The Use of Solvent/Detergent Treatment in Pathogen Reduction of Plasma

Platelet Pathogen Reduction Technology-Should We Stay or Should We Go…?

The recent COVID-19 pandemic has significantly challenged blood transfusion services (BTS) for providing blood products and for keeping blood supplies available. The possibility that a similar pandemic event may occur again has induced researchers and transfusionists to investigate the adoption of new tools to prevent and reduce these risks. Similarly, increased donor travelling and globalization, with consequent donor deferral and donor pool reduction, have contributed to raising awareness on this topic. Although recent studies have validated the use of pathogen reduction technology (PRT) for the control of transfusion-transmitted infections (TTI) this method is not a standard of care despite increasing adoption. We present a critical commentary on the role of PRT for platelets and on associated problems for blood transfusion services (BTS). The balance of the cost effectiveness of adopting PRT is also discussed.

Unraveling the Biophysical Mechanisms of How Antiviral Detergents Disrupt Supported Lipid Membranes: Toward Replacing Triton X-100

Triton X-100 (TX-100) is a membrane-disrupting detergent that is widely used to inactivate membrane-enveloped viral pathogens, yet is being phased out due to environmental safety concerns. Intense efforts are underway to discover regulatory acceptable detergents to replace TX-100, but there is scarce mechanistic understanding about how these other detergents disrupt phospholipid membranes and hence which ones are suitable to replace TX-100 from a biophysical interaction perspective. Herein, using the quartz crystal microbalance-dissipation (QCM-D) and electrochemical impedance spectroscopy (EIS) techniques in combination with supported lipid membrane platforms, we characterized the membrane-disruptive properties of a panel of TX-100 replacement candidates with varying antiviral activities and identified two distinct classes of membrane-interacting detergents with different critical micelle concentration (CMC) dependencies and biophysical mechanisms. While all tested detergents formed micelles, only a subset of the detergents caused CMC-dependent membrane solubilization similarly to that of TX-100, whereas other detergents adsorbed irreversibly to lipid membrane interfaces in a CMC-independent manner. We compared these biophysical results to virus inactivation data, which led us to identify that certain membrane-interaction profiles contribute to greater antiviral activity and such insights can help with the discovery and validation of antiviral detergents to replace TX-100.

Viral inactivation for pH-sensitive antibody formats such as multi-specific antibodies

Recently developed multi-specific antibody formats enable new therapeutic concepts. Conveniently, formats with an Fc domain allow purification in well-established mAb platform processes. However, due to the structural complexity of the formats, the assembled molecules may be sensitive to extreme pH commonly used for viral inactivation. An alternative to low pH incubation for virus inactivation is the use of a mixture of tri-n-butyl phosphate (TnBP, solvent) and Polysorbate 80 (PS80, detergent). While TnBP is toxic, this combination has a long history of use in the manufacturing of human plasma-derived products that are sensitive to low or high pH incubation. Data are provided demonstrating that the solvent/detergent (S/D) treatment using TnBP and PS80 can be successfully used for pH-sensitive, multi-specific antibody formats in the clarified cell culture fluid (CCCF). A different placement of the S/D within the purification process, namely during the capture by Protein A (PA), has been evaluated. This alternative placement allows effective viral inactivation by S/D while preserving the viral reduction and viral inactivation achieved through the PA step itself, enabling the cumulation of these effects. Furthermore, the process alternative simplifies the liquid handling by reducing the added volumes of the required S/D liquids, thus reducing the amount of toxic TnBP to a minimum. Data are shown demonstrating a complete removal of TnBP and PS80 in the process.

On-column virus inactivation by solvent/detergent treatment for a recombinant biological product

Each process step in the manufacture of biological products requires expensive resources and reduces total process productivity. Since downstream processing of biologicals is the main cost driver, process intensification is a persistent topic during the entire product life cycle. We present here one approach for the intensification of bioprocesses by applying on-column virus inactivation using solvent/detergent (S/D) treatment during ion-exchange chromatography. The established purification process of a recombinant protein was used as a model to compare key process parameters (i.e., product yield, specific activity, impurity clearance) of the novel approach to the standard process protocol. Additional wash and incubation steps with and without S/D-containing buffers were introduced to ensure sufficient contact time to effectively eliminate enveloped viruses and to significantly decrease the amount of S/D reagents. Comparison of key process parameters demonstrated equivalent process performance. To assess the viral clearance capacity of the novel approach, XMuLV was spiked as model virus to the chromatographic load and all resulting fractions were analyzed by TCID50 and RT-qPCR. Data indicates the inactivation capability of on-column virus inactivation even at 10% of the nominal S/D concentration, although the mechanism of viral clearance needs further investigation.

Solvent/detergent treated pooled human plasma can decrease the recurrence of allergic transfusion reactions in pediatric, adolescent, and young adult patients

BACKGROUND

Octaplas is a solvent/detergent (S/D)-treated pooled human plasma indicated for the treatment of thrombotic thrombocytopenic purpura (TTP) as well as multiple coagulation factor deficiency in patients with liver disease or undergoing liver transplantation or cardiac surgery. We aimed at providing pediatric, adolescent, and young adult evidence for the decrease in allergic transfusion reactions (ATRs) with S/D-treated plasma.

STUDY DESIGN/METHODS

A single-center retrospective review of patient records was performed from January 2018 through July 2022 for patients who received S/D treated plasma (Octaplas™; Octapharma).

RESULTS/FINDINGS

A total of 1415 units of S/D-treated plasma were transfused to nine patients at our institution. Patient ages ranged from 13 months to 25 years old. The reason to initiate transfusion with S/D treated plasma in six patients was mild to severe ATR to plasma-containing products and the need for therapeutic plasma exchange (TPE) or plasma transfusions (PTs). TPE or PT was performed for various clinical indications. Average S/D treated plasma volume per TPE or PT ranged from 200 to 1800 mL per event. During the study period, since initiating transfusions with S/D treated plasma, there have been no allergic or other transfusion reactions reported among these patients.

CONCLUSION

We have successfully utilized S/D treated plasma over the last 4.5 years for pediatric, adolescent, and young adult patients who otherwise would have suffered ATR due to necessary TPE or PT. S/D treated plasma is an additional tool that can be utilized by transfusion services, including pediatrics, to safely transfuse their patients.

Human butyrylcholinesterase in Cohn fraction IV-4 purified in a single chromatography step on Hupresin

Protection from the toxicity of nerve agents is achieved by pretreatment with human butyrylcholinesterase (BChE). Current methods for purifying large quantities of BChE from frozen Cohn fraction IV-4 produce 99% pure enzyme, but the yield is low (21%). Our goal was to simplify the purification procedure and increase the yield. Butyrylcholinesterase was extracted from frozen Cohn fraction IV-4 in 10 volumes of water pH 6. The filtered extract was pumped onto a Hupresin affinity column. The previously utilized anion exchange chromatography step was omitted. Solvent and detergent reagents used to inactivate lipid enveloped virus, bacteria and protozoa did not bind to Hupresin. BChE was eluted with 0.1 M tetramethylammonium bromide in 20 mM sodium phosphate pH 8.0. BChE protein was concentrated on a Pellicon tangential flow filtration system and demonstrated to be highly purified by mass spectrometry. A high pump rate produced protein aggregates, but a low pump rate caused minimal turbidity. Possible contamination by prekallikrein and prekallikrein activator was examined by LC-MS/MS and by a chromogenic substrate assay for kallikrein activity. Prekallikrein and kallikrein were not detected by mass spectrometry in the 99% pure BChE. The chromogenic assay indicated kallikrein activity was less than 9 mU/mL. This new, 1-step chromatography protocol on Hupresin increased the yield of butyrylcholinesterase by 200%. The new method significantly reduces production costs by optimizing yield of 99% pure butyrylcholinesterase.

Frozen and freeze-dried solvent/detergent treated plasma: Two different pharmaceutical formulations with comparable quality

BACKGROUND

OctaplasLG is a frozen solvent/detergent-treated plasma product used for treating complex coagulation factor deficiencies or as substitution therapy in emergency situations where specific factor concentrates are not available. A new freeze-dried (also known as lyophilized) form of OctaplasLG, referred as OctaplasLG Lyo (Octapharma AG, Switzerland) offers rapid reconstitution and more flexible storage conditions, improving logistics and utilization. This study compared the biochemical quality of OctaplasLG Lyo with OctaplasLG and single-donor fresh frozen plasma units.

STUDY DESIGN AND METHODS

Three batches of OctaplasLG Lyo, manufactured for production process qualification, and 12 batches of OctaplasLG were provided by Octapharma AB (Sweden). Twelve units of fresh frozen plasma were collected by the local FDA-licensed blood provider. All plasma samples were assessed for global coagulation parameters, coagulation factors and protease inhibitors, activation markers of coagulation and fibrinolysis, and important plasma proteins. Quality control assays were conducted in accordance with European Pharmacopeia requirements.

RESULTS

Frozen and freeze-dried OctaplasLG demonstrated comparable quality profiles upon thawing or reconstitution. All coagulation factor and protease inhibitor activity parameters were in line with levels mandated by the European Pharmacopeia. Fresh frozen plasma units showed comparable coagulation factor activities, with higher protein S and plasmin inhibitor levels than the OctaplasLG products. Fresh frozen plasma parameters showed high lot-to-lot variations.

DISCUSSION

The two pharmaceutical forms of OctaplasLG (frozen and freeze-dried) have comparable biochemical quality. Key features of OctaplasLG Lyo are rapid reconstitution time and storage flexibility, which may improve logistics and utilization, and have particular advantages in emergency situations and pre-hospital settings.

Validation of Viral Inactivation Protocols for Therapeutic Blood Products against Severe Acute Respiratory Syndrome Coronavirus-2 (SARS-COV-2)

Therapeutic blood products including convalescent plasma/serum and immunoglobulins concentrated from convalescent plasma, such as intravenous immunoglobulins or hyperimmune globulins, and monoclonal antibodies are passive immunotherapy options for novel coronavirus disease 2019 (COVID-19). They have been shown to improve the clinical status and biological and radiological parameters in some groups of COVID-19 patients. However, blood products are still potential sources of virus transmission in recipients. The use of pathogen reduction technology (PRT) should increase the safety of the products. The purpose of this study was to determine the impact of solvent/detergents (S/D) procedures on SARS-COV-2 infectivity elimination in the plasma of donors but also on COVID-19 convalescent serum (CCS) capacity to neutralize SARS-COV-2 infectivity. In this investigation, S/D treatment for all experiments was performed at a shortened process time (30 min). We first evaluated the impact of S/D treatments (1% TnBP/1% TritonX-45 and 1% TnBP/1% TritonX-100) on the inactivation of SARS-COV-2 pseudoparticles (SARS-COV-2pp)-spiked human plasma followed by S/D agent removal using a Sep-Pak Plus C18 cartridge. Both treatments were able to completely inactivate SARS-COV-2pp infectivity to an undetectable level. Moreover, the neutralizing activity of CCS against SARS-COV-2pp was preserved after S/D treatments. Our data suggested that viral inactivation methods using such S/D treatments could be useful in the implementation of viral inactivation/elimination processes of therapeutic blood products against SARS-COV-2.

Anti-Viral Photodynamic Inactivation of T4-like Bacteriophage as a Mammalian Virus Model in Blood

The laboratorial available methods applied in plasma disinfection can induce damage in other blood components. Antimicrobial photodynamic therapy (aPDT) represents a promising approach and is approved for plasma and platelet disinfection using non-porphyrinic photosensitizers (PSs), such as methylene blue (MB). In this study, the photodynamic action of three cationic porphyrins (Tri-Py(+)-Me, Tetra-Py(+)-Me and Tetra-S-Py(+)-Me) towards viruses was evaluated under white light irradiation at an irradiance of 25 and 150 mW·cm^−2, and the results were compared with the efficacy of the approved MB. None of the PSs caused hemolysis at the isotonic conditions, using a T4-like phage as a model of mammalian viruses. All porphyrins were more effective than MB in the photoinactivation of the T4-like phage in plasma. Moreover, the most efficient PS promoted a moderate inactivation rate of the T4-like phage in whole blood. Nevertheless, these porphyrins, such as MB, can be considered promising and safe PSs to photoinactivate viruses in blood plasma.

A minimally manipulated preservation and virus inactivation method for amnion/chorion

Allogeneic amnion tissues have been widely used in tissue repair and regeneration, especially a remarkable trend of clinical uses in chronic wound repair. The virus inactivation procedures are necessary and required to be verified for the clinical use and approval of biological products. Cobalt-60 (Co-60) or electron-beam (e-beam) is the common procedure for virus and bacterial reduction, but the excessive dose of irradiation was reported to be harmful to biological products. Herein, we present a riboflavin (RB)-ultraviolet light (UV) method for virus inactivation of amnion and chorion tissues. We used the standard in vitro limiting dilution assay to test the viral reduction capacity of the RB-UV method on amnion or chorion tissues loaded with four types of model viruses. We found RB-UV was a very effective procedure for inactivating viruses of amnion and chorion tissues, which could be used as a complementary method to Co-60 irradiation. In addition, we also screened the washing solutions and drying methods for the retention of growth factors.

Incidence of transfusion-related acute lung injury temporally associated with solvent/detergent plasma use in the ICU: A retrospective before and after implementation study

Background

Transfusion‐related acute lung injury (TRALI) is a severe complication of plasma transfusion, though the use of solvent/detergent pooled plasma (SDP) has nearly eliminated reported TRALI cases. The goal of this study was to investigate the incidence of TRALI in intensive care units (ICU) following the replacement of quarantined fresh frozen plasma (qFFP) by SDP.

Study design and methods

A retrospective multicenter observational before–after cohort study was performed during two 6‐month periods, before (April–October 2014) and after the introduction of SDP (April–October 2015), accounting for a washout period. A full chart review was performed for patients who received ≥1 plasma units and developed hypoxemia within 24 h.

Results

During the study period, 8944 patients were admitted to the ICU. Exactly 1171 quarantine fresh frozen plasma (qFFP) units were transfused in 376 patients, and respectively, 2008 SDP units to 396 patients after implementation. Ten TRALI cases occurred during the qFFP and nine cases occurred during the SDP period, in which plasma was transfused. The incidence was 0.85% (CI95%: 0.33%–1.4%) per unit qFFP and 0.45% (CI95%: 0.21%–0.79%, p = 0.221) per SDP unit. One instance of TRALI occurred after a single SDP unit. Mortality was 70% for patients developing TRALI in the ICU compared with 22% in patients receiving at least one plasma transfusion.

Conclusion

Implementation of SDP lowered the incidence of TRALI in which plasma products were implicated, though not significantly. Clinically diagnosed TRALI can still occur following SDP transfusion. Developing TRALI in the ICU was associated with high mortality rates, therefore, clinicians should remain vigilant.

Reported transfusion-related acute lung injury associated with solvent/detergent plasma - A case series

Background

Antibody‐mediated transfusion‐related acute lung injury (TRALI) is caused by donor HLA or HNA antibodies in plasma‐containing products. In the Netherlands 55,000 units of solvent/detergent plasma (SDP), a pooled plasma product, are transfused yearly. It's produced by combining plasma from hundreds of donors, diluting harmful antibodies. Due to a lack of reported cases following implementation, some have labeled SDP as “TRALI safe”.

Study design and methods

Pulmonary transfusion reactions involving SDP reported to the Dutch national hemovigilance network in 2016–2019 were reviewed. Reporting hospitals were contacted for additional information, cases with TRALI and imputability definite, probable, or possible were included and informed consent was sought.

Results

A total of three TRALI and nine TACO cases were reported involving SDP. The imputability of one TRALI case was revised from possible to unlikely and excluded; in one case no informed consent was obtained. We present a case description of TRALI following SDP transfusion in a 69‐year‐old male, 3 days following endovascular aortic aneurysm repair. The patient received one unit of SDP to correct a heparin‐induced coagulopathy, prior to removal of a spinal catheter post‐operatively. Within five hours he developed hypoxemic respiratory failure requiring intubation, hypotension, bilateral chest infiltrates, and leucopenia. The patient made a full recovery.

Conclusion

This case of TRALI, following transfusion of a single unit of SDP to a patient without ARDS risk factors, demonstrates that TRALI can occur with this product. Clinicians should remain vigilant and continue to report suspected cases, to help further understanding of SDP‐associated TRALI.

Defining biological and biophysical properties of SARS-CoV-2 genetic material in wastewater

SARS-CoV-2 genetic material has been detected in raw wastewater around the world throughout the COVID-19 pandemic and has served as a useful tool for monitoring community levels of SARS-CoV-2 infections. SARS-CoV-2 genetic material is highly detectable in a patient's feces and the household wastewater for several days before and after a positive COVID-19 qPCR test from throat or sputum samples. Here, we characterize genetic material collected from raw wastewater samples and determine recovery efficiency during a concentration process. We find that pasteurization of raw wastewater samples did not reduce SARS-CoV-2 signal if RNA is extracted immediately after pasteurization. On the contrary, we find that signal decreased by approximately half when RNA was extracted 24-36 h post-pasteurization and ~90% when freeze-thawed prior to concentration. As a matrix control, we use an engineered enveloped RNA virus. Surprisingly, after concentration, the recovery of SARS-CoV-2 signal is consistently higher than the recovery of the control virus leading us to question the nature of the SARS-CoV-2 genetic material detected in wastewater. We see no significant difference in signal after different 24-hour temperature changes; however, treatment with detergent decreases signal ~100-fold. Furthermore, the density of the samples is comparable to enveloped retrovirus particles, yet, interestingly, when raw wastewater samples were used to inoculate cells, no cytopathic effects were seen indicating that wastewater samples do not contain infectious SARS-CoV-2. Together, this suggests that wastewater contains fully intact enveloped particles.

Detection of Circulating VZV-Glycoprotein E-Specific Antibodies by Chemiluminescent Immunoassay (CLIA) for Varicella-Zoster Diagnosis

Varicella and herpes zoster are mild symptoms-associated diseases caused by varicella–zoster virus (VZV). They often cause severe complications (disseminated zoster), leading to death when diagnoses and treatment are delayed. However, most commercial VZV diagnostic tests have low sensitivity, and the most sensitive tests are unevenly available worldwide. Here, we developed and validated a highly sensitive VZV diagnostic kit based on the chemiluminescent immunoassay (CLIA) approach. VZV-glycoprotein E (gE) was used to develop a CLIA diagnostic approach for detecting VZV-specific IgA, IgG, and IgM. The kit was tested with 62 blood samples from 29 VZV-patients classified by standard ELISA into true-positive and equivocal groups and 453 blood samples from VZV-negative individuals. The diagnostic accuracy of the CLIA kit was evaluated by receiver-operating characteristic (ROC) analysis. The relationships of immunoglobulin-isotype levels between the two groups and with patient age ranges were analyzed. Overall, the developed CLIA-based diagnostic kit demonstrated the detection of VZV-specific immunoglobulin titers depending on sample dilution. From the ELISA-based true-positive patient samples, the diagnostic approach showed sensitivities of 95.2%, 95.2%, and 97.6% and specificities of 98.0%, 100%, and 98.9% for the detection of VZV-gE-specific IgA, IgG, and IgM, respectively. Combining IgM to IgG and IgA detection improved diagnostic accuracy. Comparative analyses on diagnosing patients with equivocal results displaying very low immunoglobulin titers revealed that the CLIA-based diagnostic approach is overall more sensitive than ELISA. In the presence of typical VZV symptoms, CLIA-based detection of high titer of IgM and low titer of IgA/IgG suggested the equivocal patients experienced primary VZV infection. Furthermore, while no difference in IgA/IgG level was found regarding patient age, IgM level was significantly higher in young adults. The CLIA approach-based detection kit for diagnosing VZV-gE-specific IgA, IgG, and IgM is simple, suitable for high-throughput routine analysis situations, and provides enhanced specificity compared to ELISA.

What Laboratory Tests and Physiologic Triggers Should Guide the Decision to Administer a Platelet or Plasma Transfusion in Critically Ill Children and What Product Attributes Are Optimal to Guide Specific Product Selection? From the Transfusion and Anemia EXpertise Initiative-Control/Avoidance of Bleeding

OBJECTIVES

To present consensus statements and supporting literature for plasma and platelet product variables and related laboratory testing for transfusions in general critically ill children from the Transfusion and Anemia EXpertise Initiative-Control/Avoidance of Bleeding.

DESIGN

Systematic review and consensus conference of international, multidisciplinary experts in platelet and plasma transfusion management of critically ill children.

SETTING

Not applicable.

PATIENTS

Critically ill pediatric patients at risk of bleeding and receiving plasma and/or platelet transfusions.

INTERVENTIONS

None.

MEASUREMENTS AND MAIN RESULTS

A panel of 10 experts developed evidence-based and, when evidence was insufficient, expert-based statements for laboratory testing and blood product attributes for platelet and plasma transfusions. These statements were reviewed and ratified by the 29 Transfusion and Anemia EXpertise Initiative - Control/Avoidance of Bleeding experts. A systematic review was conducted using MEDLINE, EMBASE, and Cochrane Library databases, from inception to December 2020. Consensus was obtained using the Research and Development/University of California, Los Angeles Appropriateness Method. Results were summarized using the Grading of Recommendations Assessment, Development, and Evaluation method. We developed five expert consensus statements and two recommendations in answer to two questions: what laboratory tests and physiologic triggers should guide the decision to administer a platelet or plasma transfusion in critically ill children; and what product attributes are optimal to guide specific product selection?

CONCLUSIONS

The Transfusion and Anemia EXpertise Initiative-Control/Avoidance of Bleeding program provides some guidance and expert consensus for the laboratory and blood product attributes used for decision-making for plasma and platelet transfusions in critically ill pediatric patients.

Oral Immunotherapy With Human Secretory Immunoglobulin A Improves Survival in the Hamster Model of Clostridioides difficile Infection

Coadministration of human secretory IgA (sIgA) together with subtherapeutic vancomycin enhanced survival in the Clostridioides difficile infection (CDI) hamster model. Vancomycin (5 or 10 mg/kg × 5 days) plus healthy donor plasma sIgA/monomeric IgA (TID × 21 days) or hyperimmune sIgA/monomeric IgA (BID × 13 days) enhanced survival. Survival was improved compared to vancomycin alone, P = .018 and .039 by log-rank Mantel-Cox, for healthy and hyperimmune sIgA, respectively. Passive immunization with sIgA (recombinant human secretory component plus IgA dimer/polymer from pooled human plasma) can be administered orally and prevents death in a partially treated CDI hamster model.

Current Therapies in Clinical Trials of Parkinson's Disease: A 2021 Update

Parkinson's disease (PD) is a progressive neurodegenerative disorder that currently has no cure, but treatments are available to improve PD symptoms and maintain quality of life. In 2020, about 10 million people worldwide were living with PD. In 1970, the United States Food and Drug Administration approved the drug levodopa as a dopamine replacement to manage PD motor symptoms; levodopa-carbidopa combination became commercialized in 1975. After over 50 years of use, levodopa is still the gold standard for PD treatment. Unfortunately, levodopa therapy-induced dyskinesia and OFF symptoms remain unresolved. Therefore, we urgently need to analyze each current clinical trial's status and therapeutic strategy to discover new therapeutic approaches for PD treatment. We surveyed 293 registered clinical trials on ClinicalTrials.gov from 2008 to 16 June 2021. After excluded levodopa/carbidopa derivative add-on therapies, we identified 47 trials as PD treatment drugs or therapies. Among them, 19 trials are in phase I (41%), 25 trials are in phase II (53%), and 3 trials are in phase III (6%). The three phase-III trials use embryonic dopamine cell implant, 5-HT_1A receptor agonist (sarizotan), and adenosine A_2A receptor antagonist (caffeine). The therapeutic strategy of each trial shows 29, 5, 1, 5, 5, and 2 trials use small molecules, monoclonal antibodies, plasma therapy, cell therapy, gene therapy, and herbal extract, respectively. Additionally, we discuss the most potent drug or therapy among these trials. By systematically updating the current trial status and analyzing the therapeutic strategies, we hope this review can provide new ideas and insights for PD therapy development.

Thawed solvent/detergent-treated plasma demonstrates comparable clinical efficacy to thawed plasma

BACKGROUND

Thawed Plasma (TP), plasma thawed and refrigerated for up to 5 days, is a commonly transfused plasma product. This pilot study was conducted to determine whether Thawed Solvent/Detergent-treated Plasma stored refrigerated for up to 5-days post-thaw (T-S/D) was as efficacious as TP.

STUDY DESIGN AND METHODS

This single institution retrospective cohort analysis evaluated the efficacy of T-S/D in reversing coagulopathies in comparison to TP. Utilizing the institution's electronic medical records, transfusion data were collected in adult patients who received either TP or T-S/D. The primary outcome was the incidence of subsequent transfusions within 24 hours after first dose of either type of plasma. Secondary outcomes included the number of blood products transfused within 24 hours of first-dose plasma, correction of pre-transfusion coagulation laboratory values, volume transfused, and clinical outcomes.

RESULTS

TP was received by 301 patients and 137 received T-S/D during the first 32 months post-implementation of T-S/D. There was no difference in incidence of subsequent transfusions or number of blood products given. The median pre-INR of both the TP and T-S/D cohorts was 1.9, with a similar decrease in INR of 0.2 and 0.3 (p = 0.36), respectively, post plasma transfusion. There was no difference in correction of PT/aPTT, mortality, transfusion reactions, readmission rates, length of stay, or inpatient deep venous thrombosis. The median volume of T-S/D plasma transfused for the first dose was 126 mL less than TP (p = .0001).

CONCLUSION

T-S/D was as efficacious as TP for the treatment of coagulopathies and the reversal of coagulation laboratory values.

Hand hygiene during COVID-19: Recommendations from the American Contact Dermatitis Society

The recent COVID-19 pandemic has resulted in increased hand hygiene and hand cleansing awareness. To prevent virus transmission, the Centers for Disease Control and Prevention recommends frequent hand washing with soap and water. Hand hygiene products are available in a variety of forms, and while each of these formulations may be effective against COVID-19, they may also alter skin barrier integrity and function. As health care workers and the general population focus on stringent hand hygiene, the American Contact Dermatitis Society anticipates an increase in both irritant contact and allergic contact hand dermatitis. Alcohol-based hand sanitizers with moisturizers have the least sensitizing and irritancy potential when compared to soaps and synthetic detergents. This article provides an overview of the most frequently used hand hygiene products and their associations with contact dermatitis as well as recommendations from the American Contact Dermatitis Society on how to treat and prevent further dermatitis.

Identification and characterization of a Triton X-100 replacement for virus inactivation

Triton X-100 detergent treatment is a robust enveloped virus inactivation unit operation included in biopharmaceutical manufacturing processes. However, the European Commission officially placed Triton X-100 on the Annex XIV authorization list in 2017 because a degradation product of Triton X-100, 4-(1,1,3,3-tetramethylbutyl) phenol (also known as 4-tert-octylphenol), is considered to have harmful endocrine disrupting activities. As a result, the use of Triton X-100 in the European Economic Area (EEA) would not be allowed unless an ECHA issued authorization was granted after the sunset date of January 4, 2021. This has prompted biopharmaceutical manufacturers to search for novel, environment-friendly alternative detergents for enveloped virus inactivation. In this study, we report the identification of such a novel detergent, Simulsol SL 11W. Simulsol SL 11W is an undecyl glycoside surfactant produced from glucose and C11 fatty alcohol. We report here that Simulsol SL 11W was able to effectively inactive enveloped viruses, such as xenotropic murine leukemia virus (XMuLV) and pseudorabies virus (PRV). By using XMuLV as a representative enveloped virus, the influence of various parameters on the effectiveness of virus inactivation was evaluated. Virus inactivation by Simulsol SL 11W was effective across different clarified bioreactor harvests at broad concentrations, pH, and temperature ranges. Simulsol SL 11W concentration, temperature of inactivation, and treatment time were identified as critical process parameters for virus inactivation. Removal of Simulsol SL 11W was readily achieved by Protein A chromatography and product quality was not affected by detergent treatment. Taken together, these results have shown the potential of Simulsol SL 11W as a desirable alternative to Triton X-100 for enveloped virus inactivation that could be readily implemented into biopharmaceutical manufacturing processes.

New strategies for the control of infectious and parasitic diseases in blood donors: the impact of pathogen inactivation methods

Around 70 infectious agents are possible threats for blood safety.

The risk for blood recipients is increasing because of new emergent agents like West Nile, Zika and Chikungunya viruses, or parasites such as Plasmodium and Trypanosoma cruzi in non-endemic regions, for instance.

Screening programmes of the donors are more and more implemented in several Countries, but these cannot prevent completely infections, especially when they are caused by new agents.

Pathogen inactivation (PI) methods might overcome the limits of the screening and different technologies have been set up in the last years.

This review aims to describe the most widely used methods focusing on their efficacy as well as on the preservation integrity of blood components.

Investigating the Effect of Encapsulation Processing Parameters on the Viability of Therapeutic Viruses in Electrospraying

The ability of viruses to introduce genetic material into cells can be usefully exploited in a variety of therapies and also vaccination. Encapsulating viruses to limit inactivation by the immune system before reaching the desired target and allowing for controlled release is a promising strategy of delivery. Conventional encapsulation methods, however, can significantly reduce infectivity. The aim of this study was to investigate electrospraying as an alternative encapsulation technique. Two commonly used therapeutic viruses, adenovirus (Ad) and modified vaccinia Ankara (MVA), were selected. First, solutions containing the viruses were electrosprayed in a single needle configuration at increasing voltages to examine the impact of the electric field. Second, the effect of exposing the viruses to pure organic solvents was investigated and compared to that occurring during coaxial electrospraying. Infectivity was determined by measuring the luminescence produced from lysed A549 cells after incubation with treated virus. Neither Ad nor MVA exhibited any significant loss in infectivity when electrosprayed within the range of electrospraying parameters relevant for encapsulation. A significant decrease in infectivity was only observed when MVA was electrosprayed at the highest voltage, 24 kV, and when MVA and Ad were exposed to selected pure organic solvents. Thus, it was concluded that electrospraying would be a viable method for virus encapsulation.

Solvent detergent treated pooled plasma and reduction of allergic transfusion reactions

BACKGROUND

Thrombotic thrombocytopenic purpura (TTP) patients have increased risk for allergic transfusion reactions (ATR) due to the number of plasma products they require. This study evaluated the efficacy of solvent detergent treated plasma (S/D treated plasma) to reduce ATRs.

STUDY DESIGN AND METHODS

All TTP patients who presented from April 2014 to February 2015 and experienced a moderate-severe ATR to untreated plasma with TPE were switched to S/D treated plasma (Octaplas) for their remaining procedures and included in the study. Patient records were retrospectively reviewed.

RESULTS

The overall ATR rate per procedure decreased from 35.0% (95% CI = 15.4%-59.2%) with untreated plasma to 1.4% ([1/73] 95% CI = 0.0%-7.4%) with S/D treated plasma. The moderate-severe ATR rate decreased from 20.0% ([4/20] 95% CI = 5.7%-43.7%) with untreated plasma to 0.0% ([0/73] 95% CI = 0.0%-4.9%) with S/D treated plasma. The overall ATR rate per plasma unit decreased from 2.6% (95%CI = 1.0%-5.1%) with untreated plasma to 0.1% (95% CI = 0.0%-0.4%) with S/D treated plasma. No patients experienced VTE while receiving untreated plasma. Four patients experienced VTE events while receiving S/D treated plasma. All patients who experienced a VTE had additional risk factors for VTE.

CONCLUSION

S/D plasma has promise as an effective product to reduce the risk of ATRs in TTP patients. Given the high risk of ATR in TTP patients, consideration of S/D plasma instead of untreated plasma for TPE in these patients may be warranted, especially for patients with a history of moderate to severe ATR. More extensive studies are needed to confirm these findings.

Amotosalen-inactivated fresh frozen plasma is comparable to solvent-detergent inactivated plasma to treat thrombotic thrombocytopenic purpura

BACKGROUND

Therapeutic Plasma Exchange (TPE) is the primary therapy of immune-mediated Thrombotic Thrombocytopenic Purpura (iTTP). Efficacy and safety data for TPE of iTTP have been assessed with Quarantine and Solvent-Detergent inactivated (SD) plasma. Here, amotosalen-UVA pathogen inactivated (AI) plasma, also in routine use, was evaluated in iTTP.

METHODS

We conducted a retrospective review of iTTP cases prospectively reported to the French national registry (2010-2013). Cases reviewed underwent TPE with ≥70% of either AI or SD plasma. The primary endpoint was time to platelet count recovery; secondary endpoints were related to follow-up (sustained remission, relapses, flare-ups and refractoriness).

RESULTS

30 Test patients were identified in the AI group which could be timely matched to 40 Control patients in the SD group. The groups were fairly comparable for clinical presentation. Major findings were: (i) iTTP patients were exposed to lower plasma volumes in the AI group than in the SD group; (ii) Recovery rates were comparable between the groups. Median time to platelet count recovery (>150 × 10⁹/L) trended to be shorter in the AI group though non significantly. Tolerance of AI vs SD plasma was of comparable frequency and severity in either group.

CONCLUSION

TPE with Amotosalen-inactivated plasma demonstrated therapeutic efficacy and tolerability for iTTP patients. In view of the retrospective design, confirmation of these results is required in larger prospective studies.

Photodynamic Inactivation of Candida albicans in Blood Plasma and Whole Blood

The few approved disinfection techniques for blood derivatives promote damage in the blood components, representing risks for the transfusion receptor. Antimicrobial photodynamic therapy (aPDT) seems to be a promising approach for the photoinactivation of pathogens in blood, but only three photosensitizers (PSs) have been approved, methylene blue (MB) for plasma and riboflavin and amotosalen for plasma and platelets. In this study, the efficiency of the porphyrinic photosensitizer Tri-Py(+)-Me and of the porphyrinic formulation FORM was studied in the photoinactivation of Candida albicans in plasma and in whole blood and the results were compared to the ones obtained with the already approved PS MB. The results show that FORM and Tri-Py(+)-Me are promising PSs to inactivate C. albicans in plasma. Although in whole blood the inactivation rates obtained were higher than the ones obtained with MB, further improvements are required. None of these PSs had promoted hemolysis at the isotonic conditions when hemolysis was evaluated in whole blood and after the addition of treated plasma with these PSs to concentrates of red blood cells.

Transfusion-related Acute Lung Injury in the Perioperative Patient

Transfusion-related acute lung injury is a leading cause of death associated with the use of blood products. Transfusion-related acute lung injury is a diagnosis of exclusion which can be difficult to identify during surgery amid the various physiologic and pathophysiologic changes associated with the perioperative period. As anesthesiologists supervise delivery of a large portion of inpatient prescribed blood products, and since the incidence of transfusion-related acute lung injury in the perioperative patient is higher than in nonsurgical patients, anesthesiologists need to consider transfusion-related acute lung injury in the perioperative setting, identify at-risk patients, recognize early signs of transfusion-related acute lung injury, and have established strategies for its prevention and treatment.

Production and Quality Requirements of Human Platelet Lysate: A Position Statement from the Working Party on Cellular Therapies of the International Society of Blood Transfusion

Human platelet lysate (HPL), rich in growth factors, is an efficient alternative supplement to fetal bovine serum (FBS) for ex vivo propagation of stromal cell-based medicinal products. Since 2014, HPL has been a focus of the Working Party for Cellular Therapies of the International Society of Blood Transfusion (ISBT). Currently, as several Good Manufacturing Practice (GMP)-compliant manufacturing protocols exist, an international consensus defining the optimal modes of industrial production, product specification, pathogen safety, and release criteria of this ancillary material (AM) is needed. This opinion article by the ISBT Working Party summarizes the current knowledge on HPL production and proposes recommendations on manufacturing and quality management in line with current technological innovations and regulations of biological products and advanced therapy medicinal products.

Transition from fresh frozen plasma to solvent/detergent plasma in the Netherlands: comparing clinical use and transfusion reaction risks

Plasma transfusion is indicated for replenishment of coagulative proteins to stop or prevent bleeding. In 2014, the Netherlands switched from using ~300mL fresh frozen plasma (FFP) units to using 200mL Omniplasma, a solvent/detergent treated pooled plasma (SD plasma), units. We evaluated the effect of the introduction of SD plasma on clinical plasma use, associated bleeding, and transfusion reaction incidences. Using diagnostic data from six Dutch hospitals, national blood bank data, and national hemovigilance data for 2011 to 2017, we compared the plasma/red blood cell (RBC) units ratio (f) and the mean number of plasma and RBC units transfused for FFP (~300mL) and SD plasma (200mL) for various patient groups, and calculated odds ratios comparing their associated transfusion reaction risks. Analyzing 13,910 transfusion episodes, the difference (Δf = f_{SD -} f_FFP) in mean plasma/RBC ratio (f) was negligible (Δf_{entire_cohort} = 0.01 [95% confidence interval (CI): −0.02 - 0.05]; P=0.48). SD plasma was associated with fewer RBC units transfused per episode in gynecological (difference of mean number of units −1.66 [95% CI: −2.72, −0.61]) and aneurysm (−0.97 [−1.59, −0.35]) patients. SD plasma was further associated with fewer anaphylactic reactions than FFP (odds ratio 0.37 [0.18, 0.77; P<0.01]) while the differences for most transfusion reactions were not statistically significant. SD plasma units, despite being one third smaller in volume than FFP units, are not associated with a higher plasma/RBC ratio. SD plasma is associated with fewer anaphylactic reactions than FFP plasma/RBC units ratio.

Pathogen reduction and blood transfusion safety in Africa: strengths, limitations and challenges of implementation in low-resource settings

Transfusion-transmitted infection risk remains an enduring challenge to blood safety in Africa. A high background incidence and prevalence of the major transfusion-transmitted infections (TTIs), dependence on high-risk donors to meet demand, suboptimal testing and quality assurance collectively contribute to the increased risk. With few exceptions, donor testing is confined to serological evaluation of human immunodeficiency virus (HIV), hepatitis B and C (HBV and HCV) and syphilis. Barriers to implementation of broader molecular methods include cost, limited infrastructure and lack of technical expertise. Pathogen reduction (PR), a term used to describe a variety of methods (e.g. solvent detergent treatment or photochemical activation) that may be applied to blood following collection, offers the means to diminish the infectious potential of multiple pathogens simultaneously. This is effective against different classes of pathogen, including the major TTIs where laboratory screening is already implemented (e.g. HIV, HBV and HCV) as well pathogens that are widely endemic yet remain unaddressed (e.g. malaria, bacterial contamination). We sought to review the available and emerging PR techniques and their potential application to resource-constrained parts of Africa, focusing on the advantages and disadvantages of such technologies. PR has been slow to be adopted even in high-income countries, primarily given the high costs of use. Logistical considerations, particularly in low-resourced parts of Africa, also raise concerns about practicality. Nonetheless, PR offers a rational, innovative strategy to contend with TTIs; technologies in development may well present a viable complement or even alternative to targeted screening in the future.

Pathogen reduction/inactivation of products for the treatment of bleeding disorders: what are the processes and what should we say to patients?

Patients with blood disorders (including leukaemia, platelet function disorders and coagulation factor deficiencies) or acute bleeding receive blood-derived products, such as red blood cells, platelet concentrates and plasma-derived products. Although the risk of pathogen contamination of blood products has fallen considerably over the past three decades, contamination is still a topic of concern. In order to counsel patients and obtain informed consent before transfusion, physicians are required to keep up to date with current knowledge on residual risk of pathogen transmission and methods of pathogen removal/inactivation. Here, we describe pathogens relevant to transfusion of blood products and discuss contemporary pathogen removal/inactivation procedures, as well as the potential risks associated with these products: the risk of contamination by infectious agents varies according to blood product/region, and there is a fine line between adequate inactivation and functional impairment of the product. The cost implications of implementing pathogen inactivation technology are also considered.

Biological Safety of a Highly Purified 10% Liquid Intravenous Immunoglobulin Preparation from Human Plasma

Background

A highly purified 10% liquid intravenous immunoglobulin, IQYMUNE^®, has been developed using an innovative manufacturing process including an affinity chromatography step for the removal of anti-A and anti-B hemagglutinins.

Objectives

The pathogen (viruses and prions) clearance efficacy of the manufacturing process and its robustness for critical steps were investigated.

Methods

The manufacturing process of IQYMUNE^® includes two dedicated complementary virus reduction steps: solvent/detergent (S/D) treatment and 20 nm nanofiltration as well as two contributing steps, namely caprylic acid fractionation and anion-exchange chromatography. The clearance capacity and robustness of these steps were evaluated with a wide range of viruses (enveloped and non-enveloped) and with a model of human transmissible spongiform encephalopathies (TSEs).

Results

The IQYMUNE^® manufacturing process demonstrated a high and robust virus removal capacity with global reduction factors (RFs) of relevant and model viruses: ≥14.8 log₁₀ for human immunodeficiency virus type 1 (HIV-1), ≥16.9 log₁₀ for bovine viral diarrhoea virus (BVDV)/Sindbis virus, ≥15.7 log₁₀ for pseudorabies virus (PRV), ≥12.8 log₁₀ for encephalomyocarditis virus (EMCV) and 11.0 log₁₀ for porcine parvovirus (PPV). The process also exhibited a high removal capacity for the TSE agent with an overall RF of ≥12.9 log₁₀ due to the complementary actions of the caprylic acid fractionation, anion-exchange chromatography and nanofiltration steps.

Conclusion

Data from virus and prion clearance studies fully support the high safety profile of IQYMUNE^®, with a minimal reduction of 11 log₁₀ for the smallest and most resistant non-enveloped virus, PPV, and more than 12 log₁₀ for the TSE agent.

Red blood cells derived from whole blood treated with riboflavin and ultraviolet light maintain adequate survival in vivo after 21 days of storage

BACKGROUND

Pathogen reduction (PR) of whole blood (WB) may increase blood safety when applied before component separation. This study evaluates the in vivo performance of red blood cells (RBCs) derived from WB treated with the riboflavin and ultraviolet (UV) light PR (Mirasol) system.

STUDY DESIGN AND METHODS

This was a prospective, two-center, single-blind, randomized, two-period, crossover clinical trial designed to evaluate autologous ⁵¹ Cr/^99m Tc-radiolabeled recovery and survival of RBCs derived from Mirasol-treated WB compared to untreated WB. RBCs were stored in AS-3 for 21 days at 1 to 6°C. In vitro RBC variables were characterized. Frequency and severity of treatment-emergent adverse event (TEAE) and neoantigenicity were determined.

RESULTS

Twenty-four healthy adult volunteers (n = 12 per site) were evaluated. The Mirasol 24-hr RBC recoveries were 82.5 ± 3.9% with one-sided 95% lower confidence limit of 80.9%, meeting US Food and Drug Administration acceptance criteria, albeit at lower level than controls (91.7 ± 6.8%, p < 0.001). Mean RBC survival and T₅₀ were reduced in the Mirasol group (61 and 23 days, respectively) versus controls (82 and 36 days, respectively; p < 0.001) with a mean area under the curve survival of treated RBCs of 83% of untreated controls. End-of-storage hemolysis in the Mirasol group was 0.22 ± 0.1% (control, 0.15 ± 0.1%; p < 0.001). No neoantigenicity or differences in TEAEs were found.

CONCLUSION

RBCs derived from Mirasol WB and stored for up to 21 days in AS-3 maintained acceptable cell quality and recovery, albeit modestly reduced compared with untreated RBCs. Mirasol WB may represent a valid single WB PR platform that allows manufacture of RBC for storage for up to 21 days.

MPLEx: a method for simultaneous pathogen inactivation and extraction of samples for multi-omics profiling

The continued emergence and spread of infectious agents is of great concern, and systems biology approaches to infectious disease research can advance our understanding of host-pathogen relationships and facilitate the development of new therapies and vaccines. Molecular characterization of infectious samples outside of appropriate biosafety containment can take place only subsequent to pathogen inactivation. Herein, we describe a modified Folch extraction using chloroform/methanol that facilitates the molecular characterization of infectious samples by enabling simultaneous pathogen inactivation and extraction of proteins, metabolites, and lipids for subsequent mass spectrometry-based multi-omics measurements. This single-sample metabolite, protein and lipid extraction (MPLEx) method resulted in complete inactivation of clinically important bacterial and viral pathogens with exposed lipid membranes, including Yersinia pestis, Salmonella Typhimurium, and Campylobacter jejuni in pure culture, and Yersinia pestis, Campylobacter jejuni, and West Nile, MERS-CoV, Ebola, and influenza H7N9 viruses in infection studies. In addition, >99% inactivation, which increased with solvent exposure time, was also observed for pathogens without exposed lipid membranes including community-associated methicillin-resistant Staphylococcus aureus, Clostridium difficile spores and vegetative cells, and adenovirus type 5. The overall pipeline of inactivation and subsequent proteomic, metabolomic, and lipidomic analyses was evaluated using a human epithelial lung cell line infected with wild-type and mutant influenza H7N9 viruses, thereby demonstrating that MPLEx yields biomaterial of sufficient quality for subsequent multi-omics analyses. Based on these experimental results, we believe that MPLEx will facilitate systems biology studies of infectious samples by enabling simultaneous pathogen inactivation and multi-omics measurements from a single specimen with high success for pathogens with exposed lipid membranes.

The Interface between Immunotransfusion and Hemostasis and Thrombosis Testing

Increasing evidence supports the existence of a close relationship between immunotransfusion, hemostasis, and thrombosis. The best example of such linkage is given by the influence of the ABO blood group antigens on von Willebrand factor (VWF) plasma levels and activity. It is well known, for instance, that individuals with non-O blood type (i.e., A, B, and AB) have higher VWF and factor VIII plasma levels than O blood type subjects and are consequently exposed to an increased thrombotic risk. There is also a close relationship between immunotransfusion, hemostasis, and thrombosis testing. The first part of this narrative review is dedicated to the issue of the relationship between immunotransfusion, hemostasis, and thrombosis, while the second part is focused on the relationship between immunotransfusion and hemostasis and thrombosis testing, as well as the effects on hemostasis of the transfusion of blood components (i.e., red blood cells, platelet concentrates, and fresh frozen plasma) and plasma-derived products.

A New Proof of Concept in Bacterial Reduction: Antimicrobial Action of Violet-Blue Light (405 nm) in Ex Vivo Stored Plasma

Bacterial contamination of injectable stored biological fluids such as blood plasma and platelet concentrates preserved in plasma at room temperature is a major health risk. Current pathogen reduction technologies (PRT) rely on the use of chemicals and/or ultraviolet light, which affects product quality and can be associated with adverse events in recipients. 405 nm violet-blue light is antibacterial without the use of photosensitizers and can be applied at levels safe for human exposure, making it of potential interest for decontamination of biological fluids such as plasma. As a pilot study to test whether 405 nm light is capable of inactivating bacteria in biological fluids, rabbit plasma and human plasma were seeded with bacteria and treated with a 405 nm light emitting diode (LED) exposure system (patent pending). Inactivation was achieved in all tested samples, ranging from low volumes to prebagged plasma. 99.9% reduction of low density bacterial populations (≤10³ CFU mL⁻¹), selected to represent typical “natural” contamination levels, was achieved using doses of 144 Jcm⁻². The penetrability of 405 nm light, permitting decontamination of prebagged plasma, and the nonrequirement for photosensitizing agents provide a new proof of concept in bacterial reduction in biological fluids, especially injectable fluids relevant to transfusion medicine.

Comprehensive US government program for dried plasma development

Transfusion of plasma early after severe injury has been associated with improved survival. There are significant logistic factors that limit the ability to deliver plasma where needed in austere environments, such as the battlefield or during a significant civilian emergency. While some countries have access to more logistically supportable dried plasma, there is no such product approved for use in the United States. There is a clear need for a Food and Drug Administration (FDA)‐approved dried plasma for military and emergency‐preparedness uses, as well as for civilian use in remote or austere settings. The Department of Defense (DoD) and Biomedical Advanced Research and Development Authority are sponsoring development of three dried plasma products, incorporating different technologic approaches and business models. At the same time, the DoD is sponsoring prospective, randomized clinical studies on the prehospital use of plasma. These efforts are part of a coordinated program to provide a dried plasma for military and civilian applications and to produce additional information on plasma use so that, by the time we have an FDA‐approved dried plasma, we will better understand how to use it.