Free nitrous acid promotes hydrogen production from dark fermentation of waste activated sludge

Outstanding enhancement of caproate production with microwave pyrolyzed highly reductive biochar addition

The integration of biochar into microbial Chain Elongation (CE) proves to be an effective tool of producing high-value bio-based products. This study innovatively applied biochar fabricated under microwave irradiation with carbon fiber cloth assistance into CE system. Results highlighted that microwave biochar achieved maximal CE efficiency yielding 8 g COD/L, with 3-fold increase to the blank group devoid of any biochar. Microwave biochar also obtained the highest substrate utilization rate of 94 %, while conventional biochar group recorded 90 % and the blank group was of 74 %. Mechanistic insights revealed that the reductive surface properties facilitated CE performance, which is relevant to fostering dominant genera of Parabacteroides, Bacteroides, and Macellibacteroides. By metagenomics, microwave biochar up-regulated functional genes and enzymes involved in CE process including ethanol oxidation, the reverse β-oxidation pathway, and the fatty acid biosynthesis pathway. This study effectively facilitated caproate production by utilizing a new microwave biochar preparation strategy.

Impact of benzalkonium chloride on anaerobic granules and its long-term effects on reactor performance

This study assessed the inhibitory and performance-degrading effects induced by the cationic surfactant benzalkonium chloride (BAC) on anaerobic granules during the long-term operation of a laboratory-scale expanded granular sludge bed (EGSB) reactor. To address the critical scientific problem of how BAC affects the efficiency of EGSB reactors, this research uniquely evaluated the long-term stress response to BAC by systematically comparing continuous and discontinuous inhibitor exposure scenarios. The novel comparison demonstrated that inhibitor concentration is of minor relevance compared to the biomass-specific cumulative inhibitor load in the reactor. After exceeding a critical biomass-specific cumulative inhibitor load of 6.1-6.5 mg BAC/g VS, continuous and discontinuous exposure to BAC caused comparable significant deterioration in reactor performance, including accumulation of volatile fatty acids (VFA), decreased removal efficiency, reduced methane production, as well as the wash-out, flotation, and disintegration of anaerobic granules. BAC exposures had a more detrimental effect on methanogenesis than on acidogenesis. Moreover, long-term stress by BAC led to an inhibition of protein production, resulting in a decreased protein-to-polysaccharide ratio of extracellular polymeric substances (EPS) that promoted destabilizing effects on the granules. Finally, hydrogenotrophic methanogenesis was triggered. Reactor performance could not be restored due to the severe loss of granular sludge.

Sulfate-reducing bacteria decreases fractional pressure of H2 to accelerate short-chain fatty acids production from waste activated sludge fermentation assisted with zero-valent iron activated sulfite pretreatment

The production of short-chain fatty acids (SCFAs) is constrained by substrate availability and the increased fractional pressure of H2 emitted by acidogenic/fermentative bacteria during anaerobic fermentation of waste activated sludge (WAS). This study introduced a novel approach employing zero-valent iron (ZVI)-activated sulfite pretreatment combined with H2-consuming sulfate-reducing bacteria (SRB) mediation to improve SCFAs, especially acetate production from WAS fermentation. Experimental results showed that the combined ZVI-activated sulfite and incomplete-oxidative SRB (io-SRB) process achieved a peak SCFAs production of 868.11 mg COD/L, with acetate accounting for 80.55 %, which was 7.90- and 2.18-fold higher than that obtained from raw WAS fermentation, respectively. This could be firstly attributed to the SO4- and OH generated by ZVI-activated sulfite, which significantly promoted WAS decomposition, e.g., soluble proteins and carbohydrates increased 14.3- and 10.8-fold, respectively, over those in raw WAS. The biodegradation of dissolved organic matter was subsequently enhanced by the synergistic interaction and H2 transfer between anaerobic fermentation bacteria (AFB) and io-SRB. The positive and negative correlations among AFB, nitrate-reducing bacteria (NRB) and the io-SRB consortia were revealed by molecular ecological network (MEN) and Mantel test. Moreover, the expression of functional genes was also improved, for instance, in relation to acetate formation, the relative abundances of phosphate acetyltransferase and acetate kinase was 0.002 % and 0.005 % higher than that in the control test, respectively. These findings emphasized the importance of sulfate radicals-based oxidation pretreatment and the collaborative relationships of multifunctional microbes on the value-added chemicals and energy recovery from sludge fermentation.

Potential of free nitrous acid (FNA) for sludge treatment and resource recovery from waste activated sludge: A review

The escalating production of waste activated sludge (WAS) presents significant challenges to wastewater treatment plants (WWTPs). Free nitrous acid (FNA), known for its biocidal effect, has gained a growing focus on sludge dewatering, sludge reduction, and resource recovery from WAS due to its eco-friendly and cost-effective properties. Nevertheless, there have been no attempts made to systematically summarize or critically analyze the application of FNA in enhancing treatment and resource utilization of sludge. In this paper, we provided an overview of the current understanding regarding the application potential and influencing factors of FNA in sludge treatment, with a specific focus on enhancing sludge dewatering efficiency and reducing volume. To foster resource development from sludge, various techniques based on FNA have recently been proposed, which were comprehensively reviewed with the corresponding mechanisms meticulously discussed. The results showed that the chemical oxidation and interaction with microorganisms of FNA played the core role in improving resource utilization. Furthermore, current challenges and future prospects of the FNA-based applications were outlined. It is expected that this review can refine the theoretical framework of FNA-based processes, providing a theoretical foundation and technical guidance for the large-scale demonstration of FNA.

Fulvic acid-mediated efficient anaerobic digestion for kitchen wastewater: Electrochemical and biochemical mechanisms

Fulvic acid, prevalent in humus derived from the anaerobic digestion of kitchen wastewater, is crucial in organic matter transformation. However, its effects and underlying mechanisms remain unclear. In this study, the fate of anaerobic digestion of artificial and kitchen wastewater with different fulvic acid contents was investigated. The results showed that 125 mg/L fulvic acid resulted in a 64.02 and 51.72 % increase in methane production in synthetic and kitchen wastewater, respectively. Fulvic acid acted as an electron mediator and increased substrate oxidation by boosting NAD and ATP levels, thereby increasing microbial metabolic rates and ensuring an adequate substrate for methane generation. Isotope analysis suggested that fulvic acid boosts the conversion of volatile fatty acids to methane via the interspecies electron transfer pathway. Gene expression analysis revealed that cytochrome c, FAD, and other electron transport coenzymes were upregulated by fulvic acid, thereby enhancing substrate utilisation and biogas quality. Fulvic acid presented a dual stimulatory and inhibitory effect on anaerobic digestion, with concentrations over 125 mg/L diminishing its positive impact. This dual effect may stem from the properties and concentrations of fulvic acid. This study revealed the effect mechanism of fulvic acid and provided insights into the humus performance in anaerobic digestion.

The Impact of Bisphenol A on the Anaerobic Sulfur Transformation: Promoting Sulfur Flow and Toxic H2S Production

Bisphenol A (BPA), as a typical leachable additive from microplastics and one of the most productive bulk chemicals, is widely distributed in sediments, sewers, and wastewater treatment plants, where active sulfur cycling takes place. However, the effect of BPA on sulfur transformation, particularly toxic H2S production, has been previously overlooked. This work found that BPA at environmentally relevant levels (i.e., 50-200 mg/kg total suspended solids, TSS) promoted the release of soluble sulfur compounds and increased H2S gas production by 14.3-31.9%. The tryptophan-like proteins of microbe extracellular polymeric substances (EPSs) can spontaneously adsorb BPA, which is an enthalpy-driven reaction (ΔH = -513.5 kJ mol-1, ΔS = -1.60 kJ mol-1K -1, and ΔG = -19.52 kJ mol-1 at 35 °C). This binding changed the composition and structure of EPSs, which improved the direct electron transfer capacity of EPSs, thereby promoting the bioprocesses of organic sulfur hydrolysis and sulfate reduction. In addition, BPA presence enriched the functional microbes (e.g., Desulfovibrio and Desulfuromonas) responsible for organic sulfur mineralization and inorganic sulfate reduction and increased the abundance of related genes involved in ATP-binding cassette transporters and sulfur metabolism (e.g., Sat and AspB), which promoted anaerobic sulfur transformation. This work deepens our understanding of the interaction between BPA and sulfur transformation occurring in anaerobic environments.

Occurrence, spatiotemporal trends, fate, and treatment technologies for microplastics and organic contaminants in biosolids: A review

This review provides a comprehensive overview of the occurrence, fate, treatment and multi-criteria analysis of microplastics (MPs) and organic contaminants (OCs) in biosolids. A meta-analysis was complementarily analysed through the literature to map out the occurrence and fate of MPs and 10 different groups of OCs. The data demonstrate that MPs (54.7% occurrence rate) and linear alkylbenzene sulfonate surfactants (44.2% occurrence rate) account for the highest prevalence of contaminants in biosolids. In turn, dioxin, polychlorinated biphenyls (PCBs) and phosphorus flame retardants (PFRs) have the lowest rates (<0.01%). The occurrence of several OCs (e.g., dioxin, per- and polyfluoroalkyl substances, polycyclic aromatic hydrocarbons, pharmaceutical and personal care products, ultraviolet filters, phosphate flame retardants) in Europe appear at higher rates than in Asia and the Americas. However, MP concentrations in biosolids from Australia are reported to be 10 times higher than in America and Europe, which required more measurement data for in-depth analysis. Amongst the OC groups, brominated flame retardants exhibited exceptional sorption to biosolids with partitioning coefficients (log Kd) higher than 4. To remove these contaminants from biosolids, a wide range of technologies have been developed. Our multicriteria analysis shows that anaerobic digestion is the most mature and practical. Thermal treatment is a viable option; however, it still requires additional improvements in infrastructure, legislation, and public acceptance.

Comparison of anaerobic digestion of starch- and petro-based bioplastic under hydrogen-rich conditions

To identify an economically viable waste management system for bioplastics, thermoplastic starch (TPS) and poly(butylene adipate-co-terephthalate) (PBAT) were anaerobically digested under hydrogen (H2)/carbon dioxide (CO2) and nitrogen (N2) gas-purged conditions to compare methane (CH4) production and biodegradation. Regardless of the type of bioplastics, CH4 production was consistently higher with H2/CO2 than with N2. The highest amount of CH4 was produced at 307.74 mL CH4/g volatile solids when TPS digested with H2/CO2. A stepwise increased in CH4 yield was observed, with a nominal initial increment followed by accelerated methanogenesis conversion as H2 was depleted. This may be attributed to a substantial shift in the microbial structure from hydrogenotrophic methanogen (Methanobacteriales and Methanomicrobiales) to heterotrophs (Spirochaetia). In contrast, no significant change was observed with PBAT, regardless of the type of purged gas. TPS was broken down into numerous derivatives, including volatile fatty acids. TPS produced more byproducts with H2/CO2 (i.e., 430) than with N2 (i.e., 320). In contrast, differential scanning calorimetry analysis on PBAT revealed an increase in crystallinity from 10.20 % to 12.31 % and 11.36 % in the H2/CO2- and N2-purged conditions, respectively, after 65 days of testing. PBAT surface modifications were characterized via Fourier transform infrared spectroscopy and scanning electron microscopy. The results suggest that the addition of H2/CO2 can enhance the CH4 yield and increase the breakdown rate of TPS more than that of PBAT. This study provides novel insights into the CH4 production potential of two bioplastics with different biodegradabilities in H2/CO2-mediated anaerobic digestion systems.

Pretreatment of free nitrous acid combined with calcium hypochlorite for enhancement of hydrogen production in waste activated sludge

A variety of variables limit the recovery of resources from anaerobic fermentation of waste activated sludge (WAS), hence pretreatment strategies are necessary to be investigated to increase its efficiency. A combination of free nitrous acid (FNA) and calcium hypochlorite [Ca(ClO)2] was employed in this investigation to significantly improve sludge fermentation performance. The yields of cumulative hydrogen for the blank and FNA treatment group were 1.09 ± 0.16 and 7.36 ± 0.21 mL/g VSS, respectively, and 6.59 ± 0.24 [0.03 g Ca(ClO)2/g TSS], 7.75 ± 0.20 (0.06), and 8.58 ± 0.22 (0.09) mL/g VSS for the Ca(ClO)2 groups. The co-treatment greatly boosted hydrogen generation, ranging from 39.97 ± 2.26 to 76.20 ± 4.78 % as compared to the solo treatment. Mechanism analysis demonstrated that the combined treatment disturbed sludge structure and cell membrane permeability even more, which released more organic substrates and enhanced biodegradability of fermentation broth. This paper describes a unique strategy to sludge pretreatment that expands the use of Ca(ClO)2 and FNA in anaerobic fermentation, with implications for sludge disposal and energy recovery.

Characterization and removal mechanism of a novel enrofloxacin-degrading microorganism, Microbacterium proteolyticum GJEE142 capable of simultaneous removal of enrofloxacin, nitrogen and phosphorus

In the study, a novel ENR-degrading microorganism, Microbacterium proteolyticum GJEE142 was isolated from aquaculture wastewater for the first time. The ENR removal of strain GJEE142 was reliant upon the provision of limited additional carbon source, and was adaptative to low temperature (13 ℃) and high salinity (50‰). The ENR removal process, to which intracellular enzymes made more contributions, was implemented in three proposed pathways. During the removal process, oxidative stress response of strain GJEE142 was activated and the bacterial toxicity of ENR was decreased. Strain GJEE142 could also achieve the synchronous removal of ammonium, nitrite, nitrate and phosphorus with the nitrogen removal pathways of nitrate → nitrite → ammonium → glutamine → glutamate → glutamate metabolism and nitrate → nitrite → gaseous nitrogen. The phosphorus removal was implemented under complete aerobic conditions with the assistance of polyphosphate kinase and exopolyphosphatase. Genomic analysis provided corresponding genetic insights for deciphering removal mechanisms of ENR, nitrogen and phosphorus. ENR, nitrogen and phosphorus in both actual aquaculture wastewater and domestic wastewater could be desirably removed. Desirable adaptation, excellent performance and wide distribution will make strain GJEE142 the hopeful strain in wastewater treatment.

Molten salt strategy to activate biochar for enhancing biohydrogen production

Generally, dark fermentation (DF) of hydrogen (H₂) synthesis has low H₂ production from industrial-scale plant. In this study, campus greening wastes-ginkgo leaves were used to produce molten salt-modified biochar (MSBC) and nitrogen (N₂)-atmosphere BC (NBC) in molten salt and N₂ environment at 800 °C, respectively. MSBC showed excellent properties including high specific surface area and electron transfer ability. After supplementation with MSBC, H₂ yield rose by 32.4% compared to the control group without carbon material. Electrochemical analysis revealed MSBC improved the electrochemical properties of sludge. Furthermore, MSBC optimized the microbial community structure and increased the relative abundance of dominant microbes, thus promoting H₂ production. This work is provide the deep understanding of two carbons that play vital roles in increasing microbial biomass, supplementing trace element and favoring electron transfer in DF reactions. Salt recovery achieved 93.57% in molten salt carbonization, which has sustainability compared with N₂-atmosphere pyrolysis.

Phenanthrene regulates metabolic pathways for hydrogen accumulation in sludge alkaline dark fermentation

The influence of phenanthrene (PHE), a general polycyclic aromatic hydrocarbon in waste activated sludge, on sludge alkaline dark fermentation for hydrogen accumulation was investigated prospectively. The yield of hydrogen was 16.2 mL/g TSS with 50 mg/kg TSS PHE, which was 1.3-fold greater than that of the control. Mechanism research demonstrated that hydrogen production and the abundance of functional microorganisms were facilitated, whereas those of homoacetogenesis were reduced. The activity of pyruvate ferredoxin oxidoreductase in the conversion of pyruvate to reduced ferredoxin for hydrogen production was promoted by 57.2%, and that of carbon monoxide dehydrogenase and formyltetrahydrofolate synthetase, closely associated with hydrogen consumption, was suppressed by 60.5% and 55.9%, respectively. Moreover, the encoding genes involved in pyruvate metabolism were significantly up-regulated, while genes related to consuming hydrogen to reduce carbon dioxide and produce 5-methyltetrahydrofolate were down-regulated. This study notably illustrates the effect of PHE on hydrogen accumulation from metabolic pathways.

Effect and mechanism of benzalkonium bromide on short chain fatty acid production from anaerobic sludge fermentation process

Quaternary ammonium compounds (QACs) was frequently detected in wastewater treatment plants and leads to potential toxicity to the related biological processes. In this study, the effect of benzalkonium bromide (BK) on anaerobic sludge fermentation process for short chain fatty acid (SCFAs) production was investigated. Batch experiments indicated that BK exposure significantly enhanced the SCFAs production from anaerobic fermentation sludge and the maximum concentration of total SCFAs increased from 474.40 ± 12.35 mg/L to 916.42 ± 20.35 mg/L with BK increasing from 0 to 8.69 mg/g VSS. Mechanism exploration exhibited that the presence of BK enhanced much more bioavailable organic matters release, little affected on hydrolysis, acidification, but seriously inhibited methanogenesis. Microbial community investigation revealed that BK exposure importantly enhanced the relative abundances of hydrolytic-acidifying bacteria and also improved the metabolic pathways and functional genes for sludge lysis. This work further supplement the information for environmental toxicity of emerging pollutants.

Effect of nitrite on hydrolysis-acidification, biogas production and microbial community in semi-continuous two-phase anaerobic digestion of sewage sludge

Previous study found that the pre-treatment of sewage sludge with nitrite improves the biogas production during the mono/two-phase anaerobic digestion (AD) using batch biochemical methane potential tests. In this study, the effects of nitrite on hydrolysis-acidification, biogas production, volatile solids destruction and microbial composition in semi-continuous two-phase AD of sewage sludge were investigated. The addition of nitrite promotes sludge organic matter solubilization (+484%) and VFAs production (+98.9%), and causes an increase in the VS degradation rate during the AD process (+8.7%). The comparison of biogas production from the acidogenic and methanogenic reactors with or without the addition of nitrite implies that the nitrite has no significant effect on the overall biogas production of two-phase sludge AD process. High-throughput sequencing analysis shows that the microbial communities of bacteria and archaea in two-phase AD reactors significantly changes after the addition of nitrite. Vulcanibacillus (bacteria) and Candidatus Methanofastidiosum (archaea) become the dominant genera in the acidogenic and methanogenic reactors with the nitrite respectively. These findings provide new insights about using nitrite to promote the organic matter degradation of sewage sludge in a semi-continuous two-phase AD system.

A novel strategy for efficiently transforming waste activated sludge into medium-chain fatty acid using free nitrous acid

The global energy crisis is approaching due to rapid population growth and overexploitation of fossil fuels. Therefore, the development and use of new and renewable energy sources is already in the extreme urgency. This work developed a novel technology to efficiently produce renewable liquid bioenergy from discarded wastes, by effectively transforming sewage sludge into high-value medium chain fatty acids (MCFA). The maximum MCFA yield in the anaerobic sludge fermentation was revealed to be 10.6 times of control when utilizing sewage sludge with 1.78 mg-N/L free nitrous acid (FNA) pretreatment. The carbon flow from sewage sludge into MCFA in the fermentation system was significantly enhanced with appropriate levels (0.71-1.78 mg-N/L) of FNA pretreatment. Compared to FNA pretreatment, however, its direct addition severely inhibited total products (i.e., carboxylates and complex alcohols) generation because of the toxicity on live cells (decreasing to 8.3 %-13.9 %) in sludge. Kinetic models (one-substrate and two-substrate) were utilized to investigate the mechanism of MCFA promotion by FNA pretreatment on anaerobic sludge fermentation, in which linear relationship analysis between FNA-derived organic release and the fitted parameters were also performed. The results indicated that the conversion of refractory materials into rapidly bioavailable substrates for MCFA production contributed to increasing MCFA production rate and potential. Moreover, the relative abundances of functional microorganisms related to hydrolysis-acidification and chain elongation process increased under FNA pretreatment, further favoring the MCFA production. This study provides a novel and effective technology of sludge energy recovery that can achieve the next-generation sustainable sewage sludge management.

Insights into the role of chitosan in hydrogen production by dark fermentation of waste activated sludge

Chitosan is widely used as a dewatering flocculant, but whether it affects hydrogen production from sludge anaerobic fermentation is unclear. This study aimed to elucidate the role of chitosan in the dark fermentation of waste activated sludge for hydrogen production. The results showed that chitosan had a negative effect on hydrogen production from sludge. Chitosan at 30 g/kg total suspended solids reduced hydrogen accumulation by 56.70 ± 1.22 % from 3.94 ± 0.12 to 1.71 ± 0.10 mL/g volatile suspended solids. Chitosan hindered the solubilization of sludge by flocculation, which reduced the available substrate for anaerobic fermentation. In addition, chitosan interfered with the electron transport system by reducing cytochrome C and caused lipid peroxidation by inducing reactive oxygen species, thereby inhibiting the activity of enzymes involved in anaerobic fermentation. Hydrogen production was reduced because hydrogen-producing processes (i.e., hydrolysis, acidification, and acetification) were inhibited more strongly than hydrogen-consuming processes (i.e., methanogenesis, sulfate reduction, and homoacetogenesis). Furthermore, chitosan enriched the abundance of Spirochaetaceae sp. and Holophagaceae sp., which occupied the survival space of hydrogen-producing microorganisms. This study reveals the potential impact of chitosan on hydrogen production in dark fermentation of sludge and provide direct evidence that chitosan triggers oxidative stress in anaerobic fermentation.

Polycarbonate microplastics induce oxidative stress in anaerobic digestion of waste activated sludge by leaching bisphenol A

Polycarbonate (PC) microplastics are frequently detected in waste activated sludge. However, understanding the potential impact of PC microplastics on biological sludge treatment remains challenging. By tracking the changes in methane production under different concentrations of PC microplastics, a dose-dependent effect of PC microplastics on anaerobic digestion of sludge was observed. PC microplastics at 10-60 particles/g total solids (TS) improved methane production by up to 24.7 ± 0.1 % (at 30 particles/g TS), while 200 particles/g TS PC microplastics reduced methane production by 8.09 ± 0.1 %. Bisphenol A (BPA) leached from 30 particles/g TS PC microplastics (1.26 ± 0.18 mg/L) down-regulated intracellular reactive oxygen species (ROS) production, thereby enhancing enzyme activity, biomass viability, and abundance of methanogenic (Methanobacterium sp. and Methanosarcina sp.), ultimately boosting methane production. Conversely, BPA leached from 200 particles/g TS PC microplastics (4.02 ± 0.15 mg/L) stimulated ROS production, resulting in decreased biomass viability and even apoptosis. Modulation of oxidative stress by leaching monomeric BPA is an underappreciated transformative mechanism for improving the mastery of the potential behavior of microplastics in biological sludge treatment.

Enhanced mesophilic fermentation of waste activated sludge by integration with in-situ nitrate reduction

This study investigated the reduction of nitrate in a mesophilic waste activated sludge (WAS) fermentation system and determined the effect of nitrate reduction on the hydrolysis, acidogenesis and acetogenesis. Experimental results showed that the initial nitrate concentrations of 100, 200 and 400 mg/L were completely reduced in 1, 2 and 7 days, respectively. The destruction of volatile suspended solids was 1.2, 1.8 and 2.8 times, respectively, that without nitrate, demonstrating nitrate promoted the release of organic matter in sludge and enhanced the biodegradability of sludge organics. Moreover, batch tests using model substrates illustrated nitrate reduction promoted sludge hydrolysis and acetogenesis, but slightly inhibited acidogenesis. This study offers a feasible method to address two major problems currently faced by biological wastewater treatment plants, i.e. the overabundance of WAS and the lack of carbon sources for the denitrification process.

Wastewater-derived biohydrogen: Critical analysis of related enzymatic processes at the research and large scales

Organic-rich wastewater is a feasible feedstock for biohydrogen production. Numerous review on the performance of microorganisms and the diversity of their communities during a biohydrogen process were published. However, there is still no in-depth overview of enzymes for biohydrogen production from wastewater and their scale-up applications. This review aims at providing an insightful exploration of critical discussion in terms of: (i) the roles and applications of enzymes in wastewater-based biohydrogen fermentation; (ii) systematical introduction to the enzymatic processes of photo fermentation and dark fermentation; (iii) parameters that affect enzymatic performances and measures for enzyme activity/ability enhancement; (iv) biohydrogen production bioreactors; as well as (v) enzymatic biohydrogen production systems and their larger scales application. Furthermore, to assess the best applications of enzymes in biohydrogen production from wastewater, existing problems and feasible future studies on the development of low-cost enzyme production methods and immobilized enzymes, the construction of multiple enzyme cooperation systems, the study of biohydrogen production mechanisms, more effective bioreactor exploration, larger scales enzymatic biohydrogen production, and the enhancement of enzyme activity or ability are also addressed.

Long-term impacts of polyethylene terephthalate (PET) microplastics in membrane bioreactor

Due to the mass production and daily use of plastic products, the potential toxicity of microplastics to the water environment has attracted worldwide attention. In this work, the effect of typical microplastics (PET) on the performance of activated sludge from membrane bioreactors (MBR) was evaluated. The impacts on biological removal efficiency were unconspicuous with continuous dosing of 60 particles/L. However, further investigations revealed that PET particle accumulation caused adverse impacts on settleability and dewaterability. The SVI value increased from 53.3 ml/g MLSS to 69.9 ml/g MLSS and the CST in the PET reactor increased by 22%. Nevertheless, hydrophobicity was reduced by 49.2%. Mechanism studies exposed that the PET microplastics accumulation improved extracellular polymeric substances (EPS) from 116.96 mg/L to 138.70 mg/L and caused cell membrane damage. The abundance and diversity of microbial community reduced in activated sludge in PET reactor compared with control reactor. These phenomena revealed a possible hypothesis that the microplastic particles increased EPS and cytotoxicity of activated sludge. However, the rate of transmembrane pressure (TMP) build-up was significantly mitigated in PET-MBR compared to that in a control-MBR (1.27 folds), which attributes that physical scour of particles may still alleviate membrane contamination in MBR.

Recent updates in biohydrogen production strategies and life-cycle assessment for sustainable future

Biohydrogen (bio-H₂) is regarded as a clean, non-toxic, energy carrier and has enormous potential for transforming fossil fuel-based economy. The development of a continuous high-rate H₂ production with low-cost economics following an environmentally friendly approach should be admired for technology demonstration. Thus, the current review discusses the biotechnological and thermochemical pathways for H₂ production. Thermochemical conversion involves pyrolysis and gasification routes, while biotechnological involves light-dependent processes (e.g., direct and indirect photolysis, photo/ dark fermentation strategies). Moreover, environmentally friendly technologies can be created while utilizing renewable energy sources including lignocellulosic, wastewater, sludge, microalgae, and others, which are still being developed. Lifecycle assessment (LCA) evaluates and integrates the economic, environmental, and social performance of H₂ production from biomass, microalgae, and biochar. Moreover, system boundaries evaluation, i.e., global warming potential, acidification, eutrophication, and sensitivity analysis could lead in development of sustainable bioenergy transition with high economic and environmental benefits.

Polystyrene microplastics and nanoplastics distinctively affect anaerobic sludge treatment for hydrogen and methane production

Microplastics and nanoplastics generally accumulated in waste activated sludge (WAS) after biological wastewater treatment. Currently, researches mainly focused on how plastics affected a particular sludge treatment method, without the comparison of different sludge systems. Herein, distinct responses of hydrogen-producing and methane-producing sludge systems were comprehensively evaluated with polystyrene microplastics (PS-MPs) and nanoplastics (PS-NPs) existence. Experimental results showed that PS particles would stimulate inhibition on anaerobic gas production except that PS-MPs were conducive to hydrogen accumulation, which was caused by the enhanced solubilization. Mechanistic investigation demonstrated that severe inhibition of PS-NPs to hydrogen production was derived from the excessively inhibitory hydrolysis despite of improving solubilization. Varying degrees of inhibition to acidification and methanation collectively contributed to reduced methane accumulation with exposure to PS-MPs and PS-NPs. Excessive oxidative stress would be generated in the presence of PS-MPs or PS-NPs, deteriorating microbial activities and richness of species responsible for hydrogen or methane production.

Densification pretreatment triggers efficient methanogenic performance and robust microbial community during anaerobic digestion of corn stover

The recalcitrant characteristics of lignocellulosic waste and difficulties in biomass transportation and storage severely limit bioenergy production through anaerobic digestion (AD). In this study, Densifying Lignocellulosic biomass with Chemicals (DLC) pretreatment was developed to address these issues. The results showed that DLC treated corn stover (CS) reached a cumulative methane yield of as high as 224.30 mL/g VS (Volatile Solids), which was 59.27 % higher than that of un-treated. The reduced scum formation in the reactor, increased components consumption of solid phase, and higher organic biodegradability of liquid phase in AD of DLC treated CS enhanced methane yield. Microbial analysis indicated that DLC pretreatment affected the bacterial and methanogenic community structure, and a co-network with Comamonas and Methanobacterium, etc. as hub microbes was constructed. This study proposed a promising technology that could be potentially applied to industrial AD of lignocellulosic biomass.

Potato peel waste for fermentative biohydrogen production using different pretreated culture

How to manage potato peel waste sustainably has been an issue faced by the potato industry. This work explored the feasibility of potato peel waste for biohydrogen production via dark fermentation, and investigated the effects of various inoculum enrichment methods (acid, aeration, heat-shock and base) on the process efficiency. It was observed that the hydrogen production showed a great variation when using various inoculum enrichment methods, and the aeration enriched inoculum obtained the maximum hydrogen yield of 71.0 mL/g-VS_added and VS removal of 28.9 %. Different enriched cultures also exhibited huge variations in the bacterial community structure and metabolic pathway. The highest abundance of Clostridium sensu stricto fundamentally contributed to the highest process efficiency for the fermenter inoculated with aeration treated culture. This work puts forward a promising strategy for recycling potato peel waste, and fills a gap in the optimal inoculum preparation method for biohydrogen fermentation of potato peel waste.

Uncovering the effect of polyethyleneimine on methane production in anaerobic digestion of sewage sludge

The potential effect of polyethyleneimine as a flocculant on anaerobic digestion of sludge was investigated. Polyethyleneimine above 12 g/kg total suspended solids inhibited the entire anaerobic digestion process including solubilization, hydrolysis, acidification, and methanogenesis. The addition of 24 g/kg total suspended solids polyethyleneimine reduced methane production from 167 ± 5 L/kg volatile suspended solids in the control reactor (without polyethyleneimine) to 141 ± 5 L/kg volatile suspended solids. Polyethyleneimine bound to extracellular polymeric substances, thus enhancing sludge agglomeration and hindering the release of organics. Meanwhile, the reduction of cytochrome C impeded electron transport, consequently curbed direct interspecies electron transfer. The adsorption of carbon dioxide by amine groups also hampered methane conversion. This study elucidated the concept that polyethyleneimine reduces mass transfer in anaerobic digestion, providing new insights into the potential behavior of flocculants in sludge treatment.

Deep insights into the anaerobic co-digestion of waste activated sludge with concentrated leachate under different salinity stresses

Treatment of high-salinity organic wastewater (e.g., concentrated leachate) is a major challenge. Anaerobic co-digestion can effectively treat high-salinity organic wastewater and recover energy. In this study, the concentrated landfill leachate and waste activated sludge (WAS) were anaerobic co-digested in the lab-scale continuous stirred tank reactors (CSTR) to understand their co-digestion performance under different salinity stresses. As revealed by the results, when the salinity was low (<10 g/L), the removal ratio of organic matter in the digester was kept at a high level (>91.3%), and the concentration of total volatile fatty acids (TVFAs) was low (<100 mg COD/L), indicating that the digester could operate efficiently and stably. However, when the salinity level was elevated from 10 g/L to 30 g/L, the removal ratio of organic matter in the digester decreased from ~91.3% to ~64.5%, the TVFAs continued to accumulate, the yields of biogas and methane also dropped sharply, and the performance of the digester decreased gradually. The results of microbial community and diversity analysis showed that there is limited adaptability of microbial community to high salinity in such process. Salinity could cause significant changes in the microbial community and diversity, thereby affecting the digestive performance. Metagenomic analysis showed that under high salinity conditions, the content of genes encoding hydrolase and methanogenic enzyme decreased, whereas the pathway of acetotrophic methanogenesis was weakened. Mechanism study showed that with the increase of salinity, the activity of microbial cells decreased, the structure of sludge flocs was damaged more significantly, and the extracellular polymeric substances (EPS) secreted by microbe increased continuously, which was used to resist the toxic effects of salinity stresses on microorganisms. The results of this study could provide certain theoretical guidance for anaerobic digestion under salinity stresses.

Microbial and physicochemical responses of anaerobic hydrogen-producing granular sludge to polyethylene micro(nano)plastics

Micro(nano)plastics is an emerging contaminant in wastewater that has showed significant impacts on various biological treatment processes. Nevertheless, the underlying effects of micro(nano)plastics with different concentrations and sizes on the anaerobic hydrogen-producing granular sludge (HPG) were still unclear. This work firstly attempted to illustrate the microbial and physicochemical responses of HPG to a shock load of polyethylene microplastics (PE-MPs) with varied concentrations and sizes. The results revealed that the PE-MPs inhibitory effect on hydrogen production by HPG was both concentration- and size-dependent. Specifically, the increase of PE-MPs concentration and the decline of PE-MPs size to nano-sized plastics (NPs) significantly decreased the hydrogen yield, downgraded to 79.9 ± 2.6% and 63.0 ± 3.9% (p = 0.001, and 0.0002) of control, respectively, at higher MPs concentration and the smaller MPs size (i.e., NPs). The higher PE-MPs concentration and PE-NPs also suppressed extracellular polymeric substances (EPS) generation more severely. The critical bio-processes involved in hydrogen production were disturbed by PE-MPs, with the extent of negative impacts depending on the dosage and size of PE-MPs. These adverse impacts further manifested as granule disintegration and loss of cellular activity. Mechanism analysis highlighted the roles of oxidative stress, leachate released from PE-MPs, interaction between PE-NPs and granules inducing physical crushing of HPG that led to possible direct contact between cells and toxic substances.

Responses of anaerobic hydrogen-producing granules to acute microplastics exposure during biological hydrogen production from wastewater

Anaerobic hydrogen-producing granule (AHPG) has been successfully applied in hydrogen production from wastewater. While various types of microplastics in large amounts are readily detected in both municipal and industrial wastewaters, however, to date the response of AHPG to multiple coexisting microplastics in wastewater is unknown yet. Herein, this study provided a first insight into the acute exposure-response relationship between multiple coexisting microplastics and the AHPG during biological hydrogen production from wastewater. Fluorescence tagging found that many microplastics accumulated and covered on the surface of the whole granule. Morphology and particle size of microplastics-bearing AHPG were characterized by microscopic observation, showing that the shock load of microplastics in the wastewater at the studied concentrations (40 and 80 mg/L) made the granule loose and even break down with the decreased particle size. The visualization of extracellular polymeric substances (EPS) structure revealed that microplastics decreased EPS production by 8.8-16.7%. Microbial community analysis demonstrated that the acute exposure of microplastics did not drive the change in the microbial community diversity and composition. However, toxic leachates and upgraded oxidative stress induced by microplastics increased cell death up to 14.7% and decreased hydrogen production by 18.7%, when the AHPG exposed to 80 mg/L of microplastics. This work gained a new insight into the response of anaerobic microorganisms to coexisting microplastics in the real environment.

Microbial compositions, ecological networks, and metabolomics in sediments of black-odour water in Dongguan, China

Black-odour water with organic compounds and heavy metals caused by domestic and industrial activities has aroused people's attention in recent years, yet little is known about the ecological effects on aquatic organisms, especially microorganisms in sediments. To explore the response of microbial communities to environmental factors, the community and metabolites of nine river sediments with different pollution in Dongguan city, China were investigated using 16S rRNA gene sequencing and liquid chromatography tandem-mass. The results revealed that the composition and structure of sedimentary microbial communities significantly changed in rivers with varying pollution levels. Cyanobacteria were the most abundant organisms in the sediment of black-odorous rivers, while the relative abundance of Thaumarchaeota was gradually increased with the river quality gets better. The relative abundance of organic acids (including amino acids), alcohols, esters, and ketones associated with microbial metabolism in sediments of polluted rivers was increased. The 16S rRNA gene sequencing-based molecular ecological network analysis indicated that the interactions amongst bacteria were enhanced in severely contaminated communities. Sphingomonadaceae and Cyanobacteria have important roles in bacterial community structures of polluted rivers and those with ongoing treatment. The correlation analysis showed significant metal resistance and/or tolerance of the following bacteria species Thalassiosira weissflogii, Aminicenantes bacterium clone OPB95, 'Candidatus Halomonas phosphatis', and archaeal species Methanolinea and unidentified Thermoplasmata. These results indicated that sedimentary microbial communities may shift in composition and structure, as well as their interaction network, to adapt and resist environmental contamination and promote restoration.

Effect of pH on the performance of hydrogen production by dark fermentation coupled denitrification

High concentration nitrogen-containing organic wastewater is a potential substrate for hydrogen production by dark fermentation. In this study, the effect of initial pH on the performance of hydrogen production by dark fermentation coupled denitrification was investigated. The hydrogen production, liquid metabolites, nitrate, nitrite and microbial community were monitored under the condition of pH varying from 4 to 11. Results showed that the highest hydrogen production (70.94 ± 4.750 mL/g VSS), chemical oxygen demand (COD) removal rate (37.13 ± 1.86%) and nitrate reduction rate (1.57 ± 0.27 mg/L/h) were obtained at pH of 5. Under this condition, the nitrate was mainly reduced to N₂ with hydrogen as the electron donor. When the initial pH was 6-11, nitrate mainly reduced to N₂ through co-action with acetate. Microbial community analysis revealed that as the initial pH increased from 4 to 11, the main hydrogen-producing microorganisms were gradually converted from Clostridium sensu stricto 12 sp. into Clostridium sensu stricto 1 sp, which leaded to changes in the hydrogen production process.

Intermittent pH control strategy in sludge anaerobic fermentation: Higher short-chain fatty acids production, lower alkali consumption, and simpler control

The pH control to promote short-chain fatty acids (SCFAs) production during anaerobic alkaline fermentation basically focused on constant pH control. In this study, a simple and consumption-reducing intermittent pH control strategy at moderate temperature (23 ± 2 °C) was investigated with adjusting pH to 10 when naturally reduced to 8. The intermittent pH control strategy could alleviate the inhibition of acid-producing bacteria by strong alkaline and high FA concentration. Meanwhile, microbial diversity promoted by 6% and 69% while the relative abundance of acid-producing bacteria increased by 36% and 61% compared to blank and constant pH fermenters. The relative genes abundance related to amino acid metabolism and fatty acid production were mostly promoted and led to enhanced SCFAs production. In the long-term fermenter, the intermittent pH control strategy could result in a 68% reduction in alkali consumption and a 37% increase in SCFAs production compared to that of the constant pH at 10.

Effect of sodium dodecylbenzene sulfonate on hydrogen production from dark fermentation of waste activated sludge

Sodium dodecylbenzene sulfonate (SDBS), a typical surfactant being widely used in various applications, was highly accumulated in waste activated sludge. To date, however, its effect on hydrogen production from dark fermentation of sludge has not been documented. The work therefore aimed to explore whether and how SDBS affects hydrogen production. Experimental results showed that with an increase of SDBS from 0 to 30 mg/g TSS, the maximal hydrogen yield increased from 2.47 to 10.73 mL/g VSS (without any treatment) and from 13.05 to 23.51 mL/g VSS (under free ammonia pretreatment). Mechanism exploration showed that SDBS lowered surface tension, facilitated organics transfer from solid to liquid. SDBS also destroyed hydrogen bonding networks of protein, promoted macromolecular organics degradation. Besides, SDBS improved the electric charge in organics, then weakened the mutual repulsion, improved adsorb, interact and promoted the availability of reaction sites between anaerobes and organic substances. Enzyme activity analysis showed that SDBS not only improved the activities of enzymes related to hydrolysis and acidification processes, but also inhibited the activities of homoacetogens and methanogens. SDBS presence lowered sludge ORP and created an environment which was helpful to the growth of butyric-type bacteria, thus enhanced butyric-type fermentation, which contributed hydrogen production largely. Microbial community analysis revealed that SDBS existence affected distributions of microbial populations, and increased the abundances of hydrogen producing microorganisms (e.g., unclassified_f_Synergistaceae). PICRUSt2 analysis showed that SDBS reduced hydrogenotrophic methanogens activity for its inhibitory effect on the biotransformation of 5,10-Methenyl-THMPT to 5-methyl-THMPT.

Achieving enhanced biological phosphorus removal utilizing waste activated sludge as sole carbon source and simultaneous sludge reduction in sequencing batch reactor

Achieving enhanced biological phosphorus removal dominated by Tetrasphaera utilizing waste activated sludge (WAS) as carbon source could solve the problems of insufficient carbon source and excessive discharge of WAS in biological phosphorus removal. Up to now, the sludge reduction ability of Tetrasphaera remained largely unknown. Furthermore, the difference between traditional sludge fermentation and sludge fermentation dominated by Tetrasphaera was still unclear. In this study, two different sequencing batch reactors (SBRs) were operated. WAS from SBR-parent was utilized as sole carbon source to enrich Tetrasphaera with the relative abundance of 91.9% in SBR-Tetrasphaera. PO₄^3--P removal and sludge reduction could simultaneously be achieved. The effluent concentration of PO₄^3--P was 0, and the sludge reduction efficiency reached about 44.14% without pretreatment of sludge. Cell integrity detected by flow cytometry, the increase of DNA concentration in the sludge supernatant and decrease of particle size of activated sludge indicated that cell death and lysis occurred in sludge reduction dominated by Tetrasphaera. Stable structure of activated sludge was also damaged in this process, which led to the sludge reduction. By analyzing the excitation-emission matrix spectra of extracellular polymeric substances and the changes of carbohydrate and protein concentration, this study proved that slowly biodegradable organics (e.g., soluble microbial byproduct, tyrosine and tryptophan aromatic protein) could be better hydrolyzed and acidized to volatile fatty acids (VFAs) in sludge fermentation dominated by Tetrasphaera than traditional sludge fermentation, which provided carbon source for biological nutrients removal and saved operation cost in wastewater treatment.

Different Pathways of Microplastics Entering the Sludge Treatment System Distinctively Affect Anaerobic Sludge Fermentation Processes

Microplastics in wastewater inevitably accumulate in waste activated sludge (WAS) via wastewater biological treatment, potentially affecting the subsequent sludge treatment unit. Nevertheless, all previous research studies focused on the impacts of the direct addition of one type of model microplastics on the sludge anaerobic treatment process. This approach actually cannot reflect the real situation where multiple different microplastics simultaneously get into the wastewater treatment unit prior to the sludge treatment unit. Herein, this work innovatively proposed a more realistic method to assess the real toxic influences of microplastics on anaerobic WAS fermentation for short-chain fatty acid (SCFA) production by initially adding four typical microplastics (i.e., polyethylene terephthalate, polystyrene, and polypropylene) to the biological wastewater treatment system. Results showed that four microplastics initially entering the biological wastewater treatment reactor had little influence on the subsequent anaerobic SCFA production since WAS solubilization increased but hydrolysis and acidification decreased. In contrast, when the four microplastics were directly dosed in a WAS anaerobic fermenter, although there was no effect on WAS solubilization, the bioprocess of hydrolysis-acidification was clearly suppressed, ultimately significantly (P = 1.86 × 10-7) inhibiting the maximal SCFA production from WAS by 21.5 ± 0.1% compared to the control without microplastic addition. The excessive oxidative stress and toxic leachates from these typical microplastics reduced the relative abundances of key anaerobes (e.g., Longilinea sp.) involved in the anaerobic fermentation. This work revealed that the different pathways of microplastics entering the sludge treatment system had different impacts on anaerobic sludge fermentation processes and selecting a more realistic and accurate approach was important to evaluate the true toxicity of microplastics on the sludge anaerobic treatment system.

Effect of Fe3+ on the sludge properties and microbial community structure in a lab-scale A2O process

During biological wastewater treatment, ferric salt (Fe³⁺) usually serves as an inorganic flocculant to improve the agglomeration and sedimentation of suspended solids, and thus the removal efficiency of pollutants to meet the increasing strictly regulated wastewater discharge standards. In this study, we investigated the effects of Fe³⁺ on the removal efficiencies of pollutants, sludge properties, dominant flora and metabolic pathways of bacterial community in a classical anaerobic-anoxic-oxic (A²O) process. The results showed that a Fe³⁺ concentration lower than 10 mg·L^-1 could improve the removal efficiencies of chemical oxygen demand (COD) and total nitrogen (TN), while an inhibition effect was exerted at concentration higher than 10 mg·L^-1. The maximum removal efficiencies of COD and TN were 97% and 89%, respectively, under the critical Fe³⁺ concentration of 10 mg·L^-1. Total phosphorous (TP) removal was constantly positively correlated with Fe³⁺ concentration, due to the enhanced adsorption of phosphorus on activated sludge with the increase of surface roughness. Thauera displayed the highest relative abundance, and certain bacteria in Proteobacteria, Dehloromonas and Candidatus-Competibacter exhibited good adaptability to high concentration of Fe³⁺. In the context of metabolic collaterals, the most abundant functional gene families were identified to be Carbohydrate Metabolism, Amino Acid Metabolism, Cell Motility, Membrane Transport, and Replication and Repair. This study provides an extensive mechanistic insight into the impact of Fe³⁺ on the A²O process, which is of fundamental significance to exploit the contributions of inorganic salts to biological wastewater treatment.

Microplastic particles in the aquatic environment: A systematic review

Microplastics (MPs) pollution has become one of the most severe environmental concerns today. MPs persist in the environment and cause adverse effects in organisms. This review aims to present a state-of-the-art overview of MPs in the aquatic environment. Personal care products, synthetic clothing, air-blasting facilities and drilling fluids from gas-oil industries, raw plastic powders from plastic manufacturing industries, waste plastic products and wastewater treatment plants act as the major sources of MPs. For MPs analysis, pyrolysis-gas chromatography-mass spectrometry (Py-GC-MS), Py-MS methods, Raman spectroscopy, and FT-IR spectroscopy are regarded as the most promising methods for MPs identification and quantification. Due to the large surface area to volume ratio, crystallinity, hydrophobicity and functional groups, MPs can interact with various contaminants such as heavy metals, antibiotics and persistent organic contaminants. Among different physical and biological treatment technologies, the MPs removal performance decreases as membrane bioreactor (> 99%) > activated sludge process (~98%) > rapid sand filtration (~97.1%) > dissolved air floatation (~95%) > electrocoagulation (> 90%) > constructed wetlands (88%). Chemical treatment methods such as coagulation, magnetic separations, Fenton, photo-Fenton and photocatalytic degradation also show moderate to high efficiency of MP removal. Hybrid treatment technologies show the highest removal efficacies of MPs. Finally, future research directions for MPs are elaborated.

Evolutionary, genomic, and biogeographic characterization of two novel xenobiotics-degrading strains affiliated with Dechloromonas

Xenobiotics are generally known as man-made refractory organic pollutants widely distributed in various environments. For exploring the bioremediation possibility of xenobiotics, two novel xenobiotics-degrading strains affiliated with Azonexaceae were isolated. We report here the phylogenetics, genome, and geo-distribution of a novel and ubiquitous Azonexaceae species that primarily joins in the cometabolic process of some xenobiotics in natural communities. Strains s22 and t15 could be proposed as a novel species within Dechloromonas based on genomic and multi-phylogenetic analysis. Pan-genome analysis showed that the 63 core genes in Dechloromonas include genes for dozens of metabolisms such as nitrogen fixation protein (nifU), nitrogen regulatory protein (glnK), dCTP deaminase, C4-dicarboxylate transporter, and fructose-bisphosphate aldolase. Strains s22 and t15 have the ability to metabolize nitrogen, including nitrogen fixation, NirS-dependent denitrification, and dissimilatory nitrate reduction. Moreover, the novel species possesses the EnvZ-OmpR two-component system for controlling osmotic stress and QseC-QseB system for quorum sensing to rapidly sense environmental changes. It is intriguing that this new species has a series of genes for the biodegradation of some xenobiotics such as azathioprine, 6-Mercaptopurine, trinitrotoluene, chloroalkane, and chloroalkene. Specifically, glutathione S-transferase (GST) and 4-oxalocrotonate tautomerase (praC) in this novel species play important roles in the detoxification metabolism of some xenobiotics like dioxin, trichloroethene, chloroacetyl chloride, benzo[a]pyrene, and aflatoxin B1. Using data from GenBank, DDBJ and EMBL databases, we also demonstrated that members of this novel species were found globally in plants (e.g. rice), guts (e.g. insect), pristine and contaminated regions. Given these data, Dechloromonas sp. strains s22 and t15 take part in the biodegradation of some xenobiotics through key enzymes.

Quorum sensing shaped microbial consortia and enhanced hydrogen recovery from waste activated sludge electro-fermentation on basis of free nitrous acid treatment

In this study, the feasibility of free nitrous acid (FNA) pretreatment coupled with quorum sensing (QS) was investigated to enhance hydrogen recovery from waste activated sludge (WAS) via electro-fermentation (EF). 3-oxo-hexanoyl-homoserine lactone (3OC6-HSL), as the signal molecule, was only added in the first three cycles of sludge inoculation at the phase of microbial electrolysis cells (MECs) startup. Results showed that QS combined FNA (AHL-FMEC) enabled highest hydrogen yield and current (4.3 mg/g VSS and 4.5 mA), while that generated from sole FNA/QS treated WAS (FMEC/AHL-RMEC) were only 3.5/3.0 mg/g VSS and 1.5/1.5 mA, respectively. Fourier transform infrared (FT-IR) spectra illustrated the effective conversion of organics in AHL-FMEC, the utilization efficiencies of proteins and carbohydrates achieved to 75.0% and 79.7%, respectively. Besides, the internal resistance decreased from 34.5 Ω (FMEC) to 22.9 Ω (AHL-RMEC), further to 18.0 Ω, indicating the promoted bioelectrochemical activity of electroactive bacteria (EAB) in AHL-FMEC. Correspondingly, both EAB (21.7%), e.g., Geobacter (9.3%) and Pseudomonas (3.2%) and anaerobic fermentation bacteria (AFB, 28.6%), e.g., Proteiniclasticum (14.2%) and Petrimonas (3.6%) enriched to peaks in AHL-FMEC. Moreover, molecular ecological network (MEN) analysis revealed the underling relationships among AFB, EAB and homo-acetogen in EF system, suggesting the possible cooperative QS has been constructed. The results obtained in this study may provide a new insight for efficient hydrogen recovery from electro-fermentation of WAS.

A preliminary metatranscriptomic insight of eggshells conditioning on substrates metabolism during food wastes anaerobic fermentation

The anaerobic treatment of food wastes (FW) for resource recovery has been extensively studied. However, the information on the traits of functional genes and enzymes for substrates metabolisms and their associations with microbial community are little. In this study, the influences of eggshells conditioning on the substrates metabolism for volatile fatty acids production (VFAs) in the process of FW fermentation were investigated at genetic levels by using the metatranscriptomic approach. The obtained results suggested that the critical genes involved in the carbohydrate and protein metabolisms (i.e. pgmB, GPI, glsA, pyrB and etc.) were up-regulated in the eggshell-conditioned reactor, which were beneficial to the bioconversion of macromolecule organics during FW fermentation. Moreover, the functional genes related with the intermediate products metabolism (i.e. pyruvate acid, butanoate) also exhibited differential genetic expression levels, which resulted in the alteration of microbial metabolic pathways and contributed to the acetic and butyric acids accumulation. In addition, a preliminary association of microbial distribution and genetic expressions was analyzed. The distinct distribution of microbial community in different FW fermentation systems affected the corresponding microbial contribution to those genetic expression levels of metabolic enzymes involved in VFAs production. This study would provide new insights of the underlying mechanism of VFAs promotion in the eggshell-conditioned FW fermentation process from the perspectives of substrates metabolisms at genetic and functional traits.

Simultaneous aerobic removal of phosphorus and nitrogen by a novel salt-tolerant phosphate-accumulating organism and the application potential in treatment of domestic sewage and aquaculture sewage

Phosphorus (P) and nitrogen (N) pollution are the worldwide challenging problem. In the present study, a new salt-tolerant phosphate-accumulating organism (PAO) was isolated and identified as Bacillus subtilis GHSP10. Strain GHSP10 did not produce hemolysin and showed high susceptibility to antibiotics. The favorable phosphorus removal C/N ratios, P/N ratios, temperature, salinities, pH values and shaking speeds of strain GHSP10 were 10-20, 0.1-0.2, 28 °C, 0-3%, 7.5-8.5 and 100-250 r/min. Besides, strain GHSP10 could conduct heterotrophic nitrification-aerobic denitrification and the maximal removal efficiencies of ammonium, nitrite and nitrate were 99.52%, 81.10% and 95.84% respectively. Moreover, the phosphorus removal process of strain GHSP10 was achieved under entirely aerobic conditions, and glycogen and poly-β-hydroxybutyrate could provide energy source for the phosphorus removal process of strain GHSP10. The amplification of ppk, hao, napA, narG, nirK genes as well as the expression of polyphosphate kinase helped to reveal the removal pathways of phosphorus and nitrogen, providing theoretical support for the phosphorus removal, nitrification and aerobic denitrification abilities of strain GHSP10. Furthermore, efficient removal of phosphorus and nitrogen from both domestic sewage and aquaculture sewage could be accomplished by strain GHSP10. This study may provide a hopeful candidate strain for simultaneous removal of phosphorus and nitrogen pollution from both freshwater sewage and saline sewage.

The entering of polyethylene terephthalate microplastics into biological wastewater treatment system affects aerobic sludge digestion differently from their direct entering into sludge treatment system

The entering of the widespread polyethylene terephthalate (PET) microplastics into biological wastewater treatment system results in their retention in sewage sludge, which inevitably enters the sludge treatment system. However, all previous studies regarding the impact of microplastics on sludge treatment system were conducted by directly adding microplastics to system and focusing on anaerobic sludge digestion, although PET microplastics commonly enter into the biological wastewater treatment system first before sludge being subsequently treated. The potential impact of the microplastics on waste activated sludge (WAS) aerobic digestion is also completely missing. Therefore, herein the influences of PET microplastics with different entry paths on WAS aerobic digestion as well as the key mechanisms involved was firstly explored. Experimental results demonstrated that compared to the control test, the entering of PET microplastics to biological wastewater treatment system inhibited WAS aerobic digestion by 10.9 ± 0.1% through the decreased hydrolysis, although WAS solubilization during aerobic digestion was improved due to the change of generated WAS characteristics. In contrast, when PET microplastics was directly added to the sludge aerobic digester, there was little impact on solubilization, while the hydrolysis were inhibited seriously, thereby suppressing WAS aerobic digestion more severely by 28.9 ± 0.1%. Further investigation revealed that PET microplastics reduced the populations of key bacteria (e.g., Saprospiraceae, Chitinophagaceae and Xanthomonadaceae) involved in aerobic digestion via induced oxidative stress or/and releasing toxic chemical. This study provided a more accurate approach to assessing the real situation regarding the influences of PET microplastics on aerobic sludge digestion.

A comparative review on clean hydrogen production from wastewaters

This paper provides a unique review of hydrogen production methods with wastewater treatment to depict a clean and sustainable approach. Various methods for hydrogen production from wastewaters are identified and discussed with recent details by discussing the critical challenges, opportunities, and future directions. Five main performance sectors are considered in detail for each hydrogen production method of the recent case studies, including economic, environmental, social, technical, and reliability. Eight hydrogen production methods are reviewed, including anaerobic method, photo fermentation, dark fermentation, electrolysis, electrodialysis, photocatalysis, photoelectrochemical methods, and super water gasification. A comparative assessment of six reviewed methods for hydrogen production, including environmental, economic, energetic, and exergetic impacts, is evaluated. The comparative assessment results indicate that dark fermentation technology is the most economical method, and it is followed by microbial electrolysis and photofermentation. The most environmentally friendly method for the lowest global warming potential (GWP) is the microbial electrolysis method, and it is followed by photocatalysis and photoelectrochemical methods. Furthermore, the highest energy and exergy efficiencies have been recorded for the microbial electrolysis to be 68% and 64.7%, respectively.

Structural changes in model compounds of sludge extracellular polymeric substances caused by exposure to free nitrous acid

Previous studies demonstrate that free nitrous acid (FNA i.e. HNO₂) detaches sewer biofilms, breaks down flocs of waste activated sludge (WAS) and enhances biogas production from WAS. This suggests possible interactions of FNA with organic extracellular polymeric substances (EPS) that bind the cells into biofilms or sludge flocs. This study evaluates the chemical interactions and reaction mechanisms between FNA and molecules representative of key EPS in biofilm and sludge flocs. Molecules chosen to represent components found in the extracellular polymeric matrix were treated with FNA at 6.09 mgN/L (NO₂^- = 250 mgN/L, pH = 5.0 ± 0.2, T = 22 °C) for 24 hours (conditions typically used in applications) so as to consider the hypothesized chemical interactions and the consequent reaction pathways. A number of analytical techniques were employed to measure the molecular changes in the EPS molecules including; proton (¹H) nuclear magnetic resonance spectroscopy (NMR), electrospray ionisation mass spectrometry (ESI-MS) and gel permeation chromatography (GPC). The results demonstrated that FNA broke down a range of large EPS molecules including carbohydrates, protein and lipids to smaller molecules. Two mechanistic pathways have been proposed including electrophilic substitution, whereby the nitrosium ion (NO⁺) was the reactive electrophile, and oxidative radical reactions, through which the nitrogen radicals (^.NO₂, ^.NO) and reactive nitrogen intermediates (RNIs) (e.g. N₂O₃ and N₂O₄) formed from the decomposition of FNA became part of the reaction products. Larger, more complex organic molecules such as humic acid, required higher concentrations of FNA (6.09 mgN/L or greater) to cause molecular breakdown, whereas smaller molecules, such as calcium alginate, was broken down at lower concentrations (3.04 mgN/L). The study contributes to the understanding of the fundamental mechanisms behind the application of FNA for biofilm control and flocular sludge disintegration.

Changes in the characteristics of dissolved organic matter during sludge treatment: A critical review

Dissolved organic matter (DOM) of sludge is a heterogeneous mixture of high to low molecular weight organic substances which is including proteinaceous compounds, carbohydrates, humic substances, lipids, lignins, organic acids, organic micropollutants and other biological derived substances generated during wastewater treatment. This paper reviews definition, composition, quantification, and transformation of DOM during different sludge treatments, and the complex interplay of DOM with microbial communities. In anaerobic digestion, anaerobic digestion-refractory organic matter, particularly compounds showing polycyclic steroid-like, alkane and aromatic structures can be generated after pretreatment. During dewatering, the DOM fraction of low molecular weight proteins (< 20,000 Dalton) is the key parameter deteriorating sludge dewaterability. During composting, decomposition and polymerization of DOM occur, followed by the formation of humic substances. During landfill treatment, the composition of DOM, particularly humic substances, are related with leachate quality. Finally, suggestions are proposed for a better understanding of the transformation and degradation of DOM during sludge treatment. Future work in sludge studies needs the establishment and implementation of definitions for sample handling and the standardization of DOM methods for analysis, including sample preparation and fractionation, and data integration. A more detailed knowledge of DOM in sludge facilitates the operation and optimization of sludge treatment technologies.

Enhanced anaerobic fermentation of waste activated sludge by reverse osmosis brine and composition distribution in fermentative liquid

This study reported a "treating waste by waste" strategy to dispose waste activated sludge (WAS), i.e. reverse osmosis (RO) brine-enhanced anaerobic fermentation. RO brine was hazardous by-product from seawater desalination process, which contains numerous Na⁺. After 4-day RO brine-enhanced anaerobic fermentation at Na⁺ concentration of 0.33 mol/L, 5.0 g/L VSS reduction (37.9% of VSS) was achievable, leading to considerable soluble chemical oxygen demand (SCOD) release of 349.6 mg/g VSS. Acetic acid was predominant component in SCOD (31.1%), followed by propionic, butyric, valeric acids and proteins (14.0-17.6%). Sludge solubilization and SCOD composition in the enhanced anaerobic fermentation with RO brine and NaCl agent were similar, whereas less nutrient release and extracellular polymeric substance (EPS) disruption were achieved by RO brine, attributing to the Ca²⁺&Mg²⁺-caused skeleton strengthening on EPS matrix. Such RO brine-based strategy provided environmental and economic benefits, e.g. none chemical consumption, synchronous disposal of WAS and RO brine.

Hydrolase activity and microbial community dynamic shift related to the lack in multivalent cations during cation exchange resin-enhanced anaerobic fermentation of waste activated sludge

The correlation of the lack in multivalent cations with hydrolase activity and microbial community in anaerobic fermentation of waste activated sludge was investigated in this study. It was demonstrated that considerable solid phase reduction of 41 % (7.87 g/L) was achievable through a cation exchange resin-enhanced anaerobic fermentation of 4 days. The protease and α-glucosidase, especially α-glucosidase, were easily influenced by a lack in multivalent cations. Furthermore, species abundance and diversity of microbial community gradually decreased. Meanwhile, the bacteria community structure presented obvious dynamic shifts. Ruminococcaceae_UCG_009, Bacteroides and Macellibacteroides responsible for organic matter biodegradation and SCFAs production became dominant bacteria in cation exchange resin-enhanced anaerobic fermentation, which was less influenced by the lack in multivalent cations, while the SCFA consumers (e.g. methanogens) were inhibited with reduced abundances due to their susceptibility to the lack in multivalent cations. Redundancy analysis revealed that the lack in multivalent cations were responsible for the microbial community evolution, which was proved by the high Grey relational coefficients (0.747-0.820) and significant negative Spearman coefficients (-0.5798 to -0.9429) between multivalent cation and microbial community. Obviously, the cation exchange resin-induced removal of multivalent cations reduced enzyme activity and modified microbial community structure, which created a beneficial environment for enhancing anaerobic fermentation.