Exposure to inhalable dust and endotoxins in agricultural industries

Bioaerosol emission characteristics and potential risks during composting: Focus on pathogens and antimicrobial resistance

In this study, we analyzed bioaerosol emission characteristics and potential risks of antimicrobial resistance (AMR) during composting using the impaction culture method and metagenomic sequencing. The results showed that the highly saturated water vapor in the emission gas mitigated particulate matter emission during the thermophilic period. About the bioaerosols, the airborne aerobic bacterial emissions were suppressed as composting enters the mature period, and the airborne fungi are usually present as single-cell or small-cell aggregates (< 3.3 µm). In addition, the microbial community structure in bioaerosols was stable and independent of composting time. Most importantly, the PM2.5 in bioaerosols contained large amounts of antibiotic resistance genes (ARGs), potential pathogens, and multidrug resistant pathogens, which were diverse and present in high concentrations. Among them, ARGs concentrations encoding 21 antibiotics ranged from - 4.50 to 0.70 ppm/m3 (Log10 ARGs). Among the 89 potential human pathogens detected, Escherichia coli, Salmonella enterica, Klebsiella pneumoniae, and Staphylococcus aureus were the only culturable potentially multidrug resistant pathogens carrying multiple ARGs encoding resistance at high concentrations (- 0.57 to 1.15 ppm/m3 (Log10 ARGs)), and were more likely to persist and multiply in oligotrophic environments. Our findings indicate that composting technology can transfer AMR from solid compost to gas phase and increase the risk of AMR transmission.

Evaluation of dust and endotoxin exposure among rice mill workers in northeast India

Exposure to particulate matter and endotoxin can lead to acute and chronic respiratory problems in workers. A study was conducted to quantify particulate matter with an aerodynamic diameter of ≤10 μm (PM10) and endotoxin levels in rice mills in northeast India. Sixty-four PM10 dust samples were collected from eight rice mills at two locations: the feeding and polishing sections for two varieties of paddy: Ranjit and Hali. Endotoxin exposures were analyzed using the Limulus Amoebocyte Lysate (LAL) gel clot test. The results showed that the geometric mean of the 8-h time-weighted average (TWA) PM10 dust concentration and endotoxin level in the rice mills were 10.69 mg/m³ and 2.2 EU/m³, respectively. Dust and endotoxin exposure were higher in the feeding section than in the polishing section. Endotoxin exposure in the feeding section during the milling of the Hali variety of paddy was 56.0 % higher than the milling of the Ranjit variety. Additionally, endotoxin exposure during the milling of the Hali variety was 24.2 % higher than that of the milling of the Ranjit variety in the polishing section. The dust exposure in the rice mills was 194.5 % higher than the standards set up by the United States Environmental Protection Agency. However, the exposure to endotoxin in rice mills was approximately 40.10 times below the recommended limit of 90 EU/m3.

Hydroxy fatty acids in the surface Earth system

Lipids are ubiquitous and highly abundant in a wide range of organisms and have been found in various types of environmental media. These molecules play a crucial role as organic tracers by providing a chemical perspective on viewing the material world, as well as offering a wealth of information on metabolic activities. Among the diverse lipid compounds, hydroxy fatty acids (HFAs) with one to multiple hydroxyl groups attached to the carbon chain stand out as important biomarkers for different sources of organic matter. HFAs are widespread in nature and are involved in biotransformation and oxidation processes in living organisms. The unique chemical and physical properties attributed to the hydroxyl group make HFAs ideal biomarkers in biomedicine and environmental toxicology, as well as organic geochemistry. The molecular distribution patterns of HFAs can be unique and diagnostic for a given class of organisms, including animals, plants, and microorganisms. Thus, HFAs can act as a valuable proxy for understanding the ecological relationships between different organisms and their environment. Furthermore, HFAs have numerous industrial applications due to their higher reactivity, viscosity, and solvent miscibility. This review paper integrates the latest research on the sources and chemical analyses of HFAs, as well as their applications in industrial/medicinal production and as biomarkers in environmental studies. This review article also provides insights into the biogeochemical cycles of HFAs in the surface Earth system, highlighting the importance of these compounds in understanding the complex interactions between living organisms and the environment.

An algorithm for quantitatively estimating occupational endotoxin exposure in the Biomarkers of Exposure and Effect in Agriculture (BEEA) study: I. Development of task-specific exposure levels from published data

BACKGROUND/OBJECTIVE

Farmers conduct numerous tasks with potential for endotoxin exposure. As a first step to characterize endotoxin exposure for farmers in the Biomarkers of Exposure and Effect in Agriculture (BEEA) Study, we used published data to estimate task-specific endotoxin concentrations.

METHODS

We extracted published data on task-specific, personal, inhalable endotoxin concentrations for agricultural tasks queried in the study questionnaire. The data, usually abstracted as summary measures, were evaluated using meta-regression models that weighted each geometric mean (GM, natural-log transformed) by the inverse of its within-study variance to obtain task-specific predicted GMs.

RESULTS

We extracted 90 endotoxin summary statistics from 26 studies for 9 animal-related tasks, 30 summary statistics from 6 studies for 3 crop-related tasks, and 10 summary statistics from 5 studies for 4 stored grain-related tasks. Work in poultry and swine confinement facilities, grinding feed, veterinarian services, and cleaning grain bins had predicted GMs > 1000 EU/m3 . In contrast, harvesting or hauling grain and other crop-related tasks had predicted GMs below 100 EU/m3 .

SIGNIFICANCE

These task-specific endotoxin GMs demonstrated exposure variability across common agricultural tasks. These estimates will be used in conjunction with questionnaire responses on task duration to quantitatively estimate endotoxin exposure for study participants, described in a companion paper.

Inflammatory and contractile profile in LPS-challenged equine isolated bronchi: Evidence for IL-6 as a potential target against AHR in equine asthma

BACKGROUND

Airway inflammation and airway hyperresponsiveness (AHR) are pivotal characteristics of equine asthma. Lipopolysaccharide (LPS) may have a central role in modulating airway inflammation and dysfunction. Therefore, the aim of this study was to match the inflammatory and contractile profile in LPS-challenged equine isolated bronchi to identify molecular targets potentially suitable to counteract AHR in asthmatic horses.

METHODS

Equine isolated bronchi were incubated overnight with LPS (0.1-100 ng/ml). The contractile response to electrical field stimulation (EFS) and the levels of cytokines, chemokines, and neurokinin A (NKA) were quantified. The role of capsaicin sensitive-sensory nerves, neurokinin-2 (NK₂) receptor, transient receptor potential vanilloid type 1 receptors (TRPV1), and epithelium were also investigated.

RESULTS

LPS 1 ng/ml elicited AHR to EFS (+238.17 ± 25.20% P < 0.001 vs. control). LPS significantly (P < 0.05 vs. control) increased the levels of IL-4 (+36.08 ± 1.62%), IL-5 (+38.60 ± 3.58%), IL-6 (+33.79 ± 2.59%), IL-13 (+40.91 ± 1.93%), IL-1β (+1650.16 ± 71.16%), IL-33 (+88.14 ± 8.93%), TGF-β (22.29 ± 1.03%), TNF-α (+56.13 ± 4.61%), CXCL-8 (+98.49 ± 17.70%), EOTAXIN (+32.26 ± 2.27%), MCP-1 (+49.63 ± 4.59%), RANTES (+36.38 ± 2.24%), and NKA (+112.81 ± 6.42%). Capsaicin sensitive-sensory nerves, NK₂ receptor, and TRPV1 were generally involved in the LPS-mediated inflammation. Epithelium removal modulated the release of IL-1β, IL-33, and TGF-β. Only the levels of IL-6 fitted with AHR to a wide range of EFS frequencies, an effect significantly (P < 0.05) inhibited by anti-IL-6 antibody; exogenous IL-6 induced significant (P < 0.05) AHR to EFS similar to that elicited by LPS.

CONCLUSION

Targeting IL-6 with specific antibody may represent an effective strategy to treat equine asthma, especially in those animals suffering from severe forms of this disease.

Particulate Matter in Swine Barns: A Comprehensive Review

Particulate matter (PM) represents an air quality management challenge for confined swine production systems. Due to the limited space and ventilation rate, PM can reach relatively high concentrations in swine barns. PM in swine barns possesses different physical, chemical, and biological characteristics than that in the atmosphere and other indoor environments. As a result, it exerts different environmental and health effects and creates some unique challenges regarding PM measurement and mitigation. Numerous research efforts have been made, generating massive data and information. However, relevant review reports are sporadic. This study aims to provide an updated comprehensive review of swine barn PM, focusing on publications since 1990. It covers various topics including PM characteristics, sources, measurement methods, and in-barn mitigation technologies. As PM in swine barns is primarily of biological origins, bioaerosols are reviewed in great detail. Relevant topics include bacterial/fungal counts, viruses, microbial community composition, antibiotic-resistant bacteria, antibiotic resistance genes, endotoxins, and (1→3)-β-D-glucans. For each topic, existing knowledge is summarized and discussed and knowledge gaps are identified. Overall, PM in swine barns is complicated in chemical and biological composition and highly variable in mass concentrations, size, and microbial abundance. Feed, feces, and skins constitute the major PM sources. Regarding in-barn PM mitigation, four technologies (oil/water sprinkling, ionization, alternation of feed and feeders, and recirculating air filtration) are dominant. However, none of them have been widely used in commercial barns. A collective discussion of major knowledge gaps and future research needs is offered at the end of the report.

Assessment of airborne endotoxin in sandstorm dust and indoor environments using a novel passive sampling device in Al Zulfi city, Saudi Arabia - Establishing threshold exposure levels

The impact of sandstorm dust events affects local air quality and public health. These issues are becoming of greater concern in Saudi Arabia. There is a significant lack of research on airborne endotoxin exposure and analysis in the Middle East countries and no coherent body of research exists focusing on sandstorm dust in worldwide. In this study, we used a novel design of an aluminum foil plate (AFP) electrostatic dust cloth (EDC) for the passive air sampling of sandstorm dust. A total of 38 sandstorm dust samples were collected during sandstorm episodes occurring between January and April 2020 in both indoor (7 days, n = 20) and outdoor environments (24 h, n = 18). After exposure, and following an extraction procedure, bacterial endotoxin levels were measured using the Limulus Amoebocyte Lysate (LAL) gel clot method. The study highlights that the airborne endotoxin level observed was between 10 and 200 EU/m² in both indoor and outdoor environments, during a sandstorm event. Agricultural activities and farmhouses observed higher airborne endotoxin levels. In general, increased endotoxin levels were related to the severity of the sandstorms. Given that the observed values were high as per existing guidelines for respiratory health, we recommend the setting an occupational airborne exposure limit for bacterial endotoxin. This is the first report and further studies across various sandstorm-hit regions will need to be undertaken, together with various sampling methods, in order to assess for seasonal and geographic trends.

Particulate matter and airborne endotoxin concentration in calf barns and their association with lung consolidation, inflammation, and infection

Agricultural operations are important sources of organic dust containing particulate matter (PM) and endotoxins, which have possible negative health consequences for both humans and animals. Dust concentrations and composition in calf barns, as well as the potential health effects for these animals, are scarcely documented. The objective of this study was to measure PM fractions and endotoxin concentrations in calf barns and study their associations with lung consolidation, respiratory tract inflammation, and infection in group-housed calves. In this cross-sectional study, samples from 24 dairy farms and 23 beef farms were collected in Belgium from January to April 2017. PM_1.0, PM_2.5 and PM₁₀ (defined as particulate matter passing through a size-selective inlet with a 50% efficiency cut-off at a 1.0-μm, 2.5-μm, and 10-μm aerodynamic diameter, respectively) were sampled during a 24-h period using a Grimm aerosol spectrometer (Grimm Aerosol Technik Ainring GmbH & Co. KG). Endotoxin concentration was measured in the PM₁₀ fraction. Thoracic ultrasonography was performed and broncho-alveolar lavage fluid was collected for cytology and bacteriology. Average PM concentrations were 16.3 µg/m³ (standard deviation, SD: 17.1; range: 0.20-771), 25.0 µg/m³ (SD: 25.3; range: 0.50-144.9), and 70.3 µg/m³ (SD: 54.5; range: 1.6-251.2) for PM_1.0, PM_2.5, and PM₁₀, respectively. Mean endotoxin in the PM₁₀ fraction was 4.2 endotoxin units (EU)/µg (SD: 5.50; range: 0.03-30.3). Concentrations in air were 205.7 EU/m³ (SD: 197.5; range: 2.32-901.0). Lung consolidations with a depth of ≥1, ≥3, and ≥6 cm were present in 43.1% (146/339), 27.4% (93/339), and 15.3% (52/339) of the calves, respectively. Exposure to fine (PM_1.0) PM fractions was associated with increased odds of lung consolidations of ≥1 cm (odds ratio, OR: 3.3; confidence interval (CI): 1.5-7.1), ≥3 cm (OR: 2.8; CI: 1.2-7.1), and ≥6 cm (OR: 12.3; CI: 1.2-125.0). The odds of having lung consolidations of ≥1 cm (OR: 13.9; CI: 3.4-58.8) and ≥3 cm (OR: 6.7; 1.7-27.0) were higher when endotoxin concentrations in the dust mass exceeded 8.5 EU/µg. Broncho-alveolar lavage fluid neutrophil percentage was positively associated with PM₁₀ concentration, and epithelial cell percentage was negatively associated with this fraction. Concentration of PM_2.5 was positively associated with epithelial cell percentage and isolation of Pasteurella multocida. Although concentrations of fine dust are lower in calf barns than in poultry and pig housings, in this study they were associated with pneumonia in calves. Dust control strategies for reducing fine dust fractions in calf barns may benefit human and animal respiratory health.

A Pilot Study to Assess Inhalation Exposures among Sugarcane Workers in Guatemala: Implications for Chronic Kidney Disease of Unknown Origin

Background: Sugarcane workers in Central America experience a heavy burden of chronic kidney disease of unknown origin. We conducted a pilot study among worker proxies in Guatemala to characterize exposures to particulate matter, silica, heavy metals, and glyphosate, as well as to examine potential nephrotoxic exposures. Methods: Air, soil, and ash samples were collected and analyzed using scanning electron microscopy, X-ray diffraction, inductively coupled plasma mass spectrometry, and an enzyme-linked immunosorbent assay. Results: The average mass concentration for particulate matter (PM)_2.5 and PM₁₀₀ exposures were 360 µg/m³ (range: 32 to 1500 µg/m³) and 555 µg/m³ (range: 229 to 1170 µg/m³), respectively. The elemental composition of particles was largely silicon. The amount of crystalline silica was below 5 μg, yet the percentage of total silica was ~17% by weight. Putatively, the silica was in the amorphous form. Concentrations of aluminum and calcium ranged from 2–7 μg/m³. Glyphosate was not detectable in analyzed air samples but was detectable at concentrations ranging from 81–165 ppb in soil samples. Conclusion: Sugarcane workers are exposed to high concentrations of particulate matter. Future studies should investigate the potential role of silica, heavy metals, and agrochemicals in the etiology of chronic kidney disease in this population.

Respiratory diseases and allergy in farmers working with livestock: a EAACI position paper

Farmers constitute a large professional group worldwide. In developed countries farms tend to become larger, with a concentration of farm operations. Animal farming has been associated with negative respiratory effects such as work-related asthma and rhinitis. However, being born and raised or working on a farm reduces the risk of atopic asthma and rhinitis later in life. A risk of chronic bronchitis and bronchial obstruction/COPD has been reported in confinement buildings and livestock farmers. This position paper reviews the literature linking exposure information to intensive animal farming and the risk of work-related respiratory diseases and focuses on prevention. Animal farming is associated with exposure to organic dust containing allergens and microbial matter including alive microorganisms and viruses, endotoxins and other factors like irritant gases such as ammonia and disinfectants. These exposures have been identified as specific agents/risk factors of asthma, rhinitis, chronic bronchitis, COPD and reduced FEV₁. Published studies on dust and endotoxin exposure in livestock farmers do not show a downward trend in exposure over the last 30 years, suggesting that the workforce in these industries is still overexposed and at risk of developing respiratory disease. In cases of occupational asthma and rhinitis, avoidance of further exposure to causal agents is recommended, but it may not be obtainable in agriculture, mainly due to socio-economic considerations. Hence, there is an urgent need for focus on farming exposure in order to protect farmers and others at work in these and related industries from developing respiratory diseases and allergy.

Characterization of inhalable endotoxin, glucan, and dust exposures in Iowa farmers

BACKGROUND

The observed deficit of lung cancer in farmers has been partly attributed to exposure to organic dusts and endotoxins based largely on surrogate metrics. To move beyond these surrogates for etiological studies, we characterized task-based and time-weighted average (TWA) exposure to inhalable endotoxin, (1 → 3)-β-D-glucan, and dust in Iowa farmers.

METHODS

We collected 320 personal inhalable dust samples from 32 farmers during 69 sample days in 2015 and 2016. Samples were collected using Button aerosol samplers and analyzed for endotoxin using a kinetic chromogenic amebocyte lysate assay, and for (1 → 3)-β-D-glucan using a Limulus endpoint assay. We assessed relationships between bioaerosol concentrations and selected tasks and farm characteristics using linear mixed-effects models.

RESULTS

Bedding work, hog handling, and working in barn/confinement buildings, grain bins, and grain elevators were associated with higher endotoxin exposure. We found a monotonic trend between higher endotoxin concentrations and increasing number of animals. Bedding work, cleaning, and feed/grain storage work were associated with higher (1 → 3)-β-D-glucan concentrations. The median concentrations by task spanned one order of magnitude for inhalable dust and two orders of magnitude for endotoxin and (1 → 3)-β-D-glucan. Pearson correlations between endotoxin and glucan concentrations were 0.22 for TWA exposure and 0.56 for task samples.

CONCLUSIONS

This characterization of exposure factors that influence bioaerosol concentrations can support the development of refined bioaerosol exposure metrics for future etiologic analyses of cancer and other health outcomes in farmers.

Parental occupational exposure to pesticides, animals and organic dust and risk of childhood leukemia and central nervous system tumors: Findings from the International Childhood Cancer Cohort Consortium (I4C)

Parental occupational exposures to pesticides, animals and organic dust have been associated with an increased risk of childhood cancer based mostly on case-control studies. We prospectively evaluated parental occupational exposures and risk of childhood leukemia and central nervous system (CNS) tumors in the International Childhood Cancer Cohort Consortium. We pooled data on 329,658 participants from birth cohorts in five countries (Australia, Denmark, Israel, Norway and United Kingdom). Parental occupational exposures during pregnancy were estimated by linking International Standard Classification of Occupations-1988 job codes to the ALOHA+ job exposure matrix. Risk of childhood (<15 years) acute lymphoblastic leukemia (ALL; n = 129), acute myeloid leukemia (AML; n = 31) and CNS tumors (n = 158) was estimated using Cox proportional hazards models to generate hazard ratios (HR) and 95% confidence intervals (CI). Paternal exposures to pesticides and animals were associated with increased risk of childhood AML (herbicides HR = 3.22, 95% CI = 0.97-10.68; insecticides HR = 2.86, 95% CI = 0.99-8.23; animals HR = 3.89, 95% CI = 1.18-12.90), but not ALL or CNS tumors. Paternal exposure to organic dust was positively associated with AML (HR = 2.38 95% CI = 1.12-5.07), inversely associated with ALL (HR = 0.55, 95% CI = 0.31-0.99) and not associated with CNS tumors. Low exposure prevalence precluded evaluation of maternal pesticide and animal exposures; we observed no significant associations with organic dust exposure. This first prospective analysis of pooled birth cohorts and parental occupational exposures provides evidence for paternal agricultural exposures as childhood AML risk factors. The different risks for childhood ALL associated with maternal and paternal organic dust exposures should be investigated further.

Occupational Exposure to Endotoxin along a Municipal Scale Fecal Sludge Collection and Resource Recovery Process in Kigali, Rwanda

Background: Little is known about occupational exposures that occur along fecal sludge collection and resource recovery processes. This study characterizes inhaled endotoxin exposure to workers of a municipal scale fecal sludge-to-fuel processes in Kigali, Rwanda. Methods: Forty-two task-based air samples were collected from workers in five tasks along the fecal sludge collection and resource recovery process. Samples were processed for endotoxin using the limulus amebocyte lysate (LAL) test. To account for exposure variability and compare measured concentrations to established exposure limits, we used Monte Carlo modeling methods to construct distributions representing full eight-hour (8-h) exposures to endotoxin across eight exposure scenarios. Results: Geometric mean (GM) endotoxin concentrations in task-based samples ranged from 11–3700 EU/m³ with exposure concentrations increasing as the dryness of the fecal sludge increased through processing. The thermal dryer task had the highest endotoxin concentrations (GM = 3700 EU/m³) and the inlet task had the lowest (GM = 11 EU/m³). The geometric means (GM) of modeled 8-h exposure concentrations were between 6.7–960 EU/m³ and highest for scenarios which included the thermal dryer task in the exposure scenario. Conclusions: Our data suggest the importance of including worker exposure considerations in the design of nascent fecal sludge management processes. The methods used in this study combine workplace sampling with stochastic modeling and are useful for exposure assessment in resource constrained contexts.

Animal farming and the risk of lymphohaematopoietic cancers: a meta-analysis of three cohort studies within the AGRICOH consortium

OBJECTIVE

Animal farming entails a variety of potential exposures, including infectious agents, endotoxins and pesticides, which may play a role in the aetiology of lymphohaematopoietic cancers (LHCs). The aim of this study was to assess whether farming specific animal species is associated with the risk of overall LHC or its subtypes.

METHODS

Data from three prospective cohort studies in the USA, France and Norway which are part of the Agricultural Cohort consortium and which collected information about animal farming and cancer were used. Analyses included 316 270 farmers and farm workers. Adjusted Cox models were used to investigate the associations of 13 histological subtypes of LHC (n=3282) with self-reported livestock (cattle, pigs and sheep/goats) and poultry (ever/never and numbers raised) farming. Cohort-specific HRs were combined using random-effects meta-analysis.

RESULTS

Ever animal farming in general or farming specific animal species was not meta-associated with overall LHC. The risk of myeloid malignancies decreased with increasing number of livestock (p trend=0.01). Increased risk of myeloproliferative neoplasms was seen with increasing number of sheep/goats (p trend <0.01), while a decreased risk was seen with increasing number of livestock (p trend=0.02). Between cohorts, we observed heterogeneity in the association of type of animal farmed and various LHC subtypes.

CONCLUSIONS

This large-scale study of three prospective agricultural cohorts showed no association between animal farming and LHC risk, but few associations between specific animal species and LHC subtypes were observed. The observed differences in associations by countries warrant further investigations.

Respiratory symptoms and lung functional impairments associated with occupational exposure to poultry house pollutants

This study aimed to assess respiratory symptoms and the pulmonary function test (PFT) in a group of poultry workers. The prevalence of respiratory symptoms was determined. Airborne concentrations of total and repairable dusts exceeded the threshold limit values. Gram-positive cocci and Cladosporium were the dominant genera of bacteria and fungi, respectively. The prevalence of respiratory symptoms was significantly higher in the exposed subjects. Mean baseline values of forced expiratory volume (FEV₁), FEV₁ to forced vital capacity (FVC) ratio (FEV₁/FVC) and peak expiratory flow (PEF) were significantly lower in the exposed group. Significant cross-shift decrements were noted in vital capacity (VC), FVC, FEV₁, PEF and FEV₁/FVC of the exposed subjects. A dominant pattern of lung function abnormality was found to be obstructive. Exposure to poultry pollutants may result in a significant increase in the prevalence of respiratory symptoms as well as both acute reversible and chronic irreversible decrements in the PFT.

Major environmental characteristics of swine husbandry that affect exposure to dust and airborne endotoxins

Inhalation of organic dust or endotoxin in the dust is considered a major risk factor for occupational respiratory illnesses. Eighteen environmental characteristics associated with animal husbandry were surveyed at 36 swine farms in seven provinces throughout South Korea. Association of these factors with levels of indoor inhalable or respirable dust or endotoxin in each type of dust was analyzed using backward stepwise multiple linear regression models. Mean levels of inhalable and respirable dust were 0.5 ± 0.35 and 0.13 ± 0.12 mg/m³ air, respectively, and mean endotoxin levels were 676 ± 463 and 48.4 ± 68.2 EU/m³, respectively, in each dust. Factors negatively associated with inhalable dust levels included pig age, indoor farm temperature, number of pigs in the building, hr/week of indoor farm work, and partly slatted floor. Factors positively associated with inhalable dust levels included floor cleaning by manual scraping and slurry deposit duration. Factors negatively associated with the level of endotoxin in inhalable dust included pig age, temperature, number of pigs, hr/week of indoor farm work, and partly slatted floor. Factors negatively associated with respirable dust level included area of the confinement building, whereas factors positively associated with respirable dust level included the number of pigs and stocking density. Endotoxin levels in respirable dust were negatively associated with h/week of indoor farm work and partly slatted floor. Overall, data suggest that husbandry variables may be adjusted to control dust and airborne endotoxin levels in swine farms.

Factors determining the exposure of dairy farmers to thoracic organic dust

Bronchial respiratory diseases are more common in dairy farmers than in the general population, perhaps because the repeated inhalation of organic dust contributes to the development of these disorders. However, the factors determining the exposure of farmers to particles that can enter the lower bronchial tract and interact with it, i.e. the thoracic fraction of the inhalable dust, remain to be identified. We therefore measured the exposure of dairy farmers to thoracic organic dust and identified the farm features and tasks that increased exposure. We measured thoracic particles (n = 110) and farm characteristics and occupational tasks in 29 Brittany dairy farms. The mean (GM) (geometric standard deviation, GSD) concentration of thoracic dust in air inhaled by farmers was 0.24 mg/m³ (2.8) and the concentrations of endotoxins, Gram-positive bacteria and fungi in the thoracic fraction were 128 EU/m³ (4.0), 960 CFU/m³ (6.3) and 690 CFU/m³ (5.4), respectively. Model-based estimates of the association between exposure, farm features and tasks indicated that manual grain and feed handling and mechanical bedding spreading significantly increased exposure to thoracic dust, endotoxins, bacteria and fungi. Exposure to bacteria and fungi was reduced by cowsheds divided into cubicles, whereas using automatic muck scrappers in alleyway and automatic milking tended to increase exposure to bacteria and endotoxins. Finally, exposure to endotoxin and fungi were reduced by warmer farm buildings and well-ventilated buildings having walls with large openings. In conclusions, major occupational tasks and specific farm features determine the exposure of Breton dairy farmers to thoracic organic dust.

Assessment of Workers' Exposure to Grain Dust and Bioaerosols During the Loading of Vessels' Hold: An Example at a Port in the Province of Québec

Longshoremen are exposed to large amounts of grain dust while loading of grain into the holds of vessels. Grain dust inhalation has been linked to respiratory diseases such as chronic bronchitis, hypersensitivity, pneumonitis, and toxic pneumonitis. Our objective was to characterize the exposure of longshoremen to inhalable and total dust, endotoxins, and cultivable bacteria and fungi during the loading of grain in a vessel's hold at the Port of Montreal in order to assess the potential health risks. Sampling campaigns were conducted during the loading of two different types of grain (wheat and corn). Environmental samples of microorganisms (bacteria, fungus, and actinomycetes) were taken near the top opening of the ship's holds while personal breathing zone measurements of dust and endotoxins were sampled during the worker's 5-hour shifts. Our study show that all measurements are above the recommendations with concentration going up to 390 mg m-3 of total dust, 89 mg m-3 of inhalable fraction, 550 000 EU m-3 of endotoxins, 20 000 CFU m-3 of bacteria, 61 000 CFU m-3 of fungus and 2500 CFU m-3 of actinomycetes. In conclusion, longshoremen are exposed to very high levels of dust and of microorganisms and their components during grain loading work. Protective equipment needs to be enforced for all workers during such tasks in order to reduce their exposure.

Exposure to Inhalable Dust, Endotoxin, and Total Volatile Organic Carbons on Dairy Farms Using Manual and Automated Feeding Systems

Introduction

Agricultural workers tend to have high exposures to organic dusts which may induce or exacerbate respiratory disorders. Studies investigating the effect of work tasks and farm characteristics on organic dust exposures among farm workers suggest that handling of animal feed is an important exposure determinant; however, the effect of the animal feeding system has not been explored in any detail.

Objectives

To measure the exposure of Irish dairy farmers to inhalable dust, endotoxin, and total volatile organic compounds (TVOCs) during parlour work and to explore whether levels of exposure to these agents depend on the applied feeding system in the farms.

Methods

Thirty-eight personal exposure measurements were collected from farmers across seven dairy farms. The farms used manual, loft, or semi-automated feeding systems. Information on worker tasks and farm characteristics was collected during the surveys. Associations between exposure concentrations and feeding systems, worker tasks, and other farm characteristics were explored in linear mixed-effect regression models with farmer identity treated as a random effect.

Results

Exposure concentrations were variable and had a geometric mean (GM; geometric standard deviation) of 1.5 mg m-3 (1.8) for inhalable dust and 128 EU m-3 (2.5) for endotoxin. More than 50% of the exposure measurements for endotoxin, and organic dust exceeded recommended health-based occupational exposure limits. Endotoxin levels were somewhat lower in farms using semi-automatic feeding systems when compared to those using manual feeding systems but in multivariate regression analysis associations were not statistically significant (β = -0.54, P = 0.4). Performance of activities related to handling and spreading of hay or straw was the strongest determinant for both inhalable dust and endotoxin exposure (β = 0.78, P ≤ 0.001; β = 0.72, P = 0.02, respectively). The level of dust exposure increased also as a consequence of a lower outdoor temperature, and higher ratio of distributed feed per cow (P = 0.01). Stationary measurements of TVOC and CO2 concentrations inside the dairy parlours had a GM of 180 ppb (1.9) and 589 ppb (1.3), respectively. The use of cow teat disinfectants and building ventilation were both strong predictors of TVOC concentrations within parlours.

Conclusions

Dairy farm workers can be exposed to high and variable levels of inhalable dust and endotoxin and may be at risk of respiratory disease. Results from this study suggest that exposure control strategies for organic dusts and TVOCs exposures should consider building ventilation and work tasks such as spreading of bedding material, using spray disinfectants and animal feeding. Until effective permanent engineering controls are established farm workers should be encouraged to wear respiratory protective equipment during these tasks.

Exposure to airborne endotoxin in Italian greenhouses: environmental analyses

The peculiar characteristics of the greenhouses as confined spaces, microclimate and poor air exchange with the outside environment, encourage the development of a large number of biological agents. Endotoxin, is probably a major causative agent of occupational health problems. The objective of this study was to measure the concentrations of airborne endotoxin in greenhouses with different cultures. The influence of microclimate was studied in correlation with endotoxin levels and type of cultured vegetables. The data indicate that workers employed greenhouses are exposed to low levels of inhalable endotoxins; endotoxin concentrations do not correlate with the temperature and relative humidity values. A strong correlation between the leaf size and endotoxin concentration was observed. The mean concentration of endotoxins in the air of greenhouses is relatively low, however, there could be peaks of exposure during harvesting and eradication of broadleaf plants.

Air exposure as a possible route for ESBL in pig farmers

Livestock can carry extended-spectrum beta-lactamase (ESBL)-producing Enterobacteriaceae, with bla_CTX-M-1 being most prevalent. ESBL carriage in farmers is associated with ESBL carriage in animals, with direct animal-human contact considered as the dominant route of transmission. However, inhalation of stable air might represent another route of transmission. We, therefore, quantified presence of bla_CTX-M group 1 genes (CTX-M-gr1) in dust and the association with CTX-M-gr1 carriage in pig farmers, family members and employees. We included 131 people living and/or working on 32 conventional Dutch pig production farms (farmers, family members and employees) during two sampling moments over a 12-month interval. Human stool samples, rectal swabs from 60 pigs per farm, and 2-5 dust samples collected using an electrostatic dust collector (EDC) (as a proxy for presence of viable CTX-M-gr1 carrying bacteria in air) were obtained per farm. Presence of ESBL-producing Escherichia Coli (E. coli) in stool samples and rectal swabs was determined by selective plating and CTX-M-gr1 was identified by PCR. Dust samples were analyzed directly by PCR for presence of CTX-M-gr1. Questionnaires were used to collect information on nature, intensity and duration of animal contact. Overall human prevalence of CTX-M-gr1 carriage was 3.6%. CTX-M-gr1 was detected in dust on 26% of the farms and in pigs on 35% of the farms, on at least one sampling moment. Human CTX-M-gr1 carriage and presence of CTX-M-gr1 in dust were associated univariately (OR=12.4, 95% CI=2.7-57.1). In multivariate analysis human CTX-M-gr1 carriage was associated with the number of working hours per week (OR=1.03, 95% CI=1.00-1.06), presence of CTX-M-gr1 carrying pigs on the farm (OR=7.4, 95% CI=1.1-49.7) and presence of CTX-M-gr1 in dust (OR=3.5, 95% CI=0.6-20.9). These results leave open the possibility of airborne CTX-M-gr1 transmission from animals to humans next to direct contact.

Pulmonary function and airway inflammation among dairy parlor workers after exposure to inhalable aerosols

BACKGROUND

Inhalation exposure to organic dust causes lung inflammation among agricultural workers. Due to changes in production and work organization, task-based inhalation exposure data, including novel lung inflammation biomarkers, will inform exposure recommendations for dairy farm workers.

METHODS

Linear regression was used to estimate the associations of airborne exposure to dust concentration, endotoxin, and muramic acid with pulmonary outcomes (i.e., FEV₁ , exhaled nitric oxide). Logistic regression was used to estimate associations with self-reported pulmonary symptoms.

RESULTS

Mean exposure concentration to inhalable dust, endotoxin, and muramic acid were 0.55 mg/m³ , 118 EU/m³ , and 3.6 mg/m³ , respectively. We found cross-shift differences for exhaled nitric oxide (P = 0.005) and self-reported pulmonary symptoms (P = 0.008) but no association of exposure with respiratory outcomes.

CONCLUSIONS

Inhalation exposures during parlor tasks, which were lower than previously reported and were not associated with cross-shift measures of pulmonary health among dairy workers. Modern milking parlor designs may be contributing to lower inhalation exposure. Am. J. Ind. Med. 60:255-263, 2017. © 2017 Wiley Periodicals, Inc.

Assessment of increased sampling pump flow rates in a disposable, inhalable aerosol sampler

A newly designed, low-cost, disposable inhalable aerosol sampler was developed to assess workers personal exposure to inhalable particles. This sampler was originally designed to operate at 10 L/min to increase sample mass and, therefore, improve analytical detection limits for filter-based methods. Computational fluid dynamics modeling revealed that sampler performance (relative to aerosol inhalability criteria) would not differ substantially at sampler flows of 2 and 10 L/min. With this in mind, the newly designed inhalable aerosol sampler was tested in a wind tunnel, simultaneously, at flows of 2 and 10 L/min flow. A mannequin was equipped with 6 sampler/pump assemblies (three pumps operated at 2 L/min and three pumps at 10 L/min) inside a wind tunnel, operated at 0.2 m/s, which has been shown to be a typical indoor workplace wind speed. In separate tests, four different particle sizes were injected to determine if the sampler's performance with the new 10 L/min flow rate significantly differed to that at 2 L/min. A comparison between inhalable mass concentrations using a Wilcoxon signed rank test found no significant difference in the concentration of particles sampled at 10 and 2 L/min for all particle sizes tested. Our results suggest that this new aerosol sampler is a versatile tool that can improve exposure assessment capabilities for the practicing industrial hygienist by improving the limit of detection and allowing for shorting sampling times.

Bioaerosols, Noise, and Ultraviolet Radiation Exposures for Municipal Solid Waste Handlers

Few studies have investigated the occupational hazards of municipal solid waste workers, particularly in developing countries. Resultantly these workers are currently exposed to unknown and unabated occupational hazards that may endanger their health. We determined municipal solid waste workers' work related hazards and associated adverse health endpoints. A multifaceted approach was utilised comprising bioaerosols sampling, occupational noise, thermal conditions measurement, and field based waste compositional analysis. Results from our current study showed highest exposure concentrations for Gram-negative bacteria (6.8 × 103 cfu/m3) and fungi (12.8 × 103 cfu/m3), in the truck cabins. Significant proportions of toxic, infectious, and surgical waste were observed. Conclusively, municipal solid waste workers are exposed to diverse work related risks requiring urgent sound interventions. A framework for assessing occupational risks of these workers must prioritize performance of exposure assessment with regard to the physical, biological, and chemical hazards of the job.

Cage Versus Noncage Laying-Hen Housings: Respiratory Exposures

The objective of this study was to compare the personal respiratory exposures of poultry workers in three different types of layer housing under commercial production conditions. Workers were randomly assigned to each of conventional cage, enriched cage, and aviary barns in a crossover repeated-measures design for three observation periods over the hens' lifetime. Inhalable and fine particulate matter (PM) and endotoxin in both size fractions were assessed by personal and area samplers over the work shift. Concentrations of inhalable PM, PM2.5 (PM with an aerodynamic diameter <2.5 μm), and endotoxin in both size fractions were higher in aviary than either the conventional or enriched barns. Geometric means (95% confidence intervals [CIs]) of inhalable PM and endotoxin for the aviary, conventional, and enriched barns were 8.9 (6.8-11.5) mg/m(3) and 7517.9 (5403.2-10,460.2) EU/m(3), 3.7 (2.8-4.8) mg/m(3) and 1655.7 (1144.6-2395.2) EU/m(3), 2.4 (1.8-3.3) mg/m(3) and 1404.8 (983.3-2007.0) EU/m(3), respectively. Area samplers recorded a lower mean inhalable PM concentration and higher PM2.5 concentration than personal samplers. Ammonia concentrations were low throughout three monitoring seasons. These findings show that the aviary barns pose higher respiratory exposures to poultry workers than either conventional or enriched barns.

Pulmonary illness as a consequence of occupational exposure to shrimp shell powder

OBJECTIVES

An employee with no prior history of allergy or asthma, experienced respiratory and flu-like symptoms during production of shrimp shell powder in a seafood savory factory in Norway. We aimed to clarify the diagnosis and to identify the cause of the symptoms by specific inhalation challenge (SIC) and by characterizing the powder's biocontaminants, particle size fractions and inflammatory potential.

METHODS

Respiratory and immunological responses were measured the day before and after each of four challenges with 20-150g shrimp shell powder during three consecutive days. The powder was analyzed for endotoxin, microorganisms and particle size fractions by standardized laboratory methods. Total inflammatory potential was quantified by reactive oxygen species (ROS) production in a granulocyte assay.

RESULTS

The patient had elevated IgG, but not IgE, towards shrimp shell powder. 20min challenge with 150g shrimp shell powder induced 15% decrease in FVC, 23% decrease in FEV1 and increased unspecific bronchial reactivity by methacholine. Neutrophils and monocytes increased 84% and 59%, respectively, and the patient experienced temperature increase and flu-like symptoms. The shrimp shell powder contained 1118 endotoxin units/g and bacteria including Bacillus cereus, and 57% respirable size fraction when aerosolized. The ROS production was higher for shrimp shell powder than for endotoxin alone.

CONCLUSIONS

Endotoxin and other bacterial components combined with a high fraction of respirable dust might be the cause of the symptoms. The patient's characteristics and response to SIC were best compatible with occupational asthma and organic dust toxic syndrome, while hypersensitivity pneumonitis could not be excluded.

Feedback on Measured Dust Concentrations Reduces Exposure Levels Among Farmers

BACKGROUND

The high burden of exposure to organic dust among livestock farmers warrants the establishment of effective preventive and exposure control strategies for these workers. The number of intervention studies exploring the effectiveness of exposure reduction strategies through the use of objective measurements has been limited.

OBJECTIVE

To examine whether dust exposure can be reduced by providing feedback to the farmers concerning measurements of the exposure to dust in their farm.

METHODS

The personal dust levels of farmers in 54 pig and 26 dairy cattle farms were evaluated in two measurement series performed approximately 6 months apart. Detailed information on work tasks and farm characteristics during the measurements were registered. Participating farms were randomized a priori to a control (n = 40) and an intervention group (n = 40). Shortly after the first visit, owners of intervention farms only received a letter with information on the measured dust concentrations in the farm together with some general advises on exposure reduction strategies (e.g. use of respirators during certain tasks). Relationships between measured dust concentrations and intervention status were quantified by means of linear mixed effect analysis with farm and worker id as random effects. Season, type of farming, and work tasks were treated as fixed effects. Changes in exposure over time were explored primarily at a farm level in models combined, as well as separate for pig and cattle farmers.

RESULTS

After adjustment for fixed effects, an overall reduction of 23% in personal dust exposures was estimated as a result of the intervention (P = 0.02). Exposure reductions attributable to the intervention were similar across pig and cattle farmers, but statistically significant only for pig farmers. Intervention effects among pig farmers did not depend on the individuals' information status; but among cattle farmers a significant 48% reduction in exposure was found only among individuals that reported to have been informed. No systematic differences in changes over time considering the use of respiratory protection between the intervention and control groups were observed.

CONCLUSION

The results of the present study suggest reductions between 20 and 30% in personal exposure to inhalable dust to be feasible through simple information provided to the farm owners regarding actual levels of exposure together with instructions on basic measures of prevention. The exact reasons for these effects are unclear, but likely they involve changes in behavior and working practices among intervention farmers.

Occupational exposure to mould and microbial metabolites during onion sorting--insights into an overlooked workplace

Manual sorting of onions is known to be associated with a bioaerosol exposure. The study aimed to gain an initial indication as to what extent manual sorting of onions is also associated with mycotoxin exposure. Twelve representative samples of outer onion skins from different onion origins were sampled and analyzed with a multimycotoxin method comprising 40 mycotoxins using a single extraction step followed by liquid chromatography with electrospray ionization and triple quadrupole mass spectrometry. Six of the 12 samples were positive for mycotoxins. In those samples, deoxynivalenol, fumonisin B1, and B2 were observed in quantitatively detectable amounts of 3940 ng/g for fumonisin B1 and in the range of 126-587 ng/g for deoxynivalenol and 55-554 ng/g for fumonisin B2. Although the results point to a lower risk due to mycotoxins, the risk should not be completely neglected and has to be considered in the risk assessment.

Cow allergen (Bos d2) and endotoxin concentrations are higher in the settled dust of homes proximate to industrial-scale dairy operations

Airborne contaminants produced by industrial agricultural facilities contain chemical and biological compounds that can impact the health of residents living in close proximity. Settled dust can be a reservoir for these contaminants and can influence long-term exposures. In this study, we sampled the indoor- and outdoor-settled dust from 40 homes that varied in proximity to industrial-scale dairies (ISD; industrial-scale dairy, a term used in this paper to describe a large dairy farm and adjacent waste sprayfields, concentrated animal feeding operation or animal feeding operation, that uses industrial processes) in the Yakima Valley, Washington. We analyzed settled dust samples for cow allergen (Bos d2, a cow allergen associated with dander, hair, sweat and urine, it is a member of the lipocalin family of allergens associated with mammals), mouse allergen (Mus m1; major mouse allergen, a mouse urinary allergen, in the lipocalin family), dust mite allergens (Der p1 (Dermatophagoides pteronissinus 1) and Der f1 (Dermatophagoides farinae 1)), and endotoxin (a component of the cell walls of gram negative bacteria, lipopolysaccharide, which can be found in air and dust and can produce a strong inflammatory response). A concentration gradient was observed for Bos d2 and endotoxin measured in outdoor-settled dust samples based on proximity to ISD. Indoor-settled dust concentrations of Bos d2 and endotoxin were also highest in proximal homes. While the associated health effects of exposure to cow allergen in settled dust is unknown, endotoxin at concentrations observed in these proximal homes (100 EU/mg) has been associated with increased negative respiratory health effects. These findings document that biological contaminants emitted from ISDs are elevated in indoor- and outdoor-settled dust samples at homes close to these facilities and extend to as much as three miles (4.8 km) away.

A Simple and Disposable Sampler for Inhalable Aerosol

The state-of-the-art for personal sampling for inhalable aerosol hazards is constrained by issues of sampler cost and complexity; these issues have limited the adoption and use of some samplers by practicing hygienists. Thus, despite the known health effects of inhalable aerosol hazards, personal exposures are routinely assessed for only a small fraction of the at-risk workforce. To address the limitations of current technologies for inhalable aerosol sampling, a disposable inhalable aerosol sampler was developed and evaluated in the laboratory. The new sampler is designed to be less expensive and simpler to use than existing technologies. The sampler incorporates a lightweight internal capsule fused to the sampling filter. This capsule-filter assembly allows for the inclusion of particles deposited on the internal walls and inlet, thus minimizing the need to wash or wipe the interior sampling cassette when conducting gravimetric analyses. Sampling efficiency and wall losses were tested in a low-velocity wind tunnel with particles ranging from 9.5 to 89.5 μm. The results were compared to the proposed low-velocity inhalability criterion as well as published data on the IOM sampler. Filter weight stability and time-to-equilibrium were evaluated as these factors affect the practicality of a design. Preliminary testing of the new sampler showed good agreement with both the IOM and the proposed low-velocity inhalability curve. The capsule and filter assemblies reached equilibrium within 25h of manufacturing when conditioned at elevated temperatures. After reaching equilibrium, the capsule-filter assemblies were stable within 0.01mg.

Particulate matter, endotoxin, and worker respiratory health on large Californian dairies

OBJECTIVE

To assess respiratory exposures and lung function in a cross-sectional study of California dairy workers.

METHODS

Exposure of 205 dairy and 45 control (vegetable processing) workers to particulate matter and endotoxin was monitored. Pre- and postshift spirometry and interviews were conducted.

RESULTS

Geometric mean inhalable and PM2.5 concentrations were 812 and 35.3 μg/m3 versus 481.9 and 19.6 μg/m3, respectively, for dairy and control workers. Endotoxin concentrations were 329 EU/m3 or 1122 pmol/m3 and 13.5 EU/m3 or 110 pmol/m3, respectively, for dairy and control workers. In a mixed-effects model, forced vital capacity decreased across a work shift by 24.5 mL (95% confidence interval, -44.7 to -4.3; P = 0.018) with log10 (total endotoxin) and by 22.0 mL (95% confidence interval, -43.2 to -0.08; P = 0.042) per hour worked.

CONCLUSIONS

Modern California dairy endotoxin exposures and shift length were associated with a mild acute decrease in forced vital capacity.

Evaluation of Dust Exposure among the Workers in Agricultural Industries in North-East India

This study aims to quantify dust exposure among the workers in four different industrial settings: rice mills, flour mills, oil mills, and tea factories and to compare the obtained data with the permissible exposure limit (PEL) of Indian Union Ministry of Labour as well as to compare the dust exposure across activities and seasons. RespiCon(TM) particle sampler was used for collecting dust concentration in the breathing zone of the workers. In total, 149 workers participated in the study and 204 samples were collected. Samples were collected in the vicinity of different processing operations. Samples in the rice mills were collected for two consecutive years in two seasons; however samples from other industries were collected for 1 year. The results indicate that geometric mean (GM) of dust exposure was significantly (P < 0.0001) different among industrial settings. Respirable dust were 8.22, 5.76, 2.98, and 6.34mg m(-3) and total dust exposure were 81.05, 111.02, 56.68, and 39.85mg m(-3) in the rice mills, oil mills, flour mills, and tea factories, respectively. Considerable variations in dust exposure were observed in different activities in the rice and oil mills; however variation was relatively less in the flour mills and tea factories. In the rice mills, dust concentration was higher in winter than those obtained in autumn and it is significantly different (P < 0.05) for inhalable dust and total dust. Positive correlation was obtained in thoracic dust (r (2) = 0.94) and inhalable dust (r (2) = 0.97) with total dust and thoracic dust with inhalable dust (r (2) = 0.89). The results show that majority of the workers are exposed to higher level of respirable dust as compared to the PEL, while total dust exposure to all the workers were higher than the PEL; thus, immediate reduction of dust exposure among the workers is necessary for preventing respiratory system impairment.

Naturally occurring diacetyl and 2,3-pentanedione concentrations associated with roasting and grinding unflavored coffee beans in a commercial setting

Over the last decade, concerns have been raised about potential respiratory health effects associated with occupational exposure to the flavoring additives diacetyl and 2,3-pentanedione. Both of these diketones are also natural components of many foods and beverages, including roasted coffee. To date, there are no published studies characterizing workplace exposures to these diketones during commercial roasting and grinding of unflavored coffee beans. In this study, we measured naturally occurring diacetyl, 2,3-pentanedione, and respirable dust at a facility that roasts and grinds coffee beans with no added flavoring agents. Sampling was conducted over the course of three roasting batches and three grinding batches at varying distances from a commercial roaster and grinder. The three batches consisted of lightly roasted soft beans, lightly roasted hard beans, and dark roasted hard beans. Roasting occurred for 37 to 41 min, and the grinding process took between 8 and 11 min. Diacetyl, 2,3-pentanedione, and respirable dust concentrations measured during roasting ranged from less than the limit of detection (<LOD) to 0.0039 ppm, <LOD to 0.018 ppm, and <LOD to 0.31 mg/m³, respectively. During grinding, diacetyl, 2,3-pentanedione, and respirable dust concentrations ranged from 0.018 to 0.39 ppm, 0.0089 to 0.21 ppm, and <LOD to 1.7 mg/m³, respectively. For any given bean/roast combination and sample location, diketone concentrations during grinding were higher than those measured during roasting. During grinding, concentrations decreased with increased distance from the source. Measured concentrations of both diketones were higher during grinding of soft beans than hard beans. The results indicate that airborne concentrations of naturally occurring diacetyl and 2,3-pentanedione associated with unflavored coffee processing: (1) are similar to the concentrations that have been measured in food flavoring facilities; (2) are likely to exceed some recommended short-term occupational exposure limits, but; (3) based on previous analyses of exposure response relationships in animal studies, are far below the concentrations that are expected to cause even minimal responses in the human respiratory tract.

Work Tasks as Determinants of Grain Dust and Microbial Exposure in the Norwegian Grain and Compound Feed Industry

OBJECTIVES

The grain and compound feed industry entails inevitable risks of exposure to grain dust and its microbial content. The objective of this study was therefore to investigate task-dependent exposure differences in order to create knowledge basis for awareness and exposure reducing measures in the Norwegian grain and compound feed industry.

METHODS

A total of 166 samples of airborne dust were collected by full-shift personal sampling during work in 20 grain elevators and compound feed mills during one autumn season and two winter seasons. The personal exposure to grain dust, endotoxins, β-1→3-glucans, bacteria, and fungal spores was quantified and used as individual outcomes in mixed models with worker nested in company as random effect and different departments and tasks as fixed effects.

RESULTS

The exposure levels were highest in grain elevator departments. Exposure to endotoxins was particularly high. Tasks that represented the highest and lowest exposures varied depending on the bioaerosol component. The most important determinants for elevated dust exposure were cleaning and process controlling. Cleaning increased the dust exposure level by a factor of 2.44 of the reference, from 0.65 to 1.58mg m(-3), whereas process controlling increased the dust exposure level by a factor of 2.97, from 0.65 to 1.93mg m(-3). Process controlling was associated with significantly less grain dust exposure in compound feed mills and the combined grain elevators and compound feed mills, than in grain elevators. The exposure was reduced by a factor of 0.18 and 0.22, from 1.93 to 0.34mg m(-3) and to 0.42mg m(-3), respectively, compared with the grain elevators. Inspection/maintenance, cleaning, and grain rotation and emptying were determinants of higher exposure to both endotoxin and β-1→3-glucans. Seed winnowing was in addition a strong determinant for endotoxin, whereas mixing of animal feed implied higher β-1→3-glucan exposure. Cleaning was the only task that contributed significantly to higher exposure to bacteria and fungal spores.

CONCLUSION

Cleaning in all companies and process controlling in grain elevators were the strongest determinants for overall exposure, whereas seed winnowing was a particular strong determinant of endotoxin exposure. Exposure reduction by technical intervention or personal protective equipment should therefore be considered at work places with identified high exposure tasks.

A comprehensive review of levels and determinants of personal exposure to dust and endotoxin in livestock farming

The respiratory health effects of livestock farming have been on debate for more than three decades. Endotoxin-contaminated organic dusts are considered as the most important respiratory hazards within livestock environments. A comprehensive review of the knowledge from studies assessing the exposure status of livestock farmers is still to be published. The present study reviews research published within the last 30 years on personal exposure of livestock farmers to organic dust and endotoxin, focusing on studies on pig, poultry and cattle farmers. Applied measurement methods and reported levels of personal exposure for the total, inhalable and respirable fractions are summarized and discussed, with emphasis on the intensity of exposure and the size and distribution of the reported exposure variability. In addition, available evidence on potential determinants of personal exposure to dust and endotoxin among these farmers are documented and discussed, taking results from exposure determinant studies using stationary sampling approaches into consideration. Research needs are addressed from an epidemiological and industrial hygiene perspective. Published studies have been heterogeneous in design, and applied methodologies and results were frequently inadequately reported. Despite these limitations and the presence of an enormous variability in personal exposure to dust and endotoxin, no clear downward trends in exposure with time were observed, suggesting that working environments within stables remains largely uncontrolled. Exposure control and prevention strategies for livestock farmers are urgently required. These should focus on the development of novel and improved methods of controlling dust and endotoxin exposure within stables based on the currently available knowledge on determinants of exposure.

Respiratory symptoms, fractional exhaled nitric oxide & endotoxin exposure among female flower farm workers in Ethiopia

Background

Greenhouse workers are exposed to organic dusts, and they are thereby at risk of developing airway disorders. This study aims to measure personal endotoxin exposure, assess respiratory symptoms and measure fractional exhaled nitric oxide (FeNO) among female flower farm workers in Ethiopia.

Methods

A cross-sectional study involving female workers (n = 248) from four flower farms was conducted. The workers were interviewed for respiratory symptoms using a standard questionnaire. Workers from two of these farms also participated in personal endotoxin sampling (46 workers, 75 measurements) on glass fiber filters (0.2 μm pore size) inside conductive 25 mm Millipore cassettes for sampling of the “total dust” fraction. They also participated in FeNO (n = 114) measurements with a portable electrochemistry-based sensor. Chi-square and independent t-tests were used to compare categorical and continuous variables respectively. A mixed-effects model was used to analyze exposure determinants.

Results

Endotoxin exposure had a geometric mean (GM) of 22.8 endotoxin units (EU)/m³ with a maximum of 180 EU/m³. Greenhouse workers had significantly higher endotoxin exposure than workers outside the greenhouses (GM = 26.7 vs. 19.3 EU/m³ respectively; p < 0.05). The mean age of the workers was 24 years, and their mean working time in the flower farm was 21 months. Greenhouse workers had higher prevalence of self-reported respiratory symptoms than those outside greenhouses. However, after adjusting for education only blocked nose remained significant. The FeNO concentration ranged 5–166 ppb (GM = 14 ppb). Two workers had FeNO concentration above 50 ppb. FeNO levels differs significantly between the farms but there was no difference between workers inside and outside greenhouses.

Conclusion

Greenhouse workers at flower farms had higher prevalence of blocked nose than workers outside, which may indicate the presence of rhinitis. Endotoxin exposure was low. There were few workers with objective signs of airway inflammation; this might be because the mean working time in the greenhouses was only two years. We suggest further studies to evaluate the effect of longer employment and exposure time as well as to investigate possible exposure to pesticides and other components in the bio-aerosols.

Endotoxin deposits on the inner surfaces of closed-face cassettes during bioaerosol sampling: a field investigation at composting facilities

A set of 270 bioaerosol samples was taken from 15 composting facilities using polystyrene closed-face filter cassettes (CFCs). The objective was to measure the quantity of endotoxin deposits on the inner surfaces of the cassettes (sometimes referred to as 'wall deposits'). The results show that endotoxins are deposited on the inner surfaces of the CFCs through sampling and/or handling of samples. The quantity of endotoxins measured on inner surfaces range between 0.05 (the limit of detection of the method) and 3100 endotoxin units per cassette. The deposits can represent a large and variable percentage of the endotoxins sampled. More than a third of the samples presented a percentage of inner surface deposits >40% of the total quantity of endotoxins collected (filter + inner surfaces). Omitting these inner surface deposits in the analytical process lead to measurement errors relative to sampling all particles entering the CFC sampler, corresponding to a developing consensus on matching the inhalable particulate sampling convention. The result would be underestimated exposures and could affect the decision as to whether or not a result is acceptable in comparison to airborne concentration limits defined in terms of the inhalability convention. The results of this study suggest including the endotoxins deposited on the inner surfaces of CFCs during analysis. Further researches are necessary to investigate endotoxin deposits on the inner cassette surfaces in other working sectors.

Marine aerosol as a possible source for endotoxins in coastal areas

Marine aerosols, that are very common in the highly populated coastal cities and communities, may contain biological constituents. Some of this biological fraction of marine aerosols, such as cyanobacteria and plankton debris, may influence human health by inflammation and allergic reactions when inhaled. In this study we identify and compare sources for endotoxins sampled on filters in an on-shore and more-inland site. Filter analysis included endotoxin content, total bacteria, gram-negative bacteria and cyanobacteria genome concentrations as well as ion content in order to identify possible sources for the endotoxins. Satellite images of chlorophyll-a levels and back trajectory analysis were used to further study the cyanobacteria blooms in the sea, close to the trajectory of the sampled air. The highest endotoxin concentrations found in the shoreline site were during winter (3.23±0.17 EU/m(3)), together with the highest cyanobacteria genome (1065.5 genome/m(3)). The elevated endotoxin concentrations were significantly correlated with cyanobacterial levels scaled to the presence of marine aerosol (r=0.90), as well as to chlorophyll-a (r=0.96). Filters sampled further inland showed lower and non-significant correlation between endotoxin and cyanobacteria (r=0.70, P value=0.19), suggesting decrease in marine-originated endotoxin, with possible contributions from other sources of gram-negative non-cyanobacteria. We conclude that marine cyanobacteria may be a dominant contributor to elevated endotoxin levels in coastal areas.

Dust, endotoxin, fungi, and bacteria exposure as determined by work task, season, and type of plant in a flower greenhouse

BACKGROUND

Greenhouse workers are exposed to dust, endotoxin, fungi, and bacteria potentially causing airway inflammation as well as systemic symptoms. Knowledge about determinants of exposure is a prerequisite for efficient prevention through knowledge-based reduction in exposure. The objective of this study was to assess the occupational exposure in a flower greenhouse and to investigate the impact of work tasks on the intensity and variability in exposure.

METHODS

Seventy-six personal full-shift exposure measurements were performed on 38 employees in a Danish flower greenhouse producing Campanula, Lavandula, Rhipsalideae, and Helleborus. The samples were gravimetrically analysed for inhalable dust. Endotoxin was assessed by the Limulus Amoebocyte Lysate test and culture-based quantification of bacteria and fungi was performed. Information on the performed tasks during sampling was extracted from the greenhouse electronic task logging system. Associations between log-transformed exposure outcomes, season, and work tasks were examined in linear mixed-effects regression with worker identity as random effect.

RESULTS

Measured concentrations ranged between 0.04 and 2.41mg m(-3) for inhalable dust and between 0.84 and 1097 EU m(-3) for endotoxin exposure, with the highest mean levels measured during Lavandula and Campanula handling, respectively. Personal exposure to fungi ranged between 1.8×10(2) and 3.4×10(6) colony-forming units (CFU) m(-3) and to bacteria between 1.6×10(1) and 4.2×10(5) CFU m(-3). Exposure to dust, endotoxin, fungi, and bacteria differed between seasons. Packing Lavandula, sticking, potting, and grading Rhipsalideae, and all examined tasks related to Campanula production except sticking increased dust exposure. Endotoxin exposure was increased during sticking Campanula and pinching or packing Rhipsalideae, and fungi exposure was elevated by subtasks performed in the research and development area for Campanula, and by potting, packing/dumping Campanula. Sticking and working with subtasks in the research and development area for Campanula increased bacteria exposure.

CONCLUSION

This study revealed moderate dust exposure levels compared to the levels observed in other greenhouse productions and other occupations with organic dust exposure such as farming. However, high exposures to bacteria and fungi were detected during selected tasks and the proposed health-based endotoxin exposure limit of 90 EU m(-3) was exceeded in 30% of the samples, which may have health implications for the employees. Exposure levels were found to vary depending on the tasks performed, and thereby results can be used to direct task-based initiatives to reduce workplace exposures.

Exposure-affecting factors of dairy farmers' exposure to inhalable dust and endotoxin

INTRODUCTION

Studies on determinants of dairy farmers' exposure to dust and endotoxin have been sparse and so far none has addressed the combined effect of tasks and farm characteristics.

OBJECTIVE

To study whether and how work tasks and specific stable characteristics influence the level of dairy farmers' personal exposure to inhalable dust and endotoxin.

METHODS

We applied an observational design involving full-shift repeated personal measurements of inhalable dust and endotoxin exposure among 77 subjects (owners and farm workers) from 26 dairy farms. Performed tasks were self-registered in activity diaries, and information on stable characteristics was collected through personal interviews and walk-through surveys. Associations between exposure, tasks, and stable characteristics were examined in linear mixed-effect models with individual and farm treated as random effects. Separate as well as combined models for tasks and stable characteristics were elaborated.

RESULTS

The 124 personal samples collected had a geometric mean level (geometric standard deviation) of 360 EU m(-3) (3.8) for endotoxin exposure and of 1.0mg m(-3) (2.7) for dust exposure. Identified factors that increased endotoxin exposure included a lower outdoor temperature and use of slope-based or back-flushed slurry systems along with milking, distribution of bedding, and handling of feed and seeds in barns. For dust, exposure was higher when fully automatic (robotic) milking was used and during re-penning of animals, handling of feed and seeds, handling of silos and when distributing bedding. Dust exposure increased also as a result of use of rail feed dispensers in a model without fully automatic milking.

CONCLUSIONS

The current exposure to dust and in particular endotoxin among Danish dairy farmers demand effective strategies to reduce their exposure. The present findings suggest that future interventions should focus on feeding and manure handling systems. Use of respirators during handling of feed and distribution of bedding should be advised until adequate risk management measures have been established. The expected increased use of fully automatic milking in the future might increase dust exposure of dairy farmers.

Exposure to airborne endotoxins among sewer workers: an exploratory study

Exploratory bioaerosol sampling was performed in order to assess exposure to airborne endotoxins during sewer work. Personal samples were collected in underground sewer pipes using 37-mm closed-face cassettes containing fibreglass filters (CFC-FG method) or polycarbonate filters (CFC-PC method). Endotoxins were quantified using the limulus amoebocyte lysate assay. Concentrations of airborne endotoxins at sewer workplaces (16-420 EU m(-3)) were higher than those measured outside the sewer network (0.6-122 EU m(-3)). Sewer worker exposure to airborne endotoxins depended on the workplace and on the tasks. Exposure levels were the highest for tasks involving agitation of water and matter, especially for 'chamber cleanup' and 'pipes cleanup' with a high-pressure water jet. Airborne endotoxin levels at the workplace tended to be higher when CFC-FG was used as the sampling method rather than CFC-PC. The adjusted mean of the measured concentrations for CFC-PC represents 57% of the mean observed with CFC-FG. The number of samples collected in the descriptive study was too low for drawing definitive conclusions and further exposure investigations are needed. Therefore, our exploratory study provides new exposure data for the insufficiently documented sewer working environment and it would be useful for designing larger exposures studies.

Exposure to grain dust and microbial components in the Norwegian grain and compound feed industry

OBJECTIVES

The aim of this study was to extensively characterize grain workers' personal exposure during work in Norwegian grain elevators and compound feed mills, to identify differences in exposures between the workplaces and seasons, and to study the correlations between different microbial components.

METHODS

Samples of airborne dust (n = 166) were collected by full-shift personal sampling during work in 20 grain elevators and compound feed mills during one autumn season and two winter seasons. The personal exposure to grain dust, endotoxins, β-1→3-glucans, bacteria, and fungal spores was quantified. Correlations between dust and microbial components and differences between workplaces and seasons were investigated. Determinants of endotoxin and β-1→3-glucan exposure were evaluated by linear mixed-effect regression modeling.

RESULTS

The workers were exposed to an overall geometric mean of 1.0mg m(-3) inhalable grain dust [geometric standard deviation (GSD) = 3.7], 628 endotoxin units m(-3) (GSD = 5.9), 7.4 µg m(-3) of β-1→3-glucan (GSD = 5.6), 21 × 10(4) bacteria m(-3) (GSD = 7.9) and 3.6 × 10(4) fungal spores m(-3) (GSD = 3.4). The grain dust exposure levels were similar across workplaces and seasons, but the microbial content of the grain dust varied substantially between workplaces. Exposure levels of all microbial components were significantly higher in grain elevators compared with all other workplaces. The grain dust exposure was significantly correlated (Pearson's r) with endotoxin (rp = 0.65), β-1→3-glucan (rp = 0.72), bacteria (rp = 0.44) and fungal spore (rp = 0.48) exposure, whereas the explained variances were strongly dependent on the workplace. Bacteria, grain dust, and workplace were important determinants for endotoxin exposure, whereas fungal spores, grain dust, and workplace were important determinants for β-1→3-glucan exposure.

CONCLUSIONS

Although the workers were exposed to a relatively low mean dust level, the microbial exposure was high. Furthermore, the exposure levels of microbial components varied between workplaces although the dust levels were similar. We therefore recommend that exposure levels at different workplaces should be assessed separately and a task-based assessment should be done for detailed evaluation of efficient dust-reducing measures. The microbial content and knowledge of health effects of the microbial components should be considered in health risk evaluations of these workplaces.

Exposure to inhalable dust and endotoxin among Danish pig farmers affected by work tasks and stable characteristics

OBJECTIVE

To identify working tasks and stable characteristics that determine intensity and variability of personal exposure to dust and endotoxin among pig farmers.

METHODS

Three hundred fifty-four personal full-shift measurements were performed in 231 farmers employed in 53 Danish pig farms. Filters were gravimetrically analysed for inhalable dust and for endotoxin by the Limulus amebocyte lysate assay. Information on working tasks and stable characteristics were collected using self-reported activity diaries and walk-through surveys performed in conjunction with the measurements. Associations between log-transformed dust and endotoxin exposure and working tasks and stable characteristics were examined using linear mixed-effects analysis. In these models, worker and farm identity were treated as random effects and working tasks and stable characteristics as fixed effects. Both separate and combined models for tasks and stable characteristics were elaborated.

RESULTS

Inhalable dust concentrations ranged between 0.1 and 48 mg m(-3) and endotoxin concentrations varied between 9.2 and 370,000 EU m(-3). Field work activities played a dominant role on the exposure variability. Indoor working tasks with intense animal activity or handling of feed materials increased exposure concentrations, whereas engagement in field work was associated with lower exposure concentrations. High-pressure water cleaning increased endotoxin exposure but did not affect exposure to inhalable dust. Stable characteristics related to feeding practices and type of ventilation were determinants of exposure to inhalable dust. For endotoxin, the most important determinants were use of dry feed and slatted floor coverage. Feeding practices solely explained all between-farms variability in exposure to inhalable dust and endotoxin.

CONCLUSIONS

These findings suggest feeding systems, flooring and ventilation to be potential areas where improved methods can reduce exposure to dust and endotoxin among pig farmers. Further, they highlight particular tasks involving feeding and intense animal handling as sources of very high levels of exposure. The pig farming industry is encouraged to focus on exposure reduction. Use of respirators during performance of working tasks where levels of exposure are particularly high ought to be considered until adequate hygienic solutions have been established.

Health risk assessment of occupational exposure to hazardous volatile organic compounds in swine gestation, farrowing and nursery barns

Livestock producers are exposed to a high number of airborne pollutants during their daily duties of cleaning, feeding and maintenance activities. Hazardous air pollutants (HAPs) are a major group of pollutants that may cause cancer or other serious health effects including neurological, respiratory, reproductive and developmental disorders. In this study, health risks of occupational exposure to eight hazardous VOCs (phenol, p-cresol, o/m-cresol, benzene, toluene, ethylbenzene, o-xylene, and m/pxylene) that are most likely to be emitted from swine buildings were assessed using Monte Carlo simulation. The purpose of the study was to calculate emission rates and to quantify cancer and hazard risks of the target VOCs. Cancer and hazard risks were calculated for workers A, B, and C, who spent six hours in the gestation, farrowing and nursery barns, respectively, and one hour in the office space every day. Concentrations of the target VOCs did not exceed their recommended exposure limits (RELs). But, concentrations of p-cresol and benzene exceeded their preliminary remediation goals (PRGs). The highest emission rates in mg s(-1) were measured from the gestation rooms while the highest emission rates in mg per s per head were measured from the farrowing rooms. Cancer risks of ethylbenzene, benzene and p-cresol were higher than EPA's benchmark of one per million. Hazard risks of benzene, toluene, p-cresol, and o/m-cresol were higher than the maximum acceptable risk threshold (10(-4)). Worker B (farrowing) had the highest cumulative cancer (16.6 in one million) and hazard (11 342 in one million) risks. It was followed by workers A (gestation) and C (nursery). Sensitivity analysis showed that inhalation unit risk (IUR) had the highest impact on cancer risk assessment while recommended exposure limit (REL) had the highest impact on hazard risk assessment.

Agricultural exposures and stroke mortality in the Agricultural Health Study

Exposures associated with common agricultural activities may increase risk of stroke. The authors evaluated associations between self-reported agricultural activities including pesticide use and handling of crops and stroke mortality among 51,603 male pesticide applicators enrolled in the Agricultural Health Study (AHS). Vital status was obtained through 2008. Stroke mortality was defined by underlying or contributing cause of death (ICD-9 430-438, ICD-10 I60-I69). Information regarding lifetime pesticide use, working with crops or animals, engagement in other agricultural activities, and potential confounders was self-reported at enrollment. Cox proportional hazards models, with age as the time scale, were used to estimate hazard ratios (HR) and 95% confidence intervals (CI) adjusted for state of residence, smoking status, and alcohol consumption. Median follow-up time was 13 yr, during which 308 stroke deaths occurred. No measure of overall or specific pesticide use was positively associated with mortality due to stroke. Stroke mortality was inversely associated with handling hay, grain, or silage at least once each year as reported at enrollment (HR: 0.75; 95% CI: 0.58, 0.98). There was no evidence of an association between pesticide use and stroke mortality. The inverse association between handling of hays and grains and stroke mortality may be due to (1) those engaging in such activities being healthier than those who did not or (2) exposure to some biological agent present in hays and grains. Further investigation of incident stroke, rather than stroke mortality, as well as stroke subtypes, is needed to determine the full role of agricultural exposures and stroke.