Magnetite particles triggering a faster and more robust syntrophic pathway of methanogenic propionate degradation

Efficient nitrate removal via microorganism-iron oxide co-evolution on biocathode surface

Sediment microbial fuel cell (SMFC) is a device for biological denitrification, in which electrons produced by sediment microorganisms can be transferred to the upper layer of the water column lacking electron donors. However, the low efficiency of denitrifying bacteria in acquiring electrons and enriching at the cathode greatly hinders the application of SMFC for nitrogen removal. In this study, we report a novel method of constructing a high-performance biocathode by modifying electrodes with zero-valent iron to enhance the enrichment and electron transfer of electroactive bacteria. The surface chemical and biological analysis of the biocathode revealed that the ZVI gradually oxidized to form magnetite and goethite, and finally stabilized into better crystallized lepidocrocite. On the other hand, the microbial community of the biocathode gradually evolved into a community dominated by denitrifying bacteria, specifically Clostridium. The co-evolved "Clostridium-lepidocrocite" composite endows the sediment microbial fuel cell with a 99% nitrate removal capacity. These results indicate that the cathode constructed by using ZVI modified electrode achieves efficient nitrate reduction by denitrifying bacteria. Furthermore, the construction method of biocathode may also have the potential application in water remediation and the geochemical cycling of elements.

Enhanced methanogenesis of wastewater anaerobic digestion by nanoscale zero-valent iron: Mechanism on intracellular energy conservation and amino acid metabolism

Nanoscale zero-valent iron (nZVI)-mediated anaerobic digestion commonly focuses on electron transfer between syntrophic bacteria, neglecting intracellular energy conservation strategies and amino acid metabolism. In this study, F420H2 dehydrogenase abundance increased by 5.1 %, 27.0 %, and 31.5 % at 10 mM, mM， 30 mM, and 50 mM nZVI dosing, respectively, enabling an efficient transmembrane proton-coupled electron transfer mode. Electron bifurcation (EB) enzymes involved in methanogenesis responded differently to nZVI, with HdrA2B2C2 initially increasing at 10 mM and decreasing at 30 mM and 50 mM, while MvhADG-HdrABC was completely down-regulated. Metabolomics further demonstrated that nZVI reduced riboflavin and flavin mononucleotide content, which is detrimental to the EB. Instead, an alternative measure to maintain electron flow and energy conservation under high nZVI exposure is high expression of ndh and F-type or V/A-type ATPase genes. Additionally, enhancing C1-unit carrier expression through amino acid metabolism regulation emerged as a key strategy. This study provides new perspectives on nZVI-mediated anaerobic digestion.

Microbial interactions with magnetite enhance methane production from hydrocarbon biodegradation

Indigenous microbial communities in fine tailings (FT) biodegrade residual diluent hydrocarbons and support CH4 emissions from oil sands tailings ponds and end-pit lakes. We investigated the effect of added crystalline Fe mineral magnetite on microbial metabolism of hydrocarbons in FT collected from methanogenically less and more active sites of an end-pit lake. Magnetite accelerated CH4 production by enhancing the biodegradation of hydrocarbons, with a more prominent effect on complex/relatively recalcitrant aliphatics (C8-C11 compounds) and monoaromatics. Interestingly, 86-92 % of total magnetite added in FT remained stable even after the metabolism of labile hydrocarbons (∼45 % of total diluent hydrocarbons). This may be due to magnetite enabling mineralogical direct interspecies electron transfer (mDIET) rather than iron reduction to enhance the methanogenic biodegradation of hydrocarbons. Enrichment of Coriobacteriaceae along with Desulfosporosinus, Syntrophus, Peptococcaceae, Smithella, Methanosaeta, and Methanoregula in magnetite-supplemented FT during hydrocarbon biodegradation suggested their potential role in developing mDIET. These results suggest that magnetite, when present, accelerates methanogenesis and potentially may increase rather than suppress CH4 emissions from FT, and also suggest the potential use of magnetite to accelerate bioremediation of other hydrocarbon-contaminated anaerobic environments.

Alleviation of propionic acid inhibition and enhancement of methane production in anaerobic digestion by micronano-bubble water supplementation

Micronano-bubble water (MNBW) was used to accelerate propionic acid (HPr) degradation and enhance methane production in anaerobic digestion (AD) in this study. Results showed that HPr degradation was accelerated by MNBW addition. Moreover, methane production was elevated by 13.5% to 18.4% under HPr inhibition by MNBW supplementation. Microbial analysis revealed that MNBW boosted the bacterial populations involved in protein and carbohydrate consumption. In addition, supplementation with MNBW improved the tolerance of archaea such as Methanosaetaceae to HPr inhibition, thus increasing methane production. MNBW also promoted alkalinity recovery, lowered intermediate alkalinity/partial alkalinity and volatile fatty acid/total alkalinity ratios, and enhanced buffering capacity. Enzyme activity increased by MNBW, including a 21.0% increase in coenzyme F420 and a 7.0% to 13.8% increase in extracellular hydrolase activity. This work highlights that MNBW is a promising approach to accelerate HPr degradation, optimize methanogenic pathways, and boost methane production.

Synergistic effect of Alnus glutinosa saplings and rhizosphere microorganisms on organochlorine pesticides remediation in contaminated soil

The widespread use of hexachlorocyclohexanes (HCH) as pesticides has raised environmental concerns due to their persistence and toxicity. Addressing the pressing need for effective bioremediation strategies, this study explores the effects of α-, β-, δ-, and ε-HCH isomers on the growth, hormonal changes, physiological parameters and bioaccumulation in Alnus glutinosa saplings (1-year-old and 2-year-old) and bacterial communities in polluted soil. A. glutinosa saplings not only withstanded HCH exposure but also enhanced the remediation efficiency by 6.8-24.4%, suggesting an acceleration of pollutant breakdown likely mediated by root exudates positively affecting the soil microbiome. Interestingly, 1-year-old saplings demonstrated greater remediation efficiency post-pruning than unpruned 2-year-old saplings, despite the latter having a larger root biomass. The hormonal analysis indicated that HCH presence led to a reduction in abscisic acid (ABA) and an increase in jasmonic acid (JA), with the magnitude of changes being age-dependent. Salicylic acid (SA) levels increased 1-year-old and decreased in 2-year-old saplings under HCH stress. Moreover, a higher presence of lin-degrading genes in the rhizosphere of treated saplings compared to controls confirmed ongoing biodegradation processes. The outcomes help to better understand the processes involved in degradation of persistent pesticides in soil. The mechanism of in-plant isomerization and the identification of metabolites should be the focus of future research.

Anaerobic sludge digestion enhancement with bioelectrochemical and electrically conductive materials augmentation: A state of the art review

Excess biological sludge processing and disposal have a significant impact on the energy balance and economics of wastewater treatment operations, and on receiving environments. Anaerobic digestion is probably the most widespread in-plant sludge processing method globally, since it stabilizes and converts biosolids organic matter into biogas, allowing partial recovery of their embedded chemical energy. A considerable number of studies concerning applicable techniques to improve biogas production, both in quantity and quality, include pre-treatment strategies to promote biosolids disintegration aimed at the release and solubilization of intracellular energy compounds, inorganic/biological amendments aimed at improving process performance, and sludge thermal pre-treatment. As for in-process amendments, iron, micro and macro-nutrients, ashes from waste incineration and nanoparticles addition have been studied for the improvement of enzymatic reactions. Recently, use of electrically conductive materials has been credited with the possibility to accelerate and stabilize the conversion of organic substrates to methane. The possibility of increasing both biogas generation and its relative biomethane content by interfacing anaerobic digestion with bioelectrochemical systems was also postulated. This review addresses the research gap surrounding the integration of anaerobic digestion with novel technologies, particularly bioelectrochemical systems, to enhance biogas production and methane enrichment. While existing studies focus on pre-treatment and in-process amendments, the feasibility, mechanisms, and benefits of such integration remain underexplored. By critically evaluating the current state of the art, this review identifies the potential of bioelectrochemical integration to improve energy recovery and process stability, while highlighting key challenges and research needs for advancing these technologies toward practical implementation.

Advances and insights into modeling extracellular electron transfer in anaerobic bioprocesses

Extracellular electron transfer (EET) plays an important role in maintaining redox balance in both natural and engineered anaerobic microbial systems, driving key biochemical processes such as energy generation, bioremediation, and waste degradation. While EET has been characterized in a limited number of microbes and applied in anaerobic digestion and bioelectrochemical systems, further research is needed to explore its mechanism across a broader range of microbial species and anaerobic processes. This review highlights advanced modeling frameworks that provide deeper insights into EET mechanisms and dynamics, aiming to optimize research efforts and minimize time and resource expenditure. Mechanistic models, encompassing thermodynamics and kinetics, are discussed for their utility in calculating conduction rates of electroactive microbes and assessing the energetics of medium chain carboxylic acids production. Genome-scale metabolic models are highlighted for elucidating the roles of cytochromes and conductive pili in the EET pathway. Machine learning is presented as a tool to improve model accuracy and predict EET mechanisms. Furthermore, the integration of quantum mechanics/molecular mechanics methods offers molecular-level insights into electron transfer, while quantum computing addresses limitations of classical computers by simulating complex electron transfer processes in multi-heme cytochromes. Developing advanced modeling techniques will complement experimental techniques, enabling precise predictions and optimization strategies for developing innovative and sustainable anaerobic biotechnologies.

Unraveling the Trade-Off Effect of Pyrogenic Carbons Between Biopseudocapacitors and Bioconductors During Anaerobic Methanogenesis

Pyrogenic carbons (PCs), with varying structures depending on the materials and thermal treatment conditions, have been extensively used to enhance anaerobic digestion by mediating electron transfer. However, the underlying mechanism has yet to be explored. Herein, the redirection and enhancement of the direct interspecies electron transfer (DIET) pathway were evidenced, along with the upregulated electrochemical properties and structural proteins in the methanogenic consortia. Further, we found that PCs featured trade-off properties of "biopseudocapacitor" and "bioconductor" during thermal treatment, as endowed by the evolution of oxygen-containing functional groups (for charging and discharging) and graphitic structure (for conductivity). Correspondingly, their trade-off effect on mediating syntrophic methanogenesis (SM) was realized between the generally acknowledged bioconductor role and the pseudocapacitive effect, as highlighted by the enhanced SM of reduced PCs from more balanced electron exchange capacities. Consequently, a performance comparison of PCs obtained at 450, 650, and 850 °C in SM resulted in an optimized sample at 650 °C, where a 61.3 ± 1.8% increase in methane production rate and a 33.4 ± 1.1% decrease in lag time were observed. Microbiologically, DIET-active Methanothrix and Geobacteraceae flourished with the intra- and extracellular electron transport channels established. These findings provide new insights into the mediating mechanism and renewable potential of PCs in regulating energy-harvesting biochemical processes toward carbon neutrality.

Elevated CO2 and goethite inhibited anaerobic oxidation of methane in paddy soils

Microbially mediated anaerobic oxidation of methane (AOM) regulates methane (CH4) fluxes. Increases in the global atmospheric carbon dioxide (CO2) concentration and iron oxide rich in paddy soils influence AOM. However, the response and mechanisms between these two processes and AOM remain unclear. Here, we investigated the coupling of elevated atmospheric CO2 concentrations (ambient CO2 + 200 ppm) and goethite with AOM via 13CH4 isotope tracer techniques and explored the dynamics of bacterial and archaeal communities by high-throughput sequencing. The coupling of 13CH4 with electron acceptors generates 13CO2, and its enrichment was used to evaluate CH4 oxidation. The results showed that elevated atmospheric CO2 and the addition of goethite resulted in a significant decrease of 13CO2 value produced from 13CH4 oxidation, thereby inhibiting CH4 oxidation. In addition, both elevated atmospheric CO2 and goethite addition increased the Richness, Shannon, and ACE indices of bacteria to varying degrees, whereas the diversity of archaea exhibited the opposite pattern. Additionally, the microbial community composition was significantly altered. Overall, the negative response of elevated atmospheric CO2 and goethite to AOM may guide CH4 emissions reduction from paddy soils under global warming and climate change, as well as the formulation of environmental policies such as carbon budgets for farmland.

Unlocking anaerobic digestion potential via extracellular electron transfer by exogenous materials: Current status and perspectives

The efficiency of energy transfer among microorganisms presents a substantial hurdle for the widespread implementation of anaerobic digestion techniques. Nonetheless, recent studies have demonstrated that enhancing the extracellular electron transfer (EET) can markedly enhance this efficiency. This review highlights recent advancements in EET for anaerobic digestion and examines the contribution of external additives to fostering enhanced efficiency within this context. Diverse mechanisms through which additives are employed to improve EET in anaerobic environments are delineated. Furthermore, specific strategies for effectively regulating EET are proposed, aiming to augment methane production from anaerobic digestion. This review thus offers a perspective on future research directions aimed at optimizing waste resources, enhancing methane production efficiency, and improving process predictability in anaerobic digestion.

Groundwater electro-bioremediation via diffuse electro-conductive zones: A critical review

Microbial electrochemical technologies (MET) can remove a variety of organic and inorganic pollutants from contaminated groundwater. However, despite significant laboratory-scale successes over the past decade, field-scale applications remain limited. We hypothesize that enhancing the electrochemical conductivity of the soil surrounding electrodes could be a groundbreaking and cost-effective alternative to deploying numerous high-surface-area electrodes in short distances. This could be achieved by injecting environmentally safe iron- or carbon-based conductive (nano)particles into the aquifer. Upon transport and deposition onto soil grains, these particles create an electrically conductive zone that can be exploited to control and fine-tune the delivery of electron donors or acceptors over large distances, thereby driving the process more efficiently. Beyond extending the radius of influence of electrodes, these diffuse electro-conductive zones (DECZ) could also promote the development of syntrophic anaerobic communities that degrade contaminants via direct interspecies electron transfer (DIET). In this review, we present the state-of-the-art in applying conductive materials for MET and DIET-based applications. We also provide a comprehensive overview of the physicochemical properties of candidate electrochemically conductive materials and related injection strategies suitable for field-scale implementation. Finally, we illustrate and critically discuss current and prospective electrochemical and geophysical methods for measuring soil electronic conductivity-both in the laboratory and in the field-before and after injection practices, which are crucial for determining the extent of DECZ. This review article provides critical information for a robust design and in situ implementation of groundwater electro-bioremediation processes.

Fast preparing bioelectrode with conductive bioink for nitrite detection in high sensitivity and stability

Electrochemically active biofilms (EABs) for nitrite detection have high specificity, rapid response, operational simplicity, and extended lifespan advantages. However, their scale production remains challenging due to time-consuming and uniform preparation. In this study, a novel approach was proposed to fast fabricate an EAB biosensor with a synthetic biofilm electrode for nitrite detection. The biofilm electrode was prepared by coating bioinks with varying conductive materials onto the surface of the graphite sheets, showing short incubation time and good reproducibility. Incorporating conductive materials into the bioinks remarkably enhanced the maximum voltage of the first cycle of bioelectrode incubation, with an increase of up to 633% for carbon nanofibers. The nitrite reduction current was amplified by a factor of 2.97, due to the enhancement of extracellular electron transfer (EET). The developed nitrite biosensor exhibited a detection range of 0.1-15 mg NO2--N L-1, with a high sensitivity of 610.8 μA mM-1 cm-2, and a stabilization operation time of at least 280 cycles. This study not only provided valuable insights into conductive materials for synthetic biofilms but also presented a practical approach for the rapid preparation, scale production, and optimization of highly sensitive and stable EAB sensors.

Crystalline iron oxide mineral (magnetite) accelerates methane production from petroleum hydrocarbon biodegradation

Methane (CH4) emissions are a factor in climate change; in addition, CH4 production may affect reclamation of fluid fine tailings (FFT) in tailings ponds, and end-pit lakes (EPLs). In laboratory cultures, we investigated the effect of crystalline iron mineral (magnetite) on CH4 production from the biodegradation of hydrocarbons added to FFT collected from methanogenically more and less active sites in a demonstration EPL. Magnetite enhanced CH4 production from both sites, having a greater effect in more active FFT, where it increased the CH4 production rate as much as 48% (from 6.67 μmol d-1 to 9.87 μmol d-1) compared to FFT without magnetite. Correspondingly, magnetite hastened biodegradation of hydrocarbons (monoaromatics, n-alkanes and iso-alkanes), with a pronounced effect on o-xylene, ethylbenzene, m/p-xylenes, n-octane, n-nonane, and 2-methyloctane, where biodegradation rates increased by 46, 117, 11, 45, 28 and 37%, respectively, compared to FFT without magnetite. Little FeII was produced, suggesting that magnetite is not being used as an electron acceptor but rather functions as a conduit for electron transfer. Thus, magnetite may be a suitable amendment to enhance bioremediation of anaerobic environments contaminated with hydrocarbons. Importantly, our observations imply that magnetite may increase CH4 emissions from terrestrial ecosystems, thus affecting carbon budget estimations.

Long-term and multiscale assessment of methanogenesis enhancement mechanisms in magnetite nanoparticle-mediated anaerobic digestion reactor

Magnetite nanoparticles (Fe3O4-NPs) have been demonstrated to be involved in direct interspecies electron transfer between syntrophic bacteria, yet a comprehensive assessment of the ability of Fe3O4-NPs to cope with process instability and volatile fatty acids (VFAs) accumulation in scaled-up anaerobic reactors is still lacking. Here, we investigated the start-up characteristics of an expanded granular sludge bed (EGSB) with Fe3O4-NPs as an adjuvant at high organic loading rate (OLR). The results showed that the methane production rate of R1 (with Fe3O4-NPs) was approximately 1.65 folds of R0 (control), and effluent COD removal efficiency was maintained at approximately 98.32% upon 20 kg COD/(m3·d) OLR. The components of volatile fatty acids are acetate and propionate, and the rapid scavenging of propionate accumulation was the difference between R1 and the control. The INT-ETS activity of R1 was consistently higher than that of R0 and R2, and the electron transfer efficiencies increased by 68.78% and 131.44%, respectively. Meanwhile, the CV curve analysis showed that the current of R1 was 40% higher than R3 (temporary addition of Fe3O4-NPs), indicating that multiple electron transfer modes might coexist. High-throughput analysis further revealed that it was difficult to reverse the progressive deterioration of system performance with increasing OLR by simply reconfiguring bacterial community structure and abundance, demonstrating that the Fe3O4-NPs-mediated DIET pathway is a prerequisite for establishing multiple electron transfer systems. This study provides a long-term and multi-scale assessment of the gaining effect of Fe3O4-NPs in anaerobic digestion scale-up devices, and provides technical support for their practical engineering applications.

Syntrophic propionate degradation in anaerobic digestion facilitated by hydrochar: Microbial insights as revealed by genome-centric metatranscriptomics

Propionate is a model substrate for studying energy-limited syntrophic communities in anaerobic digestion, and syntrophic bacteria usually catalyze its degradation in syntrophy with methanogens. In the present study, metagenomics and metatranscriptomics were used to study the effect of the supportive material (e.g., hydrochar) on the key members of propionate degradation and their cooperation mechanism. The results showed that hydrochar increased the methane production rate (up to 57.1%) from propionate. The general transcriptional behavior of the microbiome showed that both interspecies H2 transfer (IHT) and direct interspecies electron transfer (DIET) played essential roles in the hydrochar-mediated methanation of propionate. Five highly active syntrophic propionate-oxidizing bacteria were identified by genome-centric metatranscriptomics. H85pel, a member of the family Pelotomaculaceae, was specifically enriched by hydrochar. Hydrochar enhanced the expression of the flagellum subunit, which interacted with methanogens and hydrogenases in H85pel, indicating that IHT was one of the essential factors promoting propionate degradation. Hydrochar also enriched H162tha belonging to the genus of Thauera. Hydrochar induced the expression of genes related to the complete propionate oxidation pathway, which did not produce acetate. Hydrochar and e-pili-mediated DIET were enhanced, which was another factor promoting propionate degradation. These findings improved the understanding of metabolic traits and cooperation between syntrophic propionate oxidizing bacteria (SPOB) and co-metabolizing partners and provided comprehensive transcriptional insights on function in propionate methanogenic systems.

Enhancement of anaerobic treatment of antibiotic pharmaceutical wastewater through the development of iron-based and carbon-based materials: A critical review

The extensive use of antibiotics has created an urgent need to address antibiotic wastewater treatment, posing significant challenges for environmental protection and public health. Recent advances in the efficacy and mechanisms of conductive materials (CMs) for enhancing the anaerobic biological treatment of antibiotic pharmaceutical wastewater are reviewed. For the first time, the focus is on the various application forms of iron-based and carbon-based CMs in strengthening the anaerobic methanogenic system. This includes the use of single CMs such as zero-valent iron (ZVI), magnetite, biochar (BC), activated carbon (AC), and graphene (GP), as well as iron-based and carbon-based composite CMs with diverse structures. These structures include mixed, surface-loaded, and core-shell combinations, reflecting the development of CMs. Iron-based and carbon-based CMs promote the rapid removal of antibiotics through adsorption and enhanced biodegradation. They also mitigate the inhibitory effects of toxic pollutants on microbial activity and reduce the expression of antibiotic resistance genes (ARGs). Additionally, as effective electron carriers, these CMs enrich microorganisms with direct interspecies electron transfer (DIET) functions, accelerate interspecies electron transfer, and facilitate the conversion of organic matter into methane. Finally, this review proposes the use of advanced molecular detection technologies to clarify microbial ecology and metabolic mechanisms, along with microscopic characterization techniques for the modification of CMs. These methods can provide more direct evidence to analyze the mechanisms underlying the cooperative anaerobic treatment of refractory organic wastewater by CMs and microorganisms.

The effect of Fenton sludge on anaerobic digestion of papermaking wastewater in an upflow anaerobic sludge blanket reactor

An upflow anaerobic sludge blanket (UASB) reactor was used to investigate the effect of adding Fenton sludge (FS) on the anaerobic digestion of actual papermaking wastewater. The results showed that a one-time addition of 10 g/L FS could sustainably promote the performance of UASB for more than 40 days. The organic matter removal efficiency increased by 15.56%, and the biogas production increased by 24.52%. The proportion of methane in biogas increased by 12.87%. Adding FS increased the capacitance values of sludge extracellular polymeric substances and the electron transfer system activity in reactor increased by 1.76 times. The dehydrogenase activity and coenzyme F420 of the sludge increased by 1.54 and 2.11 times, respectively. Adding FS enriched the iron-reducing bacteria (Thermodesulfobacteriota) and hydrolytic acid-producing bacteria (Chloroflexota and Synergistota), thereby promoting the hydrolysis and acidification process. Adding FS was beneficial to the enrichment of methanogen, especially Methanosaeta, significantly increasing the methane production.

The enhancement effect of n-Fe3O4 on methyl orange reduction by nitrogen-fixing bacteria consortium

Although the anaerobic reduction of azo dyes is ecofriendly, high ammonia consumption remains a significant challenge. This work enriched a mixed nitrogen-fixing bacteria consortium (NFBC) using n-Fe3O4 to promote the anaerobic reduction of methyl orange (MO) without exogenous nitrogen. The enriched NFBC was dominated by Klebsiella (80.77 %) and Clostridium (17.16 %), and achieved a 92.7 % reduction of MO with an initial concentration of 25 mg·L-1. Compared with the control, the consortium increased the reduction efficiency of MO, cytochrome c content, and electron transport system (ETS) activity by 11.86 %, 89.86 %, and 58.49 %, respectively. When using 2.5 g·L-1 n-Fe3O4, the extracellular polymeric substances (EPS) of NFBC were present in a concentration of 85.35 mg·g-1. The specific reduction rates of MO by NFBC were 2.26 and 3.30 times faster than those of Fe(II) and Fe(III), respectively, while the enrichment factor of the ribosome pathway in NFBC exceeded 0.75. Transcriptome, carbon consumption, and EPS analyses suggested that n-Fe3O4 stimulated carbon metabolism and secreted protein synthesized by the mixed culture. The latter occurred due to the increased activity of consortium and the content of redox substances. These findings demonstrate that n-Fe3O4 promoted the efficiency of mixed nitrogen-fixing bacteria for removing azo dyes from wastewater. This innovative approach highlights the potential of integrating nanomaterials with biological systems to effectively address complex pollution challenges.

Uncovering the mechanisms of ethanol stimulation on magnetite-enhanced anaerobic process treating oxytetracycline contained wastewater

Magnetite has been proved to facilitate direct interspecies electron transfer (DIET)-based syntrophys and might alleviate inhibitory effects of antibiotics in anaerobic digestion (AD), while feeding ethanol was an effective approach to enrich the DIET partners. However, most of the existing studies were conducted at fixed ethanol concentration, few attentions were paid on the effects of differential ethanol proportion on AD, the underlying roles and mechanisms of ethanol stimulation remains unclear. This study systematically investigated the impact of ethanol stimulation on anaerobic processes treating oxytetracycline (OTC)-contaminated wastewater at varying proportions (20%, 50%, and 80%, based on equivalent COD value). In the presence of magnetite, ethanol stimulation promoted the methane production from 244.9 mL/g COD to a maximum 434.2 mL/g COD, with the most pronounced enhancement observed at high ethanol proportions. In particular, the average methane production obtained at 50% and 80% ethanol was 328.5 and 297.7 mL/g COD, respectively, whereas the enhancement of 20% ethanol stimulation was relatively limited. Concurrently, more stable COD removal and OTC reduction was noted in the existence of both magnetite and high ethanol proportions. Microbial analysis revealed the pivotal roles of Methanosaeta, alongside the predominance of Methanobacterium, in regulating COD conversion and driving methanogenesis through the CO2 reduction pathway. Notably, high ethanol proportions fostered the enrichment of exoelectrogens (Geobacter, Desulfovibrio) in the magnetite-amended system, accompanied by the up-regulation of genes involved in organic metabolism pathways. Further investigation of functional genes highlighted the prevalence of pilA enrichment in the magnetite-amended system at low ethanol proportions, whereas omcS became more abundant at high ethanol proportions.

Ethanol-type anaerobic digestion enhanced methanogenic performance by stimulating direct interspecies electron transfer and interspecies hydrogen transfer

Ethanol pre-fermentation of food waste effectively alleviates acidification; however, its effects on interspecies electron transfer remain unknown. This study configured the feed according to COD ratios of ethanol: sodium acetate: sodium propionate: sodium butyrate of 5:2:1.5:1.5 (ethanol-type anaerobic digestion) and 0:5:2.5:2.5 (control), and conducted semi-continuous anaerobic digestion (AD) experiments. The results showed that ethanol-type AD increased maximum tolerable organic loading rate (OLR) to 6.0 gCOD/L/d, and increased the methane production by 1.2-14.8 times compared to the control at OLRs of 1.0-5.0 gCOD/L/d. The abundance of the pilA gene, which was associated with direct interspecies electron transfer (DIET), increased by 5.6 times during ethanol-type AD. Hydrogenase genes related to interspecies hydrogen transfer (IHT), including hydA-B, hoxH-Y, hnd, ech, and ehb, were upregulated during ethanol-type AD. Ethanol-type AD improved methanogenic performance and enhanced microbial metabolism by stimulating DIET and IHT.

Neglected role of iron redox cycle in direct interspecies electron transfer in anaerobic methanogenesis: Inspired from biogeochemical processes

Anaerobic digestion is an indispensable technical option towards green and low-carbon wastewater treatment, with interspecies electron transfer (IET) playing a key role in its efficiency and operational stability. The exogenous semiconductive iron oxides have been proven to effectively enhance IET, while the cognition of the physicochemical-biochemical coupling stimulatory mechanism was circumscribed and remains to be elucidated. In this study, semiconductive iron oxides, α-Fe2O3, γ-Fe2O3, α-FeOOH, and γ-FeOOH were found to significantly enhance syntrophic methanogenesis by 76.39, 72.40, 37.33, and 32.64% through redirecting the dominant IET pathway from classical interspecies hydrogen transfer to robust direct interspecies electron transfer (DIET). Their alternative roles as electron shuttles potentially substituting for c-type cytochromes were conjectured to establish an electron transport matrix associated with conductive pili. Distinguished from the conventional electron conductor mechanism of conductive Fe3O4, semiconductive iron oxides facilitated DIET intrinsically through the capacitive Fe(III/II) redox cycles coupled with secondary mineralization. The growth of Aminobacterium, Sedimentibacter, and Methanothrix was enriched and the gene copy numbers of Geobacteraceae 16S ribosomal ribonucleic acid were selectively flourished by 2.0-∼4.5- fold to establish a favorable microflora for DIET pathway. Metabolic pathways of syntrophic acetogenesis from propionate/butyrate and CO2 reduction methanogenesis were correspondingly promoted. The above findings provide new insights into the underlying mechanism of iron minerals enhancing the DIET-oriented pathway and offer paradigms for redox-mediated energy harvesting biological wastewater treatment.

Magnetic porous microspheres altering interfacial thermodynamics of sewage sludge to drive metabolic cooperation for efficient methanogenesis

Controllable and recyclable magnetic porous microspheres (MPMs) have been proposed as a means for enhancing the anaerobic digestion (AD) of sludge, as they do not require continuous replenishment and can serve as carriers for anaerobes. However, the effects of MPMs on the interfacial thermodynamics of sludge and the biological responses triggered by abiotic effects in AD systems remain to be clarified. Herein, the underlying mechanisms by which MPMs alter the solid-liquid interface of sludge to drive methanogenesis were investigated. A significant increase in the contents of 13C and 2H (D) in methane molecules was observed in the presence of MPMs, suggesting that MPMs might enhance the CO2-reduction methanogenesis and participation of water in methane generation. Experimental results demonstrated that the addition of MPMs did not promote the anaerobic bioconversion of soluble organics for methanogenesis, suggesting that the enhanced methanogenesis and water participation were not achieved through promotion of the bioconversion of original liquid-state organics in sludge. Analyses of the capillary force, surface adhesion force, and interfacial proton-coupled electron transfer (PCET) of MPMs revealed that MPMs can enhance mass transfer, effective contact, and electron-proton transfer with sludge. These outcomes were confirmed by the statistical analyses of variations in the interfacial thermodynamics and PCET of sludge with and without MPMs during AD. It was thus proposed that the MPMs enhanced the PCET of sludge and PCET-driven release of protons from water by promoting the interfacial Lewis acid-base interactions of sludge, thereby resulting in the enrichment of free and attached methanogenic consortia and the high energy-conserving metabolic cooperation. This proposition was further confirmed by identifying the predominant syntrophic partners, suggesting that PCET-based efficient methanogenesis was attributable to the enrichment of genomes harbouring CO2-reducing pathway and genes encoding water-mediated proton transfer. These findings offer new insights into how substrate properties can be altered by exogenous materials to enable highly efficient methanogenesis.

Impact of additives on syntrophic propionate and acetate enrichments under high-ammonia conditions

High ammonia concentrations in anaerobic degradation systems cause volatile fatty acid accumulation and reduced methane yield, which often derive from restricted activity of syntrophic acid-oxidising bacteria and hydrogenotrophic methanogens. Inclusion of additives that facilitate the electron transfer or increase cell proximity of syntrophic species by flocculation can be a suitable strategy to counteract these problems, but its actual impact on syntrophic interactions has yet to be determined. In this study, microbial cultivation and molecular and microscopic analysis were performed to evaluate the impact of conductive (graphene, iron oxide) and non-conductive (zeolite) additives on the degradation rate of acetate and propionate to methane by highly enriched ammonia-tolerant syntrophic cultures derived from a biogas process. All additives had a low impact on the lag phase but resulted in a higher rate of acetate (except graphene) and propionate degradation. The syntrophic bacteria 'Candidatus Syntrophopropionicum ammoniitolerans', Syntrophaceticus schinkii and a novel hydrogenotrophic methanogen were found in higher relative abundance and higher gene copy numbers in flocculating communities than in planktonic communities in the cultures, indicating benefits to syntrophs of living in close proximity to their cooperating partner. Microscopy and element analysis showed precipitation of phosphates and biofilm formation in all batches except on the graphene batches, possibly enhancing the rate of acetate and propionate degradation. Overall, the concordance of responses observed in both acetate- and propionate-fed cultures highlight the suitability of the addition of iron oxide or zeolites to enhance acid conversion to methane in high-ammonia biogas processes. KEY POINTS: • All additives promoted acetate (except graphene) and propionate degradation. • A preference for floc formation by ammonia-tolerant syntrophs was revealed. • Microbes colonised the surfaces of iron oxide and zeolite, but not graphene.

Roles of quorum-sensing molecules in methane production from anaerobic digestion aided by biochar

Biochar has been used to enhance methane generation from anaerobic digestion through establishing direct interspecific electron transfer between microorganisms. However, the microbial communication is still inadequate, thereby limiting further methane production improvement contributed by biochar. This study investigated the roles of quorum-sensing molecules, acylated homoserine lactone (AHL), in anaerobic digestion of waste activated sludge aided by biochar. Results showed that the co-addition of separated biochar and AHL achieved best methane production performance, with the maximal methane yield of 154.7 mL/g volatile suspended solids, which increased by 51.9%, 47.2%, 17.9%, and 39.4% respectively compared to that of control, AHL-loaded biochar, sole AHL, and sole biochar groups. The reason was that the co-addition of separated biochar and AHL promoted the stages of hydrolysis and acidification, promoting the conversion of organic matters and short-chain fatty acids, and optimizing the accumulation of acetate acid. Moreover, the methanogenesis stage also performed best among experimental groups. Correspondingly, the highest activities of electron transfer and coenzyme F420 were obtained, with increase ratios of 33.2% and 27.2% respectively compared to that of control. Furthermore, biochar did more significant effects on the evolution of microbial communities than AHL, and the direct interspecific electron transfer between fermentative bacteria and methanogens were possibly promoted.

Heterogeneous g-C3N4/polyaniline composites enhanced the conversion of organics into methane during anaerobic wastewater treatment

In this study, g-C3N4/PANI was prepared by in situ oxidative polymerization. Graphite-phase carbon nitride (g-C3N4) with surface defects was deposited onto the surface of conductive polyaniline (PANI) to form a p-n heterojunction. This construction aimed to create an efficient heterogeneous catalyst, increasing the surface defect level and active sites of the composite, and augmenting its capability to capture and transfer extracellular electrons under anaerobic conditions. This addresses the challenge of low efficiency in direct interspecies electron transfer between bacteria and archaea during anaerobic digestion for methane production. The results showed that the prepared g-C3N4/PANI increased the CH4 yield and CH4 production rate by 82% and 96%, respectively. Notably, the conductivity and XPS test results showed that the ratio of g-C3N4 to PANI was 0.15, and the composite exhibited favorable conductivity, with a uniform distribution of pyrrolic nitrogen, pyridinic nitrogen, and graphitic nitrogen, each accounting for approximately 30%. Furthermore, g-C3N4/PANI effectively enhanced the metabolic efficiency of intermediate products such as acetate and butyrate. Analysis of the microbial community structure revealed that g-C3N4/PANI led to a significant increase in the abundance of hydrogenotrophic methanogen Methanolinea (from 48% to 64%) and enriched Clostridium (a rise of 1%) with direct interspecies electron transfer capability. Microbial community function analysis demonstrated that the addition of g-C3N4/PANI boosted the activities of key enzymes involved in anaerobic digestion, including phosphate transacetylase (PTA), phospho-butyryl transferase (PTB), and NAD-independent lactate dehydrogenase (NNLD), by 47%, 135%, and 153%, respectively. This acceleration in enzymatic activity promoted the metabolism of acetyl-CoA, butyryl-CoA, and pyruvate. Additionally, the function of ABC transporters was enhanced, thereby improving the efficiency of material and energy exchange among microorganisms.

Harnessing iron materials for enhanced decolorization of azo dye wastewater: A comprehensive review

Highly colored azo dye-contaminated wastewater poses significant environmental threats and requires effective treatment before discharge. The anaerobic azo dye treatment method is a cost-effective and environmentally friendly solution, while its time-consuming and inefficient processes present substantial challenges for industrial scaling. Thus, the use of iron materials presents a promising alternative. Laboratory studies have demonstrated that systems coupled with iron materials enhance the decolorization efficiency and reduce the processing time. To fully realize the potential of iron materials for anaerobic azo dye treatment, a comprehensive synthesis and evaluation based on individual-related research studies, which have not been conducted to date, are necessary. This review provides, for the first time, an extensive and detailed overview of the utilization of iron materials for azo dye treatment, with a focus on decolorization. It assesses the treatment potential, analyzes the influencing factors and their impacts, and proposes metabolic pathways to enhance anaerobic dye treatment using iron materials. The physicochemical characteristics of iron materials are also discussed to elucidate the mechanisms behind the enhanced bioreduction of azo dyes. This study further addresses the current obstacles and outlines future prospects for industrial-scale application of iron-coupled treatment systems.

Enhanced bioremediation of cyclohexaneacetic acid in offshore sediments with green synthetic iron oxide and Pseudoalteromonas sp

Naphthenic acids (NAs) have been found to exert serious threats on offshore sediment ecosystems and human health in recent years, which entails us the urgent need for NAs remediation. Bioremediation is considered an ideal method for sediment remediation due to ecological sustainability and economic feasibility. However, current bioremediation efficiency of offshore sediments suffers from relatively slow and there has never any attempts to bioremediate offshore sediment NAs contamination hitherto. In this study, the green synthetic iron oxides (gFeOx) based on Laminaria extracts was employed to enhance the biodegradation of NAs (Cyclohexylacetic acid, CHAA) in offshore sediments by Pseudoalteromonas sp. JSTW (an indigenous microorganism). The results showed that CHAA (20 mg·kg-1) in offshore sediments was removed almost 100% within 7 days at 30 mg·kg-1 gFeOx and 0.6 mg·kg-1 Strain JSTW. High-throughput sequencing results revealed that the structure and function of sediment microbial community were essentially restored to uncontaminated levels after bioremediation, highlighting the joint remediation approach is an efficient and eco-friendly method. Overall, this work has firstly provided insights into the application for NAs in situ bioremediation in offshore sediments.

Riboflavin modified carbon cloth enhances anaerobic digestion treating food waste in a pilot-scale system

Previous laboratory-scale studies have consistently shown that carbon-based conductive materials can notably improve the anaerobic digestion of food waste, typically employing reactors with regular capacity of 1-20 L. Furthermore, incorporating riboflavin-loaded conductive materials can further address the imbalance between fermentation and methanogenesis in anaerobic systems. However, there have been few reports on pilot-scale investigation. In this study, a 10 m2 of riboflavin modified carbon cloth was incorporated into a pilot-scale (2 m3) food waste anaerobic reactor to improve its treatment efficiency. The study found that the addition of riboflavin-loaded carbon cloth can increase the maximum organic loading rate (OLR) by 40% of the pilot-scale reactor, compared to the system using carbon cloth without riboflavin loading, while ensuring efficient operation of the reaction system, effectively alleviating system acidification, sustaining methanogen activity, and increasing daily methane production by 25%. Analysis of the microbial community structure revealed that riboflavin-loaded carbon cloth enriched the methanogenic archaea in the genera of Methanothrix and Methanobacterium, which are capable of extracellular direct interspecies electron transfer (DIET). And metabolic pathway analysis identified the methane production pathway, highly enriched on the reduction of acetic acid and CO2 at riboflavin-loaded carbon cloth sample. The expression levels of genes related to methane production via DIET pathway were also significantly upregulated. These results can provide important guidance for the practical application of food waste anaerobic digestion engineering.

Zero-valent iron enhanced methane production of anaerobic digestion by reinforcing microbial electron bifurcation coupled with direct inter-species electron transfer

Zero-valent iron (ZVI) can facilitate methanogens of anaerobic digestion (AD). However, the impact of ZVI on the micro-energetic strategies of AD microorganisms remains uncertain. This study aimed to elucidate the development of an energy conservation model involving direct interspecies electron transfer (DIET) and electron bifurcate (EB) by using four types of ZVI. Overall, the ZVI addition resulted in a substantial increase in methane production (1.26 to 2.18 times higher), and the effect of boron (B) doped ZVI was particularly pronounced. The underlying mechanism may be the formation of energy harvest pathway related to DIET. In detail, B-doped ZVI could enhance its interfacial binding to cytochrome c. Decreased polar solvation energy from 20.473 to 1.509 kJ/mol is beneficial for electron transfer, thereby augmenting the flavin-bounded Cytc activity and DIET process. Besides, ZVI-enhanced EB enzyme activity like HdrA2B2C2-MvhAGD could improve the EB process, which can couple with DIET for electron transfer and energy conservation. Energy analysis based on EB-coupled DIET metabolism pathways demonstrated that the ATP saved in this coupled model theoretically line in 0.25 to 0.5 mol ATP/mol substrate. Overall, this study offers valuable insights into microbial energetic strategies pertaining to the utilization of conductive materials, with the target of enhancing methane recovery efficiency from organic waste.

Unveiling the mechanisms of Fe(III)-loaded chitosan composite (CTS-Fe) in enhancing anaerobic digestion of waste activated sludge

Anaerobic digestion (AD) of waste activated sludge (WAS) is usually limited by the low generation efficiency of methane. Fe(III)-loaded chitosan composite (CTS-Fe) have been reported to effectively enhanced the digestion of WAS, but its role in promoting anaerobic sludge digestion remains unclear. In present study, the effects of CTS-Fe on the hydrolysis and methanogenesis stages of WAS anaerobic digestion were investigated. The addition of CTS-Fe increased methane production potential by 8%-23% under the tested conditions with the addition of 5-20 g/L CTS-Fe. Besides, the results demonstrate that the addition of CTS-Fe could effectively promote the hydrolysis of WAS, evidenced by lower protein or polysaccharides concentration, higher soluble organic carbon in rector adding CTS-Fe, as well as the increased activity of extracellular hydrolase with higher CTS-Fe concentration. Meanwhile, the enrichment of Clostridia abundance (iron-reducing bacteria (IRBs)) was observed in CTS-Fe adding reactor (8.9%-13.8%), which was higher than that in the control reactor (7.9%). The observation further suggesting the acceleration of hydrolysis through dissimilatory iron reduction (DIR) process, thus providing abundant substrates for methanogenesis. However, the presence of CTS-Fe was inhibited the acetoclastic and hydrogenotrophic methanogenesis process, which could be ascribed to the Fe(III) act as electron acceptor coupled to methane for anaerobic oxidation. Furthermore, coenzyme F420 activity in the CTS-Fe added reactor was 34.9% lower than in the blank, also abundance of microorganisms involved in hydrogenotrophic methanogenesis was decreased. Results from this study could provide theoretical support for the practical applications of CTS-Fe.

A bibliometric analysis of the role of nanotechnology in dark fermentative biohydrogen production

Recently, nanoparticles have drawn a lot of interest as catalysts to enhance the effectiveness and output of biohydrogen generation processes. This review article provides a comprehensive bibliometric analysis of the significance of nanotechnology in dark fermentative biohydrogen production. The study examines the scientific literature from the database of The Web of Science© while the bibliometric investigation utilized VOSviewer© and Bibliometrix software tools to conduct the analysis. The findings revealed that a total of 232 articles focused on studying dark fermentation for hydrogen production throughout the entire duration. The extracted data was used to analyze publication trends, authorship patterns, and geographic distribution along with types and effects of nanoparticles on the microbial community responsible for dark fermentative biohydrogen production. The findings of this bibliometric analysis provide valuable insights into the advancements and achievements in the utilization of nanoparticles in the dark fermentation process used to produce biohydrogen.

Elucidating carbon conversion and bacterial succession by amending Fenon-like systems during co-composting of pig manure and branch

The essential point of current study was to investigate the effect of a Fenton-like system established by oxalic acid and Fe(II) on gas emission, organic matter decomposition and humification during composting. Branches were pretreated with Fenton reagents (0.02 M FeCl2·4H2O + 1.5 M H2O2) and then adding 10 % oxalic acid (OA). The treatments were marked as B1 (control), B2 (Fenton reagent), B3 (10% OA) and B4 (Fenton-like reagent). The results collected from 80 d of composting showed that adding Fenton-like reagent benefited the degradation of organic substances, as reflected by the total organic carbon and dissolved organic carbon, and the maximum decomposition rate was observed in B4. In addition, the Fenton-like reagent could improve the synthesis of humus characterized by complex and stable compounds, which was consistent with the spectral parameters (SUVA254, SUVA280, E253/E203 and Fourier transform-infrared indicators) of DOC. Furthermore, the functional microbial succession performance and linear discriminant effect size analyses provided microbial evidence of humification improvement. Notably, compared with the control, the minimum value of CH4 cumulation was reported in B4, which decreased by 30.44 %. Concluded together, the addition of a Fenton-like reagent composed by OA and Fe(II) is a practical way to improve the humification. Furthermore, the mechanisms related to the promotion of humification should be investigated from free radicals, functional genes, and metabolic pathways.

Insight into using hydrochar to alleviate ammonia nitrogen inhibition during anaerobic digestion of waste activated sludge: Performance, metagenomic and metabolomic signatures

In this study, hydrochar (HCR) was used to alleviate high ammonia inhibition to the anaerobic digestion (AD) of waste activated sludge (WAS) and to elucidate the inner microorganism mechanism. After HCR addition, the cumulative methane yield increased by 73.6 % and 35.6 % under ammonia inhibition levels of 3000 and 6000 mg/L, respectively. Metagenomic analysis showed that HCR enriched the diversity of hydrogenotrophic methanotrophs, and the relative abundances of functional microorganisms with electron transfer capabilities (Geobacteraceae bacterium etc.) were 1.5-7.8 times higher than those without HCR addition. Metabolomics analysis implied that metabolites related to fatty acid degradation, such as glutaric acid and hexadecanal, were downregulated (2.9-15.7 %) under ammonia inhibition conditions and that HCR regulates metabolites in the methane metabolic pathway. Moreover, HCR changed the methanogenic pathway from hydrogenotrophic methanogenesis to multiple pathways under ammonia inhibition conditions, especially methanolic and methylotrophic methanogenesis, which facilitated the methane yield. This study provides valuable information for understanding the inner microbial mechanism of HCR addition on alleviating high ammonia inhibition to AD of WAS, and gives basic knowledge for the application of AD of WAS under ammonia inhibition conditions.

Syntrophic microbes involved in the oxidation of short-chain fatty acids in continuous-flow anaerobic digesters treating waste activated sludge with hydrochar

The rapid degradation of short-chain fatty acids (SCFAs) is an essential issue of anaerobic digestion (AD), in which SCFA oxidizers could generally metabolize in syntrophy with methanogens. The dynamic responses of active metagenome-assembled genomes to low concentrations of propionate and acetate were analyzed to identify specific syntrophic SCFA oxidizers and their metabolic characteristics in continuous-flow AD systems treating waste activated sludge with and without hydrochar. In this study, hydrochar increased methane production by 19%, possibly due to hydrochar enhancing acidification and methanogenesis processes. A putative syntrophic propionate oxidizer and two acetate oxidizers contributed substantially to the syntrophic degradation of SCFAs, and hydrochar positively regulated their functional gene expressions. A significant relationship was established between the replication rate of SCFA oxidizers and their stimulation-related transcriptional activity. Acetate was degraded in the hydrochar group, which might be mainly through the syntrophic acetate oxidizer from the genus Desulfallas and methanogens from the genus Methanosarcina.IMPORTANCEShort-chain fatty acid (SCFA) degradation is an important process in the methanogenic ecosystem. However, current knowledge of this microbial mechanism is mainly based on studies on a few model organisms incubated as mono- or co-cultures or in enrichments, which cannot provide appropriate evidence in complex environments. Here, this study revealed the microbial mechanism of a hydrochar-mediated anaerobic digestion (AD) system promoting SCFA degradation at the species level and identified key SCFA oxidizing bacteria. Our analysis provided new insights into the SCFA oxidizers involved in the AD of waste activated sludge facilitated by hydrochar.

Enhanced anaerobic digestion of human feces by ferrous hydroxyl complex (FHC): Stress factors alleviation and microbial resistance improvement

Anaerobic digestion (AD) offers a reliable strategy for resource recovery from source-separated human feces (HF), but is limited by a disproportionate carbon/nitrogen (C/N) ratio. Ferrous hydroxyl complex (FHC) was first introduced into the HF-AD system to mediate methanogenesis. Mono-digestion of undiluted HF was inhibited by high levels of volatile fatty acids (VFAs), ammonia, and hydrogen sulfide (H2S). FHC addition at optimum dosage (500-1000 mg/L) increased the cumulative methane (CH4) yield by 22.7%, enhanced the peak value of daily CH4 production by 60.5%, and shortened the lag phase by 24.7%. H2S concentration in biogas was also greatly decreased by FHC via precipitation. FHC mainly facilitated the hydrolysis, acidification, and methanogenesis processes. The production and transformation of VFAs were optimized in the presence of FHC, thus relieving acid stress. FHC elevated the activities of alkaline protease, cellulase, and acetate kinase by 32.3%, 18.2%, and 30.3%, respectively. Microbial analysis revealed that hydrogenotrophic methanogens prevailed in mono-digestion at high HF loading but were weakened after FHC addition. FHC also enriched Methanosarcina, thereby expanding the methanogenesis pathway and improving the resistance to ammonia stress. This work would contribute to improving the methanogenic performance and resource utilization for HF anaerobic digestion.

The survival strategy of direct interspecies electron transfer-capable coculture under electron donor-limited environments

Direct interspecies electron transfer (DIET) has been considered as an effective mechanism for interspecies electron exchange in microbial syntrophy. Understanding DIET-capable syntrophic associations under energy-limited environments is important because these conditions more closely approximate those found in natural subsurface environments than in the batch cultures in the laboratory. This study, investigated the metabolic dynamics and electron transfer mechanisms in DIET-capable syntrophic coculture of Geobacter metallireducens and Geobacter sulfurreducens under electron donor-limited condition. The wild-coculture and the mutant-coculture with a citrate synthase-deficient G. sulfurreducens exhibited similar rates of syntrophic metabolism under ethanol-limited and ethanol-replete conditions. Transcriptomic analyses revealed that, in the mutant-coculture in which interspecies electron exchange was the sole electron source for G. sulfurreducens, the transcription of genes associated with uptake hydrogenase in G. sulfurreducens were significantly repressed and thus DIET tended to be the preferred mode of interspecies electron exchange under electron donor-limited condition. To overcome electron donor limitation, c-type cytochromes in the coculture actively moved from outer membrane to extracellular environment, potentially via increased secretion of outer-membrane vesicles. These results suggested a preferred electron transfer mechanism for DIET-capable syntrophic communities' survival in the electron donor-limited environments, providing valuable insights into the biogeochemical processes mediated by DIET in natural and engineered environments.

Riboflavin-loaded carbon cloth aids the anaerobic digestion of cow dung by promoting direct interspecies electron transfer

Cow dung generates globally due to increased beef and milk consumption, but its treatment efficiency remains low. Previous studies have shown that riboflavin-loaded conductive materials can improve anaerobic digestion through enhance direct interspecies electron transfer (DIET). However, its effect on the practical anaerobic digestion of cow dung remained unclear. In this study, carbon cloth loaded with riboflavin (carbon cloth-riboflavin) was added into an anaerobic digester treating cow dung. The carbon cloth-riboflavin reactor showed a better performance than other two reactors. The metagenomic analysis revealed that Methanothrix on the surface of the carbon cloth predominantly utilized the CO2 reduction for methane production, further enhanced after riboflavin addition, while Methanothrix in bulk sludge were using the acetate decarboxylation pathway. Furthermore, the carbon cloth-riboflavin enriched various major methanogenic pathways and activated a large number of enzymes associated with DIET. Riboflavin's presence altered the microbial communities and the abundance of functional genes relate to DIET, ultimately leading to a better performance of anaerobic digestion for cow dung.

Magnetite-boosted syntrophic conversion of acetate to methane during thermophilic anaerobic digestion

Using a batch thermophilic anaerobic system established with 60 mL serum bottles, the mechanism on how microbial enrichments obtained from magnetite-amended paddy soil via repeated batch cultivation affected methane production from acetate was investigated. Magnetite-amended enrichments (MAEs) can improve the methane production rate rather than the methane yield. Compared with magnetite-unamended enrichments, the methane production rate in MAE was improved by 50%, concomitant with the pronounced electrochemical response, high electron transfer capacity, and fast acetate degradation. The promoting effects might be ascribed to direct interspecies electron transfer facilitated by magnetite, where magnetite might function as electron conduits to link the acetate oxidizers (Anaerolineaceae and Peptococcaceae) with methanogens (Methanosarcinaceae). The findings demonstrated the potential application of MAE for boosting methanogenic performance during thermophilic anaerobic digestion.

Co-enhancing effects of zero valent iron and magnetite on anaerobic methanogenesis of food waste at transition temperature (45 °C) and various organic loading rates

Deoiling of food waste (FW) after hydrothermal pretreatment occurs at high temperatures, and more energy is required for substrate cooling before the anaerobic digestion (AD) process. AD at the transition temperature (for example 45 °C) is good for energy saving and carbon emission reducing when treating deoiling FW. However, the metabolic activity of methanogens must increase at the transition temperatures. This study proposes the use of zero-valent iron (Fe0) and magnetite (Fe3O4) to boost CH4 yield from deoiling FW. The results showed a co-enhancing effect on CH4 yield upgradation when using Fe0 and Fe3O4 simultaneously, and the highest CH4 yield reached 536.23 mLCH4/gVS, which was 67.5 % higher than that of Fe0 alone (320.14 mLCH4/gVS). In addition, a high organic loading was favorable for increasing the CH4 yield from deoiling FW. Microbial diversity analysis suggested that the dominant methanogenic pathway at 45 °C was hydrogenotrophic methanogenesis. Herein, a potential metabolic pathway analysis revealed that the co-enhancing effects of Fe0 and Fe3O4 enhanced syntrophic methanogenesis and possibly boosted electron transfer efficiency.

Comprehensive study of the combined effects of biochar and iron-based conductive materials on alleviating long chain fatty acids inhibition in anaerobic digestion

This study investigated the feasibility of alleviating the negative influence of long-chain fatty acids (LCFAs) on anaerobic digestion by biochar, micron zero-valent iron, micron-magnetite (mFe3O4) and their combination. The results demonstrate that co-addition of biochar and 6 g/L mFe3O4 (BC+6 g/L mFe3O4) increased cumulative methane production by 50% as suffered from LCFAs inhibition exerted by 2 g/L glycerol trioleate. The BC+6 g/L mFe3O4 did best in accelerating total organic carbon degradation and volatile fatty acids conversion, through successively enriching Bacteroides, Corynebacterium, and DMER64 to dominant the bacterial community. The proportion of acetotrophic Methanothrix that could alternatively reduce CO2 to methane by accepting electrons via direct interspecies electron transfer (DIET) was 0.09% with BC+6 g/L mFe3O4, nine times more than the proportion in control. Prediction of functional genes revealed the enrichment of the bacterial secretion system, indicating that BC+6 g/L mFe3O4 promoted DIET by stimulating the secretion of extracellular polymeric substances. This study provided novel insights into combining biochar and iron-based conductive materials to enhance AD performance under LCFAs inhibition.

Boosting thermophilic anaerobic digestion with conductive materials: Current outlook and future prospects

Thermophilic anaerobic digestion (TAD) can provide superior process kinetics, higher methane yields, and more pathogen destruction than mesophilic anaerobic digestion (MAD). However, the broader application of TAD is still very limited, mainly due to process instabilities such as the accumulation of volatile fatty acids and ammonia inhibition in the digesters. An emerging technique to overcome the process disturbances in TAD and enhance the methane production rate is to add conductive materials (CMs) to the digester. Recent studies have revealed that CMs can promote direct interspecies electron transfer (DIET) among the microbial community, increasing the TAD performance. CMs exhibited a high potential for alleviating the accumulation of volatile fatty acids and inhibition caused by high ammonia levels. However, the types, properties, sources, and dosage of CMs can influence the process outcomes significantly, along with other process parameters such as the organic loading rates and the type of feedstocks. Therefore, it is imperative to critically review the recent research to understand the impacts of using different CMs in TAD. This review paper discusses the types and properties of CMs applied in TAD and the mechanisms of how they influence methanogenesis, digester start-up time, process disturbances, microbial community, and biogas desulfurization. The engineering challenges for industrial-scale applications and environmental risks were also discussed. Finally, critical research gaps have been identified to provide a framework for future research.

Strategy to enhance the semicontinuous anaerobic digestion of food waste via exogenous additives: experimental and machine learning approaches

The anaerobic digestion (AD) of food waste (FW) was easy to acidify and accumulate ammonia nitrogen. Adding exogenous materials to the AD system can enhance its conversion efficiency by alleviating acidification and ammonia nitrogen inhibition. This work investigated the effects of the addition frequency and additive amount on the AD of FW with increasing organic loading rate (OLR). When the OLR was 3.0 g VS per L per day and the concentration of the additives was 0.5 g per L per day, the stable methane yield reached 263 ± 22 mL per g VS, which was higher than that of the group without the additives (189 mL per g VS). Methanosaetaceae was the dominant archaea, with a maximum abundance of 93.25%. Through machine learning analysis, it was found that the optimal daily methane yield could be achieved. When the OLR was within the range of 0-3.0 g VS per L per day, the pH was within the range of 7.6-8.0, and the additive concentration was more than 0.5 g per L per day. This study proposed a novel additive and determined its usage strategy for regulating the AD of FW through experimental and simulation approaches.

Sugarcane-bagasse-ash in enhanced mesophilic Co-digestion for biogas and nutrient recovery: A concept of developing rural circular bioeconomy

Conductive agro-industrial wastes as accelerants in the anaerobic digestion (AD) of organic waste is a good technique for developing a rural circular economy, such as producing bioenergy and biofertilizer. This study disclosed the a role of sugar cane bagasse ash (SCBA) in enhancing the bioenergy (biogas) yield and digestate fertility via anaerobic co-digestion (AcoD) of buffalo dung (BD) and vegetable residue (VR) under mesophilic conditions (37 ᴼC). Firstly, an optimal BD/VR ratio (1:3) was determined based on biogas yield by introducing five different BD/VR ratios (1:0, 3:1, 1:1, 1:3, and 0:1) into AcoD systems. Secondly, the biogas yield was increased further by adding SCBA at five different concentrations (0, 0.5, 1, 1.5, and 2 wt%). Experimental results disclosed that the 1.5 wt% of SCBA gave the highest cumulative biogas yield (153.67 mL/g VS), COD removal rate (31.18%), and fertility (5.08%). Moreover, a framework is suggested to understand the role of SCBA in the enhanced DIET mechanism. This work documents an environmentally friendly and economical technique for developing a rural circular bioeconomy via the AD of organic agro-waste.

Exploring carbon conversion and balance with magnetite-amended during pig manure composting

This study was designed to explore the magnetite in maturation and humification during pig manure (PM) and wolfberry branch fillings (BF) composting. Different proportions of magnetite (T1, 0%; T2, 2.5%; T3, 5%; T4, 7.5%;) were blended with PM for 50 days of composting. The findings indicated magnetite amendment has no influence on the maturity, and the 5% ratio significantly promoted humic acid (HA) formation and fulvic acid (FA) decomposition compared to other treatments. Compared to T1, magnetite addition significantly increased CO2 and CH4 emissions by 106.39%-191.69% and 6.88-13.72 times. The further analysis suggested that magnetite improved Ruminofilibacter activity were significantly positively associated with HA, and C emissions. The further PICRUSt 2 analysis showed membrane transport may enhance environmental information processing by magnetite. Overall, these results demonstrated higher organic matter (OM) degradation and HA formation with an additional increase in microbial activity highlighted advantages of using magnetite during PM composting.

Insights into the roles and mechanisms of a green-prepared magnetic biochar in anaerobic digestion of waste activated sludge

Methane is one of the most promising renewable energies to alleviate energy crisis or replace fossil fuels, which can be recovered from anaerobic digestion of bio-wastes. However, the engineering application of anaerobic digestion is always hindered by low methane yield and production rate. This study revealed the roles and mechanisms of a green-prepared magnetic biochar (MBC) in promoting methane production performance from waste activated sludge. Results showed that the methane yield reached 208.7 mL/g volatile suspended solids with MBC additive dosage of 1 g/L, increasing by 22.1 % compared to that in control. Mechanism analysis demonstrated that MBC could promote hydrolysis, acidification, and methanogenesis stages. This was because the properties of biochar were upgraded by loading nano-magnetite, such as specific surface area, surface active sites, and surface functional groups, which made MBC have greater potential to mediate electron transfer. Correspondingly, the activity of α-glucosidase and protease respectively increased by 41.7 % and 50.0 %, and then the hydrolysis performances of polysaccharides and proteins were improved. Also, MBC improved the secretion of electroactive substances like humic substances and cytochrome C, which could promote extracellular electron transfer. Furthermore, Clostridium and Methanosarcina, as well-known electroactive microbes, were selectively enriched. The direct interspecies electron transfer between them was established via MBC. This study provided some scientific evidences to comprehensively understand the roles of MBC in anaerobic digestion, with important implications for achieving resource recovery and sludge stabilization.

Stimulating anaerobic digestion to degrade recalcitrant organic pollutants: Potential role of conductive materials-led direct interspecies electron transfer

This review aims to provide a comprehensive understanding of the potential of CMs-dominated DIET in the degradation of recalcitrant organic pollutants in AD. The review covers the mechanisms and efficiencies of recalcitrant organic pollutant degradation by CMs-dominated DIET, the comparison of degradation pathways between DIET and chemical treatment, recent insights on DIET-enhanced degradation, and the evaluation of the potential and future development of CMs-dominated DIET. The review emphasizes the importance of coupled syntrophic microorganisms, electron flux, and physicochemical properties of CMs in enhancing the degradation performance of AD. Additionally, it highlights the advantages of DIET-led syntrophic metabolism over traditional oxidation technologies in terms of environmental friendliness and efficiency. Finally, the review acknowledges the potential risks associated with introducing CMs into AD systems and provides guidance for waste treatment and energy recovery.

Effects of different types of granular activated carbon on methanogenesis of carbohydrate-rich food waste: Performance, microbial communities and optimization

Granular activated carbon (GAC) supplementation is an efficient method for enhancing methane production during the anaerobic digestion of food waste, but it remains unclear which type of GAC is optimal and what potential mechanisms are involved with different types of GAC, particularly for the methanogenic system of carbohydrate-rich food waste. This study selected three commercial GAC (GAC#1, GAC#2, GAC#3) with very distinct physical and chemical properties, and investigated their impacts on the methanogenesis of carbohydrate-rich food waste with an inoculation/substrate ratio of 1. Results indicated that Fe-doped GAC#3 had a lower specific surface area but higher conductivity, yet exhibited superior performance in facilitating methanogenesis compared with GAC#1 and GAC#2, which possessed larger specific surface areas. The addition of 10 g/L GAC#3 enhanced the methane yield by 10-folds through regulating pH levels, alleviating volatile fatty acids-induced stress, enhancing key enzymatic activity, as well as enriching direct interspecies electron transfer-mediated syntrophic partner of Syntrophomonas with Methanosarcina. Furthermore, GAC#1, which had the largest specific surface area but exhibited the poorest performance, was chemically modified to enhance its ability in promoting methanogenesis. The resulting material, named MGAC#1 (Fe3O4-loaded GAC#1), exhibited superior electro-conductivity and high methane production efficiency. The methane yield of 588 mL/g-VS showed a remarkable increase of 468 % compared with GAC#1, and a modest increase of 13 % compared with GAC#3, surpassing most values reported in literature. These findings suggested that the Fe3O4-loaded GAC with lager specific surface area, was the optimal choice for the methanogenesis of sole readily acidogenic waste, providing valuable insights for the preparation of superior-quality GAC for application in biogas industry.

Sustainable disposal of Fenton sludge and enhanced organics degradation based on dissimilatory iron reduction in the hydrolytic acidification process

Fenton sludge generated in the flocculation stage of the Fenton oxidation process contains significant amounts of ferric iron and organic pollutants, which require proper treatment. Previous studies have demonstrated that adding Fenton sludge to an anaerobic digester can decompose some of the organic pollutants in the Fenton sludge to lower its environmental risk, but iron gradually accumulates in the reactor, which weakens the sustainability of the method. In this study, Fenton sludge was introduced into a hydrolytic acidification reactor with a weak acid environment to relieve the iron accumulation as well as improve the degradation of organic matter. The results showed that the added Fenton sludge acted as an extracellular electron acceptor to induce dissimilatory iron reduction, which increased chemical oxygen demand (COD) removal and acidification efficiency by 16.1% and 19.8%, respectively, compared to the group without Fenton sludge. Along with the operation, more than 90% of the Fe(III) in Fenton sludge was reduced to Fe(II), and part of them was released to the effluent. Moreover, the Fe(II) in the effluent could be used as flocculants and Fenton reagents to further decrease the effluent COD by 29.8% and 44.5%, respectively. It provided a sustainable strategy to reuse Fenton sludge to enhance organic degradation based on the iron cycle.

Direct interspecies electron transfer mechanisms of a biochar-amended anaerobic digestion: a review

This paper explores the mechanisms of biochar that facilitate direct interspecies electron transfer (DIET) among syntrophic microorganisms leading to improved anaerobic digestion. Properties such as specific surface area (SSA), cation exchange capacity (CEC), presence of functional groups (FG), and electrical conductivity (EC) were found favorable for increased methane production, reduction of lag phase, and adsorption of inhibitors. It is revealed that these properties can be modified and are greatly affected by the synthesizing temperature, biomass types, and residence time. Additionally, suitable biochar concentration has to be observed since dosage beyond the optimal range can create inhibitions. High organic loading rate (OLR), pH shocks, quick accumulation and relatively low degradation of VFAs, and the presence of heavy metals and toxins are the major inhibitors identified. Summaries of microbial community analysis show fermentative bacteria and methanogens that are known to participate in DIET. These are Methanosaeta, Methanobacterium, Methanospirillum, and Methanosarcina for the archaeal community; whereas, Firmicutes, Proteobacteria, Synergistetes, Spirochetes, and Bacteroidetes are relatively for bacterial analyses. However, the number of defined cocultures promoting DIET is very limited, and there is still a large percentage of unknown bacteria that are believed to support DIET. Moreover, the instantaneous growth of participating microorganisms has to be validated throughout the process.