Production of docosahexaenoic acid by a novel isolated Aurantiochytrium sp. 6-2 using fermented defatted soybean as a nitrogen source for sustainable fish feed development

We focused on the production of docosahexaenoic acid (DHA)-containing microbial lipids by Aurantiochytrium sp. using of defatted soybean (DS) as a nitrogen source. Defatted soybean is a plant biomass that could provide a sustainable supply at a low cost. Results showed that Aurantiochytrium sp. could not directly assimilate the DS as a nitrogen source but could grow well in a medium containing DS fermented with rice malt. When cultivated in a fermented DS (FDS) medium, Aurantiochytrium sp. showed vigorous growth with the addition of sufficient sulfate and chloride ions as inorganic nutrients without seawater salt. A novel isolated Aurantiochytrium sp. 6-2 showed 15.8 ± 3.4 g/L DHA productivity (in 54.8 ± 12.1 g/L total fatty acid production) in 1 L of the FDS medium. Therefore, DHA produced by Aurantiochytrium sp. using FDS enables a stable and sustainable DHA supply and could be an alternative source of natural DHA derived from fish oil.

The Nitrogen Content in the Fruiting Body and Mycelium of Pleurotus Ostreatus and Its Utilization as a Medium Component in Thraustochytrid Fermentation

Following the idea of a circular bioeconomy, the use of side streams as substitutes for cultivation media (components) in bioprocesses would mean an enormous economic and ecological advantage. Costly compounds in conventional media for the production of the triterpene squalene in thraustochytrids are the main carbon source and complex nitrogen sources. Among other side streams examined, extracts from the spent mycelium of the basidiomycete Pleurotus ostreatus were best-suited to acting as alternative nitrogen sources in cultivation media for thraustochytrids. The total nitrogen (3.76 ± 0.01 and 4.24 ± 0.04%, respectively) and protein (16.47 ± 0.06 and 18.57 ± 0.18%, respectively) contents of the fruiting body and mycelium were determined. The fungal cells were hydrolyzed and extracted to generate accessible nitrogen sources. Under preferred conditions, the extracts from the fruiting body and mycelium contained 73.63 ± 1.19 and 89.93 ± 7.54 mM of free amino groups, respectively. Cultivations of Schizochytrium sp. S31 on a medium using a mycelium extract as a complex nitrogen source showed decelerated growth but a similar squalene yield (123.79 ± 14.11 mg/L after 216 h) compared to a conventional medium (111.29 ± 19.96 mg/L, although improvable by additional complex nitrogen source).

Characterization of thraustochytrid-specific sterol O-acyltransferase: modification of DGAT2-like enzyme to increase the sterol production in Aurantiochytrium limacinum mh0186

IMPORTANCE

Since the global market for sterols and vitamin D are grown with a high compound annual growth rate, a sustainable source of these compounds is required to keep up with the increasing demand. Thraustochytrid is a marine oleaginous microorganism that can synthesize several sterols, which are stored as SE in lipid droplets. DGAT2C is an unconventional SE synthase specific to thraustochytrids. Although the primary structure of DGAT2C shows high similarities with that of DGAT, DGAT2C utilizes sterol as an acceptor substrate instead of diacylglycerol. In this study, we examined more detailed enzymatic properties, intracellular localization, and structure-activity relationship of DGAT2C. Furthermore, we successfully developed a method to increase sterol and provitamin D3 productivity of thraustochytrid by more than threefold in the process of elucidating the function of the DGAT2C-specific N-terminal region. Our findings could lead to sustainable sterol and vitamin D production using thraustochytrid.

Bioprocess conditions and regulation factors to optimize squalene production in thraustochytrids

Squalene is a widely distributed natural triterpene, as it is a key precursor in the biosynthesis of all sterols. It is a compound of high commercial value worldwide because it has nutritional, medicinal, pharmaceutical, and cosmetic applications, due to its different biological properties. The main source of extraction has been shark liver oil, which is currently unviable on a larger scale due to the impacts of overexploitation. Secondary sources are mainly vegetable oils, although a limited one, as they allow low productive yields. Due to the diversity of applications that squalene presents and its growing demand, there is an increasing interest in identifying sustainable sources of extraction. Wild species of thraustochytrids, which are heterotrophic protists, have been identified to have the highest squalene content compared to bacteria, yeasts, microalgae, and vegetable sources. Several studies have been carried out to identify the bioprocess conditions and regulation factors, such as the use of eustressors that promote an increase in the production of this triterpene; however, studies focused on optimizing their productive yields are still in its infancy. This review includes the current trends that also comprises the advances in genetic regulations in these microorganisms, with a view to identify the culture conditions that have been favorable in increasing the production of squalene, and the influences that both bioprocess conditions and applied regulation factors partake at a metabolic level.

Simultaneous Imaging and Characterization of Polyunsaturated Fatty Acids, Carotenoids, and Microcrystalline Guanine in Single Aurantiochytrium limacinum Cells with Linear and Nonlinear Raman Microspectroscopy

Thraustochytrids are heterotrophic marine protists known for their high production capacity of various compounds with health benefits, such as polyunsaturated fatty acids and carotenoids. Although much effort has been focused on developing optimal cultivation methods for efficient microbial production, these high-value compounds and their interrelationships are not well understood at the single-cell level. Here we used spontaneous (linear) Raman and multiplex coherent anti-Stokes Raman scattering (CARS) microspectroscopy to visualize and characterize lipids (e.g., docosahexaenoic acid) and carotenoids (e.g., astaxanthin) accumulated in single living Aurantiochytrium limacinum cells. Spontaneous Raman imaging with the help of multivariate curve resolution-alternating least-squares enabled us to make unambiguous assignments of the molecular components we detected and derive their intracellular distributions separately. Near-IR excited CARS imaging yielded the Raman images at least an order of magnitude faster than spontaneous Raman imaging, with suppressed contributions of carotenoids. As the culture time increased from 2 to 5 days, the lipid amount increased by a factor of ∼7, whereas the carotenoid amount did not change significantly. Furthermore, we observed a highly localized component in A. limacinum cells. This component was found to be mixed crystals of guanine and other purine derivatives. The present study demonstrates the potential of the linear-nonlinear Raman hybrid approach that allows for accurate molecular identification and fast imaging in a label-free manner to link information derived from single cells with strategies for mass culture of useful thraustochytrids.

Optimal NaCl Medium Enhances Squalene Accumulation in Thraustochytrium sp. ATCC 26185 and Influences the Expression Levels of Key Metabolic Genes

Squalene, a natural lipid of the terpenoid family, is well-recognized for its roles in regulating cholesterol metabolism, preventing tumor development, and improving immunity. For large-scale squalene production, the unicellular marine protists—thraustochytrids—have shown great potential. However, the growth of thraustochytrids is known to be affected by salt stress, which can eventually influence the squalene content. Here, we study the effects of an optimal concentration of NaCl on the squalene content and transcriptome of Thraustochytrium sp. ATCC 26185. Under the optimal culture conditions (glucose, 30 g/L; yeast extract, 2.5 g/L; and NaCl, 5 g/L; 28°C), the strain yielded 67.7 mg squalene/g cell dry weight, which was significantly greater than that (5.37 mg/g) under the unoptimized conditions. NaCl was determined as the most significant (R = 135.24) factor for squalene production among glucose, yeast extract, and NaCl. Further comparative transcriptomics between the ATCC 26185 culture with and without NaCl addition revealed that NaCl (5 g/L) influences the expression of certain key metabolic genes, namely, IDI, FAS-a, FAS-b, ALDH3, GS, and NDUFS4. The differential expression of these genes possibly influenced the acetyl-CoA and glutamate metabolism and resulted in an increased squalene production. Through the integration of bioprocess technology and transcriptomics, this report provides the first evidence of the possible mechanisms underscoring increased squalene production by NaCl.

Riverine Inputs Impact the Diversity and Population Structure of Heterotrophic Fungus-like Protists and Bacterioplankton in the Coastal Waters of the South China Sea

Labyrinthulomycetes protists (LP) play an important role in ocean carbon cycling with an ubiquitous presence in marine ecosystems. As one of the most important environmental factors, salinity is known to regulate their diverse metabolic activities. However, impacts of salinity gradient on their distribution and ecological functions in natural habitats remain largely unknown. In this study, the dynamics of LP abundance and community structure were examined in the surface water of plume, offshore, and pelagic habitats in the South China Sea (SCS). The highest (5.59 × 105 copies L−1) and lowest (5.28 × 104 copies L−1) abundance of LP were found to occur in the waters of plume and pelagic habitats, respectively. Multiple dimensional scaling (MDS) analysis revealed a strong relationship between salinity and LP community variation (p < 0.05, rho = 0.67). Unexpectedly, relative low LP diversity was detected in the brackish water samples of the plume. Moreover, our results indicated the genus Aplanochytrium dominated LP communities in offshore and pelagic, while Aurantiochytrium and Ulkenia were common in the plume. Physiological and metabolic features of these genera suggested that LP ecological functions were also largely varied along this salinity gradient. Clearly, the salinity gradient likely regulates the diversity and functional partitioning of marine protistan micro-eukaryotes in the world’s oceans.

PUFA synthase-independent DHA synthesis pathway in Parietichytrium sp. and its modification to produce EPA and n-3DPA

The demand for n-3 long-chain polyunsaturated fatty acids (n-3LC-PUFAs), such as docosahexaenoic acid (DHA) and eicosapentaenoic acid (EPA), will exceed their supply in the near future, and a sustainable source of n-3LC-PUFAs is needed. Thraustochytrids are marine protists characterized by anaerobic biosynthesis of DHA via polyunsaturated fatty acid synthase (PUFA-S). Analysis of a homemade draft genome database suggested that Parietichytrium sp. lacks PUFA-S but possesses all fatty acid elongase (ELO) and desaturase (DES) genes required for DHA synthesis. The reverse genetic approach and a tracing experiment using stable isotope-labeled fatty acids revealed that the ELO/DES pathway is the only DHA synthesis pathway in Parietichytrium sp. Disruption of the C20 fatty acid ELO (C20ELO) and ∆4 fatty acid DES (∆4DES) genes with expression of ω3 fatty acid DES in this thraustochytrid allowed the production of EPA and n-3docosapentaenoic acid (n-3DPA), respectively, at the highest level among known microbial sources using fed-batch culture.

C4-monomethylsterol β-glucoside and its synthase in Aurantiochytrium limacinum mh0186

Thraustochytrids, unicellular marine protists, synthesize polyunsaturated fatty acids (PUFAs) and PUFA-containing phospholipids; however, little is known about their glycolipids and their associated metabolism. Here, we report two glycolipids (GL-A, B) and their synthases in Aurantiochytrium limacinum mh0186. Two glycolipids were purified from A. limacinum mh0186, and they were determined by gas chromatography, mass spectrometry and two-dimensional nuclear magnetic resonance to be 3-O-β-D-glucopyranosyl-stigmasta-5,7,22-triene (GL-A) and 3-O-β-D-glucopyranosyl-4α-methyl-stigmasta-7,22-diene (GL-B), both of which are sterol β-glucosides (β-SGs); the structure of GL-B has not been reported thus far. Seven candidate genes responsible for the synthesis of these β-SGs were extracted from the draft genome database of A. limacinum using the yeast sterol β-glucosyltransferase (SGT; EC 2.4.1.173) sequence as a query. Expression analysis using Saccharomyces cerevisiae revealed that two gene products (AlSGT-1 and 2) catalyze the transfer of glucose from UDP-glucose to sterols, generating sterylglucosides (SGs). Compared to AlSGT-1, AlSGT-2 exhibited wide specificity for sterols and used C4-monomethylsterol to synthesize GL-B. The disruption of alsgt-2 but not alsgt-1 in strain mh0186 resulted in a decrease in total SG and almost complete loss of GL-B, indicating that AlSGT-2 is responsible for the synthesis of β-SGs in A. limacinum mh0186, especially GL-B, which possesses a unique sterol structure.

Different carbon and nitrogen sources regulated docosahexaenoic acid (DHA) production of Thraustochytriidae sp. PKU#SW8 through a fully functional polyunsaturated fatty acid (PUFA) synthase gene (pfaB)

Docosahexaenoic acid (DHA, C22:6) production in thraustochytrids is known to be mediated independently through polyunsaturated fatty acid (PUFA) synthase and fatty acid synthase systems. This study elucidates the unresolved effects of different carbon and nitrogen sources on the functionality of PUFA synthase subunit B (pfaB) and corresponding DHA production in Thraustochytriidae sp. PKU#SW8. Carbon and nitrogen sources showed significant effect on the pfaB gene expression and DHA production patterns, but these patterns did not correspond with each other, suggesting the strong role of substrates in differential induction of the two synthase systems. Nitrogen starvation increased DHA yield in parallel with upregulated gene expression, showing strong indication of PUFA synthase activity in N-deficient culture. The fully functional catalytic activity of PfaB subunit from strain PKU#SW8 in a heterologous host was also demonstrated. This study provides the direct evidence of pfaB gene actively for DHA biosynthesis in Thraustochytriidae sp. PKU#SW8.

Fatty acid production of thraustochytrids from Saudi Arabian mangroves

This is the first report of thraustochytrids from Saudi Arabia. A total of 108 isolates of thraustochytrid were cultured from Syhat mangroves, Arabian Gulf, Saudi Arabia. Isolated thraustochytrids belonged to five genera: Aplanochytrium, Aurantiochytrium, Schizochytrium, Thraustochytrium and Ulkenia. Cultured thraustochytrids isolated from decaying leaves of Avicennia marina (77 isolates), sediment (15), seawater (10) and decaying thalli of Sargassum (6). Of the 108 isolates, three strains (SY25, SY38 and SY52) were selected based on their high biomass productivity and high percentages of PUFAs. Phylogenetic analyses based on 18S rDNA placed the three strains within the Aurantiochytrium clade with high statistical support. Species of Aurantiochytrium formed six separate clades, the two strains (SY38 and SY52) formed a separate clade that is a sister clade to the one that contains the type species A. limacinum, while SY25 grouped with Aurantiochytrium sp. TA4, that is also isolated from mangroves in Iran, Arabian Gulf. The strains (SY38 and SY52) shared the phylogenetic placement, their morphology and fatty acid profile. The strain SY25 have different shape of sporangia that divide to give zoospores directly, sporogenous cells are surrounded by thick gelatinous sheath and produce high levels of Linoleic and Oleic essential unsaturated fatty acids. The three studied strain produced high levels of Palmitic acid (ranged between 31.1 and 65.3 % of total fatty acids) that can be further optimized for biofuel production.

The strategies to reduce cost and improve productivity in DHA production by Aurantiochytrium sp.: from biochemical to genetic respects

The marine oleaginous protist Aurantiochytrium sp. (Schizochytrium sp.) is a well-known docosahexaenoic acid (DHA) producer and its different DHA products are the ideal substitute for the traditional fish oil resource. However, the cost of the DHA products derived from Aurantiochytrium sp. (Schizochytrium sp.) is still high, limiting their wide applications. In order to reduce the cost or improve the productivity of DHA from the microbial resource, many researches are focusing on exploring the renewable and low-cost materials as feedbacks, and/or the stimulators for biomass and DHA production. In addition, the genetic engineering is also being used in the Aurantiochytrium sp. (Schizochytrium sp.) system for further improvement. These break the bottleneck of the DHA production by Aurantiochytrium sp. (Schizochytrium sp.) in some degree. In this review, the strategies used currently to reduce cost and improve DHA productivity, mainly from the utilizations of low-cost materials and effective stimulators to the genetic engineering perspectives, are summarized, and the availabilities from the cost perspective are also evaluated. This review provides an overview about the strategies to revolve the production cost and yield of the DHA by Aurantiochytrium sp. (Schizochytrium sp.), a theoretical basis for genetic modification of Aurantiochytrium sp. (Schizochytrium sp.), and a practical basis for the development of DHA industry. KEY POINTS : • Utilizations of various low-cost materials for DHA production • Inducing the growth and DHA biosynthesis by the effective stimulators • Reducing cost and improving DHA productivity by genetic modification • The availability from cost perspective is evaluated.

Marine Oomycetes (Halophytophthora and Salispina): A Potential Source of Fatty Acids with Cytotoxic Activity Against Breast Adenocarcinoma Cells (MCF7)

Marine oomycetes are ubiquitous, fungus-like eukaryotes known to produce fatty acids with potential anticancer activity. The long chain omega-3 and omega-6 fatty acids are currently popular and considered as safe when used as nutraceuticals in cancer treatment. In this study, crude fatty acids from three marine oomycetes, Halophytophthora spp. (T12GP1 and T12YBP2) and Salispina hoi (USTCMS 1611), were explored for their cytotoxic and apoptotic potentials against human breast adenocarcinoma cells (MCF7) and normal human dermal fibroblasts (HDFn). Extracts from mycelia mats consisted of diverse saturated, monounsaturated, and polyunsaturated fatty acids such as linoleic, α-linolenic, γ-linolenic, eicosatrienoic and eicosapentaenoic acids. The crude fatty acids from all three oomycetes in in vitro assays for cytotoxicity showed no toxicity (30% toxicity values) on HDFn cells. On MCF7 cells, however, IC₅₀ values of 23.44, 15.63, and 26.15 µg/mL were obtained with extracts from Halophytophthora T12GP1 and T12YBP2 and S. hoi, respectively. Treated MCF7 cells exhibited deformed cell membrane in MTT assay and also aggregation of DNA and disruption of nuclear membrane aggregation in nuclear staining; further, green signals indicative of apoptosis was recorded in caspase 3/7 assay.

A thraustochytrid-specific lipase/phospholipase with unique positional specificity contributes to microbial competition and fatty acid acquisition from the environment

Thraustochytrids are heterotrophic marine protists that are considered as important decomposers in the marine ecosystem; however, how they digest and uptake lipid nutrients from the environment is largely unknown. Genomic clustering analysis using thraustochytrid draft genome databases revealed that novel proteins with a Lipase_3 domain are commonly present in thraustochytrids, including Aurantiochytrium limacinum. After heterologous expression and His tag-based purification, protein ID: 145138 was identified as lipase/phospholipase capable of hydrolyzing triacylglycerol (TG) and phosphatidylcholine (PC). 145138 was secreted into the medium, and deletion of the 145138 gene in A. limacinum reduced the degradation of extracellular lipids. Fatty acids generated by 145138 were reused for the biosynthesis of PC and TG, and 145138 allowed A. limacinum to survive in the medium containing TG as a sole carbon source. 145138 hydrolyzed all the acyl-ester linkages of TG; however, the enzyme showed strict positional specificity toward phospholipids, generating 2-acyl lysophospholipids. The 2-acyl lysophospholipids showed stronger antimicrobial activity compared with 1-acyl lysophospholipids. These results suggested that 145138 is a bifunctional enzyme that contributes to the acquisition of lipid nutrients from the environment, as well as to generate antimicrobial lysophospholipids that are beneficial for competition with bacteria over lipid nutrients in the marine environment.

Bio-based squalene production by Aurantiochytrium sp. through optimization of culture conditions, and elucidation of the putative biosynthetic pathway genes

Newly-isolated thraustochytrid strains from coastal waters of China were characterized as bioresource of squalene and the culture condition for the top producer was systematically optimized. Phylogenetic analysis revealed that eight squalene-producing isolates were closely related to genus Aurantiochytrium and one to genus Labyrinthula. The top producer, Aurantiochytrium sp. TWZ-97, produced squalene up to 188.6 mg/L at 28 °C in a 5-L bioreactor containing optimal medium (glucose: 40 g/L, monosodium glutamate: 3 g/L, yeast extract: 25 g/L, and NaCl: 6 g/L), which was 6-fold higher than that under unoptimized condition. Transcriptome analysis revealed for the first time the presence of seven key genes of mevalonate pathway for squalene biosynthesis in strain TWZ-97. Medium optimization yielded a 2.23-fold higher expression of the squalene synthase gene under optimal condition compared to unoptimized. This study provides a potential thraustochytrid strain TWZ-97 as bioresource of squalene and uncovers novel information about its squalene biosynthesis pathway for future strain improvement.

Alleviation of reactive oxygen species enhances PUFA accumulation in Schizochytrium sp. through regulating genes involved in lipid metabolism

The unicellular heterotrophic thraustochytrids are attractive candidates for commercial polyunsaturated fatty acids (PUFA) production. However, the reactive oxygen species (ROS) generated in their aerobic fermentation process often limits their PUFA titer. Yet, the specific mechanisms of ROS involvement in the crosstalk between oxidative stress and intracellular lipid synthesis remain poorly described. Metabolic engineering to improve the PUFA yield in thraustochytrids without compromising growth is an important aspect of economic feasibility. To fill this gap, we overexpressed the antioxidative gene superoxide dismutase (SOD1) by integrating it into the genome of thraustochytrid Schizochytrium sp. PKU#Mn4 using a novel genetic transformation system. This study reports the ROS alleviation, enhanced PUFA production and transcriptome changes resulting from the SOD1 overexpression. SOD1 activity in the recombinant improved by 5.2-71.6% along with 7.8-38.5% decline in ROS during the fermentation process. Interestingly, the total antioxidant capacity in the recombinant remained higher than wild-type and above zero in the entire process. Although lipid profile was similar to that of wild-type, the concentrations of major fatty acids in the recombinant were significantly (p ≤ 0.05) higher. The PUFA titer increased up to 1232 ± 41 mg/L, which was 32.9% higher (p ≤ 0.001) than the wild type. Transcriptome analysis revealed strong downregulation of genes potentially involved in β-oxidation of fatty acids in peroxisome and upregulation of genes catalyzing lipid biosynthesis. Our results enrich the knowledge on stress-induced PUFA biosynthesis and the putative role of ROS in the regulation of lipid metabolism in oleaginous thraustochytrids. This study provides a new and alternate strategy for cost-effective industrial fermentation of PUFA.

Growth medium sterilization using decomposition of peracetic acid for more cost-efficient production of omega-3 fatty acids by Aurantiochytrium

Aurantiochytrium can produce significant amounts of omega-3 fatty acids, specifically docosahexaenoic acid and docosapentaenoic acid. Use of a glucose-based medium for heterotrophic growth is needed to achieve a high growth rate and production of abundant lipids. However, heat sterilization for reliable cultivation is not appropriate to heat-sensitive materials and causes a conversion of glucose via browning (Maillard) reactions. Thus, the present study investigated the use of a direct degradation of Peracetic acid (PAA) for omega-3 production by Aurantiochytrium. Polymer-based bioreactor and glucose-containing media were chemically co-sterilized by 0.04% PAA and neutralized through a reaction with ferric ion (III) in HEPES buffer. Mono-cultivation was achieved without the need for washing steps and filtration, thereby avoiding the heat-induced degradation and dehydration of glucose. Use of chemically sterilized and neutralized medium, rather than heat-sterilized medium, led to a twofold faster growth rate and greater productivity of omega-3 fatty acids.

Regulation of TG accumulation and lipid droplet morphology by the novel TLDP1 in Aurantiochytrium limacinum F26-b

Thraustochytrids are marine single-cell protists that produce large amounts of PUFAs, such as DHA. They accumulate PUFAs in lipid droplets (LDs), mainly as constituent(s) of triacylglycerol (TG). We identified a novel protein in the LD fraction of Aurantiochytrium limacinum F26-b using 2D-difference gel electrophoresis. The protein clustered with orthologs of thraustochytrids; however, the cluster was evolutionally different from known PAT family proteins or plant LD protein; thus, we named it thraustochytrid-specific LD protein 1 (TLDP1). TLDP1 surrounded LDs when expressed as a GFP-tagged form. Disruption of the tldp1 gene decreased the content of TG and number of LDs per cell; however, irregular and unusually large LDs were generated in tldp1-deficient mutants. Although the level of TG synthesis was unchanged by the disruption of tldp1, the level of TG degradation was higher in tldp1-deficient mutants than in the WT. These phenotypic abnormalities in tldp1-deficient mutants were restored by the expression of tldp1 These results indicate that TLDP1 is a thraustochytrid-specific LD protein and regulates the TG accumulation and LD morphology in A. limacinum F26-b.

Novel squalene-producing thraustochytrids found in mangrove water

On extended screening of squalene-producing strains in Okinawa mangrove water, we identified 14 novel squalene-producing thraustochytrids from 172 unialgal clonal isolates. The novel thraustochytrids produced 13.9-7.54 mg squalene/g dry cell weight. Eight isolates were found to belong to potentially novel squalene-producing genera, forming a monophyletic cluster independent from any known thraustochytrids.

Exploring omega-3 fatty acids, enzymes and biodiesel producing thraustochytrids from Australian and Indian marine biodiversity

The marine environment harbours a vast diversity of microorganisms, many of which are unique, and have potential to produce commercially useful materials. Therefore, marine biodiversity from Australian and Indian habitat has been explored to produce novel bioactives, and enzymes. Among these, thraustochytrids collected from Indian habitats were shown to be rich in saturated fatty acids (SFAs) and monounsaturated fatty acids (MUFAs), together constituting 51-76% of total fatty acids (TFA). Indian and Australian thraustochytrids occupy separate positions in the dendrogram, showing significant differences exist in the fatty acid profiles in these two sets of thraustochytrid strains. In general, Australian strains had a higher docosahexaenoic acid (DHA) content than Indian strains with DHA at 17-31% of TFA. A range of enzyme activities were observed in the strains, with Australian strains showing overall higher levels of enzyme activity, with the exception of one Indian strain (DBTIOC-1). Comparative analysis of the fatty acid profile of 34 strains revealed that Indian thraustochytrids are more suitable for biodiesel production since these strains have higher fatty acids content for biodiesel (FAB, 76%) production than Australian thraustochytrids, while the Australian strains are more suitable for omega-3 (40%) production.

Biotechnological Production of Docosahexaenoic Acid Using Aurantiochytrium limacinum: Carbon Sources Comparison And Growth Characterization

Aurantiochytrium limacinum, a marine heterotrophic protist/microalga has shown interesting yields of docosahexaenoic acid (DHA) when cultured with different carbon sources: glucose, pure and crude glycerol. A complete study in a lab-scale fermenter allowed for the characterization and comparison of the growth kinetic parameters corresponding to each carbon source. Artificial Marine Medium (AMM) with glucose, pure and crude glycerol offered similar biomass yields. The net growth rates (0.10–0.12 h⁻¹), biomass (0.7–0.8 g cells/g Substrate) and product (0.14–0.15 g DHA/g cells) yields, as well as DHA productivity were similar using the three carbon sources. Viable potential applications to valorize crude glycerol are envisioned to avoid an environmental problem due to the excess of byproduct.

Reconstruction and analysis of the genome-scale metabolic model of schizochytrium limacinum SR21 for docosahexaenoic acid production

Background

Schizochytrium limacinum SR21 is a potential industrial strain for docosahexaenoic acid (DHA) production that contains more than 30–40 % DHA among its total fatty acids.

Methods

To resolve the DHA biosynthesis mechanism and improve DHA production at a systematic level, a genomescale metabolic model (GSMM), named iCY1170_DHA, which contains 1769 reactions, 1659 metabolites, and 1170 genes, was reconstructed.

Results

Based on genome annotation results and literature reports, a new DHA synthesis pathway based on a polyketide synthase (PKS) system was detected in S. limacinum. Similarly to conventional fatty acid synthesis, the biosynthesis of DHA via PKS requires abundant acetyl-CoA and NADPH. The in silico addition of malate and citrate led to increases of 24.5 % and 37.1 % in DHA production, respectively. Moreover, based on the results predicted by the model, six amino acids were shown to improve DHA production by experiment. Finally, 30 genes were identified as potential targets for DHA over-production using a Minimization of Metabolic Adjustment algorithm.

Conclusions

The reconstructed GSMM, iCY1170_DHA, could be used to elucidate the mechanism by which DHA is synthesized in S. limacinum and predict the requirements of abundant acetyl-CoA and NADPH for DHA production as well as the enhanced yields achieved via supplementation with six amino acids, malate, and citrate.

Electronic supplementary material

The online version of this article (doi:10.1186/s12864-015-2042-y) contains supplementary material, which is available to authorized users.

Transcriptome and gene expression analysis of DHA producer Aurantiochytrium under low temperature conditions

Aurantiochytrium is a promising docosahexaenoic acid (DHA) production candidate due to its fast growth rate and high proportions of lipid and DHA content. In this study, high-throughput RNA sequencing technology was employed to explore the acclimatization of this DHA producer under cold stress at the transcriptional level. The overall de novo assembly of the cDNA sequence data generated 29,783 unigenes, with an average length of 1,200 bp. In total, 13,245 unigenes were annotated in at least one database. A comparative genomic analysis between normal conditions and cold stress revealed that 2,013 genes were differentially expressed during the growth stage, while 2,071 genes were differentially expressed during the lipid accumulation stage. Further functional categorization and analyses showed some differentially expressed genes were involved in processes crucial to cold acclimation, such as signal transduction, cellular component biogenesis, and carbohydrate and lipid metabolism. A brief survey of the transcripts obtained in response to cold stress underlines the survival strategy of Aurantiochytrium; of these transcripts, many directly or indirectly influence the lipid composition. This is the first study to perform a transcriptomic analysis of the Aurantiochytrium under low temperature conditions. Our results will help to enhance DHA production by Aurantiochytrium in the future.

Production of arachidonic and eicosapentaenoic acids by the marine oomycete Halophytophthora

Polyunsaturated fatty acids (PUFAs) are fatty acids with more than one double bond in the chemical structure. Arachidonic acid (ARA, 20:4 (n-6)) and eicosapentaenoic acid (EPA, 22:5 (n-3)) are common PUFAs with beneficial health effects. Marine fish and meat are the main sources of omega-3 and omega-6 fatty acids in human's diet, respectively. In particular, there is a general decline in fish catch, implicating the need for an alternative source of omega-3 fatty acids. Previous studies have examined the production of polyunsaturated fatty acids including ARA and EPA by various microorganisms, including microalgae, fungi, and thraustochytrids. In this study, the production of ARA and EPA by 10 isolates of four estuarine Halophytophthora species (Halophytophthora avicenniae, Halophytophthora polymorphica, Halophytophthora vesicula, and Halophytophthora spinosa var. spinosa) cultured from fallen mangrove leaves in Taiwan was examined. The yield of ARA ranged from 0.004 to 0.052 g/L with the highest yield of ARA obtained from H. spinosa var. spinosa IMB162, but no or a very low level of EPA was produced by IMB162. For EPA production by Halophytophthora spp., the yield ranged from 0 to 0.047 g/L. Percentage of ARA in total fatty acid ranged between 7.16 and 25.02%. One-way ANOVA analysis using Tukey Test (p ≥ 0.05) suggested that there is significant difference in the percentage of EPA in total fatty acid produced by the isolates, which ranged from 0.01 to 18.42%. BODIPY 505/515 fluorescent staining suggests that lipid bodies were evenly distributed in the mycelia of Halophytophthora species.

Novel lysophospholipid acyltransferase PLAT1 of Aurantiochytrium limacinum F26-b responsible for generation of palmitate-docosahexaenoate-phosphatidylcholine and phosphatidylethanolamine

N-3 polyunsaturated fatty acids (PUFA), such as docosahexaenoic acid (DHA, 22:6n-3), have been reported to play roles in preventing cardiovascular diseases. The major source of DHA is fish oils but a recent increase in the global demand of DHA and decrease in fish stocks require a substitute. Thraustochytrids, unicellular marine protists belonging to the Chromista kingdom, can synthesize large amounts of DHA, and, thus, are expected to be an alternative to fish oils. DHA is found in the acyl chain(s) of phospholipids as well as triacylglycerols in thraustochytrids; however, how thraustochytrids incorporate DHA into phospholipids remains unknown. We report here a novel lysophospholipid acyltransferase (PLAT1), which is responsible for the generation of DHA-containing phosphatidylcholine and phosphatidylethanolamine in thraustochytrids. The PLAT1 gene, which was isolated from the genomic DNA of Aurantiochytrium limacinum F26-b, was expressed in Saccharomyces cerevisiae, and the FLAG-tagged recombinant enzyme was characterized after purification with anti-FLAG affinity gel. PLAT1 shows wide specificity for donor substrates as well as acceptor substrates in vitro, i.e, the enzyme can adopt lysophosphatidylcholine, lysophosphatidylethanolamine, lysophosphatidylserine and lysophosphatidylinositol as acceptor substrates, and 15:0/16:0-CoA and DHA-CoA as donor substrates. In contrast to the in vitro experiment, only lysophosphatidylcholine acyltransferase and lysophosphatidylethanolamine acyltransferase activities were decreased in plat1-knockout mutants, resulting in a decrease of 16:0-DHA-phosphatidylcholine (PC) [PC(38∶6)] and 16:0-DHA-phosphatidylethanolamine (PE) [PE(38∶6)], which are two major DHA-containing phospholipids in A. limacinum F26-b. However, the amounts of other phospholipid species including DHA-DHA-PC [PC(44∶12)] and DHA-DHA-PE [PE(44∶12)] were almost the same in plat-knockout mutants and the wild-type. These results indicate that PLAT1 is the enzyme responsible for the generation of 16:0-DHA-PC and 16:0-DHA-PE in the thraustochytrid.

Thraustochytrids can be grown in low-salt media without affecting PUFA production

Marine microheterotrophs thraustochytrids are emerging as a potential source for commercial production of polyunsaturated fatty acids (PUFA) that have nutritional and pharmacological values. With prospective demand for PUFAs increasing, biotechnological companies are looking for potential increases in those valuable products. However, high levels of NaCl in the culture media required for optimal thraustochytrid growth and PUFA production poses a significant problem to the biotechnological industry due to corrosion of fermenters calling for a need to reduce the amount of NaCl in the culture media, without imposing penalties on growth and yield of cultured organisms. Earlier, as reported by Shabala et al. (Environ Microbiol 11:1835-1843, 2009), we have shown that thraustochytrids use sodium predominantly for osmotic adjustment purposes and, as such, can be grown in low-salt environment without growth penalties, providing the media osmolality is adjusted. In this study, we verify if that conclusion, made for one specific strain and osmolyte only, is applicable to the larger number of strains and organic osmotica, as well as address the issue of yield quality (e.g., PUFA production in low-saline media). Using mannitol and sucrose for osmotic adjustment of the growth media enabled us to reduce NaCl concentration down to 1 mM; this is 15-100-fold lower than any method proposed so far. At the same time, the yield of essential PUFAs was increased by 15 to 20 %. Taken together, these results suggest that the proposed method can be used in industrial fermenters for commercial PUFA production.

Growth condition optimization for docosahexaenoic acid (DHA) production by Moritella marina MP-1

The marine organism Moritella marina MP-1 produces the polyunsaturated fatty acid docosahexaenoic acid (DHA). While the basic metabolic pathway for DHA production in this organism has been identified, the impact of growth conditions on DHA production is largely unknown. This study examines the effect of supplemental carbon, nitrogen and salts, growth temperature and media composition and pH on DHA and biomass production and the fatty acid profile. The addition of supplemental nitrogen significantly increased the overall DHA titer via an increase in biomass production. Supplemental glucose or glycerol increased biomass production, but decreased the amount of DHA per biomass, resulting in no net change in the DHA titer. Acidification of the baseline media pH to 6.0 increased DHA per biomass. Changes in growth temperature or provision of supplemental sodium or magnesium chloride did not increase DHA titer. This organism was also shown to grow on defined minimal media. For both media types, glycerol enabled more DHA production per biomass than glucose. Combination of these growth findings into marine broth supplemented with glycerol, yeast extract, and tryptone at pH 6.0 resulted in a final titer of 82±5 mg/L, a nearly eightfold increase relative to the titer of 11±1 mg/L seen in the unsupplemented marine broth. The relative distribution of other fatty acids was relatively robust to growth condition, but the presence of glycerol resulted in a significant increase in myristic acid (C14:0) and decrease in palmitic acid (C16:0). In summary, DHA production by M. marina MP-1 can be increased more than fivefold by changing the growth media. Metabolic engineering of this organism to increase the amount of DHA produced per biomass could result in additional increases in titer.

Versatile transformation system that is applicable to both multiple transgene expression and gene targeting for Thraustochytrids

A versatile transformation system for thraustochytrids, a promising producer for polyunsaturated fatty acids and fatty acid-derived fuels, was established. G418, hygromycin B, blasticidin, and zeocin inhibited the growth of thraustochytrids, indicating that multiple selectable marker genes could be used in the transformation system. A neomycin resistance gene (neo(r)), driven with an ubiquitin or an EF-1α promoter-terminator from Thraustochytrium aureum ATCC 34304, was introduced into representatives of two thraustochytrid genera, Aurantiochytrium and Thraustochytrium. The neo(r) marker was integrated into the chromosomal DNA by random recombination and then functionally translated into neo(r) mRNA. Additionally, we confirmed that another two genera, Parietichytrium and Schizochytrium, could be transformed by the same method. By this method, the enhanced green fluorescent protein was functionally expressed in thraustochytrids. Meanwhile, T. aureum ATCC 34304 could be transformed by two 18S ribosomal DNA-targeting vectors, designed to cause single- or double-crossover homologous recombination. Finally, the fatty acid Δ5 desaturase gene was disrupted by double-crossover homologous recombination in T. aureum ATCC 34304, resulting in an increase of dihomo-γ-linolenic acid (C(20:3n-6)) and eicosatetraenoic acid (C(20:4n-3)), substrates for Δ5 desaturase, and a decrease of arachidonic acid (C(20:4n-6)) and eicosapentaenoic acid (C(20:5n-3)), products for the enzyme. These results clearly indicate that a versatile transformation system which could be applicable to both multiple transgene expression and gene targeting was established for thraustochytrids.

Optimization of culture conditions of the thraustochytrid Aurantiochytrium sp. strain 18W-13a for squalene production

Optimum conditions of temperature, salinity and glucose concentration were investigated for squalene production of the strain of Aurantiochytrium sp. 18 W-13a, with a high content of squalene. Squalene production by this strain was optimum at 25 °C, 25-50% seawater concentration and 2-6% glucose concentration. When this strain was grown in the optimum condition, the squalene content and production of approximately 171 mg/g dry weight and 0.9 g/L were much higher than that previously reported in thraustochytrids, plants and yeasts, respectively. Therefore, 18 W-13a could be used as an alternative source of commercial squalene.

Effects of cold shock treatment on total lipid content and fatty acid composition of Aurantiochytrium limacinum strain mh0186

To examine the effect of cold shock treatment on the fatty acid composition of Aurantiochytrium limacinum strain mh0186, a marine thraustochytrid, we cultivated this strain at 28°C for 72 h with shaking and stored the obtained biomass at 10°C for 72 h. A growth experiment was carried out for comparison, wherein strain mh0186 was grown at 10 and 15°C for 72 h with shaking, and it was found that the unsaturation of fatty acids was accelerated relative to that at 28°C. In the cold shock experiment, the total lipid content significantly increased during storage at 10°C for 72 h. Overall, the percentage of unsaturated fatty acids such as docosahexaenoic acid was almost stable while that of n-6 docosapentaenoic acid decreased slightly, but significantly, relative to that in the growth experiment.

The distribution of extracellular cellulase activity in marine Eukaryotes, thraustochytrids

Cellulolytic ability was evaluated in 19 strains of thraustochytrids, representing nine genera, using carboxymethylcellulose (CMC) as a substrate. Extracellular cellulolytic enzyme activity was determined in the culture supernatants during cell growth. CMC hydrolysis was observed in 14 out of the 19 strains examined. These belonged to the genera Aplanochytrium, Botryochytrium, Oblongichytrium, Parietichytrium, Schizochytrium, Sicyoidochytrium, Thraustochytrium and Ulkenia. On the other hand, cellulolytic enzyme activity was not detected in any strains belonging to the genus Aurantiochytrium.

Production of lipids containing high levels of docosahexaenoic acid by a newly isolated microalga, Aurantiochytrium sp. KRS101

In the present study, a novel oleaginous Thraustochytrid containing a high content of docosahexaenoic acid (DHA) was isolated from a mangrove ecosystem in Malaysia. The strain identified as an Aurantiochytrium sp. by 18S rRNA sequencing and named KRS101 used various carbon and nitrogen sources, indicating metabolic versatility. Optimal culture conditions, thus maximizing cell growth, and high levels of lipid and DHA production, were attained using glucose (60 g l⁻¹) as carbon source, corn steep solid (10 g l⁻¹) as nitrogen source, and sea salt (15 g l⁻¹). The highest biomass, lipid, and DHA production of KRS101 upon fed-batch fermentation were 50.2 g l⁻¹ (16.7 g l⁻¹ day⁻¹), 21.8 g l⁻¹ (44% DCW), and 8.8 g l⁻¹ (40% TFA), respectively. Similar values were obtained when a cheap substrate like molasses, rather than glucose, was used as the carbon source (DCW of 52.44 g l⁻¹, lipid and DHA levels of 20.2 and 8.83 g l⁻¹, respectively), indicating that production of microbial oils containing high levels of DHA can be produced economically when the novel strain is used.