Overexpression of the Bt cry2Aa2 operon in chloroplasts leads to formation of insecticidal crystals

Plant-based vaccine: mice immunized with chloroplast-derived anthrax protective antigen survive anthrax lethal toxin challenge

The currently available human vaccine for anthrax, derived from the culture supernatant of Bacillus anthracis, contains the protective antigen (PA) and traces of the lethal and edema factors, which may contribute to adverse side effects associated with this vaccine. Therefore, an effective expression system that can provide a clean, safe, and efficacious vaccine is required. In an effort to produce anthrax vaccine in large quantities and free of extraneous bacterial contaminants, PA was expressed in transgenic tobacco chloroplasts by inserting the pagA gene into the chloroplast genome. Chloroplast integration of the pagA gene was confirmed by PCR and Southern analysis. Mature leaves grown under continuous illumination contained PA as up to 14.2% of the total soluble protein. Cytotoxicity measurements in macrophage lysis assays showed that chloroplast-derived PA was equal in potency to PA produced in B. anthracis. Subcutaneous immunization of mice with partially purified chloroplast-derived or B. anthracis-derived PA with adjuvant yielded immunoglobulin G titers up to 1:320,000, and both groups of mice survived (100%) challenge with lethal doses of toxin. An average yield of about 150 mg of PA per plant should produce 360 million doses of a purified vaccine free of bacterial toxins edema factor and lethal factor from 1 acre of land. Such high expression levels without using fermenters and the immunoprotection offered by the chloroplast-derived PA should facilitate development of a cleaner and safer anthrax vaccine at a lower production cost. These results demonstrate the immunogenic and immunoprotective properties of plant-derived anthrax vaccine antigen.

Induction of neutralizing antibodies by a tobacco chloroplast-derived vaccine based on a B cell epitope from canine parvovirus

The 2L21 epitope of the VP2 protein from the canine parvovirus (CPV), fused to the cholera toxin B subunit (CTB-2L21), was expressed in transgenic tobacco chloroplasts. Mice and rabbits that received protein-enriched leaf extracts by parenteral route produced high titers of anti-2L21 antibodies able to recognize the VP2 protein. Rabbit sera were able to neutralize CPV in an in vitro infection assay with an efficacy similar to the anti-2L21 neutralizing monoclonal antibody 3C9. Anti-2L21 IgG and seric IgA antibodies were elicited when mice were gavaged with a suspension of pulverized tissues from CTB-2L21 transformed plants. Combined immunization (a single parenteral injection followed by oral boosters) shows that oral boosters help to maintain the anti-2L21 IgG response induced after a single injection, whereas parenteral administration of the antigen primes the subsequent oral boosters by promoting the induction of anti-2L21 seric IgA antibodies. Despite the induced humoral response, antibodies elicited by oral delivery did not show neutralizing capacity in the in vitro assay. The high yield of the fusion protein permits the preparation of a high number of vaccine doses from a single plant and makes feasible the oral vaccination using a small amount of crude plant material. However, a big effort has still to be done to enhance the protective efficacy of subunit vaccines by the oral route.

Recombination and heterologous expression of allophycocyanin gene in the chloroplast of Chlamydomonas reinhardtii

Heterogeneous expression of multiple genes in the nucleus of transgenic plants requires the introduction of an individual gene and the subsequent backcross to reconstitute multi-subunit proteins or metabolic pathways. In order to accomplish the expression of multiple genes in a single transformation event, we inserted both large and small subunits of allophycocyanin gene (apcA and apcB) into Chlamydomonas reinhardtii chloroplast expression vector, resulting in papc-S. The constructed vector was then introduced into the chloroplast of C. reinhardtii by micro-particle bombardment. Polymerase chain reaction and Southern blot analysis revealed that the two genes had integrated into the chloroplast genome. Western blot and enzyme-linked immunosorbent assay showed that the two genes from the prokaryotic cyanobacteria could be correctly expressed in the chloroplasts of C. reinhardtii. The expressed foreign protein in transformants accounted for about 2%-3% of total soluble proteins. These findings pave the way to the reconstitution of multi-subunit proteins or metabolic pathways in transgenic C. reinhardtii chloroplasts in a single transformation event.

Inducible trans-activation of plastid transgenes: expression of the R. eutropha phb operon in transplastomic tobacco

Deleterious effects of constitutive transgene expression can occur if gene products are harmful to the transformed plant. Constraints such as growth inhibition and male sterility have been observed in plastid transformants containing the phb operon encoding the genes required for the production of the polyester polyhydroxybutyric acid (PHB). In order to induce PHB synthesis in tobacco in a well-timed manner, we have constructed a trans-activation system to regulate transcription of the phb operon in plastids. This system consists of a nuclear-located, ethanol-inducible T7RNA polymerase (T7RNAP) which is targeted to plastids harboring the phb operon under control of T7 regulatory elements. Following treatment with 5% ethanol, moderate induction of PHB synthesis was found. PHB amounts reached 1,383 ppm in dry weight, and an overall background activity of 171 ppm was measured in uninduced tissues. On the transcriptional level, T7RNAP induction was proven and we found that the phb operon is transcribed into at least two mRNAs. Without ethanol induction, development of flowers and fertile seeds was possible. Thus, the main problem of inhibitory transgene expression was solved. Our results show that this inducible trans-activation system could serve as an alternative to constitutive expression of transgenes in the plastome.

Complete chloroplast genome sequence of Gycine max and comparative analyses with other legume genomes

Lack of complete chloroplast genome sequences is still one of the major limitations to extending chloroplast genetic engineering technology to useful crops. Therefore, we sequenced the soybean chloroplast genome and compared it to the other completely sequenced legumes, Lotus and Medicago. The chloroplast genome of Glycine is 152,218 basepairs (bp) in length, including a pair of inverted repeats of 25,574 bp of identical sequence separated by a small single copy region of 17,895 bp and a large single copy region of 83,175 bp. The genome contains 111 unique genes, and 19 of these are duplicated in the inverted repeat (IR). Comparisons of Glycine, Lotus and Medicago confirm the organization of legume chloroplast genomes based on previous studies. Gene content of the three legumes is nearly identical. The rpl22 gene is missing from all three legumes, and Medicago is missing rps16 and one copy of the IR. Gene order in Glycine, Lotus, and Medicago differs from the usual gene order for angiosperm chloroplast genomes by the presence of a single, large inversion of 51 kilobases (kb). Detailed analyses of repeated sequences indicate that many of the Glycine repeats that are located in the intergenic spacer regions and introns occur in the same location in the other legumes and in Arabidopsis, suggesting that they may play some functional role. The presence of small repeats of psbA and rbcL in legumes that have lost one copy of the IR indicate that this loss has only occurred once during the evolutionary history of legumes.

Stable plastid transformation in lettuce (Lactuca sativa L.)

Although plastid transformation in higher plants was first demonstrated in the early 1990s it is only recently that the technology is being extended to a broader range of species. To date, the production of fertile transplastomic plants has been reported for tobacco, tomato, petunia, soybean, cotton and Lesquerella fendleri (Brassicaceae). In this study we demonstrate a polyethylene glycol-mediated plastid transformation system for lettuce that generates fertile, homoplasmic, plastid-transformed lines. Transformation was achieved using a vector that targets genes to the trnA/trnI intergenic region of the lettuce plastid genome employing the aadA gene as a selectable marker against spectinomycin. Spectinomycin resistance and heterologous gene transcription were shown in T(1) plants derived from self-pollinated primary regenerants demonstrating transmission of the plastid-encoded transgene to the first seed generation. Crossing with male sterile wild-type lettuce showed that spectinomycin resistance was not transmitted via pollen. Constructs containing the gfp gene showed plastid-based expression of green fluorescent protein. The lettuce plastid could have potential both as a production and a delivery system for edible human therapeutic proteins.

Transformation of an edible crop with the pagA gene of Bacillus anthracis

Vaccination against anthrax is the most important strategy to combat the disease. This study describes a generation of edible transgenic crop expressing, functional protective antigen (PA). In vitro studies showed that the plant-expressed antigen is qualitatively similar to recombinant PA. Immunization studies in mouse animal models indicated the generation of PA-specific neutralizing antibodies and stressed the need for improving expression levels to generate higher antibody titers. Genetic engineering of a plant organelle offers immense scope for increasing levels of antigen expression. An AT-rich PA gene (pagA) coding for the 83-kDa PA molecule was thus cloned and expressed in tobacco chloroplasts. Biolistics was used for the transformation of a chloroplast genome under a set of optimized conditions. The expression of the pagA gene with 69% AT content was highly favored by an AT-rich chloroplast genome. A multifold expression level of functional PA was obtained as compared with the nuclear transgenic tobacco plants. This report describes for the first time a comprehensive study on generating transgenic plants expressing PA, which may serve as a source of an edible vaccine against anthrax. Two important achievements of expressing PA in an edible crop and use of chloroplast technology to enhance the expression levels are discussed here.

Generation and analysis of soybean plastid transformants expressing Bacillus thuringiensis Cry1Ab protoxin

We describe the generation of fertile and homoplasmic soybean plastid transformants, expressing the Bacillus thuringiensis insecticidal protoxin Cry1Ab. Transgenes were targeted in the intergenic region of Glycine max plastome, between the rps12/7 and trnV genes and selection was carried out using the aadA gene encoding spectinomycin resistance. Molecular analysis confirmed the integration of the cry1Ab and aadA expression cassettes at the expected location in the soybean plastome, and the transmission of the transgenes to the next generation. Western blot analyses showed that the Cry1Ab protoxin is highly expressed in leaves, stems and seeds, but not in roots. Its expression confers strong insecticidal activity to the generated transgenic soybean, as exemplified with velvetbean caterpillar (Anticarsia gemmatalis).

Characterization of heterologous multigene operons in transgenic chloroplasts: transcription, processing, and translation

The first characterization of transcriptional, posttranscriptional, and translational processes of heterologous operons expressed via the tobacco (Nicotiana tabacum) chloroplast genome is reported here. Northern-blot analyses performed on chloroplast transgenic lines harboring seven different heterologous operons revealed that polycistronic mRNA was the predominant transcript produced. Despite the lack of processing of such polycistrons, large amounts of foreign protein accumulation was observed in these transgenic lines, indicating abundant translation of polycistrons. This is supported by polysome fractionation assays, which allowed detection of polycistronic RNA in lower fractions of the sucrose gradients. These results show that the chloroplast posttranscriptional machinery can indeed detect and translate multigenic sequences that are not of chloroplast origin. In contrast to native transcripts, processed and unprocessed heterologous polycistrons were stable, even in the absence of 3' untranslated regions (UTRs). Unlike native 5'UTRs, heterologous secondary structures or 5'UTRs showed efficient translational enhancement independent of cellular control. Abundant read-through transcripts were observed in the presence of chloroplast 3'UTRs but they were efficiently processed at introns present within the native operon. Heterologous genes regulated by the psbA (the photosystem II polypeptide D1) promoter, 5' and 3'UTRs have greater abundance of transcripts than the endogenous psbA gene because transgenes were integrated into the inverted repeat region. Addressing questions about polycistrons, and the sequences required for their processing and transcript stability, are essential in chloroplast metabolic engineering. Knowledge of such factors would enable engineering of foreign pathways independent of the chloroplast complex posttranscriptional regulatory machinery.

Engineering cytoplasmic male sterility via the chloroplast genome by expression of {beta}-ketothiolase

While investigating expression of the polydroxybutyrate pathway in transgenic chloroplasts, we addressed the specific role of beta-ketothiolase. Therefore, we expressed the phaA gene via the chloroplast genome. Prior attempts to express the phaA gene in transgenic plants were unsuccessful. We studied the effect of light regulation of the phaA gene using the psbA promoter and 5' untranslated region, and evaluated expression under different photoperiods. Stable transgene integration into the chloroplast genome and homoplasmy were confirmed by Southern analysis. The phaA gene was efficiently transcribed in all tissue types examined, including leaves, flowers, and anthers. Coomassie-stained gel and western blots confirmed hyperexpression of beta-ketothiolase in leaves and anthers, with proportionately high levels of enzyme activity. The transgenic lines were normal except for the male-sterile phenotype, lacking pollen. Scanning electron microscopy revealed a collapsed morphology of the pollen grains. Floral developmental studies revealed that transgenic lines showed an accelerated pattern of anther development, affecting their maturation, and resulted in aberrant tissue patterns. Abnormal thickening of the outer wall, enlarged endothecium, and vacuolation affected pollen grains and resulted in the irregular shape or collapsed phenotype. Reversibility of the male-sterile phenotype was observed under continuous illumination, resulting in viable pollen and copious amount of seeds. This study results in the first engineered cytoplasmic male-sterility system in plants, offers a new tool for transgene containment for both nuclear and organelle genomes, and provides an expedient mechanism for F(1) hybrid seed production.

Stable transformation of petunia plastids

Plastid transformation results in stably expressed foreign genes, which for most Angiosperms are largely excluded from sperm cells, thereby greatly reducing the risk of foreign gene spread through pollen. Prior to this work, fertile plastid transformants were restricted to tobacco, tomato and Lesquerella. Application of plastid engineering in the important floriculture industry requires the development of stable plastid transformation in a major ornamental plant species such as Petunia hybrida. Here we describe the successful isolation of fertile and stable plastid transformants in a commercial cultivar of P. hybrida (var. Pink Wave). Plastid targeting regions from tobacco were used to integrate aadA and gusA between the accD and rbcL genes of P. hybrida plastid DNA following particle bombardment of leaves. For three spectinomycin and streptomycin resistant lines, DNA blot analysis confirmed transgene integration into plastid DNA and homoplasmy. Maternal inheritance and homoplasmy resulted in 100% transmission of spectinomycin resistance to progeny after selfing. Plastid transformants expressed the gusA gene uniformly within leaves and to comparable levels in all three lines. Insertion of trait genes in place of gusA coding sequences enables immediate applications of our plastid transformation vector. Establishment of plastid transformation in P. hybrida facilitates a safe and reliable use of this important ornamental plant for research and plant biotechnology.

Phytoremediation of toxic trace elements in soil and water

Toxic heavy metals and metalloids, such as cadmium, lead, mercury, arsenic, and selenium, are constantly released into the environment. There is an urgent need to develop low-cost, effective, and sustainable methods for their removal or detoxification. Plant-based approaches, such as phytoremediation, are relatively inexpensive since they are performed in situ and are solar-driven. In this review, we discuss specific advances in plant-based approaches for the remediation of contaminated water and soil. Dilute concentrations of trace element contaminants can be removed from large volumes of wastewater by constructed wetlands. We discuss the potential of constructed wetlands for use in remediating agricultural drainage water and industrial effluent, as well as concerns over their potential ecotoxicity. In upland ecosystems, plants may be used to accumulate metals/metalloids in their harvestable biomass (phytoextraction). Plants can also convert and release certain metals/metalloids in a volatile form (phytovolatilization). We discuss how genetic engineering has been used to develop plants with enhanced efficiencies for phytoextraction and phytovolatilization. For example, metal-hyperaccumulating plants and microbes with unique abilities to tolerate, accumulate, and detoxify metals and metalloids represent an important reservoir of unique genes that could be transferred to fast-growing plant species for enhanced phytoremediation. There is also a need to develop new strategies to improve the acceptability of using genetically engineered plants for phytoremediation.

Chloroplast-derived vaccine antigens and other therapeutic proteins

The chloroplast genetic engineering offers a number of unique advantages including high level of transgene expression, multi-gene expression in single transformation event and transgene containment due to maternal inheritance. Hyper-expression of vaccine antigens or therapeutic proteins in transgenic chloroplasts (leaves) or chromoplasts (fruits/roots) facilitates efficient oral delivery. Ability of chloroplasts to correctly fold human blood proteins with proper disulfide bridges (human serum albumin or interferons) or presence of chaperones in chloroplasts to facilitate assembly of complex multi-subunit proteins or their prokaryotic nature to express native bacterial genes (up to 46.1% total leaf protein) are attractive features for therapeutic protein production. Purification of therapeutic proteins has been achieved using novel purification strategies that do not require expensive column chromatography.

Breakthrough in chloroplast genetic engineering of agronomically important crops

Chloroplast genetic engineering offers several unique advantages, including high-level transgene expression, multi-gene engineering in a single transformation event and transgene containment by maternal inheritance, as well as a lack of gene silencing, position and pleiotropic effects and undesirable foreign DNA. More than 40 transgenes have been stably integrated and expressed using the tobacco chloroplast genome to confer desired agronomic traits or express high levels of vaccine antigens and biopharmaceuticals. Despite such significant progress, this technology has not been extended to major crops. However, highly efficient soybean, carrot and cotton plastid transformation has recently been accomplished through somatic embryogenesis using species-specific chloroplast vectors. This review focuses on recent exciting developments in this field and offers directions for further research and development.

Gene stacking in transgenic plants--the challenge for 21st century plant biotechnology

One of the major technical hurdles impeding the advance of plant genetic engineering and biotechnology is the fact that the expression or manipulation of multiple genes in plants is still difficult to achieve. Although a small proportion of commercial genetically modified (GM) crops present 'stacked' or 'pyramided' traits, only a handful of products have been developed by introducing three or more novel genes. On the research front, a variety of conventional and more novel methods have been employed to introduce multiple genes into plants, but all techniques suffer from certain drawbacks. In this review, the potential and problems of these various techniques and strategies are discussed, and the prospects for improving these technologies in the future are presented.

Orally delivered malaria vaccines: not too hard to swallow

Vaccines offer efficient and cost-effective protection against a wide range of infectious diseases. Unfortunately, no effective vaccine is yet available against malaria, and this infection remains one of the most important causes of human morbidity and mortality in the developing world. Over the past two decades a number of candidate proteins for inclusion in a subunit vaccine have been identified. Malariologists believe that an effective malaria vaccine will need to include multiple proteins that induce protective immune responses against different stages of the Plasmodium life cycle. The construction of such multivalent vaccines is beset by considerable logistical difficulties, not least of which is how to deliver them to a population living in endemic areas. Compared with other routes of vaccine administration, oral delivery has several advantages that make it an attractive strategy for vaccine development. This review summarises the progress towards an oral vaccine delivery system for malaria and discusses the feasibility of this approach.

Transfer of transformed chloroplasts from Nicotiana tabacum to the Lycium barbarum plants

Plastid transformation is an attractive technology for obtaining crop plants with new useful characteristics and for fundamental researches of plastid functioning and nuclear-plastid interaction. The aim of our experiments was to obtain plants with Lycium barbarum nucleus and transformed Nicotiana tabacum plastids. Plastome of previously engineered transplastomic tobacco plants contains reporter uidA gene and selective aadA gene that confers resistance to antibiotics spectinomycin and streptomycin. Asymmetric somatic hybridization was performed for transferring transformed tobacco plastids from transplastomic tobacco plants into recipient L. barbarum wild type plants. Hybrid L. barbarum plants containing transformed tobacco plastome with active aadA and uidA genes were obtained as a result of the experiments. The work shows the possibility of obtaining transplastomic plants by transferring the transformed plastids to remote species by using somatic hybridization technology. The developed technique is especially effective for obtaining transplastomic plants that have low regeneration and transformation ability.

Metabolic engineering of the chloroplast genome using the Echerichia coli ubiC gene reveals that chorismate is a readily abundant plant precursor for p-hydroxybenzoic acid biosynthesis

p-Hydroxybenzoic acid (pHBA) is the major monomer in liquid crystal polymers. In this study, the Escherichia coli ubiC gene that codes for chorismate pyruvate-lyase (CPL) was integrated into the tobacco (Nicotiana tabacum) chloroplast genome under the control of the light-regulated psbA 5' untranslated region. CPL catalyzes the direct conversion of chorismate, an important branch point intermediate in the shikimate pathway that is exclusively synthesized in plastids, to pHBA and pyruvate. The leaf content of pHBA glucose conjugates in fully mature T1 plants exposed to continuous light (total pooled material) varied between 13% and 18% dry weight, while the oldest leaves had levels as high as 26.5% dry weight. The latter value is 50-fold higher than the best value reported for nuclear-transformed tobacco plants expressing a chloroplast-targeted version of CPL. Despite the massive diversion of chorismate to pHBA, the plastid-transformed plants and control plants were indistinguishable. The highest CPL enzyme activity in pooled leaf material from adult T1 plants was 50,783 pkat/mg of protein, which is equivalent to approximately 35% of the total soluble protein and approximately 250 times higher than the highest reported value for nuclear transformation. These experiments demonstrate that the current limitation for pHBA production in nuclear-transformed plants is CPL enzyme activity, and that the process becomes substrate-limited only when the enzyme is present at very high levels in the compartment of interest, such as the case with plastid transformation. Integration of CPL into the chloroplast genome provides a dramatic demonstration of the high-flux potential of the shikimate pathway for chorismate biosynthesis, and could prove to be a cost-effective route to pHBA. Moreover, exploiting this strategy to create an artificial metabolic sink for chorismate could provide new insight on regulation of the plant shikimate pathway and its complex interactions with downstream branches of secondary metabolism, which is currently poorly understood.

Expression of non-toxic mutant of Escherichia coli heat-labile enterotoxin in tobacco chloroplasts

Chloroplast transformation systems offer unique advantages in biotechnology, including high level of foreign gene expression, maternal inheritance, and polycistronic expression. We studied chloroplast expression of LTK63 (change Ser-->Lys at position 63 in the A subunit) which is the mutant of Escherichia coli heat-labile toxin. LTK63 is devoid of any toxic activity, but still retains its mucosal adjuvanticity. The LTK63 was cloned into chloroplast targeting vector and transformed to tobacco chloroplasts by particle bombardment. PCR and Southern blot analyses confirmed stable homologous recombination of the LTK63 gene into the chloroplast genome. The amount of LTK63 protein detected in tobacco chloroplasts was approximately 3.7% of the total soluble protein. The GM1-ganglioside binding assay confirmed that chloroplast-synthesized LTB of LTK63 binds to the intestinal membrane GM1-ganglioside receptor. Thus, the expression of LTK63 in chloroplasts provides a potential route toward the development of a plant-based edible vaccine for high expression system and environmentally friendly approach.

Expression of Bacillus anthracis protective antigen in transgenic chloroplasts of tobacco, a non-food/feed crop

The Centers for Disease Control (CDC) lists Bacillus anthracis as a category A agent and estimates the cost of an anthrax attack to exceed US$ 26 billion per 100,000 exposed individuals. Concerns regarding anthrax vaccine purity, a requirement for multiple injections, and a limited supply of the protective antigen (PA), underscore the urgent need for an improved vaccine. Therefore, the 83 kDa immunogenic Bacillus anthracis protective antigen was expressed in transgenic tobacco chloroplasts. The PA gene (pag) was cloned into a chloroplast vector along with the psbA regulatory signals to enhance translation. Chloroplast integration of the transgenes was confirmed by PCR and Southern blot analyses. Crude plant extracts contained up to 2.5 mg full length PA/g of fresh leaf tissue and this showed exceptional stability for several months in stored leaves or crude extracts. Maximum levels of expression were observed in mature leaves under continuous illumination. Co-expression of the ORF2 chaperonin from Bacillus thuringiensis did not increase PA accumulation or induce folding into cuboidal crystals in transgenic chloroplasts. Trypsin, chymotrypsin and furin proteolytic cleavage sites present in PA were protected in transgenic chloroplasts because only full length PA 83 was observed without any degradation products. Both CHAPS and SDS detergents extracted PA with equal efficiency and PA was observed in the soluble fraction. Chloroplast-derived PA was functionally active in lysing mouse macrophages when combined with lethal factor (LF). Crude leaf extracts contained up to 25 microg functional PA/ml. With an average yield of 172 mg of PA per plant using an experimental transgenic cultivar grown in a greenhouse, 400 million doses of vaccine (free of contaminants) could be produced per acre, a yield that could be further enhanced 18-fold using a commercial cultivar in the field.

Production of polyhydroxybutyrate by polycistronic expression of bacterial genes in tobacco plastid

Transgenic techniques are used to enhance and improve crop production, and their application to the production of chemical resources in plants has been under investigation. To achieve this latter goal, multiple-gene transformation is required to improve or change plant metabolic pathways; when accomplished by plant nuclear transformation, however, this procedure is costly and time consuming. We succeeded in the metabolic engineering of the tobacco plant by introducing multiple genes within a bacteria-like operon into a plastid genome. A tobacco plastid was transformed with a polycistron consisting of the spectinomycin resistance gene and three bacterial genes for the biosynthesis of the biodegradable polyester, poly[(R)-3-hydroxybutyrate] (PHB), after modification of their ribosome binding sites. DNA and RNA analysis confirmed the insertion of the introduced genes into the plastid genome and their polycistronic expression. As the result, the transplastomic tobacco accumulated PHB in its leaves. The introduced genes and the PHB productivity were maternally inherited, avoiding genetic spread by pollen diffusion, and were maintained stably in the seed progeny. Despite the low PHB productivity, this report demonstrates the feasibility of transplastomic technology for metabolic engineering. This "phyto-fermentation" system can be applied to plant production of various chemical commodities and pharmaceuticals.

Stable transformation of the cotton plastid genome and maternal inheritance of transgenes

Chloroplast genetic engineering overcomes concerns of gene containment, low levels of transgene expression, gene silencing, positional and pleiotropic effects or presence of vector sequences in transformed genomes. Several therapeutic proteins and agronomic traits have been highly expressed via the tobacco chloroplast genome but extending this concept to important crops has been a major challenge; lack of 100 homologous species-specific chloroplast transformation vectors containing suitable selectable markers, ability to regulate transgene expression in developing plastids and inadequate tissue culture systems via somatic embryogenesis are major challenges. We employed a 'Double Gene/Single Selection (DGSS)' plastid transformation vector that harbors two selectable marker genes (aph A-6 and npt II) to detoxify the same antibiotic by two enzymes, irrespective of the type of tissues or plastids; by combining this with an efficient regeneration system via somatic embryogenesis, cotton plastid transformation was achieved for the first time. The DGSS transformation vector is at least 8-fold (1 event/2.4 bombarded plates) more efficient than 'Single Gene/Single Selection (SGSS)' vector (aph A-6; 1 event per 20 bombarded plates). Chloroplast transgenic lines were fertile, flowered and set seeds similar to untransformed plants. Transgenes stably integrated into the cotton chloroplast genome were maternally inherited and were not transmitted via pollen when out-crossed with untransformed female plants. Cotton is one of the most important genetically modified crops (120 billion US dollars US annual economy). Successful transformation of the chloroplast genome should address concerns about transgene escape, insects developing resistance, inadequate insect control and promote public acceptance of genetically modified cotton.

Plastid-expressed betaine aldehyde dehydrogenase gene in carrot cultured cells, roots, and leaves confers enhanced salt tolerance

Salinity is one of the major factors that limits geographical distribution of plants and adversely affects crop productivity and quality. We report here high-level expression of betaine aldehyde dehydrogenase (BADH) in cultured cells, roots, and leaves of carrot (Daucus carota) via plastid genetic engineering. Homoplasmic transgenic plants exhibiting high levels of salt tolerance were regenerated from bombarded cell cultures via somatic embryogenesis. Transformation efficiency of carrot somatic embryos was very high, with one transgenic event per approximately seven bombarded plates under optimal conditions. In vitro transgenic carrot cells transformed with the badh transgene were visually green in color when compared to untransformed carrot cells, and this offered a visual selection for transgenic lines. BADH enzyme activity was enhanced 8-fold in transgenic carrot cell cultures, grew 7-fold more, and accumulated 50- to 54-fold more betaine (93-101 micromol g(-1) dry weight of beta-Ala betaine and Gly betaine) than untransformed cells grown in liquid medium containing 100 mm NaCl. Transgenic carrot plants expressing BADH grew in the presence of high concentrations of NaCl (up to 400 mm), the highest level of salt tolerance reported so far among genetically modified crop plants. BADH expression was 74.8% in non-green edible parts (carrots) containing chromoplasts, and 53% in proplastids of cultured cells when compared to chloroplasts (100%) in leaves. Demonstration of plastid transformation via somatic embryogenesis utilizing non-green tissues as recipients of foreign DNA for the first time overcomes two of the major obstacles in extending this technology to important crop plants.

Stable high-level transgene expression in Arabidopsis thaliana using gene silencing mutants and matrix attachment regions

Basic and applied research involving transgenic plants often requires consistent high-level expression of transgenes. However, high inter-transformant variability of transgene expression caused by various phenomena, including gene silencing, is frequently observed. Here, we show that stable, high-level transgene expression is obtained using Arabidopsis thaliana post-transcriptional gene silencing (PTGS) sgs2 and sgs3 mutants. In populations of first generation (T1) A. thaliana plants transformed with a beta-glucuronidase (GUS) gene (uidA) driven by the 35S cauliflower mosaic virus promoter (p35S), the incidence of highly expressing transformants shifted from 20% in wild type background to 100% in sgs2 and sgs3 backgrounds. Likewise, when sgs2 mutants were transformed with a cyclin-dependent kinase inhibitor 6 gene under control of p35S, all transformants showed a clear phenotype typified by serrated leaves, whereas such phenotype was only observed in about one of five wild type transformants. p35S-driven uidA expression remained high and steady in T2 sgs2 and sgs3 transformants, in marked contrast to the variable expression patterns observed in wild type T2 populations. We further show that T-DNA constructs flanked by matrix attachment regions of the chicken lysozyme gene (chiMARs) cause a boost in GUS activity by fivefold in sgs2 and 12-fold in sgs3 plants, reaching up to 10% of the total soluble proteins, whereas no such boost is observed in the wild type background. MAR-based plant transformation vectors used in a PTGS mutant background might be of high value for efficient high-throughput screening of transgene-based phenotypes as well as for obtaining extremely high transgene expression in plants.

T7 RNA polymerase-directed expression of an antibody fragment transgene in plastids causes a semi-lethal pale-green seedling phenotype

A T7 promoter-controlled transgene, AbL, encoding a camel single-domain antibody fragment that binds to the model antigen chicken egg-white lysozyme was introduced into the plastid genome of tobacco. AbL expression was activated in the transplastomic line by introducing a nuclear transgene, ST7, encoding a light-regulated plastid-targeted T7RNAP by cross-pollination. The resulting AbL x ST7 progeny seedlings developed a pale-green phenotype and ceased growth soon after germination. High levels of AbL transcripts accumulated in AbL x ST7 seedlings and expression of functional AbL antibody was detected by ELISA. Transplastomic AbL plants were also crossed with nuclear-transformed tobacco plants containing a salicylic acid-inducible transgene encoding a plastid-targeted T7RNAP (PR-T7 transgene). The resulting AbL x PR-T7 progeny were wild-type in appearance but were slow growing and prone to wilting even when provided with adequate water. Although AbL transcription was inducible by treating AbL x PR-T7 leaves with salicylic acid, high levels of T7RNAP-dependent AbL transcripts also accumulated in the absence of induction. However, AbL antibody did not accumulate at levels detectable by immunoblotting or ELISA in AbL x PR-T7 plants despite the fact that total leaf RNA containing AbL transcripts was capable of directing AbL antibody synthesis in an E. coli-derived in vitro translation system.

Bacteriophage T7 RNA polymerase-directed, inducible and tissue-specific over-expression of foreign genes in transgenic plants

A widely applicable bacteriophage T7 RNA polymerase-directed, tissue-specific and inducible over-expression of foreign genes in transgenic plants was developed. This was achieved through the simultaneous transformation of a modified T7 RNA polymerase to specifically transcribe the foreign gene placed under the control of T7 expression signals. The T7 RNA polymerase recognized the chimeric uidA gene integrated randomly into tobacco and rice genomes. Results from the use of six different promoters with different tissue specificities indicated that the recombinant protein was expressed at a several-fold (3-10-fold) higher level when compared with transgenes expressed directly under the control of these tissue-specific promoters. An important feature of the T7 system in plants was the near-uniform expression in the independently transformed plants, in contrast with the large variations observed in transgene expression under the direct control of plant promoters. In addition, our results demonstrated the application of the T7 system in the regulation of transgene expression through chemically inducible mechanisms. This versatility of controlled and regulated expression offers a powerful tool that could be used in various programmes in plant biotechnology and genomic studies.

Generation of fertile transplastomic soybean

We describe here the development of a plastid transformation method for soybean, a leguminous plant of major agronomic interest. Chloroplasts from embryogenic tissue of Glycine max have been successfully transformed by bombardment. The transforming DNA carries a spectinomycin resistance gene (aadA) under the control of tobacco plastid regulatory expression elements, flanked by two adjacent soybean plastome sequences allowing its targeted insertion between the trnV gene and the rps12/7 operon. All generated spectinomycin resistant plants were transplastomic and no remaining wild type plastome copies were detected. No spontaneous mutants were obtained. The transformation efficiency is similar to that of tobacco plastids. All transplastomic T0 plants were fertile and T1 progeny was uniformly spectinomycin resistant, showing the stability of the plastid transgene. This is the first report on the generation of fertile transplastomic soybean.

Dicistronic expression of the green fluorescent protein and antibiotic resistance genes in the plastid for selection and tracking of plastid-transformed cells in tobacco

A plastid transformation vector was constructed for dicistronic expression of the aminoglycoside 3'-adenyltransferase (aadA) and green fluorescent protein (gfp) genes under the control of the plastid rrn promoter. Gold particles coated with the vector DNA were bombarded onto tobacco leaf explants using a particle delivery system. Leaf explants produced adventitious shoots when cultured on shoot-inducing medium containing 500 mg l(-1) spectinomycin. Shoots that exhibited green fluorescence under UV light were selected. Southern blot analysis detected the presence of the aadA and gfp genes between trnA and trnI in the plastid genome. Northern blot analysis revealed that the aadA and gfp genes were both properly transcribed into a dicistronic transcriptional unit. The expression of the gfp gene in the plastid enabled separation of transformed chloroplasts from wild-type chloroplasts in the protoplast under a fluorescent microscope. The overall results indicate that dicistronic expression of the aadA and gfp genes in the plastid simplifies gene manipulation, facilitating selection and tracking of plastid-transformed cells.

Accumulation of rotavirus VP6 protein in chloroplasts of transplastomic tobacco is limited by protein stability

Rotavirus VP6 is a highly immunogenic major capsid protein that may be useful as a subunit vaccine. The expression of a bovine group A rotavirus VP6 cDNA was examined in tobacco chloroplasts following particle bombardment. Constructs containing the VP6 cDNA under the control of plastid rrn or psbA promoters, or the Escherichia coli trc promoter, were inserted, together with the aadA selectable marker gene, between the rbcL and accD genes of the tobacco plastid genome. The 40-kDa VP6 protein accumulated to about 3% of total soluble protein in seedlings and young leaves of homoplasmic transplastomic plants containing the VP6 cDNA under the control of the rrn promoter. Lower amounts of VP6 (approximately 0.6% total soluble protein) accumulated in plants containing the VP6 cDNA under the control of the psbA promoter, and VP6 was undetectable in plants containing the VP6 cDNA under the control of the trc promoter. The VP6 protein in chloroplasts was shown to form trimers, as found in the rotavirus virion. However, the amount of VP6 protein declined as the leaves matured, although VP6 transcripts were still present, suggesting that the protein was susceptible to proteolytic degradation in chloroplasts.

Enhanced translation of a chloroplast-expressed RbcS gene restores small subunit levels and photosynthesis in nuclear RbcS antisense plants

Ribulose-1,5-bisphosphate carboxylase/oxygenase (Rubisco) is a key enzyme that converts atmospheric carbon to food and supports life on this planet. Its low catalytic activity and specificity for oxygen leads to photorespiration, severely limiting photosynthesis and crop productivity. Consequently, Rubisco is a primary target for genetic engineering. Separate localization of the genes in the nuclear and chloroplast genomes and a complex assembly process resulting in a very low catalytic activity of hybrid Rubisco enzymes have rendered several earlier attempts of Rubisco engineering unsuccessful. Here we demonstrate that the RbcS gene, when integrated at a transcriptionally active spacer region of the chloroplast genome, in a nuclear RbcS antisense line and expressed under the regulation of heterologous (gene 10) or native (psbA) UTRs, results in the assembly of a functional holoenzyme and normal plant growth under ambient CO(2) conditions, fully shortcircuiting nuclear control of gene regulation. There was approximately 150-fold more RbcS transcript in chloroplast transgenic lines when compared with the nuclear RbcS antisense line, whereas the wild type has 7-fold more transcript. The small subunit protein levels in the gene 10/RbcS and psbA/RbcS plants were 60% and 106%, respectively, of the wild type. Photosynthesis of gene 10/RbcS plants was approximately double that of the antisense plants, whereas that of psbA/RbcS plants was restored almost completely to the wild-type rates. These results have opened an avenue for using chloroplast engineering for the evaluation of foreign Rubisco genes in planta that eventually can result in achieving efficient photosynthesis and increased crop productivity.

Production and glycosylation of plant-made pharmaceuticals: the antibodies as a challenge

Antibodies have long been recognized for their diagnostic and therapeutic potential. The rapidly increasing number of monoclonal antibodies approved for immunotherapy has paved the way to an even greater demand for these molecules. In order to satisfy this growing demand and to increase the production capacity, alternative systems based on antibody production in transgenic organisms are being actively explored. In this paper, we focus on transgenic plants as a promising system for the scale-up and processing of plant-made pharmaceuticals. In particular, we point out the advantages and limitations induced by glycosylation of plant-made antibodies for human therapy.

High-yield expression of a viral peptide animal vaccine in transgenic tobacco chloroplasts

The 2L21 peptide, which confers protection to dogs against challenge with virulent canine parvovirus (CPV), was expressed in tobacco chloroplasts as a C-terminal translational fusion with the cholera toxin B subunit (CTB) or the green fluorescent protein (GFP). Expression of recombinant proteins was dependent on plant age. A very high-yield production was achieved in mature plants at the time of full flowering (310 mg CTB-2L21 protein per plant). Both young and senescent plants accumulated lower amounts of recombinant proteins than mature plants. This shows the importance of the time of harvest when scaling up the process. The maximum level of CTB-2L21 was 7.49 mg/g fresh weight (equivalent to 31.1% of total soluble protein, TSP) and that of GFP-2L21 was 5.96 mg/g fresh weight (equivalent to 22.6% of TSP). The 2L21 inserted epitope could be detected with a CPV-neutralizing monoclonal antibody, indicating that the epitope is correctly presented at the C-terminus of the fusion proteins. The resulting chimera CTB-2L21 protein retained pentamerization and G(M1)-ganglioside binding characteristics of the native CTB and induced antibodies able to recognize VP2 protein from CPV. To our knowledge, this is the first report of an animal vaccine epitope expression in transgenic chloroplasts. The high expression of antigens in chloroplasts would reduce the amount of plant material required for vaccination (approximately 100 mg for a dose of 500 microg antigen) and would permit encapsulation of freeze-dried material or pill formation.

Plastid transformation in higher plants

Plastids of higher plants are semi-autonomous organelles with a small, highly polyploid genome and their own transcription-translation machinery. This review provides an overview of the technology for the genetic modification of the plastid genome including: vectors, marker genes and gene design, the use of gene knockouts and over-expression to probe plastid function and the application of site-specific recombinases for excision of target DNA. Examples for applications in basic science include the study of plastid gene transcription, mRNA editing, photosynthesis and evolution. Examples for biotechnological applications are incorporation of transgenes in the plastid genome for containment and high-level expression of recombinant proteins for pharmaceutical and industrial applications. Plastid transformation is routine only in tobacco. Progress in implementing the technology in other crops is discussed.

Expression of the B subunit of E. coli heat-labile enterotoxin in the chloroplasts of plants and its characterization

Transgenic chloroplasts have become attractive systems for heterologous gene expressions because of unique advantages. Here, we report a feasibility study for producing the nontoxic B subunit of Escherichia coli heat-labile enterotoxin (LTB) via chloroplast transformation of tobacco. Stable site-specific integration of the LTB gene into chloroplast genome was confirmed by PCR and genomic Southern blot analysis in transformed plants. Immunoblot analysis indicated that plant-derived LTB protein was oligomeric, and dissociated after boiling. Pentameric LTB molecules were the dominant molecular species in LTB isolated from transgenic tobacco leaf tissues. The amount of LTB protein detected in transplastomic tobacco leaf was approximately 2.5% of the total soluble plant protein, approximately 250-fold higher than in plants generated via nuclear transformation. The GM1-ELISA binding assay indicated that chloroplast-synthesized LTB protein bound to GM1-ganglioside receptors. LTB protein with biochemical properties identical to native LTB protein in the chloroplast of edible plants opens the way for inexpensive, safe, and effective plant-based edible vaccines for humans and animals.

Expression of ORF2 partial gene of hepatitis E virus in tomatoes and immunoactivity of expression products

AIM: To transfer hepatitis E virus (HEV) ORF2 partial gene to tomato plants, to investigate its expression in transformants and the immunoactivity of expression products, and to explore the feasibility of developing a new type of plant-derived HEV oral vaccine.

METHODS: Plant binary expression vector p1301E2, carrying a fragment of HEV open reading frame-2 (named HEV-E2), was constructed by linking the fragment to a constitutive CaMV35s promoter and nos terminator, then directly introduced into Agrobacterium tumefaciens EHA105. With leaf-disc method, tomato plants medicated by EHA105 were transformed and hygromycin-resistant plantlets were obtained in selective medium containing hygromycin. The presence and integration of foreign DNA in transgenic tomato genome were confirmed by Gus gene expression, PCR amplification and Southern dot blotting. The immunoactivity of recombinant protein extracted from transformed plants was examined by enzyme-linked immunosorbant assay (ELISA) using a monoclonal antibody specifically against HEV. ELISA was also used to estimate the recombinant protein content in leaves and fruits of the transformants.

RESULTS: Seven positive lines of HEV-E2-transgenic tomato plants confirmed by PCR and Southern blotting were obtained and the immunoactivity of recombinant protein could be detected in extracts of transformants. The expression levels of recombinant protein were 61.22 ng/g fresh weight in fruits and 6.37-47.9 ng/g fresh weight in leaves of the transformants.

CONCLUSION: HEV-E2 gene was correctly expressed in transgenic tomatoes and the recombinant antigen derived from them has normal immunoactivity. Transgenic tomatoes may hold a good promise for producing a new type of low-cost oral vaccine for hepatitis E virus.

Production of human papillomavirus type 16 virus-like particles in transgenic plants

Cervical cancer is linked to infection with human papillomaviruses (HPV) and is the third most common cancer among women worldwide. There is a strong demand for the development of an HPV preventive vaccine. Transgenic plants expressing the HPV major capsid protein L1 could be a system to produce virus-like particles for prophylactic vaccination or could even be used as edible vaccines to induce an L1-specific prophylactic immune response. Here, we describe the generation of transgenic tobacco and potato plants carrying the HPV type 16 major structural gene L1 under the control of the cauliflower mosaic virus 35S promoter. All attempts to express either the original, unmodified L1 gene or an L1 gene with a codon usage optimized for expression in plants failed. Surprisingly, small amounts of the protein were detected using an L1 gene optimized for expression in human cells. However, Northern blot analysis revealed that most of the L1 transcripts were degraded. Introduction of the translational enhancer Omega derived from the tobacco mosaic virus strongly increased transcript stability and resulted in accumulation of L1 protein to approximately 0.5 to 0.2% of total soluble protein in transgenic tobacco and potato plants, respectively. The plant-derived L1 protein displayed conformation-specific epitopes and assembled into virus-like particles. Furthermore, we did not find any indications of protein modification of the L1 protein produced in plants. Plant-derived L1 was as immunogenic as L1 expressed in baculovirus-infected insect cells. Feeding of tubers from transgenic potatoes to mice induced an anti-L1 antibody response in 3 out of 24 mice, although this response was only transient in two of the mice. Our data, however, indicate that an anti-L1 response was primed in about half of the 24 animals.

Phytoremediation of organomercurial compounds via chloroplast genetic engineering

Mercury (Hg), especially in organic form, is a highly toxic pollutant affecting plants, animals, and man. In plants, the primary target of Hg damage is the chloroplast; Hg inhibits electron transport and photosynthesis. In the present study, chloroplast genetic engineering is used for the first time to our knowledge to enhance the capacity of plants for phytoremediation. This was achieved by integrating a native operon containing the merA and merB genes (without any codon modification), which code for mercuric ion reductase (merA) and organomercurial lyase (merB), respectively, into the chloroplast genome in a single transformation event. Stable integration of the merAB operon into the chloroplast genome resulted in high levels of tolerance to the organomercurial compound, phenylmercuric acetate (PMA) when grown in soil containing up to 400 micro M PMA; plant dry weights of the chloroplast transformed lines were significantly higher than those of wild type at 100, 200, and 400 micro M PMA. That the merAB operon was stably integrated into the chloroplast genome was confirmed by polymerase chain reaction and Southern-blot analyses. Northern-blot analyses revealed stable transcripts that were independent of the presence or absence of a 3'-untranslated region downstream of the coding sequence. The merAB dicistron was the more abundant transcript, but less abundant monocistrons were also observed, showing that specific processing occurs between transgenes. The use of chloroplast transformation to enhance Hg phytoremediation is particularly beneficial because it prevents the escape of transgenes via pollen to related weeds or crops and there is no need for codon optimization to improve transgene expression. Chloroplast transformation may also have application to other metals that affect chloroplast function.

Polyester synthesis in transplastomic tobacco (Nicotiana tabacum L.): significant contents of polyhydroxybutyrate are associated with growth reduction

The pathway for synthesis of polyhydroxybutyrate (PHB), a polyester produced by three bacterial enzymes, was transferred to the tobacco plastid genome by the biolistic transformation method. The polycistronic phb operon encoding this biosynthetic pathway was cloned into plastome transformation vectors. Following selection and regeneration, the content and structure of plant-produced hydroxybutyrate was analysed by gas chromatography. Significant PHB synthesis was limited to the early stages of in vitro culture. Within the transformants, PHB synthesis levels were highly variable. In the early regeneration stage, single regenerates reached up to 1.7% PHB in dry weight. At least 70% of plant-produced hydroxybutyric acid was proven to be polymer with a molecular mass of up to 2,500 kDa. PHB synthesis levels of the transplastomic lines were decreasing when grown autotrophically but their phb transcription levels remained stable. Transcription of the three genes is divided into two transcripts with phbB being transcribed separately from phbC and phbA. In mature plants even low amounts of PHB were associated with male sterility. Fertility was only observed in a mutant carrying a defective phb operon. These results prove successful expression of the entire PHB pathway in plastids, concomitant, however, with growth deficiency and male sterility.

Oral immunization of animals with transgenic cherry tomatillo expressing HBsAg

AIM: To investigate the expression of recombinant HBsAg (rHBsAg) in transgenic cherry tomatillo in order to explore the feasibility of producing HBV oral vaccine with cherry tomatillo by animal immune tests.

METHODS: The recombinant plant expression vector containing HBsAg gene was constructed. Mediated with Agrobacterium tumefaciens, HBsAg gene was transferred into cotyledons of cherry tomatillo. Transformed cherry tomatillos were obtained through hygromycin delay-selection. Integrated DNA in transgenic cherry tomatillo was confirmed by hygromycin resistance selection, Gus detection, polymerase chain reaction (PCR) and dot blotting analysis. Antigenicity of rHBsAg was examined by ELISA and the immunogenicity of rHBsAg derived from transgenic cherry tomatillo tissues was confirmed by oral feed of transformed tissues to BALB/c mice primed with commercial HBV vaccines. Specific antibody titers in mice’s serum were examined by ELISA every week.

RESULTS: By far, 10 positive lines of transgenic cherry tomatillos containing HBsAg gene were obtained. Among different organs of the same transgenic cherry tomatillo, level of rHBsAg expressed in leaves was the highest with the yield up to 300 ng/g fresh weight. And the rHBsAg expression level in fruits was about 10 ng/g fresh weight. In animal immune tests, oral delivery with transgenic tissues to mice primed with commercial vaccine instead of naive mice resulted in significant immune response.

CONCLUSION: The result of this animal immune test indicated the rHBsAg derived from transgenic cherry tomatillo possessed normal immunogenicity. This work demonstrated the feasibility to generate oral immunogenic rHBsAg in transgenic cherry tomatillo, and would provide some experimental approach for the production of low-cost oral vaccines using transgenic cherry tomatillo in large scale.

Efficient linking and transfer of multiple genes by a multigene assembly and transformation vector system

Introduction and expression of multiple transgenes is frequently required for basic and applied studies. However, at present, multigene transformation is very difficult due to technical limitations of existing methods. Here, we describe a vector system for efficient multigene assembly and transformation. The system consists of a transformation-competent artificial chromosome (TAC)-based acceptor vector together with two donor vectors. By exploiting the CreloxP recombination system and homing endonucleases, multiple rounds of gene assembly cycling were carried out with alternate use of the donor vectors, and multiple genes were sequentially delivered into the TAC vector. With this system, we created constructs containing as many as 10 foreign DNA fragments. Multiple genes, including six resistant genes stacked in a construct, were transferred into rice genome by Agrobacterium-mediated transformation. This system extends the repertoire of molecular genetic studies and biotechnological endeavors by enabling simultaneous manipulation of multiple genes.

A chloroplast transgenic approach to hyper-express and purify Human Serum Albumin, a protein highly susceptible to proteolytic degradation

Human Serum Albumin (HSA) accounts for 60% of the total protein in blood serum and it is the most widely used intravenous protein in a number of human therapies. HSA, however, is currently extracted only from blood because of a lack of commercially feasible recombinant expression systems. HSA is highly susceptible to proteolytic degradation in recombinant systems and is expensive to purify. Expression of HSA in transgenic chloroplasts using Shine-Dalgarno sequence (SD), which usually facilitates hyper-expression of transgenes, resulted only in 0.02% HSA in total protein (tp). Modification of HSA regulatory sequences using chloroplast untranslated regions (UTRs) resulted in hyper-expression of HSA (up to 11.1% tp), compensating for excessive proteolytic degradation. This is the highest expression of a pharmaceutical protein in transgenic plants and 500-fold greater than previous reports on HSA expression in transgenic leaves. Electron micrographs of immunogold labelled transgenic chloroplasts revealed HSA inclusion bodies, which provided a simple method for purification from other cellular proteins. HSA inclusion bodies could be readily solubilized to obtain a monomeric form using appropriate reagents. The regulatory elements used in this study should serve as a model system for enhancing expression of foreign proteins that are highly susceptible to proteolytic degradation and provide advantages in purification, when inclusion bodies are formed.

Chloroplast transformation in oilseed rape

The chloroplast transformation vector pNRAB carries two expression cassettes for the spectinomycin resistance gene aadA and the insect resistance gene cry1Aa10. The two cassettes are sited between the rps7 and ndhB targeting fragments. Biolistic delivery of the vector DNA, followed by spectinomycin selection, yielded chloroplast transformants at a frequency of four in 1000 bombarded cotyledon petioles. PCR analysis and Southern blot of PCR products confirmed the site-specific integration of aadA and cry1Aa10 into the chloroplast genomes of transgenic oilseed rape. When transgenic oilseed rape leaves were fed to second instar Plutella xylostera larvae, 47% mortality was observed against this insect and the surviving larvae had significantly lower weight than the control. This is the first report of chloroplast transformation in oilseed rape and the introduction of novel genes between the rps7 and ndhB genes in the chloroplast genome. This offers an opportunity for improvement of oilseed rape by chloroplast genetic engineering.

Progress towards commercialization of plastid transformation technology

Tobacco chloroplasts are ready to be tested as a platform for the expression of recombinant proteins on a commercial scale. They hold the promise of reproducible yields of 5-25% of total soluble cellular protein in leaves and reliability has been achieved through refinement of an expression toolkit that includes vectors, recently developed expression cassettes and systems for marker gene removal. Implementation of plastid transformation technology in other crops, however, has met with difficulty and has delayed agronomic applications.

Expression of protective antigen in transgenic plants: a step towards edible vaccine against anthrax

Protective antigen (PA) is the most potent molecule for vaccination against anthrax. In the present study, we have successfully integrated protective antigen gene in nuclear genome of tobacco plants by Agrobacterium mediated leaf-disc transformation method. Expression of protective antigen gene was detected by immunoblot analysis using antisera raised against purified PA. A distinct band of approximately 83kDa lighted up in the protein extracted from transformed plants while there was no such band in untransformed plants. The plant expressed PA showed biological activity just like native PA, which was demonstrated by cytolytic assay on macrophage like cell lines with lethal factor. This study establishes for the first time expression of PA gene in a plant system and thus marks the first milestone towards developing edible vaccine against anthrax.

Complementation of the nuclear antisense rbcS-induced photosynthesis deficiency by introducing an rbcS gene into the tobacco plastid genome

The small subunit (SS) of ribulose-1,5-bisphosphate carboxylase/oxygenase (Rubisco) is a nuclear gene-encoded protein that is imported into chloroplasts where it assembles with the large subunit (LS) after removal of the transit peptide to form Rubisco. We have explored the possibility that the severe deficiency in photosynthesis exhibited in nuclear transgenic tobacco (line alpha5) expressing antisense rbcS coding DNA that results in low SS and Rubisco protein content [Rodermel et al. (1988) Cell 55: 673] could be complemented by introducing a copy of the rbcS gene into its plastid genome through chloroplast transformation. Two independent lines of transplastomic plants were generated, in which the tobacco rbcS coding sequence, either with or without the transit sequence, was site-specifically integrated into the plastid genome. We found that compared with the antisense plants, expression of the plastid rbcS gene in the transplastomic plants resulted in very high mRNA abundance but no increased accumulation of the SS and Rubisco protein or improvement in plant growth and photosynthesis. Therefore, there is a limitation in efficient translation of the rbcS mRNA in the plastid or an incorrect processing and modification of the plastid-synthesized SS protein that might cause its rapid degradation.

Edible plant vaccines: applications for prophylactic and therapeutic molecular medicine

The use of edible plants for the production and delivery of vaccine proteins could provide an economical alternative to fermentation systems. Genes encoding bacterial and viral antigens are faithfully expressed in edible tissues to form immunogenic proteins. Studies in animals and humans have shown that ingestion of transgenic plants containing vaccine proteins causes production of antigen-specific antibodies in serum and mucosal secretions. In general, the technology is limited by low expression levels for nuclear-integrated transgenes, but recent progress in plant organelle transformation shows promise for enhanced expression. The stability and immunogenicity of orally delivered antigens vary greatly, which necessitates further study on protein engineering to enhance mucosal delivery. These issues are discussed with regard to the further development of plant-based vaccine technology.

Molecular strategies for gene containment in transgenic crops

The potential of genetically modified (GM) crops to transfer foreign genes through pollen to related plant species has been cited as an environmental concern. Until more is known concerning the environmental impact of novel genes on indigenous crops and weeds, practical and regulatory considerations will likely require the adoption of gene-containment approaches for future generations of GM crops. Most molecular approaches with potential for controlling gene flow among crops and weeds have thus far focused on maternal inheritance, male sterility, and seed sterility. Several other containment strategies may also prove useful in restricting gene flow, including apomixis (vegetative propagation and asexual seed formation), cleistogamy (self-fertilization without opening of the flower), genome incompatibility, chemical induction/deletion of transgenes, fruit-specific excision of transgenes, and transgenic mitigation (transgenes that compromise fitness in the hybrid). As yet, however, no strategy has proved broadly applicable to all crop species, and a combination of approaches may prove most effective for engineering the next generation of GM crops.