meals and soybean meal were calculated using a linear regression approach. Crude protein (CP) concentrations in crickets and mealworms were higher than the value in soybean meal, BSF prepupae and BSF larvae. Ether extract concentrations were high in the insect meals and low in the soybean meal. The digestibility of most essential AA in soybean meal was higher (p < 0.05) than in crickets and BSF prepupae and not different from AA digestibility in mealworms and BSF larvae (except for arginine and histidine). The gene copy number of Escherichia coli in excreta from hens fed with BSF prepupae was lower (p < 0.05) than those fed with BSF larvae, whereas the gene copy number of Bacillus spp. and Clostridium spp. in excreta from hens fed with crickets was lower (p < 0.05) than those fed with BSF larvae. In conclusion, the chemical composition and AA digestibility varied among insect meals based on insect species and life stage. The high level of AA digestibility of insect meals supports the assessment that insect meals are a suitable feed component for laying hens, but differences in AA digestibility should be considered in diet formulation.

The impact of osmotic stresses on the biofilm formation, immunodetection, and morphology of Aeromonas hydrophila

Aeromonas hydrophila (Ah) is a zoonotic pathogen of great importance to aquaculture and human health. This study systematically evaluated the impact of salinity, sugar, ammonia nitrogen, and nitric nitrogen levels on the fitness of Ah by using Luria-Bertani (LB) broth supplemented with different concentrations of NaCl, sucrose, NH₄Cl, urea, NaNO₂ or NaNO₃. Results showed that the static biofilm formation of Ah was higher at 28 °C compared to 37 °C (P < 0.05). At 28 °C, as the NaCl (>1 %) and sucrose levels increased, the Ah biofilm formation and the binding between Ah cells and monoclonal antibodies (mAbs, for immunodetection) decreased. Elevated ammonia nitrogen and nitric nitrogen levels generated no significant impact on Ah biofilm formation or immunodetection (P > 0.05). The expression of mAbs-targeted Omp remained unchanged under high NaCl or sucrose conditions. Further analysis showed that high sucrose conditions led to the over-expression of the extracellular polysaccharides (PS) and promoted the formation of capsule-like structures. These over-expressed PS and capsule structures might be one reason explaining the inhibited immunodetection efficacy. Results generated from this study provide crucial insights for the design of recovery and detection protocols for Ah present in food or environmental samples.

Detection of Escherichia coli in Food Samples Using Culture and Polymerase Chain Reaction Methods

Methods for the rapid detection of Escherichia coli and its related toxins are key to minimizing the risk of exposure to foodborne pathogens. The present study aimed to detect E. coli in food specimens using culture and polymerase chain reaction (PCR) techniques. One hundred and fifty samples from different types of food, comprising beef (n=60), chicken (n=72), and fish (n=18), were analyzed for the identification of E. coli by conventional and PCR methods. The results showed that out of 150 food samples, 44 (29.3%) were positive by culture, and 50 (33.3%) were positive by PCR. Significant differences were detected between sample types with culture (p-value < 0.005). When culture was considered the gold standard, the sensitivity of PCR was 100%, while the specificity was 94.34%. The six-hour pre-enrichment and PCR analysis are reliable in fast detection of E. coli in food samples. Hence, the identification of food pathogens using molecular-based methods would become more useful in routine diagnostic laboratories.

Rapid and Multiplexed Detection of Single Cells of Salmonella, Escherichia coli O157, and Shigella flexneri in Ground Beef by Flow Cytometry

Salmonella, Escherichia coli O157, and Shigella flexneri are typical foodborne pathogens in ground beef, which can cause severe infection even when present as a single cell. Flow cytometry (FCM) methods are widely applied in the rapid detection of pathogens in food products. In this study, we report an FCM-based method for detecting single cells of Salmonella, E. coli O157, and S. flexneri in 25 g ground beef samples. We fluorescently labeled specific antibodies that could effectively identify bacterial cells, prepared single-cell samples by serial dilution, and optimized the pre-enrichment time. The results showed that 7 h of pre-enrichment is appropriate for sensitive single-cell detection by FCM. Finally, we evaluated this method in artificially contaminated and retail beef samples. This study outlines a novel highly sensitive FCM-based method to detect Salmonella, E. coli O157, and S. flexneri in beef samples within 8 h that can be applied to the rapid and multiplexed detection of foodborne pathogens.

Rapid and multiplexed quantification of Salmonella, Escherichia coli O157:H7, and Shigella flexneri in ground beef using flow cytometry

Salmonella, Escherichia coli O157:H7 (E. coli O157:H7) and Shigella flexneri (S. flexneri) might contaminate similar types of meat products and cause deadly diseases in humans. In reality, ground beef samples may carry more than one pathogen and a rapid and accurate detection method for the simultaneous identification of multiple specific pathogenic strains in ground beef is crucial. In this study, a sample pretreatment protocol and a flow cytometry method were developed for rapid and multiplexed quantification of the three pathogens without cultural enrichment in ground beef. The whole process of sample pretreatment, staining, and instrument analysis can be accomplished within 1 h. The three bacteria upon sample pretreatment were demonstrated good recoveries (93.8%-101.2%). The quantitative detection range of the mothed was 10³ to 10⁸ cells/g for all three pathogens, and the detection limit for Salmonella, E. coli O157:H7 and S. flexneri in ground beef were 3.1 × 10³ cells/g, 2.1 × 10³ cells/g and 2.3 × 10³ cells/g, respectively. Therefore, the as-developed approach is a rapid and quantitative method for multiplexed detection of Salmonella, E. coli O157:H7, and S. flexneri in ground beef.

Rapid and Sensitive Pathogen Detection by DNA Amplification Using Janus Particle-Enabled Rotational Diffusometry

Rapid and sensitive detection of infectious bacteria is in all-time high demand to prevent the further spread of the infection and allow early medical intervention. In this study, we use rotational diffusometry (RD), a natural phenomenon characterized by Janus particles, to detect pathogens like Escherichia coli by performing amplification of specific genes. This biosensing method is used to measure the change in viscosity of the fluid in the presence and absence of DNA in the solution by capturing images of modified microbeads at 10 Hz by a CCD camera followed by cross-correlation algorithm analysis. Using rotational diffusometry, we have achieved E. coli detection with 50 pg/μL DNA with a measurement time of 30 s and a sample volume of 2 μL. This sensitivity was achieved with 30 thermal cycles for three different amplicons, viz., 84, 147, and 246 bp. Meanwhile, in the case of 10 and 20 thermal cycles, the detection sensitivity was achieved with 0.1 and 1 ng/μL DNA concentrations for a 246 bp amplicon. Compared with conventional PCR, this technique appears to improve the detection time, thereby reaching a turnaround time of less than 60 min. Other studies showed a successful identification of DNA amplification up to 10 thermal cycles with different sizes of amplicons. The effect of DNA concentration, amplicon size, and the number of thermal cycles on the detection of E. coli was examined in detail and represented in the form of three maps. These maps show the clear difference and the advantages of RD method in comparison with conventional PCR. This unconventional and rapid biosensing method can be used further for downstream application of nucleic acid amplification-based pathogen detection and early disease control.

Rapid and simultaneous purification of aflatoxin B1, zearalenone and deoxynivalenol using their monoclonal antibodies and magnetic nanoparticles

To develop a new simple and simultaneous purification method for mycotoxins in feeds and grains, magnetic nanoparticles (MNPs) conjugated with monoclonal antibodies (mAbs) against mycotoxins were used to separate aflatoxin B1 (AFB₁), zearalenone (ZEA) and deoxynivalenol (DON). For a single spike of each mycotoxin into the buffer solution (16% MeOH in PBS), mean recoveries were 93.1-95.0% for AFB₁ (5-20 ng/mL spiked), 87.2-96.0% for ZEA (125-500 ng/mL spiked) and 75.2-96.9% for DON (250-1,000 ng/mL spiked) by HPLC and ELISA. Recoveries of AFB₁ (20 ng/mL) and ZEA (500 ng/mL) simultaneously spiked into the buffer solution were 87.0 and 99.8%, respectively. Recovery rates of AFB₁/DON and DON/ZEA spiked simultaneously were 86.2%/76.6% and 92.0%/86.7%, respectively, at concentrations of 20 ng/mL AFB₁, 500 ng/mL ZEA, and 1,000 ng/mL DON. Recoveries using the novel mAb-MNP conjugated system in a buffer solution simultaneously spiked with AFB₁, ZEA and DON were 82.5, 94.6 and 73.4%, respectively. Recoveries of DON in animal feed were 107.7-132.5% at concentrations of 250-1,000 ng/g spiked in feed. The immunoaffinity chromatography (IAC) clean-up method was compared with the purification method using novel mAb-MNP. After fortification of animal feed with AFB₁ (5, 10 and 20 ng/g feed) and ZEA (125, 250 and 500 ng/g feed), AFB₁ and ZEA were purified using both the methods. In the case of the novel mAb-MNP conjugated system, mean recoveries for AFB₁ were 89.4, 73.1 and 88.3% at concentrations of 5, 10 and 20 ng/g feed, respectively. For ZEA, mean recoveries were 86.7, 85.9 and 79.1% at concentrations of 125, 250 and 500 ng/g, respectively. For IAC purification, recoveries were 42.9-45.1% for AFB₁ and 96.8-103.2% for ZEA. In conclusion, the present purification method using monoclonal antibodies conjugated to MNPs can be used for simple and simultaneous purification of mycotoxins from feed and maize.

Supplementary Information

The online version contains supplementary material available at 10.1007/s43188-020-00083-w.

Rapid detection of trace Salmonella in milk using an effective pretreatment combined with droplet digital polymerase chain reaction

Salmonella is one of the most dangerous food-borne pathogens around the world to cause a threat to humans and it is urgent to develop the rapid detection method of trace Salmonella in food. Although many advanced techniques have been widely applied to shorten the detection time, the pretreatment method usually used of traditional enrichment and plate culturing to separate Salmonella are complicated and time-consuming. Herein, we developed an effective pretreatment method based on in situ enrichment culture with an immunomagnetic separation step, combined with droplet digital polymerase chain reaction (ddPCR) technology to achieve rapid detection of trace Salmonella in milk, which allowed detecting as low as 10^-1 CFU/mL level of Salmonella. It took 8 h to perform the entire testing process from pretreatment to ddPCR detection and analysis. The pretreatment method could be a suitable platform integrating with many detection techniques for the rapid detection of trace Salmonella.

Multiplex Detection of Salmonella spp., E. coli O157 and L. monocytogenes by qPCR Melt Curve Analysis in Spiked Infant Formula

Food poisoning continue to be a threat in the food industry showing a need to improve the detection of the pathogen responsible for the hospitalization cases and death. DNA-based techniques represent a real advantage and allow the detection of several targets at the same time, reducing cost and time of analysis. The development of new methodology using SYBR Green qPCR for the detection of L. monocytogenes, Salmonella spp. and E. coli O157 simultaneously was developed and a non-competitive internal amplification control (NC-IAC) was implemented to detect reaction inhibition. The formulation and supplementation of the enrichment medium was also optimized to allow the growth of all pathogens. The limit of detection (LoD) 95% obtained was <1 CFU/25 g for E. coli O157, and 2 CFU/25 g for Salmonella spp. and L. monocytogenes and regarding the multiplex detection a LoD 95% of 1.7 CFU/25 g was observed. The specificity, relative sensitivity and accuracy of full methodology were 100% and the use of the NC-IAC allowed the reliability of the results without interfering with the sensitivity of the methodology. The described study proved to obtain results comparable to those of probe-based qPCR, and more economically than classical high resolution melting qPCR, being both important aspects for its implementation in the food industry.

Rapid detection of Salmonella in poultry environmental samples using real-time PCR coupled with immunomagnetic separation and whole genome amplification

We evaluated the combination of immunomagnetic separation (IMS), multiple displacement amplification (MDA), and real-time PCR to detect Salmonella from poultry environmental samples. The limits of detection (LODs) of IMS-MDA real-time PCR with different culture enrichment hours (0, 4, 6, and 8 h) were determined in artificially inoculated litter samples from a specific pathogen-free (SPF) poultry farm. In addition, Salmonella detection rate of IMS-MDA real-time PCR with 8-h culture enrichment was compared with that of conventional real-time PCR and culture-based detection by analyzing 174 poultry environmental samples (boot swabs, drag swabs, and litter), and the levels of Salmonella in the samples were quantified using the most probably number method. The LODs of IMS-MDA real-time PCR with 0, 4 to 6, and 8-h enrichment were 10, 1, and 0.1 CFU/g, respectively. Salmonella was detected in 25 of the 174 environmental samples (14.4%) by IMS-MDA real-time PCR, compared with 24 (13.8%) by conventional real-time PCR and 19 (10.9%) by culturing. Cohen's kappa index indicated strong concordance (0.79) between IMS-MDA real-time PCR and culture detection. We demonstrated the potential of the IMS-MDA real-time PCR assay as a faster and more sensitive alternative to culture-based Salmonella detection from poultry environmental samples.

Persistent contamination ofSalmonella,Campylobacter,Escherichia coli, andStaphylococcus aureusat a broiler farm in New Zealand

Intensive poultry production due to public demand raises the risk of contamination, creating potential foodborne hazards to consumers. The prevalence and microbial load of the pathogens Campylobacter, Salmonella, Staphylococcus aureus, and Escherichia coli was determined by standard methods at the farm level. After disinfection, swab samples collected from wall crevices, drinkers, and vents were heavily contaminated, as accumulated organic matter and dust likely protected the pathogens from the disinfectants used. The annex floor also showed high microbial concentrations, suggesting the introduction of pathogens from external environments, highlighting the importance of erecting hygiene barriers at the entrance of the main shed. Therefore, pathogen control measures and proper application of disinfectants are recommended as intervention strategies. Additionally, quantitative polymerase chain reaction (qPCR) was evaluated as a quantification tool. qPCR showed limitations with samples containing low microbial counts because of the low detection limit of the method. Thus, bacterial pre-enrichment of test samples may be necessary to improve the detection of pathogens by qPCR.

Effect of prebiotic and synbiotic supplementation in diet on growth performance, small intestinal morphology, stress, and bacterial population under high stocking density condition of broiler chickens

The current study investigated the effect of prebiotic mannan-oligosaccharide (MOS) and synbiotic (MOS mixed with Bacillus subtilis and Bacillus licheniformis) on growth performance and bacterial population under high stocking density (HSD) conditions in broilers. A total of 605 one-day-old male Arbor Acres broiler chickens were randomly assigned to 4 treatments: normal stocking density (NSD; 30 kg/m2 fed basal diets), HSD (40 kg/m2 fed basal diets), HSD chickens fed 0.1% prebiotic (HSDp), and HSD fed 0.1% synbiotic (HSDs). At 35 D of age, the body weight of HSD and HSDp were poorer than NSD group (P < 0.01), whereas the feed conversion ratio (FCR) of the HSDs) group was better than the NSD group (P < 0.01). The HSDp and HSDs groups improved FCR (P < 0.01) and has cheaper feed cost per gain compared to the HSD group. Moreover, the body weight of HSDs group was heavier than the HSDp group (P < 0.05). The level of corticosterone and the heterophil to lymphocyte ratio were highest in the HSD group, whereas these indexes were reduced in both HSDp and HSDs groups (P < 0.05). Duodenal, jejunal, and ileal villus heights were shortest in the HSD group (P < 0.01), and the lowest ileal segment goblet cell counts were also observed in this group (P < 0.05). The HSDp and HSDs groups improved the morphology of gastrointestinal (GI) tract (P < 0.05). The Lactobacillus sp. and Clostridium sp. count in the GI tract of HSD group were low (P < 0.01), whereas Escherichia coli was high (P < 0.01), and Salmonella spp. in jejunum and cecum were detectable when compared with NSD group. Conversely, Bacillus sp., Lactobacillus sp., and Clostridium sp. in HSDp and HSDs groups were increased, and E. coli was reduced in the HSDs group (P < 0.01). Therefore, it is clear that stress from HSD negatively affected growth performance, gut morphology, and microbial population, whereas the supplementation of prebiotic or synbiotic can mitigate the effect of stress and microbial dysbiosis in gut of broiler chickens under HSD condition. Comparatively, under this condition, using synbiotic appears to have more beneficial effects than using the prebiotic.

Rapid and sensitive detection of Salmonella with reduced graphene oxide-carbon nanotube based electrochemical aptasensor

Rapid detection of foodborne pathogens is crucial as ingestion of contaminated food products may endanger human health. Thus, the objective of this study was to develop a biosensor using reduced graphene oxide-carbon nanotubes (rGO-CNT) nanocomposite via the hydrothermal method for accurate and rapid label-free electrochemical detection of pathogenic bacteria such as Salmonella enterica. The rGO-CNT nanocomposite was characterized using Fourier transform infrared spectroscopy, Raman spectroscopy, X-ray diffraction and transmission electron microscopy. The nanocomposite was dropped cast on the glassy carbon electrode and further modified with amino-modified DNA aptamer. The resultant ssDNA/rGO-CNT/GCE aptasensor was then used to detect bacteria by using differential pulse voltammetry (DPV) technique. Synergistic effects of aptasensor was evident through the combination of enhanced electrical properties and facile chemical functionality of both rGO and CNT for the stable interface. Under optimal experimental conditions, the aptasensor could detect S. Typhimurium in a wide linear dynamic range from 10¹ until 10⁸ cfu mL^-1 with a 10¹ cfu mL^-1 of the limit of detection. This aptasensor also showed good sensitivity, selectivity and specificity for the detection of microorganisms. Furthermore, we have successfully applied the aptasensor for S. Typhimurium detection in real food samples.

Quantification of Microbial Source Tracking and Pathogenic Bacterial Markers in Water and Sediments of Tiaoxi River (Taihu Watershed)

Taihu Lake is one of the largest freshwater lakes in China, serving as an important source of drinking water; >60% of source water to this lake is provided by the Tiaoxi River. This river faces serious fecal contamination issues, and therefore, a comprehensive investigation to identify the sources of fecal contamination was carried out and is presented here. The performance of existing universal (BacUni and GenBac), human (HF183-Taqman, HF183-SYBR, BacHum, and Hum2), swine (Pig-2-Bac), ruminant (BacCow), and avian (AV4143 and GFD) associated microbial source tracking (MST) markers was evaluated prior to their application in this region. The specificity and sensitivity results indicated that BacUni, HF183-TaqMan, Pig-2-Bac, and GFD assays are the most suitable in identifying human and animal fecal contamination. Therefore, these markers along with marker genes specific to selected bacterial pathogens were quantified in water and sediment samples of the Tiaoxi River, collected from 15 locations over three seasons during 2014 and 2015. Total/universal Bacteroidales markers were detected in all water and sediment samples (mean concentration 6.22 log10 gene copies/100 ml and 6.11 log10 gene copies/gram, respectively), however, the detection of host-associated MST markers varied. Human and avian markers were the most frequently detected in water samples (97 and 89%, respectively), whereas in sediment samples, only human-associated markers were detected more often (86%) than swine (64%) and avian (8.8%) markers. The results indicate that several locations in the Tiaoxi River are heavily polluted by fecal contamination and this correlated well with land use patterns. Among the five bacterial pathogens tested, Shigella spp. and Campylobacter jejuni were the most frequently detected pathogens in water (60% and 62%, respectively) and sediment samples (91% and 53%, respectively). Shiga toxin-producing Escherichia coli (STEC) and pathogenic Leptospira spp. were less frequently detected in water samples (55% and 33%, respectively) and sediment samples (51% and 13%, respectively), whereas E. coli O157:H7 was only detected in sediment samples (11%). Overall, the higher prevalence and concentrations of Campylobacter jejuni, Shigella spp., and STEC, along with the MST marker detection at a number of locations in the Tiaoxi River, indicates poor water quality and a significant human health risk associated with this watercourse. GRAPHICAL ABSTRACTTracking fecal contamination and pathogens in watersheds using molecular methods.

Carbon nanotube-based aptasensor for sensitive electrochemical detection of whole-cell Salmonella

In this study, an amino-modified aptasensor using multi-walled carbon nanotubes (MWCNTs)-deposited ITO electrode was prepared and evaluated for the detection of pathogenic Salmonella bacteria. An amino-modified aptamer (ssDNA) which binds selectively to whole-cell Salmonella was immobilised on the COOH-rich MWCNTs to produce the ssDNA/MWCNT/ITO electrode. The morphology of the MWCNT before and after interaction with the aptamers were observed using scanning electron microscopy (SEM). Cyclic voltammetry and electrochemical impedance spectroscopy techniques were used to investigate the electrochemical properties and conductivity of the aptasensor. The results showed that the impedance measured at the ssDNA/MWCNT/ITO electrode surface increased after exposure to Salmonella cells, which indicated successful binding of Salmonella on the aptamer-functionalised surface. The developed ssDNA/MWCNT/ITO aptasensor was stable and maintained linearity when the scan rate was increased from 10 mV s^-1 to 90 mV s^-1. The detection limit of the ssDNA/MWCNT/ITO aptasensor, determined from the sensitivity analysis, was found to be 5.5 × 10¹ cfu mL^-1 and 6.7 × 10¹ cfu mL^-1 for S. Enteritidis and S. Typhimurium, respectively. The specificity test demonstrated that Salmonella bound specifically to the ssDNA/MWCNT/ITO aptasensor surface, when compared with non-Salmonella spp. The prepared aptasensor was successfully applied for the detection of Salmonella in food samples.

Single Locked Nucleic Acid-Enhanced Nanopore Genetic Discrimination of Pathogenic Serotypes and Cancer Driver Mutations

Accurate and rapid detection of single-nucleotide polymorphism (SNP) in pathogenic mutants is crucial for many fields such as food safety regulation and disease diagnostics. Current detection methods involve laborious sample preparations and expensive characterizations. Here, we investigated a single locked nucleic acid (LNA) approach, facilitated by a nanopore single-molecule sensor, to accurately determine SNPs for detection of Shiga toxin producing Escherichia coli (STEC) serotype O157:H7, and cancer-derived EGFR L858R and KRAS G12D driver mutations. Current LNA applications that require incorporation and optimization of multiple LNA nucleotides. But we found that in the nanopore system, a single LNA introduced in the probe is sufficient to enhance the SNP discrimination capability by over 10-fold, allowing accurate detection of the pathogenic mutant DNA mixed in a large amount of the wild-type DNA. Importantly, the molecular mechanistic study suggests that such a significant improvement is due to the effect of the single-LNA that both stabilizes the fully matched base-pair and destabilizes the mismatched base-pair. This sensitive method, with a simplified, low cost, easy-to-operate LNA design, could be generalized for various applications that need rapid and accurate identification of single-nucleotide variations.

All-carbon suspended nanowire sensors as a rapid highly-sensitive label-free chemiresistive biosensing platform

Nanowire sensors offer great potential as highly sensitive electrochemical and electronic biosensors because of their small size, high aspect ratios, and electronic properties. Nevertheless, the available methods to fabricate carbon nanowires in a controlled manner remain limited to expensive techniques. This paper presents a simple fabrication technique for sub-100 nm suspended carbon nanowire sensors by integrating electrospinning and photolithography techniques. Carbon Microelectromechanical Systems (C-MEMS) fabrication techniques allow fabrication of high aspect ratio carbon structures by patterning photoresist polymers into desired shapes and subsequent carbonization of resultant structures by pyrolysis. In our sensor platform, suspended nanowires were deposited by electrospinning while photolithography was used to fabricate support structures. We have achieved suspended carbon nanowires with sub-100 nm diameters in this study. The sensor platform was then integrated with a microfluidic chip to form a lab-on-chip device for label-free chemiresistive biosensing. We have investigated this nanoelectronics label-free biosensor's performance towards bacterial sensing by functionalization with Salmonella-specific aptamer probes. The device was tested with varying concentrations of Salmonella Typhimurium to evaluate sensitivity and various other bacteria to investigate specificity. The results showed that the sensor is highly specific and sensitive in detection of Salmonella with a detection limit of 10 CFU mL^-1. Moreover, this proposed chemiresistive assay has a reduced turnaround time of 5 min and sample volume requirement of 5 µL which are much less than reported in the literature.

Optimizations needed for lateral flow assay for rapid detection of pathogenic E. coli

Lateral flow assay (LFA), or the immunochromatographic strip test, is popular to use for rapid and sensitive immunoassays. Gold nanoparticles (GNPs), due to tunable optical characteristics and easy manipulation of size or shape, represent an attractive approach for LFA technology. Since most enterohemorrhagic infections result from water and food contaminations of Escherichia coli O157:H7, selective and rapid detection of this organism in environmental and biological complexes is necessary. In this study, optimized parameters of antibody (Ab)-based LFA for rapid detection of pathogenic E. coli O157:H7 are described. GNPs were used as visualizing agents. The measuring parameters include the Ab concentration on the capture lines, the concentration of gold conjugate, and flow rate. M180 and 36 nm were the ideal membrane and GNP size, respectively, for bacterial detection of LFA. The target, E. coli O157:H7, could be detected with a visual limit of detection of 105 cfu/mL in 3-5 min. Selectivity of the system was very high and the target was recognized by developed strips, regardless of its presence singly or in mixed bacterial samples.

Graphene-based label-free electrochemical aptasensor for rapid and sensitive detection of foodborne pathogen

Reduced graphene oxide (rGO) has emerged as a promising nanomaterial for reliable detection of pathogenic bacteria due to its exceptional properties such as ultrahigh electron transfer ability, large surface to volume ratio, biocompatibility, and its unique interactions with DNA bases of the aptamer. In this study, rGO-azophloxine (AP) nanocomposite aptasensor was developed for a sensitive, rapid, and robust detection of foodborne pathogens. Besides providing an excellent conductive and soluble rGO nanocomposite, the AP dye also acts as an electroactive indicator for redox reactions. The interaction of the label-free single-stranded deoxyribonucleic acid (ssDNA) aptamer with the test organism, Salmonella enterica serovar Typhimurium (S. Typhimurium), was monitored by differential pulse voltammetry analysis, and this aptasensor showed high sensitivity and selectivity for whole-cell bacteria detection. Under optimum conditions, this aptasensor exhibited a linear range of detection from 10⁸ to 10¹ cfu mL^-1 with good linearity (R ² = 0.98) and a detection limit of 10¹ cfu mL^-1. Furthermore, the developed aptasensor was evaluated with non-Salmonella bacteria and artificially spiked chicken food sample with S. Typhimurium. The results demonstrated that the rGO-AP aptasensor possesses high potential to be adapted for the effective and rapid detection of a specific foodborne pathogen by an electrochemical approach. Graphical abstract Fabrication of graphene-based nanocomposite aptasensor for detection of foodborne pathogen.

A qPCR-Based Tool to Diagnose the Presence of Harmful Cyanobacteria and Cyanotoxins in Drinking Water Sources

Harmful cyanobacteria have been an important concern for drinking water quality for quite some time, as they may produce cyanotoxins and odorants. Microcystis and Cylindrospermopsis are two common harmful cyanobacterial genera detected in freshwater lakes and reservoirs, with microcystins (MCs) and cylindrospermopsin (CYN) as their important metabolites, respectively. In this study, two sets of duplex qPCR systems were developed, one for quantifying potentially-toxigenic Microcystis and Microcystis, and the other one for cylindrospermopsin-producing cyanobacteria and Cylindrospermopsis. The duplex qPCR systems were developed and validated in the laboratory by using 338 samples collected from 29 reservoirs in Taiwan and her offshore islands. Results show that cell numbers of Microcystis and Cylindorspermopsis enumerated with microscopy, and MCs and CYN concentrations measured with the enzyme-linked immuno-sorbent assay method, correlated well with their corresponding gene copies determined with the qPCR systems (range of coefficients of determination R² = 0.392−0.740). The developed qPCR approach may serve as a useful tool for the water industry to diagnose the presence of harmful cyanobacteria and the potential presence of cyanotoxins in source waters.

Contamination with bacterial zoonotic pathogen genes in U.S. streams influenced by varying types of animal agriculture

Animal waste, stream water, and streambed sediment from 19 small (<32km(2)) watersheds in 12U.S. states having either no major animal agriculture (control, n=4), or predominantly beef (n=4), dairy (n=3), swine (n=5), or poultry (n=3) were tested for: 1) cholesterol, coprostanol, estrone, and fecal indicator bacteria (FIB) concentrations, and 2) shiga-toxin producing and enterotoxigenic Escherichia coli, Salmonella, Campylobacter, and pathogenic and vancomycin-resistant enterococci by polymerase chain reaction (PCR) on enrichments, and/or direct quantitative PCR. Pathogen genes were most frequently detected in dairy wastes, followed by beef, swine and poultry wastes in that order; there was only one detection of an animal-source-specific pathogen gene (stx1) in any water or sediment sample in any control watershed. Post-rainfall pathogen gene numbers in stream water were significantly correlated with FIB, cholesterol and coprostanol concentrations, and were most highly correlated in dairy watershed samples collected from 3 different states. Although collected across multiple states and ecoregions, animal-waste gene profiles were distinctive via discriminant analysis. Stream water gene profiles could also be discriminated by the watershed animal type. Although pathogen genes were not abundant in stream water or streambed samples, PCR on enrichments indicated that many genes were from viable organisms, including several (shiga-toxin producing or enterotoxigenic E. coli, Salmonella, vancomycin-resistant enterococci) that could potentially affect either human or animal health. Pathogen gene numbers and types in stream water samples were influenced most by animal type, by local factors such as whether animals had stream access, and by the amount of local rainfall, and not by studied watershed soil or physical characteristics. Our results indicated that stream water in small agricultural U.S. watersheds was susceptible to pathogen gene inputs under typical agricultural practices and environmental conditions. Pathogen gene profiles may offer the potential to address both source of, and risks associated with, fecal pollution.

Protein Chips for Detection of Salmonella spp. from Enrichment Culture

Food pathogens are the cause of foodborne epidemics, therefore there is a need to detect the pathogens in food productions rapidly. A pre-enrichment culture followed by selective agar plating are standard detection methods. Molecular methods such as qPCR have provided a first rapid protocol for detection of pathogens within 24 h of enrichment culture. Biosensors also may provide a rapid tool to individuate a source of Salmonella contamination at early times of pre-enrichment culture. Forty mL of Salmonella spp. enrichment culture were processed by immunoseparation using the Pathatrix, as in AFNOR validated qPCR protocols. The Salmonella biosensor combined with immunoseparation showed a limit of detection of 100 bacteria/40 mL, with a 400 fold increase to previous results. qPCR analysis requires processing of bead-bound bacteria with lysis buffer and DNA clean up, with a limit of detection of 2 cfu/50 μL. Finally, a protein chip was developed and tested in screening and identification of 5 common pathogen species, Salmonella spp., E. coli, S. aureus, Campylobacter spp. and Listeria spp. The protein chip, with high specificity in species identification, is proposed to be integrated into a Lab-on-Chip system, for rapid and reproducible screening of Salmonella spp. and other pathogen species contaminating food productions.

A Four-Plex Real-Time PCR Assay, Based on rfbE, stx1, stx2, and eae Genes, for the Detection and Quantification of Shiga Toxin-Producing Escherichia coli O157 in Cattle Feces

Several real-time polymerase chain reaction (PCR) assays have been developed to detect and quantify Shiga toxin-producing Escherichia coli (STEC) O157:H7, but none have targeted the O-antigen specific gene (rfbEO157) in combination with the three major virulence genes, stx1, stx2, and eae. Our objectives were to develop and validate a four-plex, quantitative PCR (mqPCR) assay targeting rfbE(O157), stx1, stx2, and eae for the detection and quantification of STEC O157 in cattle feces, and compare the applicability of the assay to detect STEC O157 to a culture method and conventional PCR (cPCR) targeting the same four genes. Specificity of the mqPCR assay to differentially detect the four genes was confirmed with strains of O157 and non-O157 STEC with different profiles of target genes. In cattle feces spiked with pure cultures, detection limits were 2.8×10(4) and 2.8×10(0) colony-forming units/g before and after enrichment, respectively. Detection of STEC O157 in feedlot cattle fecal samples (n=278) was compared between mqPCR, cPCR, and a culture method. The mqPCR detected 48.9% (136/278) of samples as positive for E. coli O157. Of the 100 samples that were randomly picked from 136 mqPCR-positive samples, 35 and 48 tested positive by cPCR and culture method, respectively. Of the 100 samples randomly chosen from 142 mqPCR-negative samples, all were negative by cPCR, but 21 samples tested positive by the culture method. McNemar's chi-square tests indicated significant disagreement between the proportions of positive samples detected by the three methods. In conclusion, the mqPCR assay that targets four genes is a novel and more sensitive method than the cPCR or culture method to detect STEC O157 in cattle feces. However, the use of real-time PCR as a screening method to identify positive samples and then subjecting only positive samples to a culture method may underestimate the presence of STEC O157 in fecal samples.

Rapid and Specific Enrichment of Culturable Gram Negative Bacteria Using Non-Lethal Copper-Free Click Chemistry Coupled with Magnetic Beads Separation

Currently, identification of pathogenic bacteria present at very low concentration requires a preliminary culture-based enrichment step. Many research efforts focus on the possibility to shorten this pre-enrichment step which is needed to reach the minimal number of cells that allows efficient identification. Rapid microbiological controls are a real public health issue and are required in food processing, water quality assessment or clinical pathology. Thus, the development of new methods for faster detection and isolation of pathogenic culturable bacteria is necessary. Here we describe a specific enrichment technique for culturable Gram negative bacteria, based on non-lethal click chemistry and the use of magnetic beads that allows fast detection and isolation. The assimilation and incorporation of an analog of Kdo, an essential component of lipopolysaccharides, possessing a bio-orthogonal azido function (Kdo-N₃), allow functionalization of almost all Gram negative bacteria at the membrane level. Detection can be realized through strain-promoted azide-cyclooctyne cycloaddition, an example of click chemistry, which interestingly does not affect bacterial growth. Using E. coli as an example of Gram negative bacterium, we demonstrate the excellent specificity of the technique to detect culturable E. coli among bacterial mixtures also containing either dead E. coli, or live B. subtilis (as a model of microorganism not containing Kdo). Finally, in order to specifically isolate and concentrate culturable E. coli cells, we performed separation using magnetic beads in combination with click chemistry. This work highlights the efficiency of our technique to rapidly enrich and concentrate culturable Gram negative bacteria among other microorganisms that do not possess Kdo within their cell envelope.

Bacterial pathogen gene abundance and relation to recreational water quality at seven Great Lakes beaches

Quantitative assessment of bacterial pathogens, their geographic variability, and distribution in various matrices at Great Lakes beaches are limited. Quantitative PCR (qPCR) was used to test for genes from E. coli O157:H7 (eaeO157), shiga-toxin producing E. coli (stx2), Campylobacter jejuni (mapA), Shigella spp. (ipaH), and a Salmonella enterica-specific (SE) DNA sequence at seven Great Lakes beaches, in algae, water, and sediment. Overall, detection frequencies were mapA>stx2>ipaH>SE>eaeO157. Results were highly variable among beaches and matrices; some correlations with environmental conditions were observed for mapA, stx2, and ipaH detections. Beach seasonal mean mapA abundance in water was correlated with beach seasonal mean log10 E. coli concentration. At one beach, stx2 gene abundance was positively correlated with concurrent daily E. coli concentrations. Concentration distributions for stx2, ipaH, and mapA within algae, sediment, and water were statistically different (Non-Detect and Data Analysis in R). Assuming 10, 50, or 100% of gene copies represented viable and presumably infective cells, a quantitative microbial risk assessment tool developed by Michigan State University indicated a moderate probability of illness for Campylobacter jejuni at the study beaches, especially where recreational water quality criteria were exceeded. Pathogen gene quantification may be useful for beach water quality management.

Luminescence based enzyme-labeled phage (Phazyme) assays for rapid detection of Shiga toxin producing Escherichia coli serogroups

Most diagnostic approaches for Shiga toxin producing Escherichia coli (STEC) have been designed to detect only serogroup O157 that causes a majority, but not all STEC related outbreaks in the United States. Therefore, there is a need to develop methodology that would enable the detection of other STEC serogroups that cause disease. Three bacteriophages (phages) that infect STEC serogroups O26, O103, O111, O145 and O157 were chemically labeled with horseradish peroxidase (HRP). The enzyme-labeled phages (Phazymes) were individually combined with a sampling device (a swab), STEC serogroup-specific immunomagnetic separation (IMS) beads, bacterial enrichment broth and luminescent HRP substrate, in a self-contained test device, while luminescence was measured in a hand-held luminometer.The O26 and O157 Phazyme assays correctly identified more than 93% of the bacteria tested during this study, the O123 Phazyme assay identified 89.6%, while the O111 and O145 Phazyme assays correctly detected 82.4% and 75.9%, respectively. The decreased specificity of the O111 and O145 assays was related to the broad host ranges of the phages used in both assays. The Phazyme assays were capable of directly detecting between 10(5) and 10(6) CFU/ml in pure culture, depending on the serogroup. In food trials, the O157 Phazyme assay was able to detect E. coli O157:H7 in spinach consistently at levels of 1 CFU/g and occasionally at levels of 0.1 CFU/g. The assay detected 10(0) CFU/100 cm(2) on swabbed meat samples and 10(2) CFU/100 ml in water samples. The Phazyme assay effectively detects most STEC in a simple and rapid manner, with minimal need for instrumentation to interpret the test result.

Microbiological analysis of environmental samples collected from child care facilities in North and South Carolina

BACKGROUND

Children cared for outside the home are at an increased risk of enteric disease. Microbiological analyses were performed on environmental samples collected from child care facilities in North and South Carolina.

METHODS

There were 326 samples collected from 40 facilities corresponding to common surfaces (77% of samples) and the hands of care providers (23% of samples). Samples were analyzed for total aerobic plate counts (APCs), total coliforms, biotype I Escherichia coli, and pathogens Shigella spp, Salmonella enterica, E coli O157, Campylobacter jejuni, and human norovirus.

RESULTS

Median APCs and coliform counts for hands were 4.6 and 1.0 log10 colony-forming units (CFU) per hand, respectively. Median APCs for surfaces were 2.0 and 2.6 log10 CFU for flat and irregular surfaces, respectively. Coliforms were detected in 16% of samples, with counts ranging from 1.0 log10 to > 4.3 log10 CFU, with higher counts most often observed for hand rinse samples. Biotype I E coli counts were below assay detection limits (< 1 log10 CFU) for all but 1 sample. No samples were positive for any of the 4 bacterial pathogens, whereas 4 samples showed evidence of human norovirus RNA.

CONCLUSION

The relative absence of pathogens and biotype I E coli in environmental samples suggests the child care facilities sampled in this study managed fecal contamination well.

Real-time PCR method combined with immunomagnetic separation for detecting healthy and heat-injured Salmonella Typhimurium on raw duck wings

Conventional culture detection methods are time consuming and labor-intensive. For this reason, an alternative rapid method combining real-time PCR and immunomagnetic separation (IMS) was investigated in this study to detect both healthy and heat-injured Salmonella Typhimurium on raw duck wings. Firstly, the IMS method was optimized by determining the capture efficiency of Dynabeads(®) on Salmonella cells on raw duck wings with different bead incubation (10, 30 and 60 min) and magnetic separation (3, 10 and 30 min) times. Secondly, three Taqman primer sets, Sal, invA and ttr, were evaluated to optimize the real-time PCR protocol by comparing five parameters: inclusivity, exclusivity, PCR efficiency, detection probability and limit of detection (LOD). Thirdly, the optimized real-time PCR, in combination with IMS (PCR-IMS) assay, was compared with a standard ISO and a real-time PCR (PCR) method by analyzing artificially inoculated raw duck wings with healthy and heat-injured Salmonella cells at 10(1) and 10(0) CFU/25 g. Finally, the optimized PCR-IMS assay was validated for Salmonella detection in naturally contaminated raw duck wing samples. Under optimal IMS conditions (30 min bead incubation and 3 min magnetic separation times), approximately 85 and 64% of S. Typhimurium cells were captured by Dynabeads® from pure culture and inoculated raw duck wings, respectively. Although Sal and ttr primers exhibited 100% inclusivity and exclusivity for 16 Salmonella spp. and 36 non-Salmonella strains, the Sal primer showed lower LOD (10(3) CFU/ml) and higher PCR efficiency (94.1%) than the invA and ttr primers. Moreover, for Sal and invA primers, 100% detection probability on raw duck wings suspension was observed at 10(3) and 10(4) CFU/ml with and without IMS, respectively. Thus, the Sal primer was chosen for further experiments. The optimized PCR-IMS method was significantly (P=0.0011) better at detecting healthy Salmonella cells after 7-h enrichment than traditional PCR method. However there was no significant difference between the two methods with longer enrichment time (14 h). The diagnostic accuracy of PCR-IMS was shown to be 98.3% through the validation study. These results indicate that the optimized PCR-IMS method in this study could provide a sensitive, specific and rapid detection method for Salmonella on raw duck wings, enabling 10-h detection. However, a longer enrichment time could be needed for resuscitation and reliable detection of heat-injured cells.