1
|
Soleimani A, Alizadeh H. Unlocking the potential of Extensin Signal peptide and Elastin-like polypeptide tag fused to Shigella dysenteriae's IpaDSTxB to improve protein expression and purification in Nicotiana tabacum and Medicagosativa. Protein Expr Purif 2024; 222:106521. [PMID: 38852714 DOI: 10.1016/j.pep.2024.106521] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/29/2024] [Revised: 06/04/2024] [Accepted: 06/05/2024] [Indexed: 06/11/2024]
Abstract
Plants are often seen as a potent tool in the recombinant protein production industry. However, unlike bacterial expression, it is not a popular method due to the low yield and difficulty of protein extraction and purification. Therefore, developing a new high efficient and easy to purify platform is crucial. One of the best approaches to make extraction easier is to utilize the Extensin Signal peptide (EXT) to translocate the recombinant protein to the outside of the cell, along with incorporating an Elastin-like polypeptide tag (ELP) to enhance purification and accumulation rates. In this research, we transiently expressed Shigella dysenteriae's IpaDSTxB fused to both NtEXT and ELP in both Nicotiana tabacum and Medicago sativa. Our results demonstrated that N. tabacum, with an average yield of 6.39 ng/μg TSP, outperforms M. sativa, which had an average yield of 3.58 ng/μg TSP. On the other hand, analyzing NtEXT signal peptide indicated that merging EXT to the constructs facilitates translocation of IpaDSTxB to the apoplast by 78.4% and 65.9% in N. tabacum and M. sativa, respectively. Conversely, the mean level for constructs without EXT was below 25% for both plants. Furthermore, investigation into the orientation of ELP showed that merging it to the C-terminal of IpaDSTxB leads to a higher accumulation rate in both N. tabacum and M. sativa by 1.39 and 1.28 times, respectively. It also facilitates purification rate by over 70% in comparison to 20% of the 6His tag. The results show a highly efficient and easy to purify platform for the expression of heterologous proteins in plant.
Collapse
Affiliation(s)
- AmirMohammad Soleimani
- Department of Agronomy and Plant Breeding, College of Agriculture and Natural Resources, University of Tehran, Karaj, Iran.
| | - Houshang Alizadeh
- Department of Agronomy and Plant Breeding, College of Agriculture and Natural Resources, University of Tehran, Karaj, Iran
| |
Collapse
|
2
|
Zahmanova G, Aljabali AAA, Takova K, Minkov G, Tambuwala MM, Minkov I, Lomonossoff GP. Green Biologics: Harnessing the Power of Plants to Produce Pharmaceuticals. Int J Mol Sci 2023; 24:17575. [PMID: 38139405 PMCID: PMC10743837 DOI: 10.3390/ijms242417575] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/08/2023] [Revised: 12/11/2023] [Accepted: 12/15/2023] [Indexed: 12/24/2023] Open
Abstract
Plants are increasingly used for the production of high-quality biological molecules for use as pharmaceuticals and biomaterials in industry. Plants have proved that they can produce life-saving therapeutic proteins (Elelyso™-Gaucher's disease treatment, ZMapp™-anti-Ebola monoclonal antibodies, seasonal flu vaccine, Covifenz™-SARS-CoV-2 virus-like particle vaccine); however, some of these therapeutic proteins are difficult to bring to market, which leads to serious difficulties for the manufacturing companies. The closure of one of the leading companies in the sector (the Canadian biotech company Medicago Inc., producer of Covifenz) as a result of the withdrawal of investments from the parent company has led to the serious question: What is hindering the exploitation of plant-made biologics to improve health outcomes? Exploring the vast potential of plants as biological factories, this review provides an updated perspective on plant-derived biologics (PDB). A key focus is placed on the advancements in plant-based expression systems and highlighting cutting-edge technologies that streamline the production of complex protein-based biologics. The versatility of plant-derived biologics across diverse fields, such as human and animal health, industry, and agriculture, is emphasized. This review also meticulously examines regulatory considerations specific to plant-derived biologics, shedding light on the disparities faced compared to biologics produced in other systems.
Collapse
Affiliation(s)
- Gergana Zahmanova
- Department of Plant Physiology and Molecular Biology, University of Plovdiv, 4000 Plovdiv, Bulgaria; (K.T.)
- Center of Plant Systems Biology and Biotechnology, 4000 Plovdiv, Bulgaria
| | - Alaa A. A. Aljabali
- Department of Pharmaceutics and Pharmaceutical Technology, Faculty of Pharmacy, Yarmouk University, Irbid 21163, Jordan;
| | - Katerina Takova
- Department of Plant Physiology and Molecular Biology, University of Plovdiv, 4000 Plovdiv, Bulgaria; (K.T.)
| | - George Minkov
- Department of Plant Physiology and Molecular Biology, University of Plovdiv, 4000 Plovdiv, Bulgaria; (K.T.)
| | - Murtaza M. Tambuwala
- Lincoln Medical School, University of Lincoln, Brayford Pool Campus, Lincoln LN6 7TS, UK;
| | - Ivan Minkov
- Center of Plant Systems Biology and Biotechnology, 4000 Plovdiv, Bulgaria
- Institute of Molecular Biology and Biotechnologies, 4108 Markovo, Bulgaria
| | | |
Collapse
|
3
|
Feng Z, Li X, Fan B, Zhu C, Chen Z. Maximizing the Production of Recombinant Proteins in Plants: From Transcription to Protein Stability. Int J Mol Sci 2022; 23:13516. [PMID: 36362299 PMCID: PMC9659199 DOI: 10.3390/ijms232113516] [Citation(s) in RCA: 7] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/14/2022] [Revised: 10/31/2022] [Accepted: 11/01/2022] [Indexed: 11/07/2023] Open
Abstract
The production of therapeutic and industrial recombinant proteins in plants has advantages over established bacterial and mammalian systems in terms of cost, scalability, growth conditions, and product safety. In order to compete with these conventional expression systems, however, plant expression platforms must have additional economic advantages by demonstrating a high protein production yield with consistent quality. Over the past decades, important progress has been made in developing strategies to increase the yield of recombinant proteins in plants by enhancing their expression and reducing their degradation. Unlike bacterial and animal systems, plant expression systems can utilize not only cell cultures but also whole plants for the production of recombinant proteins. The development of viral vectors and chloroplast transformation has opened new strategies to drastically increase the yield of recombinant proteins from plants. The identification of promoters for strong, constitutive, and inducible promoters or the tissue-specific expression of transgenes allows for the production of recombinant proteins at high levels and for special purposes. Advances in the understanding of RNAi have led to effective strategies for reducing gene silencing and increasing recombinant protein production. An increased understanding of protein translation, quality control, trafficking, and degradation has also helped with the development of approaches to enhance the synthesis and stability of recombinant proteins in plants. In this review, we discuss the progress in understanding the processes that control the synthesis and degradation of gene transcripts and proteins, which underlie a variety of developed strategies aimed at maximizing recombinant protein production in plants.
Collapse
Affiliation(s)
- Ziru Feng
- College of Life Sciences, China Jiliang University, Hangzhou 310018, China
| | - Xifeng Li
- College of Life Sciences, China Jiliang University, Hangzhou 310018, China
| | - Baofang Fan
- Department of Botany and Plant Pathology, Purdue Center for Plant Biology, Purdue University, West Lafayette, IN 47907-2054, USA
| | - Cheng Zhu
- College of Life Sciences, China Jiliang University, Hangzhou 310018, China
| | - Zhixiang Chen
- College of Life Sciences, China Jiliang University, Hangzhou 310018, China
- Department of Botany and Plant Pathology, Purdue Center for Plant Biology, Purdue University, West Lafayette, IN 47907-2054, USA
| |
Collapse
|
4
|
Gong L, Yang Z, Zhang F, Gao W. Cytokine conjugates to elastin-like polypeptides. Adv Drug Deliv Rev 2022; 190:114541. [PMID: 36126792 DOI: 10.1016/j.addr.2022.114541] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/08/2022] [Revised: 06/25/2022] [Accepted: 09/13/2022] [Indexed: 01/24/2023]
Abstract
Cytokines are a group of pleiotropic proteins which are crucial for various biological processes and useful as therapeutics. However, they usually suffer from the poor stability, extreme short circulation half-life, difficulty in high-yield and large-scale production and side effects, which greatly restricts their applications. Over the past decades, conjugation of cytokines with elastin-like polypeptides (ELPs), a type of promising biomaterials, have showed great potential in solving these challenges due to ELP's thermal responsiveness, excellent biocompatibility and biodegradability, non-immunogenicity, and ease of design and control at the genetic level. This review presents recent progress in the design and production of a variety of ELP conjugated cytokines for extended circulation, enhanced stability, increased soluble protein expression, simplified purification, improved drug delivery, and controlled release. Notably, the unique thermoresponsive properties of cytokine-ELP conjugates make it possible to self-assemble into micelles with drastically extended circulatory half-life for targeted delivery or to in situ form drug depots for topical administration and controlled release. The challenges and issues in the emerging field are further discussed and the future directions are pointed out at the end of this review.
Collapse
Affiliation(s)
- Like Gong
- Institute of Medical Technology, Peking University Health Science Center, Beijing 100191, China; Department of Geriatric Dentistry, Beijing Laboratory of Biomedical Materials, Peking University School and Hospital of Stomatology, Beijing 100081, China; Biomedical Engineering Department, Peking University, Beijing 100191, China; Peking University International Cancer Institute, Beijing 100191, China; Peking University-Yunnan Baiyao International Medical Research Center, Beijing 100191, China
| | - Zhaoying Yang
- Institute of Medical Technology, Peking University Health Science Center, Beijing 100191, China; Department of Geriatric Dentistry, Beijing Laboratory of Biomedical Materials, Peking University School and Hospital of Stomatology, Beijing 100081, China; Biomedical Engineering Department, Peking University, Beijing 100191, China; Peking University International Cancer Institute, Beijing 100191, China; Peking University-Yunnan Baiyao International Medical Research Center, Beijing 100191, China
| | - Fan Zhang
- Institute of Medical Technology, Peking University Health Science Center, Beijing 100191, China; Department of Geriatric Dentistry, Beijing Laboratory of Biomedical Materials, Peking University School and Hospital of Stomatology, Beijing 100081, China; Biomedical Engineering Department, Peking University, Beijing 100191, China; Peking University International Cancer Institute, Beijing 100191, China; Peking University-Yunnan Baiyao International Medical Research Center, Beijing 100191, China
| | - Weiping Gao
- Institute of Medical Technology, Peking University Health Science Center, Beijing 100191, China; Department of Geriatric Dentistry, Beijing Laboratory of Biomedical Materials, Peking University School and Hospital of Stomatology, Beijing 100081, China; Biomedical Engineering Department, Peking University, Beijing 100191, China; Peking University International Cancer Institute, Beijing 100191, China; Peking University-Yunnan Baiyao International Medical Research Center, Beijing 100191, China.
| |
Collapse
|
5
|
Rozov SM, Deineko EV. Increasing the Efficiency of the Accumulation of Recombinant Proteins in Plant Cells: The Role of Transport Signal Peptides. PLANTS (BASEL, SWITZERLAND) 2022; 11:2561. [PMID: 36235427 PMCID: PMC9572730 DOI: 10.3390/plants11192561] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 09/05/2022] [Revised: 09/23/2022] [Accepted: 09/26/2022] [Indexed: 06/16/2023]
Abstract
The problem with increasing the yield of recombinant proteins is resolvable using different approaches, including the transport of a target protein to cell compartments with a low protease activity. In the cell, protein targeting involves short-signal peptide sequences recognized by intracellular protein transport systems. The main systems of the protein transport across membranes of the endoplasmic reticulum and endosymbiotic organelles are reviewed here, as are the major types and structure of the signal sequences targeting proteins to the endoplasmic reticulum and its derivatives, to plastids, and to mitochondria. The role of protein targeting to certain cell organelles depending on specific features of recombinant proteins and the effect of this targeting on the protein yield are discussed, in addition to the main directions of the search for signal sequences based on their primary structure. This knowledge makes it possible not only to predict a protein localization in the cell but also to reveal the most efficient sequences with potential biotechnological utility.
Collapse
|
6
|
Li X, Li X, Fan B, Zhu C, Chen Z. Specialized endoplasmic reticulum-derived vesicles in plants: Functional diversity, evolution, and biotechnological exploitation. JOURNAL OF INTEGRATIVE PLANT BIOLOGY 2022; 64:821-835. [PMID: 35142108 PMCID: PMC9314129 DOI: 10.1111/jipb.13233] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 12/21/2022] [Accepted: 02/07/2022] [Indexed: 06/14/2023]
Abstract
A central role of the endoplasmic reticulum (ER) is the synthesis, folding and quality control of secretory proteins. Secretory proteins usually exit the ER to enter the Golgi apparatus in coat protein complex II (COPII)-coated vesicles before transport to different subcellular destinations. However, in plants there are specialized ER-derived vesicles (ERDVs) that carry specific proteins but, unlike COPII vesicles, can exist as independent organelles or travel to the vacuole in a Golgi-independent manner. These specialized ERDVs include protein bodies and precursor-accumulating vesicles that accumulate storage proteins in the endosperm during seed development. Specialized ERDVs also include precursor protease vesicles that accumulate amino acid sequence KDEL-tailed cysteine proteases and ER bodies in Brassicales plants that accumulate myrosinases that hydrolyzes glucosinolates. These functionally specialized ERDVs act not only as storage organelles but also as platforms for signal-triggered processing, activation and deployment of specific proteins with important roles in plant growth, development and adaptive responses. Some specialized ERDVs have also been exploited to increase production of recombinant proteins and metabolites. Here we discuss our current understanding of the functional diversity, evolutionary mechanisms and biotechnological application of specialized ERDVs, which are associated with some of the highly remarkable characteristics important to plants.
Collapse
Affiliation(s)
- Xie Li
- College of Life Science, Key Laboratory of Marine Food Quality and Hazard Controlling Technology of Zhejiang ProvinceChina Jiliang UniversityHangzhou310018China
| | - Xifeng Li
- College of Life Science, Key Laboratory of Marine Food Quality and Hazard Controlling Technology of Zhejiang ProvinceChina Jiliang UniversityHangzhou310018China
| | - Baofang Fan
- Department of Botany and Plant Pathology, Center for Plant BiologyPurdue UniversityWest Lafayette47907‐2054INUSA
| | - Cheng Zhu
- College of Life Science, Key Laboratory of Marine Food Quality and Hazard Controlling Technology of Zhejiang ProvinceChina Jiliang UniversityHangzhou310018China
| | - Zhixiang Chen
- College of Life Science, Key Laboratory of Marine Food Quality and Hazard Controlling Technology of Zhejiang ProvinceChina Jiliang UniversityHangzhou310018China
- Department of Botany and Plant Pathology, Center for Plant BiologyPurdue UniversityWest Lafayette47907‐2054INUSA
| |
Collapse
|
7
|
Improving Protein Quantity and Quality—The Next Level of Plant Molecular Farming. Int J Mol Sci 2022; 23:ijms23031326. [PMID: 35163249 PMCID: PMC8836236 DOI: 10.3390/ijms23031326] [Citation(s) in RCA: 11] [Impact Index Per Article: 5.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/26/2021] [Revised: 01/21/2022] [Accepted: 01/22/2022] [Indexed: 12/15/2022] Open
Abstract
Plants offer several unique advantages in the production of recombinant pharmaceuticals for humans and animals. Although numerous recombinant proteins have been expressed in plants, only a small fraction have been successfully put into use. The hugely distinct expression systems between plant and animal cells frequently cause insufficient yield of the recombinant proteins with poor or undesired activity. To overcome the issues that greatly constrain the development of plant-produced pharmaceuticals, great efforts have been made to improve expression systems and develop alternative strategies to increase both the quantity and quality of the recombinant proteins. Recent technological revolutions, such as targeted genome editing, deconstructed vectors, virus-like particles, and humanized glycosylation, have led to great advances in plant molecular farming to meet the industrial manufacturing and clinical application standards. In this review, we discuss the technological advances made in various plant expression platforms, with special focus on the upstream designs and milestone achievements in improving the yield and glycosylation of the plant-produced pharmaceutical proteins.
Collapse
|
8
|
Abstract
Elastin-like polypeptides (ELPs) are stimulus-responsive biopolymers derived from human elastin. Their unique properties—including lower critical solution temperature phase behavior and minimal immunogenicity—make them attractive materials for a variety of biomedical applications. ELPs also benefit from recombinant synthesis and genetically encoded design; these enable control over the molecular weight and precise incorporation of peptides and pharmacological agents into the sequence. Because their size and sequence are defined, ELPs benefit from exquisite control over their structure and function, qualities that cannot be matched by synthetic polymers. As such, ELPs have been engineered to assemble into unique architectures and display bioactive agents for a variety of applications. This review discusses the design and representative biomedical applications of ELPs, focusing primarily on their use in tissue engineering and drug delivery.
Collapse
Affiliation(s)
- Anastasia K. Varanko
- Department of Biomedical Engineering, Duke University, Durham, North Carolina 27708, USA
| | - Jonathan C. Su
- Department of Biomedical Engineering, Duke University, Durham, North Carolina 27708, USA
| | - Ashutosh Chilkoti
- Department of Biomedical Engineering, Duke University, Durham, North Carolina 27708, USA
| |
Collapse
|
9
|
Kuna M, Waller JP, Logue OC, Bidwell GL. Polymer size affects biodistribution and placental accumulation of the drug delivery biopolymer elastin-like polypeptide in a rodent pregnancy model. Placenta 2018; 72-73:20-27. [PMID: 30501877 PMCID: PMC6287274 DOI: 10.1016/j.placenta.2018.10.005] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Submit a Manuscript] [Subscribe] [Scholar Register] [Received: 06/11/2018] [Revised: 09/19/2018] [Accepted: 10/18/2018] [Indexed: 02/06/2023]
Abstract
INTRODUCTION Fusion of therapeutic agents to Elastin-like Polypeptide (ELP) is a novel drug delivery strategy for prevention of placental drug transfer. Previous studies have used a 60 kDa ELP tag for this purpose. However, placental transfer of ELP may be size dependent. The goal of this study was to measure the effects of ELP polymer size on pharmacokinetics, biodistribution, and placental transfer of ELP. METHODS Three ELPs ranging from 25 to 86 kDa (4.1-6.8 nm hydrodynamic radius) were fluorescently labeled and administered by i.v. bolus to pregnant Sprague Dawley rats on gestational day 14. Plasma levels were monitored for 4 h, organ levels and placental transfer determined by ex vivo fluorescence imaging, and placental localization determined by confocal microscopy. RESULTS Increasing ELP size resulted in slower plasma clearance and increased deposition in all major maternal organs, except in the kidneys where an opposite effect was observed. Placental levels increased with an increase in size, while in the pups, little to no ELP was detected. DISCUSSION Pharmacokinetics and biodistribution of ELPs during pregnancy are size dependent, but all ELPs tested were too large to traverse the placental barrier. These studies verify that ELP fusion is a powerful method of modulating half-life and preventing placental transfer of cargo molecules. The tunable nature of the ELP sequence makes it ideal for drug delivery applications during pregnancy, where it can be used to target drugs to the mother while preventing fetal drug exposure.
Collapse
Affiliation(s)
- Marija Kuna
- Department of Cell and Molecular Biology, University of Mississippi Medical Center, Jackson, MS, USA
| | - Jamarius P Waller
- Department of Neurology, University of Mississippi Medical Center, Jackson, MS, USA
| | - Omar C Logue
- Department of Neurology, University of Mississippi Medical Center, Jackson, MS, USA
| | - Gene L Bidwell
- Department of Cell and Molecular Biology, University of Mississippi Medical Center, Jackson, MS, USA; Department of Neurology, University of Mississippi Medical Center, Jackson, MS, USA.
| |
Collapse
|
10
|
Abstract
Plant molecular farming depends on a diversity of plant systems for production of useful recombinant proteins. These proteins include protein biopolymers, industrial proteins and enzymes, and therapeutic proteins. Plant production systems include microalgae, cells, hairy roots, moss, and whole plants with both stable and transient expression. Production processes involve a narrowing diversity of bioreactors for cell, hairy root, microalgae, and moss cultivation. For whole plants, both field and automated greenhouse cultivation methods are used with products expressed and produced either in leaves or seeds. Many successful expression systems now exist for a variety of different products with a list of increasingly successful commercialized products. This chapter provides an overview and examples of the current state of plant-based production systems for different types of recombinant proteins.
Collapse
Affiliation(s)
| | - Thomas Bley
- Bioprocess Engineering, Institute of Food Technology and Bioprocess Engineering, TU Dresden, Dresden, Germany
| |
Collapse
|
11
|
Miletic S, Hünerberg M, Kaldis A, MacDonald J, Leuthreau A, McAllister T, Menassa R. A Plant-Produced Candidate Subunit Vaccine Reduces Shedding of Enterohemorrhagic Escherichia coli in Ruminants. Biotechnol J 2017; 12. [PMID: 28869356 DOI: 10.1002/biot.201700405] [Citation(s) in RCA: 6] [Impact Index Per Article: 0.9] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/02/2017] [Revised: 08/30/2017] [Indexed: 12/18/2022]
Abstract
Enterohemorrhagic Escherichia coli (EHEC) are commonly present in the gastrointestinal tract of cattle and cause serious infectious disease in humans. Immunizing cattle against EHEC is a promising strategy to decrease the risk of food contamination; however, veterinary vaccines against EHEC such as Econiche have not been widely adopted by the agricultural industry, and have been discontinued, prompting the need for more cost-effective EHEC vaccines. The objective of this project is to develop a platform to produce plant-made antigens for oral vaccination of ruminants against EHEC. Five recombinant proteins were designed as vaccine candidates and expressed transiently in Nicotiana benthamiana and transplastomically in Nicotiana tabacum. Three of these EHEC proteins, NleA, Stx2b, and a fusion of EspA accumulated when transiently expressed. Transient protein accumulation was the highest when EHEC proteins were fused to an elastin-like polypeptide (ELP) tag. In the transplastomic lines, EspA accumulated up to 479 mg kg-1 in lyophilized leaf material. Sheep that were administered leaf tissue containing recombinant EspA shed less E. coli O157:H7 when challenged, as compared to control animals. These results suggest that plant-made, transgenic EspA has the potential to reduce EHEC shedding in ruminants.
Collapse
Affiliation(s)
- Sean Miletic
- Agriculture and Agri-Food Canada, London Research and Development Centre, 1391 Sandford Street, London N5V 4T3, Ontario, Canada
- Department of Biology, University of Western Ontario, 1151 Richmond Street, London N6A 3K7, Ontario, Canada
| | - Martin Hünerberg
- Lethbridge Research and Development Centre, Agriculture and Agri-Food Canada, 5403-1 Avenue South, Lethbridge T1J 4P4, Alberta, Canada
- Department of Animal Sciences, Ruminant Nutrition Unit, University of Göttingen, 37077 Göttingen, Germany
| | - Angelo Kaldis
- Agriculture and Agri-Food Canada, London Research and Development Centre, 1391 Sandford Street, London N5V 4T3, Ontario, Canada
| | - Jacqueline MacDonald
- Agriculture and Agri-Food Canada, London Research and Development Centre, 1391 Sandford Street, London N5V 4T3, Ontario, Canada
| | - Antoine Leuthreau
- Agriculture and Agri-Food Canada, London Research and Development Centre, 1391 Sandford Street, London N5V 4T3, Ontario, Canada
- Université de Bordeaux and INRA, UMR 1332 Biologie du Fruit et Pathologie, Villenave d'ornon, France
| | - Tim McAllister
- Lethbridge Research and Development Centre, Agriculture and Agri-Food Canada, 5403-1 Avenue South, Lethbridge T1J 4P4, Alberta, Canada
| | - Rima Menassa
- Agriculture and Agri-Food Canada, London Research and Development Centre, 1391 Sandford Street, London N5V 4T3, Ontario, Canada
- Department of Biology, University of Western Ontario, 1151 Richmond Street, London N6A 3K7, Ontario, Canada
| |
Collapse
|
12
|
Melon13-lipoxygenase CmLOX18 may be involved in C6 volatiles biosynthesis in fruit. Sci Rep 2017; 7:2816. [PMID: 28588227 PMCID: PMC5460189 DOI: 10.1038/s41598-017-02559-6] [Citation(s) in RCA: 12] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/13/2016] [Accepted: 04/13/2017] [Indexed: 12/31/2022] Open
Abstract
To better understand the function role of the melon CmLOX18 gene in the biosynthesis of C6 volatiles during fruit ripening, we biochemically characterized CmLOX18 and identified its subcellular localization in transgenic tomato plants. Heterologous expression in yeast cells showed that the molecular weight of the CmLOX18 protein was identical to that predicted, and that this enzyme possesseed lipoxygenase activity. Linoleic acid was demonstrated to be the preferred substrate for the purified recombinant CmLOX18 protein, which exhibited optimal catalytic activity at pH 4.5 and 30 °C. Chromatogram analysis of the reaction product indicated that the CmLOX18 protein exhibited positional specificity, as evidenced by its release of only a C-13 oxidized product. Subcellular localization analysis by transient expression in Arabidopsis protoplasts showed that CmLOX18 was localized to non-chloroplast organelles. When the CmLOX18 gene was transgenically expressed in tomato via Agrobacterium tumefaciens-mediated transformation, it was shown to enhance expression levels of the tomato hydroperoxide lyase gene LeHPL, whereas the expression levels of six TomLox genes were little changed. Furthermore, transgenic tomato fruits exhibited increases in the content of the C6 volatiles, namely hexanal, (Z)-3-hexanal, and (Z)-3-hexen-1-ol, indicating that CmLOX18 probably plays an important role in the synthesis of C6 compounds in fruits.
Collapse
|
13
|
Ponndorf D, Ehmke S, Walliser B, Thoss K, Unger C, Görs S, Daş G, Metges CC, Broer I, Nausch H. Stable production of cyanophycinase in Nicotiana benthamiana and its functionality to hydrolyse cyanophycin in the murine intestine. PLANT BIOTECHNOLOGY JOURNAL 2017; 15:605-613. [PMID: 27808470 PMCID: PMC5399006 DOI: 10.1111/pbi.12658] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/08/2016] [Revised: 10/05/2016] [Accepted: 10/30/2016] [Indexed: 05/09/2023]
Abstract
Food supplementation with the conditionally essential amino acid arginine (Arg) has been shown to have nutritional benefits. Degradation of cyanophycin (CGP), a peptide polymer used for nitrogen storage by cyanobacteria, requires cyanophycinase (CGPase) and results in the release of β-aspartic acid (Asp)-Arg dipeptides. The simultaneous production of CGP and CGPase in plants could be a convenient source of Arg dipeptides. Different variants of the cphB coding region from Thermosynechococcus elongatus BP-1 were transiently expressed in Nicotiana benthamiana plants. Translation and enzyme stability were optimized to produce high amounts of active CGPase. Protein stability was increased by the translational fusion of CGPase to the green fluorescent protein (GFP) or to the transit peptide of the small subunit of RuBisCO for peptide production in the chloroplasts. Studies in mice showed that plant-expressed CGP fed in combination with plant-made CGPase was hydrolysed in the intestine, and high levels of ß-Asp-Arg dipeptides were found in plasma, demonstrating dipeptide absorption. However, the lack of an increase in Asp and Arg or its metabolite ornithine in plasma suggests that Arg from CGP was not bioavailable in this mouse group. Intestinal degradation of CGP by CGPase led to low intestinal CGP content 4 h after consumption, but after ingestion of CGP alone, high CGP concentrations remained in the large intestine; this indicated that intact CGP was transported from the small to the large intestine and that CGP was resistant to colonic microbes.
Collapse
Affiliation(s)
- Daniel Ponndorf
- Faculty of Agricultural and Environmental SciencesDepartment of Agrobiotechnology and Risk Assessment for Bio‐ and Gene TechnologyUniversity of RostockRostockGermany
| | - Sven Ehmke
- Faculty of Agricultural and Environmental SciencesDepartment of Agrobiotechnology and Risk Assessment for Bio‐ and Gene TechnologyUniversity of RostockRostockGermany
- Present address: Paraxel International GmbHKlinikum am Westend, Haus 18, SpandauerDamm 130, 14050BerlinGermany
| | - Benjamin Walliser
- Faculty of Agricultural and Environmental SciencesDepartment of Agrobiotechnology and Risk Assessment for Bio‐ and Gene TechnologyUniversity of RostockRostockGermany
| | - Kerstin Thoss
- Faculty of Agricultural and Environmental SciencesDepartment of Agrobiotechnology and Risk Assessment for Bio‐ and Gene TechnologyUniversity of RostockRostockGermany
| | - Christoph Unger
- Faculty of Agricultural and Environmental SciencesDepartment of Agrobiotechnology and Risk Assessment for Bio‐ and Gene TechnologyUniversity of RostockRostockGermany
| | - Solvig Görs
- Leibniz Institute for Farm Animal Biology (FBN)Institute of Nutritional Physiology ‘Oskar Kellner’DummerstorfGermany
| | - Gürbüz Daş
- Leibniz Institute for Farm Animal Biology (FBN)Institute of Nutritional Physiology ‘Oskar Kellner’DummerstorfGermany
| | - Cornelia C. Metges
- Leibniz Institute for Farm Animal Biology (FBN)Institute of Nutritional Physiology ‘Oskar Kellner’DummerstorfGermany
| | - Inge Broer
- Faculty of Agricultural and Environmental SciencesDepartment of Agrobiotechnology and Risk Assessment for Bio‐ and Gene TechnologyUniversity of RostockRostockGermany
| | - Henrik Nausch
- Faculty of Agricultural and Environmental SciencesDepartment of Agrobiotechnology and Risk Assessment for Bio‐ and Gene TechnologyUniversity of RostockRostockGermany
| |
Collapse
|
14
|
Yin L, Yuvienco C, Montclare JK. Protein based therapeutic delivery agents: Contemporary developments and challenges. Biomaterials 2017; 134:91-116. [PMID: 28458031 DOI: 10.1016/j.biomaterials.2017.04.036] [Citation(s) in RCA: 68] [Impact Index Per Article: 9.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/13/2017] [Revised: 04/18/2017] [Accepted: 04/21/2017] [Indexed: 12/15/2022]
Abstract
As unique biopolymers, proteins can be employed for therapeutic delivery. They bear important features such as bioavailability, biocompatibility, and biodegradability with low toxicity serving as a platform for delivery of various small molecule therapeutics, gene therapies, protein biologics and cells. Depending on size and characteristic of the therapeutic, a variety of natural and engineered proteins or peptides have been developed. This, coupled to recent advances in synthetic and chemical biology, has led to the creation of tailor-made protein materials for delivery. This review highlights strategies employing proteins to facilitate the delivery of therapeutic matter, addressing the challenges for small molecule, gene, protein and cell transport.
Collapse
Affiliation(s)
- Liming Yin
- Department of Chemical and Biomolecular Engineering, NYU Tandon School of Engineering, Brooklyn, NY 11201, United States
| | - Carlo Yuvienco
- Department of Chemical and Biomolecular Engineering, NYU Tandon School of Engineering, Brooklyn, NY 11201, United States
| | - Jin Kim Montclare
- Department of Chemical and Biomolecular Engineering, NYU Tandon School of Engineering, Brooklyn, NY 11201, United States; Department of Chemistry, New York University, New York, NY 10003, United States; Department of Biomaterials, NYU College of Dentistry, New York, NY 10010, United States; Department of Biochemistry, SUNY Downstate Medical Center, Brooklyn, NY 11203, United States.
| |
Collapse
|
15
|
Peng CA, Russo J, Gravgaard C, McCartney H, Gaines W, Marcotte WR. Spider silk-like proteins derived from transgenic Nicotiana tabacum. Transgenic Res 2016; 25:517-26. [PMID: 27026165 DOI: 10.1007/s11248-016-9949-1] [Citation(s) in RCA: 9] [Impact Index Per Article: 1.1] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/05/2015] [Accepted: 03/03/2016] [Indexed: 10/22/2022]
Abstract
The high tensile strength and biocompatibility of spider dragline silk makes it a desirable material in many engineering and tissue regeneration applications. Here, we present the feasibility to produce recombinant proteins in transgenic tobacco Nicotiana tabacum with sequences representing spider silk protein building blocks . Recombinant mini-spidroins contain native N- and C-terminal domains of major ampullate spidroin 1 (rMaSp1) or rMaSp2 flanking an abbreviated number (8, 16 or 32) of consensus repeat domains. Two different expression plasmid vectors were tested and a downstream chitin binding domain and self-cleavable intein were included to facilitate protein purification. We confirmed gene insertion and RNA transcription by PCR and reverse-transcriptase PCR, respectively. Mini-spidroin production was detected by N-terminus specific antibodies. Purification of mini-spidroins was performed through chitin affinity chromatography and subsequent intein activation with reducing reagent. Mini-spidroins, when dialyzed and freeze-dried, formed viscous gelatin-like fluids.
Collapse
Affiliation(s)
- Congyue Annie Peng
- Department of Genetics and Biochemistry, Clemson University, 130 McGinty Court, 153 Robert F. Poole Agricultural Center, Clemson, SC, 29634, USA
| | - Julia Russo
- Department of Genetics and Biochemistry, Clemson University, 130 McGinty Court, 153 Robert F. Poole Agricultural Center, Clemson, SC, 29634, USA
| | - Charlene Gravgaard
- Department of Genetics and Biochemistry, Clemson University, 130 McGinty Court, 153 Robert F. Poole Agricultural Center, Clemson, SC, 29634, USA
- College of Pharmacy, Medical University of South Carolina, Charleston, SC, 29425, USA
| | - Heather McCartney
- Department of Genetics and Biochemistry, Clemson University, 130 McGinty Court, 153 Robert F. Poole Agricultural Center, Clemson, SC, 29634, USA
- Department of Cell and Developmental Biology, Vanderbilt University, Nashville, TN, 37232, USA
| | - William Gaines
- Department of Genetics and Biochemistry, Clemson University, 130 McGinty Court, 153 Robert F. Poole Agricultural Center, Clemson, SC, 29634, USA
| | - William R Marcotte
- Department of Genetics and Biochemistry, Clemson University, 130 McGinty Court, 153 Robert F. Poole Agricultural Center, Clemson, SC, 29634, USA.
| |
Collapse
|
16
|
Yeboah A, Cohen RI, Rabolli C, Yarmush ML, Berthiaume F. Elastin-like polypeptides: A strategic fusion partner for biologics. Biotechnol Bioeng 2016; 113:1617-27. [DOI: 10.1002/bit.25998] [Citation(s) in RCA: 54] [Impact Index Per Article: 6.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/21/2015] [Revised: 04/08/2016] [Accepted: 04/11/2016] [Indexed: 12/25/2022]
Affiliation(s)
- Agnes Yeboah
- Department of Chemical and Biochemical Engineering; Rutgers University; Piscataway New Jersey
| | - Rick I. Cohen
- Department of Biomedical Engineering; Rutgers University; 599 Taylor Road Piscataway 08854 New Jersey
| | - Charles Rabolli
- Department of Biomedical Engineering; Rutgers University; 599 Taylor Road Piscataway 08854 New Jersey
| | - Martin L. Yarmush
- Department of Biomedical Engineering; Rutgers University; 599 Taylor Road Piscataway 08854 New Jersey
- Center for Engineering in Medicine; Massachusetts General Hospital and Shriners Burns Hospital; Boston Massachusetts
| | - Francois Berthiaume
- Department of Biomedical Engineering; Rutgers University; 599 Taylor Road Piscataway 08854 New Jersey
| |
Collapse
|
17
|
Burlakovskiy MS, Yemelyanov VV, Lutova LA. Plant Based Bioreactors of Recombinant Cytokines (Review). APPL BIOCHEM MICRO+ 2016; 52:121-137. [PMID: 32214409 PMCID: PMC7087682 DOI: 10.1134/s0003683816020034] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.1] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/12/2015] [Indexed: 01/16/2023]
Abstract
Cytokines are a family of signaling polypeptides involved in intercellular interactions in the process of the immune response, as well as in the regulation of a number of normal physiological functions. Cytokines are used in medicine for the treatment of cancer, immune disorders, viral infections, and other socially significant diseases, but the extent of their use is limited by the high production cost of the active agent. The development of this area of pharmacology is associated with the success of genetic engineering, which allows the production of significant amounts of protein by transgenic organisms. The review discusses the latest advances in the production of various cytokines with the use of genetically modified plants.
Collapse
Affiliation(s)
- M. S. Burlakovskiy
- Biology Faculty, St. Petersburg State University, St. Petersburg, 199034 Russia
| | - V. V. Yemelyanov
- Biology Faculty, St. Petersburg State University, St. Petersburg, 199034 Russia
| | - L. A. Lutova
- Biology Faculty, St. Petersburg State University, St. Petersburg, 199034 Russia
| |
Collapse
|
18
|
Łojewska E, Kowalczyk T, Olejniczak S, Sakowicz T. Extraction and purification methods in downstream processing of plant-based recombinant proteins. Protein Expr Purif 2015; 120:110-7. [PMID: 26742898 DOI: 10.1016/j.pep.2015.12.018] [Citation(s) in RCA: 19] [Impact Index Per Article: 2.1] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/25/2015] [Revised: 12/23/2015] [Accepted: 12/24/2015] [Indexed: 01/02/2023]
Abstract
During the last two decades, the production of recombinant proteins in plant systems has been receiving increased attention. Currently, proteins are considered as the most important biopharmaceuticals. However, high costs and problems with scaling up the purification and isolation processes make the production of plant-based recombinant proteins a challenging task. This paper presents a summary of the information regarding the downstream processing in plant systems and provides a comprehensible overview of its key steps, such as extraction and purification. To highlight the recent progress, mainly new developments in the downstream technology have been chosen. Furthermore, besides most popular techniques, alternative methods have been described.
Collapse
Affiliation(s)
- Ewelina Łojewska
- Department of Genetics and Plant Molecular Biology and Biotechnology, The University of Lodz, Banacha Street 12/16, 90-237 Lodz, Poland.
| | - Tomasz Kowalczyk
- Department of Genetics and Plant Molecular Biology and Biotechnology, The University of Lodz, Banacha Street 12/16, 90-237 Lodz, Poland
| | - Szymon Olejniczak
- Department of Genetics and Plant Molecular Biology and Biotechnology, The University of Lodz, Banacha Street 12/16, 90-237 Lodz, Poland
| | - Tomasz Sakowicz
- Department of Genetics and Plant Molecular Biology and Biotechnology, The University of Lodz, Banacha Street 12/16, 90-237 Lodz, Poland
| |
Collapse
|
19
|
Rodríguez-Cabello JC, Piña MJ, Ibáñez-Fonseca A, Fernández-Colino A, Arias FJ. Nanotechnological Approaches to Therapeutic Delivery Using Elastin-Like Recombinamers. Bioconjug Chem 2015; 26:1252-65. [DOI: 10.1021/acs.bioconjchem.5b00183] [Citation(s) in RCA: 19] [Impact Index Per Article: 2.1] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/17/2023]
Affiliation(s)
- José Carlos Rodríguez-Cabello
- BIOFORGE (Group for Advanced
Materials and Nanobiotechnology), CIBER-BBN, University of Valladolid, 47011 Valladolid, Spain
| | - María Jesús Piña
- BIOFORGE (Group for Advanced
Materials and Nanobiotechnology), CIBER-BBN, University of Valladolid, 47011 Valladolid, Spain
| | - Arturo Ibáñez-Fonseca
- BIOFORGE (Group for Advanced
Materials and Nanobiotechnology), CIBER-BBN, University of Valladolid, 47011 Valladolid, Spain
| | - Alicia Fernández-Colino
- BIOFORGE (Group for Advanced
Materials and Nanobiotechnology), CIBER-BBN, University of Valladolid, 47011 Valladolid, Spain
| | - Francisco Javier Arias
- BIOFORGE (Group for Advanced
Materials and Nanobiotechnology), CIBER-BBN, University of Valladolid, 47011 Valladolid, Spain
| |
Collapse
|
20
|
Miletic S, Simpson DJ, Szymanski CM, Deyholos MK, Menassa R. A Plant-Produced Bacteriophage Tailspike Protein for the Control of Salmonella. FRONTIERS IN PLANT SCIENCE 2015; 6:1221. [PMID: 26779243 PMCID: PMC4705272 DOI: 10.3389/fpls.2015.01221] [Citation(s) in RCA: 6] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/15/2015] [Accepted: 12/18/2015] [Indexed: 05/07/2023]
Abstract
The receptor binding domain of the tailspike protein Gp9 from the P22 bacteriophage was recently shown to reduce Salmonella colonization in the chicken gut. In this study, we transiently expressed the receptor binding domain of the Gp9 tailspike protein in Nicotiana benthamiana, and targeted it to the endoplasmic reticulum (ER) or to the chloroplasts. Gp9 was also fused to either an elastin-like polypeptide (ELP) or hydrophobin I tag, which were previously described to improve accumulation levels of recombinant proteins. The highest levels of recombinant protein accumulation occurred when unfused Gp9 was targeted to the ER. Lower levels of chloroplast-targeted Gp9 were also detected. ELP-fused Gp9 was purified and demonstrated to bind to Salmonella enterica serovar Typhimurium in vitro. Upon oral administration of lyophilized leaves expressing Gp9-ELP to newly hatched chickens, we found that this tailspike protein has the potential to be used as a therapeutic to control Salmonella contamination in chickens.
Collapse
Affiliation(s)
- Sean Miletic
- Southern Crop Protection and Food Research Centre, Agriculture and Agri-Food Canada, LondonON, Canada
- Department of Biology, University of Western Ontario, LondonON, Canada
| | - David J. Simpson
- Alberta Glycomics Centre and Department of Biological Sciences, University of Alberta, EdmontonAB, Canada
| | - Christine M. Szymanski
- Alberta Glycomics Centre and Department of Biological Sciences, University of Alberta, EdmontonAB, Canada
| | | | - Rima Menassa
- Southern Crop Protection and Food Research Centre, Agriculture and Agri-Food Canada, LondonON, Canada
- Department of Biology, University of Western Ontario, LondonON, Canada
- *Correspondence: Rima Menassa,
| |
Collapse
|
21
|
Morgenfeld M, Lentz E, Segretin ME, Alfano EF, Bravo-Almonacid F. Translational fusion and redirection to thylakoid lumen as strategies to enhance accumulation of human papillomavirus E7 antigen in tobacco chloroplasts. Mol Biotechnol 2014; 56:1021-31. [PMID: 24981330 DOI: 10.1007/s12033-014-9781-x] [Citation(s) in RCA: 11] [Impact Index Per Article: 1.1] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/25/2022]
Abstract
Human papillomavirus (HPV) is the causal agent of cervical cancer, one of the most common causes of death in women worldwide, and its E7 antigen is the major candidate for a therapeutic vaccine. The large scale production of E7 by molecular farming that would lead to the development of a safe and inexpensive vaccine is impaired by its low accumulation level in the plant cell. To enhance antigen production in the plastids, two alternative strategies were carried out: the expression of E7 as a translational fusion to β-glucuronidase enzyme and redirection of E7 into the thylakoid lumen. The use of the β-glucuronidase as a partner protein turned out to be a successful strategy, antigen expression levels were enhanced between 30 and 40 times relative to unfused E7. Moreover, best accumulation, albeit at a high metabolic cost that compromised biomass production, was obtained redirecting E7 into the thylakoid lumen by the incorporation of the N-terminal transit peptide, Str. Following this approach lumenal E7 production exceeded the stromal by two orders of magnitude. Our results highlight the relevance of exploring different strategies to improve recombinant protein stability for certain transgenes in order to exploit potential advantages of recombinant protein accumulation in chloroplasts.
Collapse
Affiliation(s)
- Mauro Morgenfeld
- Instituto de Ingeniería Genética y Biología Molecular "Dr, Hector Torres" (INGEBI-CONICET), Vuelta de Obligado 2490, C.C 1428ADN, Ciudad Autónoma de Buenos Aires, Argentina
| | | | | | | | | |
Collapse
|
22
|
Ryu JS, Raucher D. Elastin-like polypeptide for improved drug delivery for anticancer therapy: preclinical studies and future applications. Expert Opin Drug Deliv 2014; 12:653-67. [PMID: 25350837 DOI: 10.1517/17425247.2015.974546] [Citation(s) in RCA: 22] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/05/2022]
Abstract
INTRODUCTION Despite their poor specificity, small molecule drugs are considered more powerful and effective than other current chemotherapies. A promising method for targeting these anticancer drugs to tumors, elastin-like polypeptides (ELP), has recently emerged. When an anticancer drug that has been conjugated to an ELP is administered, and focal hyperthermia applied, the thermoresponsive properties and enhanced permeability and retention effects of the ELP facilitate drug aggregation within tumor tissues. By incorporating a cell penetrating peptide onto this ELP-chemotherapeutic construct, even greater drug uptake into tumor cells can be achieved. AREAS COVERED The review explores the preclinical study progress of ELP-based drug delivery technology and discusses its potential in cancer therapy. Recent experimental work has shown that a delivery construct consisting of an ELP-therapeutic peptide (e.g., the c-Myc-inhibitory peptide, or the p21(WAF1/CIP1)-derived peptide), as well as ELP-small molecule drugs (e.g., doxorubicin, paclitaxel), can be thermally targeted to accumulate in tumors and diminish their growth. EXPERT OPINION ELP drug delivery technology is complementary and synergistic to current drug delivery modalities and based on existing hyperthermia technology. By using this technology to achieve chemotherapeutic targeting, efficacy can be improved and side effects reduced in comparison with current regimens, providing treatment alternatives and/or augmenting current therapies for cancer treatment.
Collapse
Affiliation(s)
- Jung Su Ryu
- University of Mississippi Medical Center, Department of Biochemistry , 2500 North State Street, Jackson, MS 39216 , USA +1 601 984 1510 ; +1 601 984 1501 ;
| | | |
Collapse
|
23
|
MacEwan SR, Chilkoti A. Applications of elastin-like polypeptides in drug delivery. J Control Release 2014; 190:314-30. [PMID: 24979207 DOI: 10.1016/j.jconrel.2014.06.028] [Citation(s) in RCA: 176] [Impact Index Per Article: 17.6] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/28/2014] [Revised: 06/17/2014] [Accepted: 06/18/2014] [Indexed: 01/08/2023]
Abstract
Elastin-like polypeptides (ELPs) are biopolymers inspired by human elastin. Their lower critical solution temperature phase transition behavior and biocompatibility make them useful materials for stimulus-responsive applications in biological environments. Due to their genetically encoded design and recombinant synthesis, the sequence and size of ELPs can be exactly defined. These design parameters control the structure and function of the ELP with a precision that is unmatched by synthetic polymers. Due to these attributes, ELPs have been used extensively for drug delivery in a variety of different embodiments-as soluble macromolecular carriers, self-assembled nanoparticles, cross-linked microparticles, or thermally coacervated depots. These ELP systems have been used to deliver biologic therapeutics, radionuclides, and small molecule drugs to a variety of anatomical sites for the treatment of diseases including cancer, type 2 diabetes, osteoarthritis, and neuroinflammation.
Collapse
Affiliation(s)
- Sarah R MacEwan
- Department of Biomedical Engineering, Duke University, Durham, NC 27708, USA; Research Triangle MRSEC, Duke University, Durham, NC 27708, USA
| | - Ashutosh Chilkoti
- Department of Biomedical Engineering, Duke University, Durham, NC 27708, USA; Research Triangle MRSEC, Duke University, Durham, NC 27708, USA.
| |
Collapse
|
24
|
Pereira EO, Kolotilin I, Conley AJ, Menassa R. Production and characterization of in planta transiently produced polygalacturanase from Aspergillus niger and its fusions with hydrophobin or ELP tags. BMC Biotechnol 2014; 14:59. [PMID: 24970673 PMCID: PMC4083859 DOI: 10.1186/1472-6750-14-59] [Citation(s) in RCA: 20] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/07/2014] [Accepted: 06/18/2014] [Indexed: 01/09/2023] Open
Abstract
BACKGROUND Pectinases play an important role in plant cell wall deconstruction and have potential in diverse industries such as food, wine, animal feed, textile, paper, fuel, and others. The demand for such enzymes is increasing exponentially, as are the efforts to improve their production and to implement their use in several industrial processes. The goal of this study was to examine the potential of producing polygalacturonase I from Aspergillus niger in plants and to investigate the effects of subcellular compartmentalization and protein fusions on its accumulation and activity. RESULTS Polygalacturonase I from Aspergillus niger (AnPGI) was transiently produced in Nicotiana benthamiana by targeting it to five different cellular compartments: apoplast, endoplasmic reticulum (ER), vacuole, chloroplast and cytosol. Accumulation levels of 2.5%, 3.0%, and 1.9% of total soluble protein (TSP) were observed in the apoplast, ER, and vacuole, respectively, and specific activity was significantly higher in vacuole-targeted AnPGI compared to the same enzyme targeted to the ER or apoplast. No accumulation was found for AnPGI when targeted to the chloroplast or cytosol. Analysis of AnPGI fused with elastin-like polypeptide (ELP) revealed a significant increase in the protein accumulation level, especially when targeted to the vacuole where the protein doubles its accumulation to 3.6% of TSP, while the hydrophobin (HFBI) fusion impaired AnPGI accumulation and both tags impaired activity, albeit to different extents. The recombinant protein showed activity against polygalacturonic acid with optimum conditions at pH 5.0 and temperature from 30 to 50°C, depending on its fusion. In vivo analysis of reducing sugar content revealed a higher release of reducing sugars in plant tissue expressing recombinant AnPGI compared to wild type N. benthamiana leaves. CONCLUSION Our results demonstrate that subcellular compartmentalization of enzymes has an impact on both the target protein accumulation and its activity, especially in the case of proteins that undergo post-translational modifications, and should be taken into consideration when protein production strategies are designed. Using plants to produce heterologous enzymes for the degradation of a key component of the plant cell wall could reduce the cost of biomass pretreatment for the production of cellulosic biofuels.
Collapse
Affiliation(s)
- Eridan Orlando Pereira
- Agriculture and Agri-Food Canada, 1391 Sandford Street, London, ON N5V 4T3, Canada
- Department of Biology, Western University, London, ON N6A 5B7, Canada
- Current address: Universidade Estadual do Ceará, Av. Dr. Silas Munguba, 1700 - Campus do Itaperi, Fortaleza 60714-903, Brazil
| | - Igor Kolotilin
- Agriculture and Agri-Food Canada, 1391 Sandford Street, London, ON N5V 4T3, Canada
| | | | - Rima Menassa
- Agriculture and Agri-Food Canada, 1391 Sandford Street, London, ON N5V 4T3, Canada
- Department of Biology, Western University, London, ON N6A 5B7, Canada
| |
Collapse
|
25
|
Phan HT, Hause B, Hause G, Arcalis E, Stoger E, Maresch D, Altmann F, Joensuu J, Conrad U. Influence of elastin-like polypeptide and hydrophobin on recombinant hemagglutinin accumulations in transgenic tobacco plants. PLoS One 2014; 9:e99347. [PMID: 24914995 PMCID: PMC4051685 DOI: 10.1371/journal.pone.0099347] [Citation(s) in RCA: 32] [Impact Index Per Article: 3.2] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/13/2014] [Accepted: 04/30/2014] [Indexed: 11/19/2022] Open
Abstract
Fusion protein strategies are useful tools to enhance expression and to support the development of purification technologies. The capacity of fusion protein strategies to enhance expression was explored in tobacco leaves and seeds. C-terminal fusion of elastin-like polypeptides (ELP) to influenza hemagglutinin under the control of either the constitutive CaMV 35S or the seed-specific USP promoter resulted in increased accumulation in both leaves and seeds compared to the unfused hemagglutinin. The addition of a hydrophobin to the C-terminal end of hemagglutinin did not significantly increase the expression level. We show here that, depending on the target protein, both hydrophobin fusion and ELPylation combined with endoplasmic reticulum (ER) targeting induced protein bodies in leaves as well as in seeds. The N-glycosylation pattern indicated that KDEL sequence-mediated retention of leaf-derived hemagglutinins and hemagglutinin-hydrophobin fusions were not completely retained in the ER. In contrast, hemagglutinin-ELP from leaves contained only the oligomannose form, suggesting complete ER retention. In seeds, ER retention seems to be nearly complete for all three constructs. An easy and scalable purification method for ELPylated proteins using membrane-based inverse transition cycling could be applied to both leaf- and seed-expressed hemagglutinins.
Collapse
Affiliation(s)
- Hoang Trong Phan
- Department of Molecular Genetics, Leibniz Institute of Plant Genetics and Crop Plant Research (IPK), Gatersleben, Germany
- Department of Plant Cell Biotechnology, Institute of Biotechnology (IBT), Vietnam Academy of Science and Technology (VAST), Hanoi, Vietnam
| | - Bettina Hause
- Cell and Metabolic Biology, Leibniz Institute of Plant Biochemistry (IPB), Halle, Germany
| | - Gerd Hause
- Microscopy Unit, Biocenter, University of Halle-Wittenberg, Halle, Germany
| | - Elsa Arcalis
- Molecular Plant Physiology, University of Natural Resources and Applied Life Sciences, Vienna, Austria
| | - Eva Stoger
- Molecular Plant Physiology, University of Natural Resources and Applied Life Sciences, Vienna, Austria
| | - Daniel Maresch
- Department of Chemistry, University of Natural Resources and Applied Life Sciences, Vienna, Austria
| | - Friedrich Altmann
- Department of Chemistry, University of Natural Resources and Applied Life Sciences, Vienna, Austria
| | - Jussi Joensuu
- VTT Technical Research Centre of Finland, Espoo, Finland
| | - Udo Conrad
- Department of Molecular Genetics, Leibniz Institute of Plant Genetics and Crop Plant Research (IPK), Gatersleben, Germany
| |
Collapse
|
26
|
TURNER PAULA, JOSHI GAURAVV, WEEKS CANDREW, WILLIAMSON RSCOTT, PUCKETT AAROND, JANORKAR AMOLV. NANO AND MICRO-STRUCTURES OF ELASTIN-LIKE POLYPEPTIDE-BASED MATERIALS AND THEIR APPLICATIONS: RECENT DEVELOPMENTS. ACTA ACUST UNITED AC 2014. [DOI: 10.1142/s1793984413430022] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.1] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/18/2022]
Abstract
Elastin-like polypeptide (ELP) containing materials have spurred significant research interest for biomedical applications exploiting their biocompatible, biodegradable and nonimmunogenic nature while maintaining precise control over their chemical structure and functionality through genetic engineering. Physical, mechanical and biological properties of ELPs could be further manipulated using genetic engineering or through conjugation with a variety of chemical moieties. These chemical and physical modifications also achieve interesting micro- and nanostructured ELP-based materials. Here, we review the recent developments during the past decade in the methods to engineer elastin-like materials, available genetic and chemical modification methods and applications of ELP micro and nanostructures in tissue engineering and drug delivery.
Collapse
Affiliation(s)
- PAUL A. TURNER
- Department of Biomedical Materials Science, School of Dentistry, University of Mississippi Medical Center, 2500 North State Street, Jackson, MS 39216, USA
| | - GAURAV V. JOSHI
- Department of Biomedical Materials Science, School of Dentistry, University of Mississippi Medical Center, 2500 North State Street, Jackson, MS 39216, USA
| | - C. ANDREW WEEKS
- Department of Biomedical Materials Science, School of Dentistry, University of Mississippi Medical Center, 2500 North State Street, Jackson, MS 39216, USA
| | - R. SCOTT WILLIAMSON
- Department of Biomedical Materials Science, School of Dentistry, University of Mississippi Medical Center, 2500 North State Street, Jackson, MS 39216, USA
| | - AARON D. PUCKETT
- Department of Biomedical Materials Science, School of Dentistry, University of Mississippi Medical Center, 2500 North State Street, Jackson, MS 39216, USA
| | - AMOL V. JANORKAR
- Department of Biomedical Materials Science, School of Dentistry, University of Mississippi Medical Center, 2500 North State Street, Jackson, MS 39216, USA
| |
Collapse
|
27
|
da Cunha NB, Vianna GR, da Almeida Lima T, Rech E. Molecular farming of human cytokines and blood products from plants: Challenges in biosynthesis and detection of plant-produced recombinant proteins. Biotechnol J 2013; 9:39-50. [DOI: 10.1002/biot.201300062] [Citation(s) in RCA: 19] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/10/2013] [Revised: 10/21/2013] [Accepted: 11/19/2013] [Indexed: 12/20/2022]
|
28
|
Sainsbury F, Varennes-Jutras P, Goulet MC, D'Aoust MA, Michaud D. Tomato cystatin SlCYS8 as a stabilizing fusion partner for human serpin expression in plants. PLANT BIOTECHNOLOGY JOURNAL 2013; 11:1058-68. [PMID: 23911079 DOI: 10.1111/pbi.12098] [Citation(s) in RCA: 20] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/19/2013] [Revised: 05/30/2013] [Accepted: 06/19/2013] [Indexed: 05/18/2023]
Abstract
Studies have reported the usefulness of fusion proteins to bolster recombinant protein yields in plants. Here, we assess the potential of tomato SlCYS8, a Cys protease inhibitor of the cystatin protein superfamily, as a stabilizing fusion partner for human alpha-1-antichymotrypsin (α1ACT) targeted to the plant cell secretory pathway. Using the model expression platform Nicotiana benthamiana, we show that the cystatin imparts a strong stabilizing effect when expressed as a translational fusion with α1ACT, allowing impressive accumulation yields of over 2 mg/g of fresh weight tissue for the human serpin, a 25-fold improvement on the yield of α1ACT expressed alone. Natural and synthetic peptide linkers inserted between SlCYS8 and α1ACT have differential effects on protease inhibitory potency of the two protein partners in vitro. They also have a differential impact on the yield of α1ACT, dependent on the extent to which the hybrid protein may remain intact in the plant cell environment. The stabilizing effect of SlCYS8 does not involve Cys protease inhibition and can be partly reproduced in the cytosol, where peptide linkers are less susceptible to degradation. The effect of SlCYS8 on α1ACT yields could be explained by: (i) an improved translation of the human protein coding sequence; and/or (ii) an overall stabilization of its tertiary structure preventing proteolytic degradation and/or polymerization. These findings suggest the potential of plant cystatins as stabilizing fusion partners for recombinant proteins in plant systems. They also underline the need for an empirical assessment of peptide linker functions in plant cell environments.
Collapse
Affiliation(s)
- Frank Sainsbury
- Département de Phytologie, Université Laval, Pavillon Envirotron, Québec, QC, Canada
| | | | | | | | | |
Collapse
|
29
|
Hauptmann V, Weichert N, Rakhimova M, Conrad U. Spider silks from plants - a challenge to create native-sized spidroins. Biotechnol J 2013; 8:1183-92. [DOI: 10.1002/biot.201300204] [Citation(s) in RCA: 17] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/10/2013] [Revised: 07/17/2013] [Accepted: 08/27/2013] [Indexed: 11/06/2022]
|
30
|
De Buck S, Nolf J, De Meyer T, Virdi V, De Wilde K, Van Lerberge E, Van Droogenbroeck B, Depicker A. Fusion of an Fc chain to a VHH boosts the accumulation levels in Arabidopsis seeds. PLANT BIOTECHNOLOGY JOURNAL 2013; 11:1006-16. [PMID: 23915060 DOI: 10.1111/pbi.12094] [Citation(s) in RCA: 29] [Impact Index Per Article: 2.6] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/08/2012] [Revised: 05/22/2013] [Accepted: 05/24/2013] [Indexed: 05/18/2023]
Abstract
Nanobodies® (VHHs) provide powerful tools in therapeutic and biotechnological applications. Nevertheless, for some applications, bivalent antibodies perform much better, and for this, an Fc chain can be fused to the VHH domain, resulting in a bivalent homodimeric VHH-Fc complex. However, the production of bivalent antibodies in Escherichia coli is rather inefficient. Therefore, we compared the production of VHH7 and VHH7-Fc as antibodies of interest in Arabidopsis seeds for detecting prostate-specific antigen (PSA), a well-known biomarker for prostate cancer in the early stages of tumour development. The influence of the signal sequence (camel versus plant) and that of the Fc chain origin (human, mouse or pig) were evaluated. The accumulation levels of VHHs were very low, with a maximum of 0.13% VHH of total soluble protein (TSP) in homozygous T3 seeds, while VHH-Fc accumulation levels were at least 10- to 100-fold higher, with a maximum of 16.25% VHH-Fc of TSP. Both the camel and plant signal peptides were efficiently cleaved off and did not affect the accumulation levels. However, the Fc chain origin strongly affected the degree of proteolysis, but only had a slight influence on the accumulation level. Analysis of the mRNA levels suggested that the low amount of VHHs produced in Arabidopsis seeds was not due to a failure in transcription, but rather to translation inefficiency, protein instability and/or degradation. Most importantly, the plant-produced VHH7 and VHH7-Fc antibodies were functional in detecting PSA and could thus be used for diagnostic applications.
Collapse
Affiliation(s)
- Sylvie De Buck
- Department of Plant Systems Biology, VIB, Gent, Belgium; Department of Plant Biotechnology and Bioinformatics, Ghent University, Gent, Belgium
| | | | | | | | | | | | | | | |
Collapse
|
31
|
Musiychuk K, Sivalenka R, Jaje J, Bi H, Flores R, Shaw B, Jones RM, Golovina T, Schnipper J, Khandker L, Sun R, Li C, Kang L, Voskinarian-Berse V, Zhang X, Streatfield S, Hambor J, Abbot S, Yusibov V. Plant-produced human recombinant erythropoietic growth factors support erythroid differentiation in vitro. Stem Cells Dev 2013; 22:2326-40. [PMID: 23517237 PMCID: PMC3730378 DOI: 10.1089/scd.2012.0489] [Citation(s) in RCA: 9] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/18/2012] [Accepted: 03/21/2013] [Indexed: 01/11/2023] Open
Abstract
Clinically available red blood cells (RBCs) for transfusions are at high demand, but in vitro generation of RBCs from hematopoietic stem cells requires significant quantities of growth factors. Here, we describe the production of four human growth factors: erythropoietin (EPO), stem cell factor (SCF), interleukin 3 (IL-3), and insulin-like growth factor-1 (IGF-1), either as non-fused proteins or as fusions with a carrier molecule (lichenase), in plants, using a Tobacco mosaic virus vector-based transient expression system. All growth factors were purified and their identity was confirmed by western blotting and peptide mapping. The potency of these plant-produced cytokines was assessed using TF1 cell (responsive to EPO, IL-3 and SCF) or MCF-7 cell (responsive to IGF-1) proliferation assays. The biological activity estimated here for the cytokines produced in plants was slightly lower or within the range cited in commercial sources and published literature. By comparing EC50 values of plant-produced cytokines with standards, we have demonstrated that all four plant-produced growth factors stimulated the expansion of umbilical cord blood-derived CD34+ cells and their differentiation toward erythropoietic precursors with the same potency as commercially available growth factors. To the best of our knowledge, this is the first report on the generation of all key bioactive cytokines required for the erythroid development in a cost-effective manner using a plant-based expression system.
Collapse
Affiliation(s)
| | | | - Jennifer Jaje
- Fraunhofer USA Center for Molecular Biotechnology, Newark, Delaware
| | - Hong Bi
- Fraunhofer USA Center for Molecular Biotechnology, Newark, Delaware
| | - Rosemary Flores
- Fraunhofer USA Center for Molecular Biotechnology, Newark, Delaware
| | - Brenden Shaw
- Fraunhofer USA Center for Molecular Biotechnology, Newark, Delaware
| | - R. Mark Jones
- Fraunhofer USA Center for Molecular Biotechnology, Newark, Delaware
| | - Tatiana Golovina
- Fraunhofer USA Center for Molecular Biotechnology, Newark, Delaware
| | | | | | - Ruiqiang Sun
- Celgene Cellular Therapeutics, Warren, New Jersey
| | - Chang Li
- Celgene Cellular Therapeutics, Warren, New Jersey
| | - Lin Kang
- Celgene Cellular Therapeutics, Warren, New Jersey
| | | | | | | | - John Hambor
- Celgene Cellular Therapeutics, Warren, New Jersey
| | | | - Vidadi Yusibov
- Fraunhofer USA Center for Molecular Biotechnology, Newark, Delaware
| |
Collapse
|
32
|
Duvenage L, Hitzeroth II, Meyers AE, Rybicki EP. Expression in tobacco and purification of beak and feather disease virus capsid protein fused to elastin-like polypeptides. J Virol Methods 2013; 191:55-62. [PMID: 23578703 DOI: 10.1016/j.jviromet.2013.03.028] [Citation(s) in RCA: 14] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/13/2012] [Revised: 03/20/2013] [Accepted: 03/25/2013] [Indexed: 02/05/2023]
Abstract
Psittacine beak and feather disease, caused by beak and feather disease virus (BFDV), is a threat to endangered psittacine species. There is currently no vaccine against BFDV, which necessitates the development of safe and affordable vaccine candidates. A subunit vaccine based on BFDV capsid protein (CP), the major antigenic determinant, expressed in the inexpensive and highly scalable plant expression system could satisfy these requirements. Full-length CP and a truncated CP (ΔN40 CP) were transiently expressed in tobacco (Nicotiana benthamiana) as fusions to elastin-like polypeptide (ELP). These two proteins were fused to ELPs of different lengths in order to increase expression levels and to provide a simple means of purification. The ELP fusion proteins were purified by inverse transition cycling (ITC) and it was found that a membrane filtration-based ITC method improved the recovery of ΔN40 CP-ELP51 fusion protein relative to a centrifugation-based method.
Collapse
Affiliation(s)
- Lucian Duvenage
- Department of Molecular and Cell Biology, University of Cape Town, Rondebosch 7700, South Africa
| | | | | | | |
Collapse
|
33
|
Kaldis A, Ahmad A, Reid A, McGarvey B, Brandle J, Ma S, Jevnikar A, Kohalmi SE, Menassa R. High-level production of human interleukin-10 fusions in tobacco cell suspension cultures. PLANT BIOTECHNOLOGY JOURNAL 2013; 11:535-45. [PMID: 23297698 PMCID: PMC3712471 DOI: 10.1111/pbi.12041] [Citation(s) in RCA: 37] [Impact Index Per Article: 3.4] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/17/2012] [Revised: 11/20/2012] [Accepted: 11/28/2012] [Indexed: 05/18/2023]
Abstract
The production of pharmaceutical proteins in plants has made much progress in recent years with the development of transient expression systems, transplastomic technology and humanizing glycosylation patterns in plants. However, the first therapeutic proteins approved for administration to humans and animals were made in plant cell suspensions for reasons of containment, rapid scale-up and lack of toxic contaminants. In this study, we have investigated the production of human interleukin-10 (IL-10) in tobacco BY-2 cell suspension and evaluated the effect of an elastin-like polypeptide tag (ELP) and a green fluorescent protein (GFP) tag on IL-10 accumulation. We report the highest accumulation levels of hIL-10 obtained with any stable plant expression system using the ELP fusion strategy. Although IL-10-ELP has cytokine activity, its activity is reduced compared to unfused IL-10, likely caused by interference of ELP with folding of IL-10. Green fluorescent protein has no effect on IL-10 accumulation, but examining the trafficking of IL-10-GFP over the cell culture cycle revealed fluorescence in the vacuole during the stationary phase of the culture growth cycle. Analysis of isolated vacuoles indicated that GFP alone is found in vacuoles, while the full-size fusion remains in the whole-cell extract. This indicates that GFP is cleaved off prior to its trafficking to the vacuole. On the other hand, IL-10-GFP-ELP remains mostly in the ER and accumulates to high levels. Protein bodies were observed at the end of the culture cycle and are thought to arise as a consequence of high levels of accumulation in the ER.
Collapse
Affiliation(s)
- Angelo Kaldis
- Southern Crop Protection and Food Research Centre, Agriculture and Agri-Food CanadaLondon, ON, Canada
| | - Adil Ahmad
- Southern Crop Protection and Food Research Centre, Agriculture and Agri-Food CanadaLondon, ON, Canada
- Department of Biology, Western UniversityLondon, ON, Canada
| | - Alexandra Reid
- Southern Crop Protection and Food Research Centre, Agriculture and Agri-Food CanadaLondon, ON, Canada
| | - Brian McGarvey
- Southern Crop Protection and Food Research Centre, Agriculture and Agri-Food CanadaLondon, ON, Canada
| | - Jim Brandle
- Vineland Research and Innovation CentreVineland Station, ON, Canada
| | - Shengwu Ma
- Department of Biology, Western UniversityLondon, ON, Canada
- Transplantation Immunology Group, Lawson Health Research InstituteLondon, ON, Canada
- Plantigen Inc.London, ON, Canada
| | - Anthony Jevnikar
- Transplantation Immunology Group, Lawson Health Research InstituteLondon, ON, Canada
- Plantigen Inc.London, ON, Canada
| | | | - Rima Menassa
- Southern Crop Protection and Food Research Centre, Agriculture and Agri-Food CanadaLondon, ON, Canada
- Department of Biology, Western UniversityLondon, ON, Canada
| |
Collapse
|
34
|
Phan HT, Pohl J, Floss DM, Rabenstein F, Veits J, Le BT, Chu HH, Hause G, Mettenleiter T, Conrad U. ELPylated haemagglutinins produced in tobacco plants induce potentially neutralizing antibodies against H5N1 viruses in mice. PLANT BIOTECHNOLOGY JOURNAL 2013; 11:582-93. [PMID: 23398695 DOI: 10.1111/pbi.12049] [Citation(s) in RCA: 31] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/28/2012] [Revised: 12/17/2012] [Accepted: 01/07/2013] [Indexed: 06/01/2023]
Abstract
Reducing the cost of vaccine production is a key priority for veterinary research, and the possibility of heterologously expressing antigen in plants provides a particularly attractive means of achieving this. Here, we report the expression of the avian influenza virus haemagglutinin (AIV HA) in tobacco, both as a monomer and as a trimer in its native and its ELPylated form. We firstly presented evidence to produce stabilized trimers of soluble HA in plants. ELPylation of these trimers does not influence the trimerization. Strong expression enhancement in planta caused by ELPylation was demonstrated for trimerized H5-ELP. ELPylated trimers could be purified by a membrane-based inverse transition cycling procedure with the potential of successful scale-up. The trimeric form of AIV HA was found to enhance the HA-specific immune response compared with the monomeric form. Plant-derived AIV HA trimers elicited potentially neutralizing antibodies interacting with both homologous virus-like particles from plants and heterologous inactivated AIV. ELPylation did not influence the functionality and the antigenicity of the stabilized H5 trimers. These data allow further developments including scale-up of production, purification and virus challenge experiments with the final goal to achieve suitable technologies for efficient avian flu vaccine production.
Collapse
Affiliation(s)
- Hoang T Phan
- Leibniz Institute of Plant Genetics and Crop Plant Research-IPK, Gatersleben, Germany
| | | | | | | | | | | | | | | | | | | |
Collapse
|
35
|
Gutiérrez SP, Saberianfar R, Kohalmi SE, Menassa R. Protein body formation in stable transgenic tobacco expressing elastin-like polypeptide and hydrophobin fusion proteins. BMC Biotechnol 2013; 13:40. [PMID: 23663656 PMCID: PMC3659085 DOI: 10.1186/1472-6750-13-40] [Citation(s) in RCA: 41] [Impact Index Per Article: 3.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/06/2013] [Accepted: 05/06/2013] [Indexed: 01/04/2023] Open
Abstract
BACKGROUND Plants are recognized as an efficient and inexpensive system to produce valuable recombinant proteins. Two different strategies have been commonly used for the expression of recombinant proteins in plants: transient expression mediated by Agrobacterium; or stable transformation of the plant genome. However, the use of plants as bioreactors still faces two main limitations: low accumulation levels of some recombinant proteins and lack of efficient purification methods. Elastin-like polypeptide (ELP), hydrophobin I (HFBI) and Zera® are three fusion partners found to increase the accumulation levels of recombinant proteins and induce the formation of protein bodies (PBs) in leaves when targeted to the endoplasmic reticulum (ER) in transient expression assays. In this study the effects of ELP and HFBI fusion tags on recombinant protein accumulation levels and PB formation was examined in stable transgenic Nicotiana tabacum. RESULTS The accumulation of recombinant protein and PB formation was evaluated in two cultivars of Nicotiana tabacum transformed with green fluorescent protein (GFP) fused to ELP or HFBI, both targeted and retrieved to the ER. The ELP and HFBI tags increased the accumulation of the recombinant protein and induced the formation of PBs in leaves of stable transgenic plants from both cultivars. Furthermore, these tags induced the formation of PBs in a concentration-dependent manner, where a specific level of recombinant protein accumulation was required for PBs to appear. Moreover, agro-infiltration of plants accumulating low levels of recombinant protein with p19, a suppressor of post-transcriptional gene silencing (PTGS), increased accumulation levels in four independent transgenic lines, suggesting that PTGS might have caused the low accumulation levels in these plants. CONCLUSION The use of ELP and HFBI tags as fusion partners in stable transgenic plants of tobacco is feasible and promising. In a constitutive environment, these tags increase the accumulation levels of the recombinant protein and induce the formation of PBs regardless of the cultivar used. However, a specific level of recombinant protein accumulation needs to be reached for PBs to form.
Collapse
Affiliation(s)
- Sonia P Gutiérrez
- Department of Biology, University of Western Ontario, London, ON, Canada
- Southern Crop Protection and Food Research Centre, Agriculture and Agri-Food Canada, London, ON, Canada
| | - Reza Saberianfar
- Department of Biology, University of Western Ontario, London, ON, Canada
- Southern Crop Protection and Food Research Centre, Agriculture and Agri-Food Canada, London, ON, Canada
| | - Susanne E Kohalmi
- Department of Biology, University of Western Ontario, London, ON, Canada
| | - Rima Menassa
- Department of Biology, University of Western Ontario, London, ON, Canada
- Southern Crop Protection and Food Research Centre, Agriculture and Agri-Food Canada, London, ON, Canada
| |
Collapse
|
36
|
Heidebrecht A, Scheibel T. Recombinant production of spider silk proteins. ADVANCES IN APPLIED MICROBIOLOGY 2013; 82:115-53. [PMID: 23415154 DOI: 10.1016/b978-0-12-407679-2.00004-1] [Citation(s) in RCA: 87] [Impact Index Per Article: 7.9] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/26/2022]
Abstract
Natural spider silk fibers combine extraordinary properties such as stability and flexibility which results in a toughness superseding that of all other fiber materials. As the spider's aggressive territorial behavior renders their farming not feasible, the biotechnological production of spider silk proteins (spidroins) is essential in order to investigate and employ them for applications. In order to accomplish this task, two approaches have been tested: firstly, the expression of partial cDNAs, and secondly, the expression of synthetic genes in several host organisms, including bacteria, yeast, plants, insect cells, mammalian cells, and transgenic animals. The experienced problems include genetic instability, limitations of the translational and transcriptional machinery, and low solubility of the produced proteins. Here, an overview of attempts to recombinantly produce spidroins will be given, and advantages and disadvantages of the different approaches and host organisms will be discussed.
Collapse
|
37
|
Yang L, Hirose S, Takahashi H, Kawakatsu T, Takaiwa F. Recombinant protein yield in rice seed is enhanced by specific suppression of endogenous seed proteins at the same deposit site. PLANT BIOTECHNOLOGY JOURNAL 2012; 10:1035-45. [PMID: 22882653 DOI: 10.1111/j.1467-7652.2012.00731.x] [Citation(s) in RCA: 25] [Impact Index Per Article: 2.1] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 05/20/2023]
Abstract
Human IL-10 (hIL-10) is a therapeutic treatment candidate for inflammatory allergy and autoimmune diseases. Rice seed-produced IL-10 can be effectively delivered directly to gut-associated lymphoreticular tissue (GALT) via bio-encapsulation. Previously, the codon-optimized hIL-10 gene was expressed in transgenic rice with the signal peptide and endoplasmic reticulum (ER) retention signal (KDEL) at its 5' and 3' ends, respectively, under the control of the endosperm-specific glutelin GluB-1 promoter. The resulting purified hIL-10 was biologically active. In this study, the yield of hIL-10 in transgenic rice seed was improved. This protein accumulated at the intended deposition sites, which had been made vacant through the selective reduction, via RNA interference, of the endogenous seed storage proteins prolamins or glutelins. Upon suppression of prolamins that were sequestered into ER-derived protein bodies (PB-I), hIL-10 accumulation increased approximately 3-fold as compared to rice seed with no such suppression and reached 219 μg/grain. In contrast, reducing the majority of the glutelins stored in protein-storage vacuoles (PB-II) did not significantly affect the accumulation of hIL-10. Considering that hIL-10 is synthesized in the ER lumen and subsequently buds off in ER-derived granules called IL-10 granules in a manner similar to PB-Is, these results indicate that increases in the available deposition space for the desired recombinant proteins may be crucial for improvements in yield. Furthermore, efficient dimeric intermolecular formation of hIL-10 by inhibiting interaction with Cys-rich prolamins also contributed to the enhanced formation of IL-10 bodies. Higher yield of hIL-10 produced in rice seeds is expected to have broad application in the future.
Collapse
Affiliation(s)
- Lijun Yang
- Functional Transgenic Crops Research Unit, National Institute of Agrobiological Sciences, Tsukuba, Ibaraki, Japan
| | | | | | | | | |
Collapse
|
38
|
Lotter-Stark HCT, Rybicki EP, Chikwamba RK. Plant made anti-HIV microbicides--a field of opportunity. Biotechnol Adv 2012; 30:1614-26. [PMID: 22750509 PMCID: PMC7132877 DOI: 10.1016/j.biotechadv.2012.06.002] [Citation(s) in RCA: 10] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/24/2011] [Revised: 06/10/2012] [Accepted: 06/20/2012] [Indexed: 12/15/2022]
Abstract
HIV remains a significant global burden and without an effective vaccine, it is crucial to develop microbicides to halt the initial transmission of the virus. Several microbicides have been researched with various levels of success. Amongst these, the broadly neutralising antibodies and peptide lectins are promising in that they can immediately act on the virus and have proven efficacious in in vitro and in vivo protection studies. For the purpose of development and access by the relevant population groups, it is crucial that these microbicides be produced at low cost. For the promising protein and peptide candidate molecules, it appears that current production systems are overburdened and expensive to establish and maintain. With recent developments in vector systems for protein expression coupled with downstream protein purification technologies, plants are rapidly gaining credibility as alternative production systems. Here we evaluate the advances made in host and vector system development for plant expression as well as the progress made in expressing HIV neutralising antibodies and peptide lectins using plant-based platforms.
Collapse
|
39
|
Westerhof LB, Wilbers RHP, Roosien J, van de Velde J, Goverse A, Bakker J, Schots A. 3D domain swapping causes extensive multimerisation of human interleukin-10 when expressed in planta. PLoS One 2012; 7:e46460. [PMID: 23049703 PMCID: PMC3462211 DOI: 10.1371/journal.pone.0046460] [Citation(s) in RCA: 16] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/24/2012] [Accepted: 08/30/2012] [Indexed: 11/20/2022] Open
Abstract
Heterologous expression platforms of biopharmaceutical proteins have been significantly improved over the last decade. Further improvement can be established by examining the intrinsic properties of proteins. Interleukin-10 (IL-10) is an anti-inflammatory cytokine with a short half-life that plays an important role in re-establishing immune homeostasis. This homodimeric protein of 36 kDa has significant therapeutic potential to treat inflammatory and autoimmune diseases. In this study we show that the major production bottleneck of human IL-10 is not protein instability as previously suggested, but extensive multimerisation due to its intrinsic 3D domain swapping characteristic. Extensive multimerisation of human IL-10 could be visualised as granules in planta. On the other hand, mouse IL-10 hardly multimerised, which could be largely attributed to its glycosylation. By introducing a short glycine-serine-linker between the fourth and fifth alpha helix of human IL-10 a stable monomeric form of IL-10 (hIL-10(mono)) was created that no longer multimerised and increased yield up to 20-fold. However, hIL-10(mono) no longer had the ability to reduce pro-inflammatory cytokine secretion from lipopolysaccharide-stimulated macrophages. Forcing dimerisation restored biological activity. This was achieved by fusing human IL-10(mono) to the C-terminal end of constant domains 2 and 3 of human immunoglobulin A (Fcα), a natural dimer. Stable dimeric forms of IL-10, like Fcα-IL-10, may not only be a better format for improved production, but also a more suitable format for medical applications.
Collapse
Affiliation(s)
- Lotte B Westerhof
- Laboratory of Nematology, Wageningen University, Wageningen, The Netherlands.
| | | | | | | | | | | | | |
Collapse
|
40
|
Green factory: Plants as bioproduction platforms for recombinant proteins. Biotechnol Adv 2012; 30:1171-84. [DOI: 10.1016/j.biotechadv.2011.08.020] [Citation(s) in RCA: 132] [Impact Index Per Article: 11.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/08/2011] [Revised: 08/24/2011] [Accepted: 08/30/2011] [Indexed: 12/15/2022]
|
41
|
Lentz EM, Garaicoechea L, Alfano EF, Parreño V, Wigdorovitz A, Bravo-Almonacid FF. Translational fusion and redirection to thylakoid lumen as strategies to improve the accumulation of a camelid antibody fragment in transplastomic tobacco. PLANTA 2012; 236:703-14. [PMID: 22526499 DOI: 10.1007/s00425-012-1642-x] [Citation(s) in RCA: 14] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/25/2012] [Accepted: 03/28/2012] [Indexed: 05/03/2023]
Abstract
Fragments from camelid single-chain antibodies known as VHHs or nanobodies represent a valuable tool in diagnostics, investigation and passive immunity therapy. Here, we explored different strategies to improve the accumulation of a neutralizing VHH antibody against rotavirus in tobacco transplastomic plants. First, we attempted to express the VHH in the chloroplast stroma and then two alternative strategies were carried out to improve the expression levels: expression as a translational fusion to the β-glucuronidase enzyme (GUS-E-VHH), and redirection of the VHH into the thylakoid lumen (pep-VHH). Every attempt to produce transplastomic plants expressing the VHH in the stroma was futile. The transgene turned out to be unstable and the presence of the VHH protein was almost undetectable. Although pep-VHH plants also presented some of the aforementioned problems, higher accumulation of the nanobody was observed (2-3% of the total soluble proteins). The use of β-glucuronidase as a partner protein turned out to be a successful strategy and expression levels reached 3% of the total soluble proteins. The functionality of the VHHs produced by pep-VHH and GUS-E-VHH plants was studied and compared with that of the antibody produced in Escherichia coli. This work contributes to optimizing the expression of VHH in transplastomic plants. Recombinant proteins could be obtained either by accumulation in the thylakoid lumen or as a fusion protein with β-glucuronidase, and both strategies allow for further optimization.
Collapse
Affiliation(s)
- Ezequiel M Lentz
- Instituto de Investigaciones en Ingeniería Genética y Biología Molecular (INGEBI), CONICET, Vuelta de Obligado 2490, C1428ADN, Buenos Aires, Argentina
| | | | | | | | | | | |
Collapse
|
42
|
Goulet C, Khalf M, Sainsbury F, D'Aoust MA, Michaud D. A protease activity-depleted environment for heterologous proteins migrating towards the leaf cell apoplast. PLANT BIOTECHNOLOGY JOURNAL 2012; 10:83-94. [PMID: 21895943 DOI: 10.1111/j.1467-7652.2011.00643.x] [Citation(s) in RCA: 48] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 05/24/2023]
Abstract
Recombinant proteins face major constraints along the plant cell secretory pathway, including proteolytic processing compromising their structural integrity. Here, we demonstrate the potential of protease inhibitors as in situ stabilizing agents for recombinant proteins migrating towards the leaf apoplast. Genomic data for Arabidopsis, rice and Nicotiana spp. were assessed to determine the relative incidence of protease families in the cell secretory pathway. Transient expression assays with the model platform Nicotiana benthamiana were then performed to test the efficiency of protease inhibitors in stabilizing proteins targeted to the apoplast. Current genomic data suggest the occurrence of proteases from several families along the secretory pathway, including A1 and A22 Asp proteases; C1A and C13 Cys proteases; and S1, S8 and S10 Ser proteases. In vitro protease assays confirmed the presence of various proteases in N. benthamiana leaves, notably pointing to the deposition of A1- and S1-type activities preferentially in the apoplast. Accordingly, transient expression and secretion of the A1/S1 protease inhibitor, tomato cathepsin D inhibitor (SlCDI), negatively altered A1 and S1 protease activities in this cell compartment, while increasing the leaf apoplast protein content by ∼45% and improving the accumulation of a murine diagnostic antibody, C5-1, co-secreted in the apoplast. SlCYS9, an inhibitor of C1A and C13 Cys proteases, had no impact on the apoplast proteases and protein content, but stabilized C5-1 in planta, presumably upstream in the secretory pathway. These data confirm, overall, the potential of protease inhibitors for the in situ protection of recombinant proteins along the plant cell secretory pathway.
Collapse
Affiliation(s)
- Charles Goulet
- Département de phytologie, Université Laval, Pavillon des Services (INAF), Québec, QC, Canada
| | | | | | | | | |
Collapse
|
43
|
Tian L, Sun SSM. A cost-effective ELP-intein coupling system for recombinant protein purification from plant production platform. PLoS One 2011; 6:e24183. [PMID: 21918684 PMCID: PMC3168869 DOI: 10.1371/journal.pone.0024183] [Citation(s) in RCA: 30] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/13/2011] [Accepted: 08/02/2011] [Indexed: 02/07/2023] Open
Abstract
BACKGROUND Plant bioreactor offers an efficient and economical system for large-scale production of recombinant proteins. However, high cost and difficulty in scaling-up of downstream purification of the target protein, particularly the common involvement of affinity chromatography and protease in the purification process, has hampered its industrial scale application, therefore a cost-effective and easily scale-up purification method is highly desirable for further development of plant bioreactor. METHODOLOGY/PRINCIPAL FINDINGS To tackle this problem, we investigated the ELP-intein coupling system for purification of recombinant proteins expressed in transgenic plants using a plant lectin (PAL) with anti-tumor bioactivity as example target protein and rice seeds as production platform. Results showed that ELP-intein-PAL (EiP) fusion protein formed novel irregular ER-derived protein bodies in endosperm cells by retention of endogenous prolamins. The fusion protein was partially self-cleaved in vivo, but only self-cleaved PAL protein was detected in total seed protein sample and deposited in protein storage vacuoles (PSV). The in vivo uncleaved EiP protein was accumulated up to 2-4.2% of the total seed protein. The target PAL protein could be purified by the ELP-intein system efficiently without using complicated instruments and expensive chemicals, and the yield of pure PAL protein by the current method was up to 1.1 mg/g total seed protein. CONCLUSION/SIGNIFICANCE This study successfully demonstrated the purification of an example recombinant protein from rice seeds by the ELP-intein system. The whole purification procedure can be easily scaled up for industrial production, providing the first evidence on applying the ELP-intein coupling system to achieve cost-effective purification of recombinant proteins expressed in plant bioreactors and its possible application in industry.
Collapse
Affiliation(s)
- Li Tian
- School of Life Sciences, Tsinghua University, Beijing, China
- Life Science Division, Graduate School at Shenzhen, Tsinghua University, Shenzhen, China
- School of Life Sciences, The Chinese University of Hong Kong, Shatin, N.T., Hong Kong, China
| | - Samuel S. M. Sun
- Life Science Division, Graduate School at Shenzhen, Tsinghua University, Shenzhen, China
- School of Life Sciences, The Chinese University of Hong Kong, Shatin, N.T., Hong Kong, China
- * E-mail:
| |
Collapse
|
44
|
Soria-Guerra RE, Moreno-Fierros L, Rosales-Mendoza S. Two decades of plant-based candidate vaccines: a review of the chimeric protein approaches. PLANT CELL REPORTS 2011; 30:1367-1382. [PMID: 21505834 DOI: 10.1007/s00299-011-1065-3] [Citation(s) in RCA: 31] [Impact Index Per Article: 2.4] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/24/2011] [Revised: 03/20/2011] [Accepted: 03/22/2011] [Indexed: 05/30/2023]
Abstract
Genetic engineering revolutionized the concept of traditional vaccines since subunit vaccines became reality. Additionally, over the past two decades plant-derived antigens have been studied as potential vaccines with several advantages, including low cost and convenient administration. More specifically, genetic fusions allowed the expression of fusion proteins carrying two or more components with the aim to elicit immune responses against different targets, including antigens from distinct pathogens or strains. This review aims to provide an update in the field of the production of plant-based vaccine, focusing on those approaches based on the production of chimeric proteins comprising antigens from human pathogens, emphasizing the case of cholera toxin/E. coli enterotoxin fusions, chimeric viruses like particles approaches as well as the possible use of adjuvant-producing plants as expression hosts. Challenges for the near future in this field are also discussed.
Collapse
Affiliation(s)
- Ruth Elena Soria-Guerra
- Laboratorio de biofarmacéuticos recombinantes, Facultad de Ciencias Químicas, Universidad Autónoma de San Luis Potosí, Av. Dr. Manuel Nava 6, 78210, San Luis Potosi, SLP, Mexico
| | | | | |
Collapse
|
45
|
Saumonneau A, Rottier K, Conrad U, Popineau Y, Guéguen J, Francin-Allami M. Expression of a new chimeric protein with a highly repeated sequence in tobacco cells. PLANT CELL REPORTS 2011; 30:1289-302. [PMID: 21373795 DOI: 10.1007/s00299-011-1040-z] [Citation(s) in RCA: 9] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/25/2011] [Revised: 02/04/2011] [Accepted: 02/09/2011] [Indexed: 05/30/2023]
Abstract
In wheat, the high-molecular weight (HMW) glutenin subunits are known to contribute to gluten viscoelasticity, and show some similarities to elastomeric animal proteins as elastin. When combining the sequence of a glutenin with that of elastin is a way to create new chimeric functional proteins, which could be expressed in plants. The sequence of a glutenin subunit was modified by the insertion of several hydrophobic and elastic motifs derived from elastin (elastin-like peptide, ELP) into the hydrophilic repetitive domain of the glutenin subunit to create a triblock protein, the objective being to improve the mechanical (elastomeric) properties of this wheat storage protein. In this study, we investigated an expression model system to analyze the expression and trafficking of the wild-type HMW glutenin subunit (GS(W)) and an HMW glutenin subunit mutated by the insertion of elastin motifs (GS(M)-ELP). For this purpose, a series of constructs was made to express wild-type subunits and subunits mutated by insertion of elastin motifs in fusion with green fluorescent protein (GFP) in tobacco BY-2 cells. Our results showed for the first time the expression of HMW glutenin fused with GFP in tobacco protoplasts. We also expressed and localized the chimeric protein composed of plant glutenin and animal elastin-like peptides (ELP) in BY-2 protoplasts, and demonstrated its presence in protein body-like structures in the endoplasmic reticulum. This work, therefore, provides a basis for heterologous production of the glutenin-ELP triblock protein to characterize its mechanical properties.
Collapse
Affiliation(s)
- Amélie Saumonneau
- Institut National de la Recherche Agronomique, UR1268, Biopolymères Interactions Assemblages, Nantes, France
| | | | | | | | | | | |
Collapse
|
46
|
Recombinant cytokines from plants. Int J Mol Sci 2011; 12:3536-52. [PMID: 21747693 PMCID: PMC3131577 DOI: 10.3390/ijms12063536] [Citation(s) in RCA: 21] [Impact Index Per Article: 1.6] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/31/2011] [Revised: 05/11/2011] [Accepted: 05/27/2011] [Indexed: 11/21/2022] Open
Abstract
Plant-based platforms have been successfully applied for the last two decades for the efficient production of pharmaceutical proteins. The number of commercialized products biomanufactured in plants is, however, rather discouraging. Cytokines are small glycosylated polypeptides used in the treatment of cancer, immune disorders and various other related diseases. Because the clinical use of cytokines is limited by high production costs they are good candidates for plant-made pharmaceuticals. Several research groups explored the possibilities of cost-effective production of animal cytokines in plant systems. This review summarizes recent advances in this field.
Collapse
|
47
|
Conley AJ, Joensuu JJ, Richman A, Menassa R. Protein body-inducing fusions for high-level production and purification of recombinant proteins in plants. PLANT BIOTECHNOLOGY JOURNAL 2011; 9:419-33. [PMID: 21338467 DOI: 10.1111/j.1467-7652.2011.00596.x] [Citation(s) in RCA: 47] [Impact Index Per Article: 3.6] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 05/08/2023]
Abstract
For the past two decades, therapeutic and industrially important proteins have been expressed in plants with varying levels of success. The two major challenges hindering the economical production of plant-made recombinant proteins include inadequate accumulation levels and the lack of efficient purification methods. To address these limitations, several fusion protein strategies have been recently developed to significantly enhance the production yield of plant-made recombinant proteins, while simultaneously assisting in their subsequent purification. Elastin-like polypeptides are thermally responsive biopolymers composed of a repeating pentapeptide 'VPGXG' sequence that are valuable for the purification of recombinant proteins. Hydrophobins are small fungal proteins capable of altering the hydrophobicity of their respective fusion partner, thus enabling efficient purification by surfactant-based aqueous two-phase systems. Zera, a domain of the maize seed storage protein γ-zein, can induce the formation of protein storage bodies, thus facilitating the recovery of fused proteins using density-based separation methods. These three novel protein fusion systems have also been shown to enhance the accumulation of a range of different recombinant proteins, while concurrently inducing the formation of protein bodies. The packing of these fusion proteins into protein bodies may exclude the recombinant protein from normal physiological turnover. Furthermore, these systems allow for quick, simple and inexpensive nonchromatographic purification of the recombinant protein, which can be scaled up to industrial levels of protein production. This review will focus on the similarities and differences of these artificial storage organelles, their biogenesis and their implication for the production of recombinant proteins in plants and their subsequent purification.
Collapse
Affiliation(s)
- Andrew J Conley
- Southern Crop Protection and Food Research Centre, Agriculture and Agri-Food Canada, London, ON, Canada
| | | | | | | |
Collapse
|
48
|
Conley AJ, Zhu H, Le LC, Jevnikar AM, Lee BH, Brandle JE, Menassa R. Recombinant protein production in a variety of Nicotiana hosts: a comparative analysis. PLANT BIOTECHNOLOGY JOURNAL 2011; 9:434-44. [PMID: 21040385 DOI: 10.1111/j.1467-7652.2010.00563.x] [Citation(s) in RCA: 26] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 05/03/2023]
Abstract
Although many different crop species have been used to produce a wide range of vaccines, antibodies, biopharmaceuticals and industrial enzymes, tobacco has the most established history for the production of recombinant proteins. To further improve the heterologous protein yield of tobacco platforms, transient and stable expression of four recombinant proteins (i.e. human erythropoietin and interleukin-10, an antibody against Pseudomonas aeruginosa, and a hyperthermostable α-amylase) was evaluated in numerous species and cultivars of Nicotiana. Whereas the transient level of recombinant protein accumulation varied significantly amongst the different Nicotiana plant hosts, the variety of Nicotiana had little practical impact on the recombinant protein concentration in stable transgenic plants. In addition, this study examined the growth rate, amount of leaf biomass, total soluble protein levels and the alkaloid content of the various Nicotiana varieties to establish the best plant platform for commercial production of recombinant proteins. Of the 52 Nicotiana varieties evaluated, Nicotiana tabacum (cv. I 64) produced the highest transient concentrations of recombinant proteins, in addition to producing a large amount of biomass and a relatively low quantity of alkaloids, probably making it the most effective plant host for recombinant protein production.
Collapse
Affiliation(s)
- Andrew J Conley
- Department of Biology, University of Western Ontario, London, ON, Canada
| | | | | | | | | | | | | |
Collapse
|
49
|
Llop-Tous I, Ortiz M, Torrent M, Ludevid MD. The expression of a xylanase targeted to ER-protein bodies provides a simple strategy to produce active insoluble enzyme polymers in tobacco plants. PLoS One 2011; 6:e19474. [PMID: 21559333 PMCID: PMC3084875 DOI: 10.1371/journal.pone.0019474] [Citation(s) in RCA: 32] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/03/2011] [Accepted: 04/04/2011] [Indexed: 12/26/2022] Open
Abstract
BACKGROUND Xylanases deserve particular attention due to their potential application in the feed, pulp bleaching and paper industries. We have developed here an efficient system for the production of an active xylanase in tobacco plants fused to a proline-rich domain (Zera) of the maize storage protein γ-zein. Zera is a self-assembling domain able to form protein aggregates in vivo packed in newly formed endoplasmic reticulum-derived organelles known as protein bodies (PBs). METHODOLOGY/PRINCIPAL FINDINGS Tobacco leaves were transiently transformed with a binary vector containing the Zera-xylanase coding region, which was optimized for plant expression, under the control of the 35S CaMV promoter. The fusion protein was efficiently expressed and stored in dense PBs, resulting in yields of up to 9% of total protein. Zera-xylanase was post-translationally modified with high-mannose-type glycans. Xylanase fused to Zera was biologically active not only when solubilized from PBs but also in its insoluble form. The resistance of insoluble Zera-xylanase to trypsin digestion demonstrated that the correct folding of xylanase in PBs was not impaired by Zera oligomerization. The activity of insoluble Zera-xylanase was enhanced when substrate accessibility was facilitated by physical treatments such as ultrasound. Moreover, we found that the thermostability of the enzyme was improved when Zera was fused to the C-terminus of xylanase. CONCLUSION/SIGNIFICANCE In the present work we have successfully produced an active insoluble aggregate of xylanase fused to Zera in plants. Zera-xylanase chimeric protein accumulates within ER-derived protein bodies as active aggregates that can easily be recovered by a simple density-based downstream process. The production of insoluble active Zera-xylanase protein in tobacco outlines the potential of Zera as a fusion partner for producing enzymes of biotechnological relevance. Zera-PBs could thus become efficient and low-cost bioreactors for industrial purposes.
Collapse
Affiliation(s)
- Immaculada Llop-Tous
- Department of Molecular Genetics, Centre for Research in Agricultural Genomics (CRAG, Consortium CSIC-IRTA-UAB), Barcelona, Spain
- ERA Biotech, Barcelona, Spain
| | - Miriam Ortiz
- Department of Molecular Genetics, Centre for Research in Agricultural Genomics (CRAG, Consortium CSIC-IRTA-UAB), Barcelona, Spain
| | - Margarita Torrent
- Department of Molecular Genetics, Centre for Research in Agricultural Genomics (CRAG, Consortium CSIC-IRTA-UAB), Barcelona, Spain
| | - M. Dolors Ludevid
- Department of Molecular Genetics, Centre for Research in Agricultural Genomics (CRAG, Consortium CSIC-IRTA-UAB), Barcelona, Spain
| |
Collapse
|
50
|
Rising A, Widhe M, Johansson J, Hedhammar M. Spider silk proteins: recent advances in recombinant production, structure-function relationships and biomedical applications. Cell Mol Life Sci 2011; 68:169-84. [PMID: 20668909 PMCID: PMC11114806 DOI: 10.1007/s00018-010-0462-z] [Citation(s) in RCA: 145] [Impact Index Per Article: 11.2] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/17/2010] [Revised: 06/04/2010] [Accepted: 07/09/2010] [Indexed: 11/26/2022]
Abstract
Spider dragline silk is an outstanding material made up of unique proteins-spidroins. Analysis of the amino acid sequences of full-length spidroins reveals a tripartite composition: an N-terminal non-repetitive domain, a highly repetitive central part composed of approximately 100 polyalanine/glycine rich co-segments and a C-terminal non-repetitive domain. Recent molecular data on the terminal domains suggest that these have different functions. The composite nature of spidroins allows for recombinant production of individual and combined regions. Miniaturized spidroins designed by linking the terminal domains with a limited number of repetitive segments recapitulate the properties of native spidroins to a surprisingly large extent, provided that they are produced and isolated in a manner that retains water solubility until fibre formation is triggered. Biocompatibility studies in cell culture or in vivo of native and recombinant spider silk indicate that they are surprisingly well tolerated, suggesting that recombinant spider silk has potential for biomedical applications.
Collapse
Affiliation(s)
- Anna Rising
- Department of Anatomy Physiology and Biochemistry, The Biomedical Centre, Swedish University of Agricultural Sciences, 751-23 Uppsala, Sweden
| | - Mona Widhe
- Department of Anatomy Physiology and Biochemistry, The Biomedical Centre, Swedish University of Agricultural Sciences, 751-23 Uppsala, Sweden
| | - Jan Johansson
- Department of Anatomy Physiology and Biochemistry, The Biomedical Centre, Swedish University of Agricultural Sciences, 751-23 Uppsala, Sweden
| | - My Hedhammar
- Department of Anatomy Physiology and Biochemistry, The Biomedical Centre, Swedish University of Agricultural Sciences, 751-23 Uppsala, Sweden
| |
Collapse
|