101
|
Cai C, Li L, Hua Y, Liu H, Dai X. Ferroferric oxide promotes metabolism in Anaerolineae other than microbial syntrophy in anaerobic methanogenesis of antibiotic fermentation residue. THE SCIENCE OF THE TOTAL ENVIRONMENT 2021; 758:143601. [PMID: 33261864 DOI: 10.1016/j.scitotenv.2020.143601] [Citation(s) in RCA: 17] [Impact Index Per Article: 5.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/18/2020] [Revised: 10/28/2020] [Accepted: 10/31/2020] [Indexed: 06/12/2023]
Abstract
Antibiotic fermentation residue (AFR) is a kind of protein-rich biosolids that would be utilized as valuable substrates for biogas production. However, the effectiveness of conductive material supplementation and its effect on the microbiome in anaerobic digestion of AFR have not been fully elucidated. The objective of this study is to access the impact of Fe3O4 addition on anaerobic digestion of AFR and reveal its microbial mechanism. By adding Fe3O4 at concentration of 150 mg/gTS to two typical AFRs, the methane yield was decreased while the methane production rate was significantly enhanced by 48% and 21%, respectively. Genomic analyses revealed that the Fe3O4 addition altered the microbial community by selecting the unknown genus of Anaerolineae with the metabolic capacity of carbohydrate hydrolysis and proteolysis. Meanwhile, the hydrogenotrophic methanogenesis was the dominant pathway in the AFR digestion system, which was mostly contributed by the Methanoculleus and Methanolinea. More interestingly, Methanoculleus might possess fermentative capability involved in the versatile hydrolysis pathway. Although the genes related to electrically conductive pili were detected, the induction of direct interspecies electron transfer by Fe3O4 supplementation was not confirmed in this study. In summary, except the accelerated methane production rate, Fe3O4 addition functioned as biostimulator for Anaerolineae other than electron conduit in anaerobic methanogenesis in the AFR digestion system.
Collapse
Affiliation(s)
- Chen Cai
- State Key Laboratory of Pollution Control and Resources Reuse, College of Environmental Science and Engineering, Tongji University, Shanghai 200092, China
| | - Lei Li
- State Key Laboratory of Pollution Control and Resources Reuse, College of Environmental Science and Engineering, Tongji University, Shanghai 200092, China
| | - Yu Hua
- State Key Laboratory of Pollution Control and Resources Reuse, College of Environmental Science and Engineering, Tongji University, Shanghai 200092, China
| | - Huiling Liu
- State Key Laboratory of Pollution Control and Resources Reuse, College of Environmental Science and Engineering, Tongji University, Shanghai 200092, China
| | - Xiaohu Dai
- State Key Laboratory of Pollution Control and Resources Reuse, College of Environmental Science and Engineering, Tongji University, Shanghai 200092, China.
| |
Collapse
|
102
|
Elsamadony M, Mostafa A, Fujii M, Tawfik A, Pant D. Advances towards understanding long chain fatty acids-induced inhibition and overcoming strategies for efficient anaerobic digestion process. WATER RESEARCH 2021; 190:116732. [PMID: 33316662 DOI: 10.1016/j.watres.2020.116732] [Citation(s) in RCA: 47] [Impact Index Per Article: 15.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/30/2020] [Revised: 11/24/2020] [Accepted: 12/06/2020] [Indexed: 06/12/2023]
Abstract
The inhibition of the anaerobic digestion (AD) process, caused by long chain fatty acids (LCFAs), has been considered as an important issue in the wastewater treatment sector. Proper understanding of mechanisms behind the inhibition is a must for further improvements of the AD process in the presence of LCFAs. Through analyzing recent literature, this review extensively describes the mechanism of LCFAs degradation, during AD. Further, a particular focus was directed to the key parameters which could affect such process. Besides, this review highlights the recent research efforts in mitigating LCFAs-caused inhibition, through the addition of commonly used additives such as cations and natural adsorbents. Specifically, additives such as bentonite, cation-based adsorbents, as well as zeolite and other natural adsorbents for alleviating the LCFAs-induced inhibition are discussed in detail. Further, panoramic evaluations for characteristics, various mechanisms of reaction, merits, limits, recommended doses, and preferred conditions for each of the different additives are provided. Moreover, the potential for increasing the methane production via pretreatment using those additives are discussed. Finally, we provide future horizons for the alternative materials that can be utilized, more efficiently, for both mitigating LCFAs-based inhibition and boosting methane potential in the subsequent digestion of LCFA-related wastes.
Collapse
Affiliation(s)
- Mohamed Elsamadony
- Tokyo Institute of Technology, Civil and Environmental Engineering Department, Meguro-ku, Tokyo, 152-8552, Japan; Tanta University, Faculty of Engineering, Public Works Engineering Department, 31521, Tanta City, Egypt.
| | - Alsayed Mostafa
- Department of Smart City Engineering, Inha University, 100 Inharo, Nam-gu, Incheon 22212, South Korea
| | - Manabu Fujii
- Tokyo Institute of Technology, Civil and Environmental Engineering Department, Meguro-ku, Tokyo, 152-8552, Japan.
| | - Ahmed Tawfik
- National Research Centre, Water Pollution Research Department, Giza, 12622, Egypt
| | - Deepak Pant
- Separation & Conversion Technology, Flemish Institute for Technological Research (VITO), Boeretang 200, Mol 2400, Belgium
| |
Collapse
|
103
|
Meng X, Sui Q, Liu J, Yu D, Wang Y, Wei Y. Relieving ammonia inhibition by zero-valent iron (ZVI) dosing to enhance methanogenesis in the high solid anaerobic digestion of swine manure. WASTE MANAGEMENT (NEW YORK, N.Y.) 2020; 118:452-462. [PMID: 32977305 DOI: 10.1016/j.wasman.2020.08.021] [Citation(s) in RCA: 20] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/28/2019] [Revised: 07/20/2020] [Accepted: 08/15/2020] [Indexed: 06/11/2023]
Abstract
Relieving from ammonia inhibition and enhancing the utilization of thermodynamically unfavorable propionate are crucial for methane harvest in the high solid anaerobic digestion (HSAD) of ammonia-rich swine manure. In this study, the potential of dosing zero-valent iron (ZVI, 150 um) for enhancing the methanogenesis to resist total ammonia (TAN) over 5.0 g-N·L-1 was investigated via batch experiments under mesophilic condition. The cumulative methane production was enhanced by 22.2% at ≥160 mM ZVI dosage and the HSAD duration was further shortened by 50.6% at ≥320 mM ZVI dosage. The enhanced methanogenesis was mainly resulted from the full utilization of propionate and the accelerated collapse of posterior-biodegradable organics which might be driven by ZVI. Results of microbial community and qPCR (mcrA) showed that ZVI might trigger the blooming of Methanosarcina (from 27.9% to 78.3%) and Syntrophomonas (0.5% to 3.7%) and attribute to their possible direct interspecies electron transfer (DIET) to enhance propionate utilization. Besides, the main methanogenesis might remain in the effective aceticlastic pathway even under free ammonia (FAN) almost 1.0 g-N·L-1 because syntrophic acetate oxidizing bacteria (SAOB) decreased to almost none at 320 mM ZVI dosage. Dosing ZVI could relieve HSAD from TAN inhibition and more dosage was required to resist FAN inhibition.
Collapse
Affiliation(s)
- Xiaoshan Meng
- State Key Joint Laboratory of Environment Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; School of Chemical & Environmental Engineering, China University of Mining & Technology (Beijing), Beijing 100083, China
| | - Qianwen Sui
- State Key Joint Laboratory of Environment Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
| | - Jibao Liu
- State Key Joint Laboratory of Environment Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
| | - Dawei Yu
- State Key Joint Laboratory of Environment Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
| | - Yawei Wang
- State Key Joint Laboratory of Environment Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
| | - Yuansong Wei
- State Key Joint Laboratory of Environment Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; College of Resources and Environment, University of Chinese Academy of Sciences, Beijing 100049, China; Institute of Energy, Jiangxi Academy of Sciences, Nanchang 330029, China.
| |
Collapse
|
104
|
Ziganshina EE, Belostotskiy DE, Bulynina SS, Ziganshin AM. Effect of magnetite on anaerobic digestion of distillers grains and beet pulp: Operation of reactors and microbial community dynamics. J Biosci Bioeng 2020; 131:290-298. [PMID: 33172764 DOI: 10.1016/j.jbiosc.2020.10.003] [Citation(s) in RCA: 21] [Impact Index Per Article: 5.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/11/2020] [Revised: 10/08/2020] [Accepted: 10/09/2020] [Indexed: 10/23/2022]
Abstract
It has been previously shown that magnetite (Fe3O4) nanoparticles stimulate the anaerobic digestion process in several anaerobic reactors. Here we evaluate the effect of magnetite nanoparticles on the efficiency of anaerobic digestion of distillers grains with solubles and sugar beet pulp in mesophilic batch experiments. The addition of magnetite nanopowder had a positive effect on the anaerobic digestion process. CH4 was produced faster in the presence of 50 mg of Fe3O4 per 1 g of added total solids than from treatments without addition of Fe3O4. These results demonstrate that the addition of magnetite enhances the methanogenic decomposition of organic acids. Microbial community structure and dynamics were investigated based on bacterial and archaeal 16S rRNA genes, as well as mcrA genes encoding the methyl-CoM reductase. Depending on the reactor, Bacteroides, midas_1138, Petrimonas, unclassified Rikenellaceae (class Bacteroidia), Ruminiclostridium, Proteiniclasticum, Herbinix, and Intestinibacter (class Clostridia) were the main representatives of the bacterial communities. The archaeal communities in well-performed anaerobic reactors were mainly represented by representatives of the genera Methanosarcina and Methanobacterium. Based on our findings, Fe3O4 nanoparticles, when used properly, will improve biomethane production.
Collapse
Affiliation(s)
- Elvira E Ziganshina
- Department of Microbiology, Kazan (Volga Region) Federal University, Kazan 420008, Republic of Tatarstan, Russia
| | - Dmitry E Belostotskiy
- Department of Microbiology, Kazan (Volga Region) Federal University, Kazan 420008, Republic of Tatarstan, Russia
| | - Svetlana S Bulynina
- Department of Microbiology, Kazan (Volga Region) Federal University, Kazan 420008, Republic of Tatarstan, Russia
| | - Ayrat M Ziganshin
- Department of Microbiology, Kazan (Volga Region) Federal University, Kazan 420008, Republic of Tatarstan, Russia.
| |
Collapse
|
105
|
Yan M, Treu L, Zhu X, Tian H, Basile A, Fotidis IA, Campanaro S, Angelidaki I. Insights into Ammonia Adaptation and Methanogenic Precursor Oxidation by Genome-Centric Analysis. ENVIRONMENTAL SCIENCE & TECHNOLOGY 2020; 54:12568-12582. [PMID: 32852203 PMCID: PMC8154354 DOI: 10.1021/acs.est.0c01945] [Citation(s) in RCA: 38] [Impact Index Per Article: 9.5] [Reference Citation Analysis] [Abstract] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/28/2020] [Revised: 08/22/2020] [Accepted: 08/27/2020] [Indexed: 05/04/2023]
Abstract
Ammonia released from the degradation of protein and/or urea usually leads to suboptimal anaerobic digestion (AD) when N-rich organic waste is used. However, the insights behind the differential ammonia tolerance of anaerobic microbiomes remain an enigma. In this study, the cultivation in synthetic medium with different carbon sources (acetate, methanol, formate, and H2/CO2) shaped a common initial inoculum into four unique ammonia-tolerant syntrophic populations. Specifically, various levels of ammonia tolerance were observed: consortia fed with methanol and H2/CO2 could grow at ammonia levels up to 7.25 g NH+-N/L, whereas the other two groups (formate and acetate) only thrived at 5.25 and 4.25 g NH+-N/L, respectively. Metabolic reconstruction highlighted that this divergent microbiome might be achieved by complementary metabolisms to maximize biomethane recovery from carbon sources, thus indicating the importance of the syntrophic community in the AD of N-rich substrates. Besides, sodium/proton antiporter operon, osmoprotectant/K+ regulator, and osmoprotectant synthesis operon may function as the main drivers of adaptation to the ammonia stress. Moreover, energy from the substrate-level phosphorylation and multiple energy-converting hydrogenases (e.g., Ech and Eha) could aid methanogens to balance the energy request for anabolic activities and contribute to thriving when exposed to high ammonia levels.
Collapse
Affiliation(s)
- Miao Yan
- Department of Environmental
Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kongens Lyngby, Denmark
| | - Laura Treu
- Department of Biology, University
of Padova, Via U. Bassi
58/b, 35121 Padova, Italy
| | - Xinyu Zhu
- Department of Environmental
Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kongens Lyngby, Denmark
| | - Hailin Tian
- Department of Environmental
Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kongens Lyngby, Denmark
- NUS Environmental Research Institute, National
University of Singapore, 1 Create Way, 138602, Singapore
| | - Arianna Basile
- Department of Biology, University
of Padova, Via U. Bassi
58/b, 35121 Padova, Italy
| | - Ioannis A. Fotidis
- Department of Environmental
Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kongens Lyngby, Denmark
- School of Civil Engineering, Southeast University, 210096 Nanjing, China
| | - Stefano Campanaro
- Department of Biology, University
of Padova, Via U. Bassi
58/b, 35121 Padova, Italy
- CRIBI Biotechnology Center, University of Padua, 35131 Padua, Italy
| | - Irini Angelidaki
- Department of Environmental
Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kongens Lyngby, Denmark
| |
Collapse
|
106
|
Influence of Granular Activated Carbon on Anaerobic Co-Digestion of Sugar Beet Pulp and Distillers Grains with Solubles. Processes (Basel) 2020. [DOI: 10.3390/pr8101226] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/16/2022] Open
Abstract
Anaerobic digestion is an important technology to receive energy from various types of biomass. In this work, the impact of granular activated carbon (GAC) on the mesophilic anaerobic co-digestion of sugar beet pulp and distillers grains was investigated. After a short period, anaerobic reactors began to produce biomethane and were ready for completion within 19–24 days. The addition of GAC to reactors (5–10 g L−1) significantly enhanced the methane production rate and consumption of produced volatile fatty acids. Thus, the maximum methane production rate increased by 13.7% in the presence of GAC (5 g L−1). Bacterial and archaeal community structure and dynamics were investigated, based on 16S rRNA genes analysis. The abundant classes of bacteria in GAC-free and GAC-containing reactors were Clostridia, Bacteroidia, Actinobacteria, and Synergistia. Methanogenic communities were mainly represented by the genera Methanosarcina, Methanoculleus, Methanothrix, and Methanomassiliicoccus in GAC-free and GAC-containing reactors. Our results indicate that the addition of granular activated carbon at appropriate dosages has a positive effect on anaerobic co-digestion of by-products of the processing of sugar beet and ethanol distillation process.
Collapse
|
107
|
Chen L, Huang JJ, Hua B, Droste R, Ali S, Zhao W. Effect of steel slag in recycling waste activated sludge to produce anaerobic granular sludge. CHEMOSPHERE 2020; 257:127291. [PMID: 32531493 DOI: 10.1016/j.chemosphere.2020.127291] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/10/2020] [Revised: 05/29/2020] [Accepted: 06/01/2020] [Indexed: 06/11/2023]
Abstract
The amount of waste activated sludge (WAS) has grown dramatically in China. WAS is considered as a problematic and hazardous waste, which should be disposed in a safe and sustainable manner. In order to recycle WAS to an anaerobic granular sludge (AnGS) process for anaerobic digestion, Fe powder and steel slags (rusty and clean slags) were used to enhance the granulation process. The results demonstrated that both rusty and clean slags encouraged the development of granular sludge. Adding 10 g/L clean slags could increase AnGS granulation rate by 37%. In the presence of clean slags, extracellular polymeric substances (EPS) concentration in granules increased noticeably to 715 mg/g mixed liquor suspended solids (MLSS). High throughput sequencing analysis exhibited more diversity and higher abundance of functional microbial communities in the batch bottle with 10 g/L clean slags. This study suggested that adding clean slags at 10 g/L dosage was a sustainable and effective method for the sludge granulation.
Collapse
Affiliation(s)
- Lu Chen
- College of Environmental Science and Engineering/Sino-Canada Joint R&D Centre on Water and Environmental Safety, Nankai University, Tianjin, 300071, PR China
| | - Jinhui Jeanne Huang
- College of Environmental Science and Engineering/Sino-Canada Joint R&D Centre on Water and Environmental Safety, Nankai University, Tianjin, 300071, PR China.
| | - Binbin Hua
- College of Environmental Science and Engineering/Sino-Canada Joint R&D Centre on Water and Environmental Safety, Nankai University, Tianjin, 300071, PR China
| | - Ronald Droste
- Department of Civil Engineering, University of Ottawa, Ottawa, ON, K1N 6N5, Canada
| | - Salman Ali
- College of Environmental Science and Engineering/Sino-Canada Joint R&D Centre on Water and Environmental Safety, Nankai University, Tianjin, 300071, PR China
| | - Weixin Zhao
- College of Environmental Science and Engineering/Sino-Canada Joint R&D Centre on Water and Environmental Safety, Nankai University, Tianjin, 300071, PR China
| |
Collapse
|
108
|
Sun WX, Fu SF, Zhu R, Wang ZY, Zou H, Zheng Y. Improved anaerobic digestion efficiency of high-solid sewage sludge by enhanced direct interspecies electron transfer with activated carbon mediator. BIORESOURCE TECHNOLOGY 2020; 313:123648. [PMID: 32563791 DOI: 10.1016/j.biortech.2020.123648] [Citation(s) in RCA: 20] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/17/2020] [Revised: 06/03/2020] [Accepted: 06/05/2020] [Indexed: 06/11/2023]
Abstract
High-solid anaerobic digestion (AD) faces the problems of easy acidification and low methane production efficiency. In this study, activated carbon (AC)-enhanced direct interspecies electron transfer (DIET) was investigated to overcome such problems. Results showed the conversion of volatile fatty acids (VFAs) into methane rate was increased with AC addition, which led improved methane production efficiency. The methane yields from the early AD stage improved by 124.0-146.3% with AC addition. The T80 shortened by 8-9 days with AC addition. The relative abundances of Geobacter, Syntrophomonas and Methanosaeta that associated with DIET improved for 63.65%, 256.3% and 4.35% by AC addition, which reflected the enhanced DIET with AC addition. The redox activity of AC might be responsible for the enhanced DIET. This study would advance the understanding of DIET and provide a potential solution to the problems existed in high-solid AD.
Collapse
Affiliation(s)
- Wen-Xin Sun
- School of Environment and Civil Engineering, Jiangnan University, Wuxi, Jiangsu Province 214122, PR China
| | - Shan-Fei Fu
- School of Environment and Civil Engineering, Jiangnan University, Wuxi, Jiangsu Province 214122, PR China; Jiangsu Key Laboratory of Anaerobic Biotechnology, Jiangnan University, Wuxi, Jiangsu Province 214122, PR China
| | - Rong Zhu
- School of Environment and Civil Engineering, Jiangnan University, Wuxi, Jiangsu Province 214122, PR China
| | - Zhen-Yu Wang
- School of Environment and Civil Engineering, Jiangnan University, Wuxi, Jiangsu Province 214122, PR China
| | - Hua Zou
- School of Environment and Civil Engineering, Jiangnan University, Wuxi, Jiangsu Province 214122, PR China; Jiangsu Key Laboratory of Anaerobic Biotechnology, Jiangnan University, Wuxi, Jiangsu Province 214122, PR China.
| | - Yi Zheng
- Department of Grain Science and Industry, Kansas State University, 101C BIVAP, 1980 Kimball Avenue, Manhattan, KS 66506, USA
| |
Collapse
|
109
|
Lim EY, Tian H, Chen Y, Ni K, Zhang J, Tong YW. Methanogenic pathway and microbial succession during start-up and stabilization of thermophilic food waste anaerobic digestion with biochar. BIORESOURCE TECHNOLOGY 2020; 314:123751. [PMID: 32619808 DOI: 10.1016/j.biortech.2020.123751] [Citation(s) in RCA: 46] [Impact Index Per Article: 11.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/22/2020] [Revised: 06/24/2020] [Accepted: 06/25/2020] [Indexed: 05/22/2023]
Abstract
One of the major obstacles for thermophilic anaerobic digestion is the process instability during start-up. This study proposed the use of a cost-effective additive, biochar, to accelerate and stabilize the start-up of thermophilic semi-continuous food waste anaerobic digestion. The results showed that the reactors with biochar addition resulted in up to 18% higher methane yield as compared to the control reactors (without biochar). The key microbial networks were elucidated through thermochemical and microbial analysis. Particularly, the addition of biochar promoted the growth of electroactive Clostridia and other electroactive bacteria, while the absence of biochar promoted the growth of homoacetogenic Clostridia and syntrophic acetate oxidizing bacteria. It was revealed that biochar promoted direct interspecies electron transfer between the microbes and was responsible for the faster degradation of volatile fatty acids. Furthermore, reactors with biochar also enhanced the thermodynamically favourable acetoclastic methanogenic pathway due to the higher abundance of Methanosarcina.
Collapse
Affiliation(s)
- Ee Yang Lim
- Department of Chemical and Biomolecular Engineering, National University of Singapore, 4 Engineering Drive 4, S117576 Singapore, Singapore
| | - Hailin Tian
- NUS Environment Research Institute, National University of Singapore, 5A Engineering Drive 1, Singapore 117411, Singapore
| | - Yangyang Chen
- Department of Chemical Engineering and Applied Chemistry, University of Toronto, Canada
| | - Kewei Ni
- Department of Chemical Engineering and Applied Chemistry, University of Toronto, Canada
| | - Jingxin Zhang
- China-UK Low Carbon College, Shanghai Jiao Tong University, Shanghai 201306, China
| | - Yen Wah Tong
- Department of Chemical and Biomolecular Engineering, National University of Singapore, 4 Engineering Drive 4, S117576 Singapore, Singapore; NUS Environment Research Institute, National University of Singapore, 5A Engineering Drive 1, Singapore 117411, Singapore.
| |
Collapse
|
110
|
Yan W, Mukherjee M, Zhou Y. Direct interspecies electron transfer (DIET) can be suppressed under ammonia-stressed condition - Reevaluate the role of conductive materials. WATER RESEARCH 2020; 183:116094. [PMID: 32668350 DOI: 10.1016/j.watres.2020.116094] [Citation(s) in RCA: 44] [Impact Index Per Article: 11.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/02/2020] [Revised: 06/17/2020] [Accepted: 06/20/2020] [Indexed: 06/11/2023]
Abstract
Thermal hydrolysis pretreatment (THP) and anaerobic digestion (AD) integrated (THP-AD) process is a promising process for sludge management. However, the high ammonia production during the THP-AD process severely affects system's stability and performance. Conductive materials are widely reported to stimulate AD, thus they are potentially helpful in alleviating ammonia inhibition. This study investigated the effects of three widely studied conductive materials, i.e. zero-valent iron (ZVI), magnetite nanoparticles (Mag.) and powder activated carbon (PAC), on THP-AD process. Results showed that all the tested materials could effectively stimulate methanogenesis process under non-ammonia inhibition conditions. However, upon ammonia stress, these materials behaved distinctively with the best methanogenic performance in ZVI group followed by Mag. Group, and even worsened inhibition occurred in PAC group. The mechanisms behind were investigated from two levels-the reaction kinetics of each anaerobic digestion step and the responses of intracellular metabolism. It is revealed that ZVI effectively promoted all AD reactions, especially the energy unfavorable propanoate and butanoate metabolism and overall methanogenesis. In addition, ZVI likely acted as intracellular electron shuttles, and the conjunction point of ZVI to electron transfer system was identified as EtfAB: quinone oxidoreductase. On the contrary, the declined methanogenic performance in PAC group was attributed to selectively stimulated the growth of acetoclastic methanogen - Methanosaeta, which is sensitive to ammonia toxicity. The proteomic information further revealed that ammonia stress was unfavorable to the formation of direct interspecies electron transfer between syntrophic anaerobes. Overall, the present study provides fundamental knowledge about the role of different conductive materials in AD systems from intracellular proteomic level.
Collapse
Affiliation(s)
- Wangwang Yan
- Advanced Environmental Biotechnology Centre, Nanyang Environment and Water Research Institute, Nanyang Technological University, 637141, Singapore
| | - Manisha Mukherjee
- Singapore Centre for Environmental Life Science Engineering, Nanyang Technological University, 639798, Singapore
| | - Yan Zhou
- Advanced Environmental Biotechnology Centre, Nanyang Environment and Water Research Institute, Nanyang Technological University, 637141, Singapore; School of Civil and Environmental Engineering, Nanyang Technological University, 639798, Singapore.
| |
Collapse
|
111
|
Wang Z, Yun S, Shi J, Han F, Liu B, Wang R, Li X. Critical evidence for direct interspecies electron transfer with tungsten-based accelerants: An experimental and theoretical investigation. BIORESOURCE TECHNOLOGY 2020; 311:123519. [PMID: 32446236 DOI: 10.1016/j.biortech.2020.123519] [Citation(s) in RCA: 6] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/08/2020] [Revised: 05/05/2020] [Accepted: 05/07/2020] [Indexed: 06/11/2023]
Abstract
Accelerants can significantly enhance the biodegradability in anaerobic digestion (AD), which can be attributed to the direct interspecies electron transfer (DIET) mechanism. However, critical evidence for DIET mechanism is absent. In this work, nano-scale tungsten (W)-based compounds (WC, W2N, and W18O49) are employed to clarify the roles of W-based accelerants in AD systems. A DIET mechanism based on the W-based accelerants is proposed, and three critical pieces of evidence are provided: (i) First-principle density functional theory calculations provide theoretical evidence, illustrating that W-based accelerants are of zero band gap. (ii) Electrical conductivity evaluation further elucidates that W-based accelerants have superior electronic transport. (iii) Pyrosequencing of 16S rRNA gene confirms the existence of acetogens and methanogens in AD systems, which can act as electron-donor bacteria and electron-acceptor archaea, respectively. Combining theoretical with experimental results, the critical evidence provides a general strategy for understanding the DIET mechanism of accelerant in AD systems.
Collapse
Affiliation(s)
- Ziqi Wang
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Sining Yun
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China.
| | - Jing Shi
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Feng Han
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Bingyin Liu
- Key Laboratory of Northwest Water Resource, Environment and Ecology, MOE, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Ru Wang
- Key Laboratory of Northwest Water Resource, Environment and Ecology, MOE, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Xue Li
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| |
Collapse
|
112
|
Liu J, Zheng J, Niu Y, Zuo Z, Zhang J, Wei Y. Effect of zero-valent iron combined with carbon-based materials on the mitigation of ammonia inhibition during anaerobic digestion. BIORESOURCE TECHNOLOGY 2020; 311:123503. [PMID: 32446234 DOI: 10.1016/j.biortech.2020.123503] [Citation(s) in RCA: 21] [Impact Index Per Article: 5.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/02/2020] [Revised: 05/01/2020] [Accepted: 05/05/2020] [Indexed: 06/11/2023]
Abstract
Ammonia inhibition is a prominent problem for anaerobic digestion (AD) of nitrogen-rich organic wastes. This study evaluated the effect of zero valent iron (ZVI) and its hybrid with activated carbon (AC), graphite and Fe-C material on the mitigation of ammonia inhibition under ammonia concentration over 5 g/L, according to the batch mode experiments. Results showed that ZVI (4 g/L) and its hybrid with carbon-based material preserving methane production from ammonia inhibition, with kinetics of shortening lag phase from 4.77 d to 2.62 d or even below 2 d with carbon-based material. ZVI preserved methane production with the enrichment of Methanosarcina (the relative abundance was over 80%), which was mostly derived from the activating hydrogenotrophic methanogenesis through the enhanced DIET but not the changes of ORP and FAN.
Collapse
Affiliation(s)
- Jibao Liu
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
| | - Jiaxi Zheng
- Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China
| | - Yutong Niu
- Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
| | - Zhuang Zuo
- Beijing Drainage Group CO., LTD, Beijing 100192, China
| | - Junya Zhang
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
| | - Yuansong Wei
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China.
| |
Collapse
|
113
|
Chen J, Yun S, Shi J, Wang Z, Abbas Y, Wang K, Han F, Jia B, Xu H, Xing T, Li B. Role of biomass-derived carbon-based composite accelerants in enhanced anaerobic digestion: Focusing on biogas yield, fertilizer utilization, and density functional theory calculations. BIORESOURCE TECHNOLOGY 2020; 307:123204. [PMID: 32224426 DOI: 10.1016/j.biortech.2020.123204] [Citation(s) in RCA: 28] [Impact Index Per Article: 7.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/01/2020] [Revised: 03/14/2020] [Accepted: 03/14/2020] [Indexed: 06/10/2023]
Abstract
The performance of anaerobic digestion (AD) can be improved by the addition of accelerants. Three types of biomass-derived carbon-based composites (Co/C, CoO/C, and Co3O4/C) were used as accelerants to investigate the effect on AD systems in this work. These accelerants significantly improved the cumulative biogas yield (576-585 mL/g VS), and the total chemical oxygen demand degradation rate (68.48-71.11%) compared to the reference group (435.8 mL/g VS, 50.74%). The digestates with accelerants exhibited exceptional stability (59.24-63.67%) and superior fertilizer utilization (3.50-4.55%). In addition, first-principle density functional theory (DFT) calculations were conducted to provide the theoretical basis for the direct interspecies electron transfer (DIET), and a general strategy was proposed to help understand the enhanced methanogenesis pathway induced by the biomass-derived carbon-based composites. These important findings provide a novel avenue for the development of composite accelerants for AD systems.
Collapse
Affiliation(s)
- Jiageng Chen
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Sining Yun
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China.
| | - Jing Shi
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Ziqi Wang
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Yasir Abbas
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Kaijun Wang
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Feng Han
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Bo Jia
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Hongfei Xu
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Tian Xing
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Bingjie Li
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| |
Collapse
|
114
|
Guo SH, Jiang LY, Xu ZM, Li QS, Wang JF, Ye HJ, Wang LL, He BY, Zhou C, Zeng EY. Biological mechanisms of cadmium accumulation in edible Amaranth (Amaranthus mangostanus L.) cultivars promoted by salinity: A transcriptome analysis. ENVIRONMENTAL POLLUTION (BARKING, ESSEX : 1987) 2020; 262:114304. [PMID: 32179214 DOI: 10.1016/j.envpol.2020.114304] [Citation(s) in RCA: 14] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/17/2019] [Revised: 01/22/2020] [Accepted: 02/29/2020] [Indexed: 06/10/2023]
Abstract
Strategies to prevent cadmium (Cd) mobilization by crops under salinity conditions differs among distinct genotypes, but the biological mechanisms of Cd accumulation in different genotype crops promoted by salinity have remained scarce. In this study, we investigated the biological mechanisms of Cd accumulation in two quite different amaranth cultivars of low-Cd accumulator Quanhong (QH) and high-Cd accumulator Liuye (LY) in response to salt stress. Transcriptomes analysis was carried out on leaves and roots tissues of LY and QH grown with exchangeable Cd 0.27 mg kg-1 and salinity 3.0 g kg-1 treatment or control conditions, respectively. A total of 3224 differentially expressed genes (DEGs) in LY (1119 in roots, 2105 in leaves) and 848 in QH (207 in roots, 641 in leaves) were identified. Almost in each fold change category (2-25, 25-210, >210), the numbers of DEGs induced by salinity in LY treatments were much more than those in QH treatments, indicating that LY is more salt sensitive. Gene ontology (GO) analysis revealed that salinity stress promoted soil acidification and Cd mobilization in LY treatments through the enhancive expression of genes related to adenine metabolism (84-fold enrichment) and proton pumping ATPase (50-fold enrichment) in roots, and carbohydrate hydrolysis (2.5-fold enrichment) in leaves compared with that of whole genome, respectively. The genes expression of organic acid transporter (ALMT) was promoted by 2.71- to 3.94-fold in roots, facilitating the secretion of organic acids. Salt stress also inhibited the expression of key enzymes related to cell wall biosynthesis in roots, reducing the physical barriers for Cd uptake. All these processes altered in LY were more substantially compared with that of QH, suggesting that salt sensitive cultivars might accumulate more Cd and pose a higher health risk.
Collapse
Affiliation(s)
- Shi-Hong Guo
- Guangdong Key Laboratory of Environmental Pollution and Health, School of Environment, Jinan University, Guangzhou, 510632, China; Fujian Provincial Academy of Environmental Science, Fuzhou, 350013, China
| | - Ling-Yan Jiang
- Hainan Key Laboratory for Sustainable Utilization of Tropical Bioresource, Institute of Tropical Agriculture and Forestry, Hainan University, Haikou, 570228, China
| | - Zhi-Min Xu
- Guangdong Key Laboratory of Environmental Pollution and Health, School of Environment, Jinan University, Guangzhou, 510632, China
| | - Qu-Sheng Li
- Guangdong Key Laboratory of Environmental Pollution and Health, School of Environment, Jinan University, Guangzhou, 510632, China.
| | - Jun-Feng Wang
- Guangdong Key Laboratory of Environmental Pollution and Health, School of Environment, Jinan University, Guangzhou, 510632, China
| | - Han-Jie Ye
- Guangdong Key Laboratory of Environmental Pollution and Health, School of Environment, Jinan University, Guangzhou, 510632, China
| | - Li-Li Wang
- Guangdong Key Laboratory of Environmental Pollution and Health, School of Environment, Jinan University, Guangzhou, 510632, China
| | - Bao-Yan He
- Guangdong Key Laboratory of Environmental Pollution and Health, School of Environment, Jinan University, Guangzhou, 510632, China
| | - Chu Zhou
- Guangdong Key Laboratory of Environmental Pollution and Health, School of Environment, Jinan University, Guangzhou, 510632, China
| | - Eddy Y Zeng
- Guangdong Key Laboratory of Environmental Pollution and Health, School of Environment, Jinan University, Guangzhou, 510632, China; Research Center of Low Carbon Economy for Guangzhou Region, Jinan University, Guangzhou, 510632, China
| |
Collapse
|
115
|
Liu J, Zheng J, Zhang J, Yu D, Wei Y. The performance evaluation and kinetics response of advanced anaerobic digestion for sewage sludge under different SRT during semi-continuous operation. BIORESOURCE TECHNOLOGY 2020; 308:123239. [PMID: 32251856 DOI: 10.1016/j.biortech.2020.123239] [Citation(s) in RCA: 12] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/28/2020] [Revised: 03/20/2020] [Accepted: 03/20/2020] [Indexed: 06/11/2023]
Abstract
Sludge retention time (SRT) is vital for advanced anaerobic digestion (AD) to realize energy self-sufficient. However, the criteria on reasonable SRT has not been fully understood. This study investigated the performance and kinetics response of AD under different SRT in semi-continuous AD with microwave (MW) pretreatment, according to the long-term operation and methane production during one feeding interval. Results showed that modified Gompertz model better described the kinetics than first-order model. At short SRT (15 d), pretreatment coupled with two-stage AD preserved methane production with the high attainable methane potential (B0) of 257.98 mL/g VS and hydrolysis rate constant (khyd) of 0.075 h-1. But the acceptable decrease of methane production rate seems to be unavoidable, which was possibly derived from the evolution of methanogenesis pathway. This study emphasized the importance of improved methane production rate in semi-continuous AD under short SRT rather than methane production potential obtained from batch experiment.
Collapse
Affiliation(s)
- Jibao Liu
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
| | - Jiaxi Zheng
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China
| | - Junya Zhang
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
| | - Dawei Yu
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
| | - Yuansong Wei
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China.
| |
Collapse
|
116
|
Wang G, Gao X, Li Q, Zhao H, Liu Y, Wang XC, Chen R. Redox-based electron exchange capacity of biowaste-derived biochar accelerates syntrophic phenol oxidation for methanogenesis via direct interspecies electron transfer. JOURNAL OF HAZARDOUS MATERIALS 2020; 390:121726. [PMID: 31806442 DOI: 10.1016/j.jhazmat.2019.121726] [Citation(s) in RCA: 50] [Impact Index Per Article: 12.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/29/2019] [Revised: 11/18/2019] [Accepted: 11/19/2019] [Indexed: 06/10/2023]
Abstract
In this study, six different types of biochar (based on two feedstocks and three pyrolytic temperatures) were prepared as individual additives for both syntrophic phenol degradation and methanogenesis promotion. The results showed that for phenol degradation, the addition of biochar (15 g/L) shortened the methanogenic lag time from 15.0 days to 1.1-3.2 days and accelerated the maximum CH4 production rate from 4.0 mL/d to 10.4-13.9 mL/d. Microbial community analysis revealed that the electro-active Geobacter was enriched (from 3.8-7.7% to 11.1-23.1%), depending on the type of biochar that was added. This indicates a potential shift of syntrophic phenol metabolism from a thermodynamically unfavorable pathway with H2 as the interspecies electron transfer mediator to direct interspecies electron transfer (DIET). Integrated analysis of methanogenesis dynamics and the electrochemical properties of biochar showed that compared with electrical conductivity, the electron exchange capacity of biochar was more likely to dominate the DIET process, which was due to the presence of redox-active organic functional groups in biochar. The removal of biochar from the anaerobic system generally prolonged the lag time, revealing the importance of adsorption capacity of biochar to mitigate bio-toxicity of phenol to microbial activity.
Collapse
Affiliation(s)
- Gaojun Wang
- International Science and Technology Cooperation Center for Urban Alternative Water Resources Development, Key Laboratory of Northwest Water Resource, Environment and Ecology, MOE, Engineering Technology Research Center for Wastewater Treatment and Reuse, Shaanxi, Key Laboratory of Environmental Engineering, Shaanxi, Xi'an University of Architecture and Technology, No. 13 Yanta Road, Xi'an 710055, PR China
| | - Xin Gao
- International Science and Technology Cooperation Center for Urban Alternative Water Resources Development, Key Laboratory of Northwest Water Resource, Environment and Ecology, MOE, Engineering Technology Research Center for Wastewater Treatment and Reuse, Shaanxi, Key Laboratory of Environmental Engineering, Shaanxi, Xi'an University of Architecture and Technology, No. 13 Yanta Road, Xi'an 710055, PR China
| | - Qian Li
- International Science and Technology Cooperation Center for Urban Alternative Water Resources Development, Key Laboratory of Northwest Water Resource, Environment and Ecology, MOE, Engineering Technology Research Center for Wastewater Treatment and Reuse, Shaanxi, Key Laboratory of Environmental Engineering, Shaanxi, Xi'an University of Architecture and Technology, No. 13 Yanta Road, Xi'an 710055, PR China.
| | - Hexiang Zhao
- Shaanxi Coal and Chemistry Technology Institute Co., Ltd., Xi'an 710065, PR China
| | - Yanzheng Liu
- International Science and Technology Cooperation Center for Urban Alternative Water Resources Development, Key Laboratory of Northwest Water Resource, Environment and Ecology, MOE, Engineering Technology Research Center for Wastewater Treatment and Reuse, Shaanxi, Key Laboratory of Environmental Engineering, Shaanxi, Xi'an University of Architecture and Technology, No. 13 Yanta Road, Xi'an 710055, PR China
| | - Xiaochang C Wang
- International Science and Technology Cooperation Center for Urban Alternative Water Resources Development, Key Laboratory of Northwest Water Resource, Environment and Ecology, MOE, Engineering Technology Research Center for Wastewater Treatment and Reuse, Shaanxi, Key Laboratory of Environmental Engineering, Shaanxi, Xi'an University of Architecture and Technology, No. 13 Yanta Road, Xi'an 710055, PR China
| | - Rong Chen
- International Science and Technology Cooperation Center for Urban Alternative Water Resources Development, Key Laboratory of Northwest Water Resource, Environment and Ecology, MOE, Engineering Technology Research Center for Wastewater Treatment and Reuse, Shaanxi, Key Laboratory of Environmental Engineering, Shaanxi, Xi'an University of Architecture and Technology, No. 13 Yanta Road, Xi'an 710055, PR China.
| |
Collapse
|
117
|
Zhao Z, Li Y, Zhao Z, Yu Q, Zhang Y. Effects of dissimilatory iron reduction on acetate production from the anaerobic fermentation of waste activated sludge under alkaline conditions. ENVIRONMENTAL RESEARCH 2020; 182:109045. [PMID: 31863944 DOI: 10.1016/j.envres.2019.109045] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/04/2019] [Revised: 11/12/2019] [Accepted: 12/13/2019] [Indexed: 06/10/2023]
Abstract
Anaerobic digestion of waste activated sludge (WAS) to produce acetate has recently attracted growing interest, while the slow hydrolytic acidification of sludge and the consumption of acetate by methanogens both decrease the yield of acetate. In this study, Fe3O4 was added to a WAS anaerobic digester under alkaline conditions (pH = 10). The concentration of short-chain fatty acids (SCFA) during WAS anaerobic fermentation was found to be affected positively by Fe3O4. The maximal SCFA production of the Fe3O4-added digester was 3619.4 mg/L, while the maximal SCFA production in the control was 2899.7 mg/L. The increase of SCFA with Fe3O4 was mainly resulted from the increase in acetate accumulation (accounting for 90%), because Fe3O4 stimulated dissimilatory iron reduction (DIR) that participated in the decomposition of complex organics and the transformation of pronionate and butyrate into acetate. Further investigation showed that each step of hydrolytic-acidification process was promoted except the homoacetogenesis. The activity of enzymes and abundance of microbes relevant to hydrolysis and acidification were in agreement with the above results.
Collapse
Affiliation(s)
- Zisheng Zhao
- Key Laboratory of Industrial Ecology and Environmental Engineering (Dalian University of Technology), Ministry of Education, School of Environmental Science and Technology, Dalian University of Technology, Dalian, 116024, China; School of Water Conservancy and Environment, Zhengzhou University, Kexue Road 100, Zhengzhou, 450001, China
| | - Yang Li
- Key Laboratory of Industrial Ecology and Environmental Engineering (Ministry of Education), School of Food and Environment, Dalian University of Technology, Panjin, 124221, China
| | - Zhiqiang Zhao
- Key Laboratory of Industrial Ecology and Environmental Engineering (Dalian University of Technology), Ministry of Education, School of Environmental Science and Technology, Dalian University of Technology, Dalian, 116024, China
| | - Qilin Yu
- Key Laboratory of Industrial Ecology and Environmental Engineering (Dalian University of Technology), Ministry of Education, School of Environmental Science and Technology, Dalian University of Technology, Dalian, 116024, China
| | - Yaobin Zhang
- Key Laboratory of Industrial Ecology and Environmental Engineering (Dalian University of Technology), Ministry of Education, School of Environmental Science and Technology, Dalian University of Technology, Dalian, 116024, China.
| |
Collapse
|
118
|
Mostafa A, Im S, Song YC, Kang S, Kim DH. Enhanced Anaerobic Digestion of Long Chain Fatty Acid by Adding Magnetite and Carbon Nanotubes. Microorganisms 2020; 8:E333. [PMID: 32120882 PMCID: PMC7143112 DOI: 10.3390/microorganisms8030333] [Citation(s) in RCA: 26] [Impact Index Per Article: 6.5] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/01/2020] [Revised: 02/18/2020] [Accepted: 02/25/2020] [Indexed: 12/30/2022] Open
Abstract
This study investigated the impact of stimulating direct interspecies electron transfer (DIET), by supplementing nano-sized magnetite (nFe3O4, 0.5 g Fe/g VSS) and carbon nanotubes (CNT, 1 g/L), in anaerobic digestion of oleic acid (OA) at various concentrations (0.10 - 4.00 g chemical oxygen demand(COD)/L). Both supplementations could enhance CH4 production, and its beneficial impact increased with increased OA concentration. The biggest improvements of 114% and 165% compared to the control were achieved by nFe3O4 and CNT, respectively, at OA of 4 g COD/L. The enhancement can be attributed to the increased sludge conductivity: 7.1 ± 0.5 (control), 12.5 ± 0.8 (nFe3O4-added), and 15.7 ± 1.1 µS/cm (CNT-supplemented). Dissolved iron concentration, released from nFe3O4, seemed to have a negligible role in improving CH4 production. The excretion of electron shuttles, i.e., humic-like substances and protein-like substances, were found to be stimulated by supplementing nFe3O4 and CNT. Microbial diversity was found to be simplified under DIET-stimulating conditions, whereby five genera accounted for 88% of the total sequences in the control, while more than 82% were represented by only two genera (Methanotrix concilli and Methanosarcina flavescens) by supplementing nFe3O4 and CNT. In addition, the abudance of electro-active bacteria such as Syntrophomonas zehnderi was significantly increased from 17% to around 45%.
Collapse
Affiliation(s)
- Alsayed Mostafa
- Department of Civil Engineering, Inha University, 100 Inha-ro, Nam-gu, Incheon 402-751, Korea; (A.M.); (S.I.)
| | - Seongwon Im
- Department of Civil Engineering, Inha University, 100 Inha-ro, Nam-gu, Incheon 402-751, Korea; (A.M.); (S.I.)
| | - Young-Chae Song
- Department of Environmental Engineering, Korea Maritime and Ocean University, Busan 49112, Korea;
| | - Seoktae Kang
- Department of Civil and Environmental Engineering, KAIST 291 Daehak-ro, Yuseong-gu, Daejeon 34141, Korea;
| | - Dong-Hoon Kim
- Department of Civil Engineering, Inha University, 100 Inha-ro, Nam-gu, Incheon 402-751, Korea; (A.M.); (S.I.)
| |
Collapse
|
119
|
Pan C, Fu X, Lu W, Ye R, Guo H, Wang H, Chusov A. Effects of conductive carbon materials on dry anaerobic digestion of sewage sludge: Process and mechanism. JOURNAL OF HAZARDOUS MATERIALS 2020; 384:121339. [PMID: 31593864 DOI: 10.1016/j.jhazmat.2019.121339] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/05/2019] [Revised: 09/22/2019] [Accepted: 09/26/2019] [Indexed: 06/10/2023]
Abstract
Dry anaerobic digestion of sewage sludge (SS-DAD) is often inhibited by excessive acidification due to low water content and high organic loading. The effects of conductive carbon materials including powdered activated carbon (PAC) and powdered graphite (PG) on SS-DAD under mesophilic condition (35℃) were investigated. The results demonstrated that the addition of PAC increased methane production of SS-DAD. The methane yield of PAC50% reactor (dosage of PAC is 50% of the volatile solids) amounted to 210 mL·gVSadded-1, which is 49% higher than that of control. PAC addition significantly enhanced the biodegradation process, as the reduction rate of total solids (TS) and volatile solids (VS) were increased by 36.4% and 34.1%, respectively, compared to the control. Inhibitory substrate adsorption experiments showed that PAC has significant adsorption (13.6 mg g-1) for VFAs, while PG showed almost no adsorption (0.81 mg g-1). Microbial community structure analysis showed hydrogenotrophic methanogens (Methanobrevibacter and Methanosphaera) were reduced in the PAC50% reactor, while methanogens (Methanobacterium) which can also use formate as electron donor were increased. PAC amendment reshaped the microbial community in the SS-DAD system which may result in shifting of the major electron carrier from hydrogen to formate and increasing electron transfer efficiency of the SS-DAD system.
Collapse
Affiliation(s)
- Chao Pan
- School of Environment, Tsinghua University, Beijing 100084, China
| | - Xindi Fu
- School of Environment, Tsinghua University, Beijing 100084, China
| | - Wenjing Lu
- School of Environment, Tsinghua University, Beijing 100084, China.
| | - Rong Ye
- School of Environment, Tsinghua University, Beijing 100084, China
| | - Hanwen Guo
- School of Environment, Tsinghua University, Beijing 100084, China
| | - Hongtao Wang
- School of Environment, Tsinghua University, Beijing 100084, China
| | - Aleksandr Chusov
- Civil Engineering Institute, Peter the Great St. Petersburg Polytechnic University, Saint-Petersburg, 195251, Russia
| |
Collapse
|
120
|
Yan W, Qian T, Soh YNA, Zhou Y. Micro-level evaluation of organic compounds transformation in anaerobic digestion under feast and famine conditions assisted by iron-based materials - Revealing the true mechanism of AD enhancement. ENVIRONMENT INTERNATIONAL 2020; 135:105362. [PMID: 31830729 DOI: 10.1016/j.envint.2019.105362] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/19/2019] [Revised: 11/21/2019] [Accepted: 11/22/2019] [Indexed: 06/10/2023]
Abstract
Conductive materials have been applied to assist syntrophic metabolism in anaerobic digestion. However, their role in the transformation of organic compounds, particularly recalcitrant compounds, has not been revealed. In this study, iron-based materials - magnetite nanoparticles and Fe2+- were employed to explore their effects on the transformation of different organic matters in anaerobic system. Prompted methane production rates and quantity in iron-based materials groups were found due to the improved solubilization of organic particles, enhanced degradation of recalcitrant compounds, and maintained microbial activity under substrate-limited conditions. Specifically, the proportion of the reducing functional groups (C-C/H or CC) and O/C ratio were always significantly lower in iron-based materials supplemented groups (Fe groups) compared to Control group, despite hydrolysis was greatly enhanced in Fe groups. The greater dehydrogenation oxidation was confirmed in the presence of iron-based materials. The remaining humic-like substances (HS), a typical type of recalcitrant compound, was about 2.5 times higher in Control group (221.2 ± 5.3 mg/L-C) compared to Fe groups after 30 days degradation. By tracking the aromaticity of HS and individual compounds at molecular level, this study reveals that iron-based materials were more effective in stimulating the degradation of aliphatic moieties than the aromatic moieties of recalcitrant compounds. When readily biodegradable substrates were limited, Fe groups continued methane generation by using recalcitrant compounds (e.g. thiethylperazine and fluvoxamino acid) as carbon source, and the microbial activity was maintained according to higher relative abundance of protonated nitrogen and continuous methanogenesis activity at starvation phase.
Collapse
Affiliation(s)
- Wangwang Yan
- School of Civil and Environmental Engineering, Nanyang Technological University, 639798 Singapore; Advanced Environmental Biotechnology Centre, Nanyang Environment and Water Research Institute, Nanyang Technological University, 637141 Singapore
| | - Tingting Qian
- Advanced Environmental Biotechnology Centre, Nanyang Environment and Water Research Institute, Nanyang Technological University, 637141 Singapore
| | - Yan Ni Annie Soh
- Advanced Environmental Biotechnology Centre, Nanyang Environment and Water Research Institute, Nanyang Technological University, 637141 Singapore
| | - Yan Zhou
- School of Civil and Environmental Engineering, Nanyang Technological University, 639798 Singapore; Advanced Environmental Biotechnology Centre, Nanyang Environment and Water Research Institute, Nanyang Technological University, 637141 Singapore.
| |
Collapse
|
121
|
Abstract
The microbiome residing in anaerobic digesters drives the anaerobic digestion (AD) process to convert various feedstocks to biogas as a renewable source of energy. This microbiome has been investigated in numerous studies in the last century. The early studies used cultivation-based methods and analysis to identify the four guilds (or functional groups) of microorganisms. Molecular biology techniques overcame the limitations of cultivation-based methods and allowed the identification of unculturable microorganisms, revealing the high diversity of microorganisms involved in AD. In the past decade, omics technologies, including metataxonomics, metagenomics, metatranscriptomics, metaproteomics, and metametabolomics, have been or start to be used in comprehensive analysis and studies of biogas-producing microbiomes. In this chapter, we reviewed the utilities and limitations of these analysis methods, techniques, and technologies when they were used in studies of biogas-producing microbiomes, as well as the new information on diversity, composition, metabolism, and syntrophic interactions of biogas-producing microbiomes. We also discussed the current knowledge gaps and the research needed to further improve AD efficiency and stability.
Collapse
|
122
|
Ren G, Chen P, Yu J, Liu J, Ye J, Zhou S. Recyclable magnetite-enhanced electromethanogenesis for biomethane production from wastewater. WATER RESEARCH 2019; 166:115095. [PMID: 31542548 DOI: 10.1016/j.watres.2019.115095] [Citation(s) in RCA: 8] [Impact Index Per Article: 1.6] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/07/2019] [Revised: 08/20/2019] [Accepted: 09/14/2019] [Indexed: 06/10/2023]
Abstract
Improving the yield and methane content of biogas is of great concern for wastewater treatment by anaerobic digestion. Herein we developed a nanomagnetite-enhanced electromethanogenesis (EMnano) process for the first time, the sustainable utilization of which improved the biomethane production rate from dairy wastewater. The maximum CH4 production rate in the EMnano process is 2.3 ± 0.3-fold higher than it is in the conventional methanogenesis (CM) process, and it is accompanied by an almost delay-free start-up. The technical-economic evaluation revealed that an 82.1 ± 5.0% greater net benefit was obtained in the third generation of the EMnano process compared with the CM process. The improved methanogenesis was attributed to the formation of dense planktonic cell co-aggregates that are triggered by nanomagnetite, which facilitated the interspecies electron exchange during acetoclastic methanogenesis. Simultaneously, a cathode biofilm with high viability and catalytic activity was also formed in the EMnano process that decreased the biofilm resistance and facilitated the electron transfer during electromethanogenesis. This study is a worthwhile attempt to combine recyclable conductive materials with an electromethanogenesis process for wastewater treatment, and it effectively achieves energy recovery with high stability and cost-effectiveness.
Collapse
Affiliation(s)
- Guoping Ren
- Fujian Provincial Key Laboratory of Soil Environmental Health and Regulation, College of Resources and Environment, Fujian Agriculture and Forestry University, Fuzhou, 350002, China
| | - Piao Chen
- Fujian Provincial Key Laboratory of Soil Environmental Health and Regulation, College of Resources and Environment, Fujian Agriculture and Forestry University, Fuzhou, 350002, China
| | - Jing Yu
- Fujian Provincial Key Laboratory of Soil Environmental Health and Regulation, College of Resources and Environment, Fujian Agriculture and Forestry University, Fuzhou, 350002, China
| | - Jianbo Liu
- College of Environmental Science and Engineering, Hunan University, Changsha, 410082, China
| | - Jie Ye
- Fujian Provincial Key Laboratory of Soil Environmental Health and Regulation, College of Resources and Environment, Fujian Agriculture and Forestry University, Fuzhou, 350002, China.
| | - Shungui Zhou
- Fujian Provincial Key Laboratory of Soil Environmental Health and Regulation, College of Resources and Environment, Fujian Agriculture and Forestry University, Fuzhou, 350002, China.
| |
Collapse
|
123
|
Wang C, Wang C, Jin L, Lu D, Chen H, Zhu W, Xu X, Zhu L. Response of syntrophic aggregates to the magnetite loss in continuous anaerobic bioreactor. WATER RESEARCH 2019; 164:114925. [PMID: 31382155 DOI: 10.1016/j.watres.2019.114925] [Citation(s) in RCA: 28] [Impact Index Per Article: 5.6] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/18/2019] [Revised: 07/25/2019] [Accepted: 07/27/2019] [Indexed: 06/10/2023]
Abstract
Increasing studies indicate that magnetite addition could accelerate the methanogenesis via enhancing direct interspecies electron transfer (DIET)-based anaerobic syntrophy. However, magnetite is found to run off in continuous bioreactor, and the effect of magnetite loss on syntrophic aggregates is still underreported. In this study, two EGSB reactors (RM with magnetite-enhanced sludge, and RB as a control) were operated to investigate the magnetite behavior in continuous bioreactor and the corresponding response of syntrophic aggregates. Results showed that magnetite in RM was washed out gradually in form of iron ions, and a slightly acidic niche was supposed to be the major cause. Nevertheless, candidate DIET partners like Geobacter and Methanothrix along with syntrophic volatile fatty acids (VFAs)-degrading microbes were enriched in RM. In addition, the improved redox activity of extracellular polymeric substance (EPS), higher sludge conductivity and electron transport activity suggested that the DIET ability of sludge in RM was still enhanced, which favors the syntrophic metabolism of VFAs. Interestingly, syntrophic partners were loosely combined under the condition of high organic loading rate (OLR) in the presence of magnetite, but with gradual loss of magnetite, dense and active anaerobic granular sludge (AGS) was formed in RM. This study provided a comprehensive understanding of magnetite behavior in continuous bioreactor and the response of syntrophic aggregates. The robust DIET-based syntrophy after magnetite adding could favor the high-efficient anaerobic wastewater treatment and resource recovery in the future, and further investigations on magnetite resupply and the mechanism of magnetite enriching candidate DIET partners are recommended.
Collapse
Affiliation(s)
- Caiqin Wang
- Institute of Environment Pollution Control and Treatment, Zhejiang University, Hangzhou, 310058, China
| | - Chen Wang
- Institute of Environment Pollution Control and Treatment, Zhejiang University, Hangzhou, 310058, China
| | - Luonan Jin
- Hangzhou Urban & Rural Construction Design Institute Co., LTD, Hangzhou, 310004, China
| | - Donghui Lu
- Institute of Environment Pollution Control and Treatment, Zhejiang University, Hangzhou, 310058, China
| | - Hui Chen
- Institute of Environment Pollution Control and Treatment, Zhejiang University, Hangzhou, 310058, China
| | - Weitang Zhu
- Environmental Protection Bureau of Changxing County, Huzhou, 313100, China
| | - Xiangyang Xu
- Institute of Environment Pollution Control and Treatment, Zhejiang University, Hangzhou, 310058, China; Zhejiang Province Key Laboratory for Water Pollution Control and Environmental Safety, Hangzhou, 310058, China; Zhejiang Provincial Engineering Laboratory of Water Pollution Control, 388 Yuhangtang Road, Hangzhou, 310058, China
| | - Liang Zhu
- Institute of Environment Pollution Control and Treatment, Zhejiang University, Hangzhou, 310058, China; Zhejiang Province Key Laboratory for Water Pollution Control and Environmental Safety, Hangzhou, 310058, China; Zhejiang Provincial Engineering Laboratory of Water Pollution Control, 388 Yuhangtang Road, Hangzhou, 310058, China.
| |
Collapse
|
124
|
Zhang J, Lu T, Wang Z, Wang Y, Zhong H, Shen P, Wei Y. Effects of magnetite on anaerobic digestion of swine manure: Attention to methane production and fate of antibiotic resistance genes. BIORESOURCE TECHNOLOGY 2019; 291:121847. [PMID: 31357044 DOI: 10.1016/j.biortech.2019.121847] [Citation(s) in RCA: 34] [Impact Index Per Article: 6.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/10/2019] [Revised: 07/16/2019] [Accepted: 07/18/2019] [Indexed: 06/10/2023]
Abstract
Effects of magnetite on methane production and fate of antibiotic resistance genes (ARGs) during anaerobic digestion (AD) of swine manure were investigated. Results showed that methane production was increased by maximum 16.1%, and magnetite could enhance the acetoclastic methanogenesis not hydrogenotrophic methanogenesis reflected by the functional gene quantification and microbial community analysis. The propionate degradation rate was improved, and it was syntrophic oxidized into H+/e-/CO2 for direct interspecies electron transfer (DIET) and acetate, where DIET was further enhanced by magnetite and the acetate was transformed into methane through syntrophic acetate oxidation (SAO) pathway. Magnetite mainly influenced the ARGs at the interim period of AD, where ARGs especially ermF were significantly enriched. Magnetite did not influence the total ARGs abundance at the end, although the tetM was enriched and mefA was reduced finally. Statistical analysis indicated that magnetite influenced the ARGs fate mainly through the changes of microbial community.
Collapse
Affiliation(s)
- Junya Zhang
- State Key Joint Laboratory of Environmental Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China
| | - Tiedong Lu
- College of Life Science and Technology, Guangxi University, Nanning 530005, Guangxi, China
| | - Ziyue Wang
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin 300401, China
| | - Yawei Wang
- State Key Joint Laboratory of Environmental Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China
| | - Hui Zhong
- State Key Joint Laboratory of Environmental Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China
| | - Peihong Shen
- College of Life Science and Technology, Guangxi University, Nanning 530005, Guangxi, China
| | - Yuansong Wei
- State Key Joint Laboratory of Environmental Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China.
| |
Collapse
|
125
|
Pan J, Ma J, Zhai L, Luo T, Mei Z, Liu H. Achievements of biochar application for enhanced anaerobic digestion: A review. BIORESOURCE TECHNOLOGY 2019; 292:122058. [PMID: 31488335 DOI: 10.1016/j.biortech.2019.122058] [Citation(s) in RCA: 74] [Impact Index Per Article: 14.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/30/2019] [Revised: 08/21/2019] [Accepted: 08/23/2019] [Indexed: 06/10/2023]
Abstract
Anaerobic digestion (AD) and pyrolysis are two promising technologies used worldwide for waste biomass treatment. Interests on intensification techniques of AD has been increasing to obtain sufficient and sustainable methane production with stable digester performance. For instance, considerable attention has been devoted to the coupling of AD with biochar, which is produced by biomass thermochemical conversion. This manuscript presents a comprehensive review about recent achievements in enhancing AD efficiency with the utilization of biochar. The key roles of biochar include enhancing and equilibrating hydrolysis, acidogenesis-acetogenesis, and methanogenesis, as well as alleviating inhibitor stress were summarized. Biochar can promote biomethane process mainly by serving as a provision for bioelectrical connections between fermentative bacteria and methanogens, a support for microbial colonies, and a reinforcer for buffer capacity. Through an overview of the early applications, this paper aims to pinpoint the potential mechanism and future explorative directions of biochar enhancing AD performance.
Collapse
Affiliation(s)
- Junting Pan
- Key Laboratory of Non-point Source Pollution of Ministry of Agricultural and Rural Affairs, Institute of Agricultural Resources and Regional Planning, Chinese Academy of Agricultural Sciences, 100081 Beijing, PR China
| | - Junyi Ma
- Key Laboratory of Non-point Source Pollution of Ministry of Agricultural and Rural Affairs, Institute of Agricultural Resources and Regional Planning, Chinese Academy of Agricultural Sciences, 100081 Beijing, PR China; College of Mechanic and Electronic Engineering, Northwest A&F University, 712100 Yangling, PR China
| | - Limei Zhai
- Key Laboratory of Non-point Source Pollution of Ministry of Agricultural and Rural Affairs, Institute of Agricultural Resources and Regional Planning, Chinese Academy of Agricultural Sciences, 100081 Beijing, PR China
| | - Tao Luo
- Biogas Institute of Ministry of Agriculture (BIOMA), 610041 Chengdu, Sichuan, PR China
| | - Zili Mei
- Biogas Institute of Ministry of Agriculture (BIOMA), 610041 Chengdu, Sichuan, PR China
| | - Hongbin Liu
- Key Laboratory of Non-point Source Pollution of Ministry of Agricultural and Rural Affairs, Institute of Agricultural Resources and Regional Planning, Chinese Academy of Agricultural Sciences, 100081 Beijing, PR China.
| |
Collapse
|
126
|
Yan W, Zhou Y. The presence of ferrihydrite enhances greenhouse gas-methane emission in the environment. THE SCIENCE OF THE TOTAL ENVIRONMENT 2019; 688:462-469. [PMID: 31252246 DOI: 10.1016/j.scitotenv.2019.06.234] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.2] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/06/2019] [Revised: 06/10/2019] [Accepted: 06/15/2019] [Indexed: 06/09/2023]
Abstract
Aquatic system is the major source of atmospheric methane. This study explored the influences of ferrihydrite, which is widely existed in natural aquatic system, on methane emission. Results showed that the presence of ferrihydrite led to 26.4% more methane emission. By tracking the transformation of organic compounds, it is revealed that the enhanced methane emission was attributed to greater hydrolysis and degradation of refractory compounds. More specifically, the remaining humic-like substances (HS) in ferrihydrite group (46.4 mg/L-C) were only half of that in control group (80.1 g/L-C) after 30-day incubation. The X-ray photoelectron spectroscopy spectrum confirmed the more active oxidation of organics occurred in ferrihydrite group. It was also found that ferrihydrite aided in sustaining microbial activity at stationary and starvation phases. Further study on microbial communities found that ferrihydrite promoted the enrichment of both functional and electroactive genera. This study provides insights into the greenhouse gas emission in natural environment.
Collapse
Affiliation(s)
- Wangwang Yan
- Advanced Environmental Biotechnology Centre, Nanyang Environment and Water Research Institute, Nanyang Technological University, 637141 Singapore, Singapore
| | - Yan Zhou
- Advanced Environmental Biotechnology Centre, Nanyang Environment and Water Research Institute, Nanyang Technological University, 637141 Singapore, Singapore; School of Civil and Environmental Engineering, Nanyang Technological University, 639798 Singapore, Singapore.
| |
Collapse
|
127
|
Jin Z, Zhao Z, Zhang Y. Potential of direct interspecies electron transfer in synergetic enhancement of methanogenesis and sulfate removal in an up-flow anaerobic sludge blanket reactor with magnetite. THE SCIENCE OF THE TOTAL ENVIRONMENT 2019; 677:299-306. [PMID: 31059873 DOI: 10.1016/j.scitotenv.2019.04.372] [Citation(s) in RCA: 16] [Impact Index Per Article: 3.2] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/19/2019] [Revised: 04/24/2019] [Accepted: 04/25/2019] [Indexed: 06/09/2023]
Abstract
Anaerobic digestion (AD) has been widely applied in the treatment of industrial wastewater containing oxidized sulfur compounds. However, the production of hydrogen sulfide usually limits the syntrophic metabolism proceeded by interspecies hydrogen transfer (IHT), due to its corrosive and toxic properties. The current study was in an attempt to establish direct interspecies electron transfer (DIET) to resist the toxic inhibition from hydrogen sulfide and keep syntrophic metabolism stable. The results showed that, in the presence of magnetite, the methane production was improved about 3-10 folds at each ratio of COD/SO42-, while the enhancement of methanogenesis had almost no negative effect on sulfate reduction. With magnetite, the sludge conductance increased about 3 folds, but the concentration of c-type cytochromes decreased, suggesting that the potential DIET via both electrically conductive pili and outer surface c-type cytochromes was established. Microbial community revealed that, Veillonella species, the Fe(III)-reducing genus capable of reducing sulfate to hydrogen sulfide, were specially enriched with magnetite. Together with the relatively higher abundance of Methanothrix and Methanosarcina species, the novel DIET between Fe(III)/sulfate-reducing genus and methanogens was inferred to be responsible for the synergetic enhancement of methanogenesis and sulfate removal.
Collapse
Affiliation(s)
- Zhen Jin
- Key Laboratory of Industrial Ecology and Environmental Engineering, Ministry of Education, School of Environmental Science and Technology, Dalian University of Technology, Dalian 116024, China
| | - Zhiqiang Zhao
- Key Laboratory of Industrial Ecology and Environmental Engineering, Ministry of Education, School of Environmental Science and Technology, Dalian University of Technology, Dalian 116024, China.
| | - Yaobin Zhang
- Key Laboratory of Industrial Ecology and Environmental Engineering, Ministry of Education, School of Environmental Science and Technology, Dalian University of Technology, Dalian 116024, China
| |
Collapse
|
128
|
A critical review: emerging bioeconomy and waste-to-energy technologies for sustainable municipal solid waste management. ACTA ACUST UNITED AC 2019. [DOI: 10.1007/s42768-019-00013-z] [Citation(s) in RCA: 59] [Impact Index Per Article: 11.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/16/2022]
|
129
|
Dyksma S, Gallert C. Candidatus Syntrophosphaera thermopropionivorans: a novel player in syntrophic propionate oxidation during anaerobic digestion. ENVIRONMENTAL MICROBIOLOGY REPORTS 2019; 11:558-570. [PMID: 30985964 DOI: 10.1111/1758-2229.12759] [Citation(s) in RCA: 46] [Impact Index Per Article: 9.2] [Reference Citation Analysis] [Abstract] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/02/2018] [Accepted: 04/12/2019] [Indexed: 06/09/2023]
Abstract
Propionate is an important intermediate in the anaerobic mineralization of organic matter. In methanogenic environments, its degradation relies on syntrophic associations between syntrophic propionate-oxidizing bacteria (SPOB) and Archaea. However, only 10 isolated species have been identified as SPOB so far. We report syntrophic propionate oxidation in thermophilic enrichments of Candidatus Syntrophosphaera thermopropionivorans, a novel representative of the candidate phylum Cloacimonetes. In enrichment culture, methane was produced from propionate, while Ca. S. thermopropionivorans contributed 63% to total bacterial cells. The draft genome of Ca. S. thermopropionivorans encodes genes for propionate oxidation via methymalonyl-CoA. Phylogenetically, Ca. S. thermopropionivorans affiliates with the uncultured Cloacimonadaceae W5 and is more distantly related (86.4% 16S rRNA gene identity) to Ca. Cloacimonas acidaminovorans. Although Ca. S. thermopropionivorans was enriched from a thermophilic biogas reactor, Ca. Syntrophosphaera was in particular associated with mesophilic anaerobic digestion systems. 16S rRNA gene amplicon sequencng and a novel genus-specific quantitative PCR assay consistently identified Ca. Syntrophosphaera/Cloacimonadaceae W5 in 9 of 12 tested full-scale biogas reactors thereby outnumbering other SPOB such as Pelotomaculum, Smithella and Syntrophobacter. Taken together the ubiquity and abundance of Ca. Syntrophosphaera, those SPOB might be key players for syntrophic propionate metabolism that have been overlooked before.
Collapse
Affiliation(s)
- Stefan Dyksma
- Faculty of Technology, Microbiology - Biotechnology, University of Applied Sciences Emden/Leer, Emden, Germany
| | - Claudia Gallert
- Faculty of Technology, Microbiology - Biotechnology, University of Applied Sciences Emden/Leer, Emden, Germany
| |
Collapse
|
130
|
Wang Z, Yun S, Xu H, Wang C, Zhang Y, Chen J, Jia B. Mesophilic anaerobic co-digestion of acorn slag waste with dairy manure in a batch digester: Focusing on mixing ratios and bio-based carbon accelerants. BIORESOURCE TECHNOLOGY 2019; 286:121394. [PMID: 31078077 DOI: 10.1016/j.biortech.2019.121394] [Citation(s) in RCA: 11] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/04/2019] [Revised: 04/25/2019] [Accepted: 04/26/2019] [Indexed: 06/09/2023]
Abstract
Co-digestion of acorn slag waste (ASW) and dairy manure (DM) with two bio-based carbon (BC) accelerants are investigated via batch experiments under mesophilic condition. With the favorable synergistic effect of the mixed substrate and BC accelerant, the anaerobic digestion (AD) systems assembled with aloe peel-derived BC (2.16 g/L) show significantly improved methanogenesis on the basis of the optimum wet weight ratio of ASW to DM (1:3). The cumulative biogas yield is 580.9 mL/g VS, and the total chemical oxygen demand reduction is 79.37%. These results are higher than those of the AD systems without carbon-based accelerants. The feasibility of digestate utilization is evaluated by thermal and fertilizer analyses, which manifest outstanding stability and excellent fertility (6.93%-7.40%) of digestate in co-digestion systems. A general strategy for understanding the enhanced methanogenesis pathways, induced by BC in AD systems, is demonstrated. These important findings open an innovative opportunity for developing carbon-based accelerants in anaerobic co-digestion.
Collapse
Affiliation(s)
- Ziqi Wang
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Sining Yun
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China.
| | - Hongfei Xu
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Chen Wang
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Yangliang Zhang
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Jiageng Chen
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Bo Jia
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| |
Collapse
|
131
|
Zhang W, Dong B, Dai X. Mechanism analysis to improve sludge dewaterability during anaerobic digestion based on moisture distribution. CHEMOSPHERE 2019; 227:247-255. [PMID: 30991199 DOI: 10.1016/j.chemosphere.2019.03.150] [Citation(s) in RCA: 14] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/05/2018] [Revised: 03/12/2019] [Accepted: 03/23/2019] [Indexed: 06/09/2023]
Abstract
Previous studies have demonstrated that anaerobic digestion (AD) enhances sludge dewaterability. However, the mechanism of AD influence on digested sludge dewaterability is still not well understood. In this study, moisture distribution and bond energy were used to evaluate the influence of AD on sludge dewaterability. The change from free moisture (FM) to mechanically bound moisture (MBM) was analysed, along with degradation of organic fractions in extracellular polymeric substances (EPSs) of the sludge during AD. Results indicated that the AD process, with a 41.9% reduction in volatile solids (VS) and cumulative methane production of 283.2 mL/g VS, improved sludge dewaterability by disintegrating macro-molecular organic matter into micro-molecular matter. MBM reduction reached 7% in 40 days. Correlations between FM/MBM and extracellular protein (extra-PN) were significant (R = -0.861, p < 0.01; R = 0.869, p < 0.01). Therefore, it can be concluded that the degradation of protein in the extra-microcolony polymer (EMPS) layer results in the destruction of the bond between organic fractions and moisture. As a result, the release of mechanically bound moisture is accelerated. In addition, the moisture content, as well as the extra-PN, continued to vary when AD entered the stabilisation stage, that is, the destruction of protein in EMPS stimulated mechanically bound moisture release during AD. The results of this work provide a better understanding on the effect of AD on sludge reduction.
Collapse
Affiliation(s)
- Wei Zhang
- School of Environmental Science and Engineering. Tongji University, Shanghai, 200092, PR China
| | - Bin Dong
- School of Environmental Science and Engineering. Tongji University, Shanghai, 200092, PR China; Shanghai Institute of Pollution Control and Ecological Security, Shanghai, 200092, PR China.
| | - Xiaohu Dai
- School of Environmental Science and Engineering. Tongji University, Shanghai, 200092, PR China; Shanghai Institute of Pollution Control and Ecological Security, Shanghai, 200092, PR China.
| |
Collapse
|
132
|
Yin C, Shen Y, Yuan R, Zhu N, Yuan H, Lou Z. Sludge-based biochar-assisted thermophilic anaerobic digestion of waste-activated sludge in microbial electrolysis cell for methane production. BIORESOURCE TECHNOLOGY 2019; 284:315-324. [PMID: 30952059 DOI: 10.1016/j.biortech.2019.03.146] [Citation(s) in RCA: 49] [Impact Index Per Article: 9.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/05/2019] [Revised: 03/28/2019] [Accepted: 03/29/2019] [Indexed: 06/09/2023]
Abstract
The development of microbial electrolysis cells (MECs) for methane production from waste activated sludge (WAS) is arrested due to the limited methane yield and fragile system stability. This study proposed a strategy to accelerate and stabilize MEC via 1.0 g/g DM (dry matter) sludge-based biochar (BC). The results showed that BC clearly accelerated methane production by 24.7% and enhanced VS removal efficiency by 17.9%, compared to control group. Variations of SCOD, proteins, carbohydrates and VFAs indicated biochar promoted hydrolysis and acidogenesis process. Cyclic voltammetry (CV) curves and coulombic efficiency (CE) suggested organic matters degradation and electron generation on anode were enhanced with supplement of biochar. Microbial community analyses revealed that biochar addition could both promote DIET through substituting exoelectrogen (e.g., Thermincola) on anode and enrich hydrogenotrophic methanogens (e.g., Methanothermobacter) on cathode, which is beneficial to development of MEC as to methane recovery from organic matters.
Collapse
Affiliation(s)
- Changkai Yin
- School of Environmental Science and Engineering, Shanghai Jiao Tong University, Shanghai 200240, PR China
| | - Yanwen Shen
- School of Environmental Science and Engineering, Shanghai Jiao Tong University, Shanghai 200240, PR China
| | - Rongxue Yuan
- School of Environmental Science and Engineering, Shanghai Jiao Tong University, Shanghai 200240, PR China
| | - Nanwen Zhu
- School of Environmental Science and Engineering, Shanghai Jiao Tong University, Shanghai 200240, PR China; Shanghai Institute of Pollution Control and Ecological Security, Shanghai 200092, PR China.
| | - Haiping Yuan
- School of Environmental Science and Engineering, Shanghai Jiao Tong University, Shanghai 200240, PR China
| | - Ziyang Lou
- School of Environmental Science and Engineering, Shanghai Jiao Tong University, Shanghai 200240, PR China
| |
Collapse
|
133
|
Lee J, Koo T, Yulisa A, Hwang S. Magnetite as an enhancer in methanogenic degradation of volatile fatty acids under ammonia-stressed condition. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2019; 241:418-426. [PMID: 31035235 DOI: 10.1016/j.jenvman.2019.04.038] [Citation(s) in RCA: 76] [Impact Index Per Article: 15.2] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/01/2018] [Revised: 03/28/2019] [Accepted: 04/13/2019] [Indexed: 05/23/2023]
Abstract
Anaerobic batch tests with a 22 full-factorial design of ammonia (1.5, 6.5 g N/L) and magnetite concentrations (0, 20 mmol/L) were conducted separately for methanogenic degradation of acetate, propionate, and butyrate (volatile fatty acids (VFAs)) to 1) quantify the effect of magnetite as an enhancer in methanogenic degradation of each of the VFAs in conditions without ammonia stress (1.5 g N/L) and with ammonia stress (6.5 g N/L), and 2) identify methanogenic consortia that are related to such enhancement. Among the three VFAs, methanogenic degradation of propionate was the least feasible (57% lower specific methanogenic activity RCH4 and three times longer lag time λ than acetate degradation). At low ammonia concentration, only propionate showed improvement in RCH4 (46%) with supplementation of magnetite. In the ammonia-stressed condition without magnetite, RCH4 decreased by 38-58% and λ increased 2.2-8.8 times for all VFAs; magnetite supplementation significantly alleviated these effects. These results demonstrate that magnetite supplementation effectively increases methanogenic degradation of the VFAs even under ammonia-stressed conditions. 16S metagenomic sequencing revealed that distinctive methanogenic consortia were active in the different combinations of substrate, ammonia and magnetite. Alkaliphilus, Hyphomonadaceae SWB02 and Clostridia DTU014, Clostridia D8A-2, Christensenellaceae R-7 group and Rikenellaceae DMER64 were identified as potential syntrophic bacteria that can establish magnetite-mediated direct electron transfer with methanogens (Methanosaeta concilii, Methanosaeta harundinacea, Methanolinea tarda, Methanoculleus bourgensis and Methanosarcina spp.) during methanogenic degradation of VFAs. The results may be useful as a reference to develop effective strategies using magnetite supplementation to remediate anaerobic digestion processes that have been afflicted by VFA accumulation and ammonia inhibition.
Collapse
Affiliation(s)
- Joonyeob Lee
- Division of Environmental Science and Engineering, Pohang University of Science and Technology (POSTECH), Pohang, Gyeongbuk, Republic of Korea
| | - Taewoan Koo
- Division of Environmental Science and Engineering, Pohang University of Science and Technology (POSTECH), Pohang, Gyeongbuk, Republic of Korea
| | - Arma Yulisa
- Division of Environmental Science and Engineering, Pohang University of Science and Technology (POSTECH), Pohang, Gyeongbuk, Republic of Korea
| | - Seokhwan Hwang
- Division of Environmental Science and Engineering, Pohang University of Science and Technology (POSTECH), Pohang, Gyeongbuk, Republic of Korea.
| |
Collapse
|
134
|
Han F, Yun S, Zhang C, Xu H, Wang Z. Steel slag as accelerant in anaerobic digestion for nonhazardous treatment and digestate fertilizer utilization. BIORESOURCE TECHNOLOGY 2019; 282:331-338. [PMID: 30877914 DOI: 10.1016/j.biortech.2019.03.029] [Citation(s) in RCA: 11] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/26/2019] [Revised: 03/05/2019] [Accepted: 03/06/2019] [Indexed: 06/09/2023]
Abstract
Accelerants can effectively enhance the performance of anaerobic digestion (AD) system. The effects of optimized steel slag as accelerant in the AD of cow manure and the fertility utilization of the digestate were investigated. Results show that all steel slags collected from different iron and steel companies (slag-1, slag-2, and slag-3) positively affect AD performance in terms of enhancing the biogas yield, methane yield, and chemical oxygen demand (COD) degradation rate. The cumulative biogas yield, methane yield, and COD degradation rate of slag-2 are 507.29 mL/g VS, 274.70 mL/g VS, and 58.62%, respectively. Thermal analysis reveals that the digestate with steel slag has excellent thermal stability and potential application as a component of nitrogen, phosphorus, and potassium organic compound fertilizers. The use of different steel slags as accelerants in the AD system provides a safe and economical avenue to realize the resource utilization and harmless treatment of waste resource.
Collapse
Affiliation(s)
- Feng Han
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Sining Yun
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China.
| | - Chen Zhang
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Hongfei Xu
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| | - Ziqi Wang
- Functional Materials Laboratory (FML), School of Materials Science and Engineering, Xi'an University of Architecture and Technology, Xi'an, Shaanxi 710055, China
| |
Collapse
|
135
|
Van Steendam C, Smets I, Skerlos S, Raskin L. Improving anaerobic digestion via direct interspecies electron transfer requires development of suitable characterization methods. Curr Opin Biotechnol 2019; 57:183-190. [DOI: 10.1016/j.copbio.2019.03.018] [Citation(s) in RCA: 60] [Impact Index Per Article: 12.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/04/2019] [Revised: 03/27/2019] [Accepted: 03/27/2019] [Indexed: 02/06/2023]
|
136
|
Xia X, Zhang J, Song T, Lu Y. Stimulation of Smithella-dominating propionate oxidation in a sediment enrichment by magnetite and carbon nanotubes. ENVIRONMENTAL MICROBIOLOGY REPORTS 2019; 11:236-248. [PMID: 30790444 DOI: 10.1111/1758-2229.12737] [Citation(s) in RCA: 31] [Impact Index Per Article: 6.2] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/31/2018] [Accepted: 01/29/2019] [Indexed: 06/09/2023]
Abstract
Recent studies have shown that application of conductive materials including magnetite and carbon nanotubes (CNTs) can promote the methanogenic decomposition of short-chain fatty acids and even more complex organic matter in anaerobic digesters and natural habitats. The linkage to microbial identity and the mechanisms, however, remain poorly understood. Here, we evaluate the effects of nanoscale magnetite (nanoFe3 O4 ) and multiwalled CNTs on the syntrophic oxidation of propionate in an enrichment obtained from lake sediment. The microbial populations were composed mainly of Smithella, Syntrophomonas, Methanosaeta, Methanosarcina and Methanoregula. In addition to acetate, butyrate was transiently accumulated indicating that propionate was oxidized by Smithella via the dismutation pathway and part of the leaked butyrate was oxidized by Syntrophomonas. Propionate oxidation and CH4 production were significantly accelerated in the presence of nanoFe3 O4 and CNTs. While propionate oxidation was suppressed upon H2 application and suspended completely upon formate application in the control, this suppressive effect was substantially compromised in the presence of nanoFe3 O4 and CNTs. The tests on hydrogenotrophic methanogenesis of a pure culture methanogen and of the enrichment culture without propionate showed negative effect by both materials. The positive effect of nanoFe3 O4 disappeared when it was insulated by surface-coating with silica. Observations made with fluorescence in situ hybridization and scanning electron microscope indicated the extensive formation of microbial cell-conductive material mixture aggregates. Our results suggest that direct interspecies electron transfer is likely activated by the conductive materials and operates in concert with H2 /formate-dependent electron transfer for syntrophic propionate oxidation in the sediment enrichment.
Collapse
Affiliation(s)
- Xingxuan Xia
- Urban and Environmental Sciences, Peking University, Beijing, 100871, China
| | - Jianchao Zhang
- Institute of Surface-Earth System Science, Tianjin University, 300072, China
| | - Tianze Song
- Urban and Environmental Sciences, Peking University, Beijing, 100871, China
| | - Yahai Lu
- Urban and Environmental Sciences, Peking University, Beijing, 100871, China
| |
Collapse
|
137
|
Zhang J, Wang Z, Lu T, Liu J, Wang Y, Shen P, Wei Y. Response and mechanisms of the performance and fate of antibiotic resistance genes to nano-magnetite during anaerobic digestion of swine manure. JOURNAL OF HAZARDOUS MATERIALS 2019; 366:192-201. [PMID: 30528589 DOI: 10.1016/j.jhazmat.2018.11.106] [Citation(s) in RCA: 58] [Impact Index Per Article: 11.6] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/18/2018] [Revised: 11/07/2018] [Accepted: 11/28/2018] [Indexed: 06/09/2023]
Abstract
Swine manure is an important reservoir of environmental antibiotic resistance genes (ARGs), and anaerobic digestion (AD) is a commonly used method for swine manure treatment. In this study, the optimized dosage of nano-magnetite to enhance methane production was figured out, the changes of the fate of ARGs response to nano-magnetite were investigated, and the microbial mechanisms were deciphered through the microbial community analysis and key functional genes quantification. Results showed that nano-magnetite could improve the methane production by maximum 6.0%, the maximum daily methane production could be increased by 47.8%, and the AD time could be shortened by above 20.0% at the addition of 75 mmol. The improved performance could be associated with the enhancement of direct interspecies electron transfer (DIET) and the inhibition release due to the formation of Fe-S precipitation not the nutrition elements role of nano-magnetite, and nano-magnetite did not significantly influence the dynamics of microbial community. Nano-magnetite could enhance the methanogenesis instead of the acetogenesis reflected by the functional genes analysis, and the limited effects of nano-magnetite on the fate of ARGs could be associated with its limited influence on the microbial community which determined the fate of ARGs during AD of swine manure.
Collapse
Affiliation(s)
- Junya Zhang
- State Key Joint Laboratory of Environmental Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China.
| | - Ziyue Wang
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin 300401, China
| | - Tiedong Lu
- College of Life Science and Technology, Guangxi University, Nanning 530005, Guangxi, China
| | - Jibao Liu
- State Key Joint Laboratory of Environmental Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China
| | - Yawei Wang
- State Key Joint Laboratory of Environmental Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China
| | - Peihong Shen
- College of Life Science and Technology, Guangxi University, Nanning 530005, Guangxi, China
| | - Yuansong Wei
- State Key Joint Laboratory of Environmental Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China.
| |
Collapse
|
138
|
Zhuang L, Tang Z, Ma J, Yu Z, Wang Y, Tang J. Enhanced Anaerobic Biodegradation of Benzoate Under Sulfate-Reducing Conditions With Conductive Iron-Oxides in Sediment of Pearl River Estuary. Front Microbiol 2019; 10:374. [PMID: 30881355 PMCID: PMC6406033 DOI: 10.3389/fmicb.2019.00374] [Citation(s) in RCA: 19] [Impact Index Per Article: 3.8] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/01/2018] [Accepted: 02/13/2019] [Indexed: 12/12/2022] Open
Abstract
Anaerobic biodegradation of aromatic compounds under sulfate-reducing conditions is important to marine sediments. Sulfate respiration by a single bacterial strain and syntrophic metabolism by a syntrophic bacterial consortium are primary strategies for sulfate-dependent biodegradation of aromatic compounds. The objective of this study was to investigate the potential of conductive iron oxides to facilitate the degradation of aromatic compounds under sulfate-reducing conditions in marine sediments, using benzoate as a model aromatic compound. Here, in anaerobic incubations of sediments from the Pearl River Estuary, the addition of hematite or magnetite (20 mM as Fe atom) enhanced the rates of sulfate-dependent benzoate degradation by 81.8 and 91.5%, respectively, compared with control incubations without iron oxides. Further experiments demonstrated that the rate of sulfate-dependent benzoate degradation accelerated with increased magnetite concentration (5, 10, and 20 mM). The detection of acetate as an intermediate product implied syntrophic benzoate degradation pathway, which was also supported by the abundance of putative acetate- or/and H2-utilizing sulfate reducers from microbial community analysis. Microbial reduction of iron oxides under sulfate-reducing conditions only accounted for 2–11% of electrons produced by benzoate oxidation, thus the stimulatory effect of conductive iron oxides on sulfate-dependent benzoate degradation was not mainly due to an increased pool of terminal electron acceptors. The enhanced rates of syntrophic benzoate degradation by the presence of conductive iron oxides probably resulted from the establishment of a direct interspecies electron transfer (DIET) between syntrophic partners. In the presence of magnetite, Bacteroidetes and Desulfobulbaceae with potential function of extracellular electron transfer might be involved in syntrophic benzoate degradation. Results from this study will contribute to the development of new strategies for in situ bioremediation of anaerobic sediments contaminated with aromatic compounds, and provide a new perspective for the natural attenuation of aromatic compounds in iron-rich marine sediments.
Collapse
Affiliation(s)
- Li Zhuang
- Guangdong Key Laboratory of Environmental Pollution and Health, School of Environment, Jinan University, Guangzhou, China
| | - Ziyang Tang
- Guangdong Key Laboratory of Agricultural Environment Pollution Integrated Control, Guangdong Institute of Eco-environmental Science and Technology, Guangzhou, China
| | - Jinlian Ma
- Guangdong Key Laboratory of Agricultural Environment Pollution Integrated Control, Guangdong Institute of Eco-environmental Science and Technology, Guangzhou, China
| | - Zhen Yu
- Guangdong Key Laboratory of Agricultural Environment Pollution Integrated Control, Guangdong Institute of Eco-environmental Science and Technology, Guangzhou, China
| | - Yueqiang Wang
- Guangdong Key Laboratory of Agricultural Environment Pollution Integrated Control, Guangdong Institute of Eco-environmental Science and Technology, Guangzhou, China
| | - Jia Tang
- Guangdong Key Laboratory of Agricultural Environment Pollution Integrated Control, Guangdong Institute of Eco-environmental Science and Technology, Guangzhou, China
| |
Collapse
|
139
|
Wang C, Liu Y, Jin S, Chen H, Xu X, Wang Z, Xing B, Zhu L. Responsiveness extracellular electron transfer (EET) enhancement of anaerobic digestion system during start-up and starvation recovery stages via magnetite addition. BIORESOURCE TECHNOLOGY 2019; 272:162-170. [PMID: 30336398 DOI: 10.1016/j.biortech.2018.10.013] [Citation(s) in RCA: 60] [Impact Index Per Article: 12.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/13/2018] [Revised: 10/02/2018] [Accepted: 10/04/2018] [Indexed: 06/08/2023]
Abstract
Two up-flow anaerobic sludge blanket (UASB) reactors (RM with 10 g Fe L-1 magnetite, RB without magnetite) feeding with synthetic wastewater were built to investigate the effect of magnetite addition on anaerobic digestion (AD) performance during start-up and starvation recovery stages. With the magnetite addition, the COD removal efficiency and biogas production during the two stages were enhanced, and the recovery time of RM was shortened by about 50%. The reduced synthesis of riboflavin and heme c along with enhanced sludge conductivity of RM indicated that magnetite could replace their roles for efficient extracellular electron transfer (EET), which favors the growth of anaerobes. Microbial community analysis showed that potential syntrophic partners like Syntrophaceae and Methanothrix were enriched in RM during the recovery stage, and the performance was improved with quick responsiveness. Results demonstrated that addition of conductive materials like magnetite could improve the stability and restorability of AD process efficiently.
Collapse
Affiliation(s)
- Caiqin Wang
- Institute of Environment Pollution Control and Treatment, Zhejiang University, Hangzhou 310058, China
| | - Yang Liu
- Institute of Environment Pollution Control and Treatment, Zhejiang University, Hangzhou 310058, China
| | - Shuai Jin
- Institute of Environment Pollution Control and Treatment, Zhejiang University, Hangzhou 310058, China
| | - Hui Chen
- Institute of Environment Pollution Control and Treatment, Zhejiang University, Hangzhou 310058, China
| | - Xiangyang Xu
- Institute of Environment Pollution Control and Treatment, Zhejiang University, Hangzhou 310058, China; Zhejiang Province Key Laboratory for Water Pollution Control and Environmental Safety, Hangzhou 310058, China; Zhejiang Provincial Engineering Laboratory of Water Pollution Control, 388 Yuhangtang Road, Hangzhou 310058, China
| | - Zhirong Wang
- Zhejiang Provincal Office of Agricultural Ecology and Energy, Hangzhou 310012, China
| | - Bo Xing
- Shaoxing Environmental Monitoring Center, Shaoxing 312000, China
| | - Liang Zhu
- Institute of Environment Pollution Control and Treatment, Zhejiang University, Hangzhou 310058, China; Zhejiang Province Key Laboratory for Water Pollution Control and Environmental Safety, Hangzhou 310058, China; Zhejiang Provincial Engineering Laboratory of Water Pollution Control, 388 Yuhangtang Road, Hangzhou 310058, China.
| |
Collapse
|